2002 Ford Crown Victoria

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

IN SEPTEMBER 2002, A FUEL CYLINDER IN A NATURAL GAS POWERED VEHICLE (NGV) EXPLODED DURING A FIRE.FORD AND VRTC TEST ENGINEERS JOINTLY EXAMINED THE INCIDENT VEHICLE AND REVIEWED TESTING TO DETERMINE WHETHER THE PERFORMANCE OF THE PRESSURE RELIEF VALVE (PRD) WAS PROPER.THE PURPOSE OF A PRD IS TO PROTECT A COMPRESSED NATURAL GAS TANK FROM OVERPRESSURE BY ALLOWING THE CNG TO VENT WHEN THE TEMPERATURE REACHES A SPECIFIC POINT.THE PRD WAS REMOVED FROM THE FAILED TANK AND SUBJECTED TO A YIELD TEMPERATURE DETERMINATION TEST. IT WAS CONCLUDED THAT A DIRECT FLAME (FROM THE INTERIOR OF THE VEHICLE) ONTO THE CYLINDER (LOCATED BEHIND THE REAR SEAT IN THE TRUNK)COMPROMISED THE HOOP STRENGTH OF THE NATURAL GAS CYLINDER, THUS ALLOWING THE CYLINDER TO FAIL PRIOR TO THE PRD RELEASING AT ITSDESIGNED TEMPERATURE.AS A RESULT OF THIS TESTING AND REVIEW OF THE INVOLVED VEHICLE, FORD HAS DEVELOPED AN INSULATOR TO INSULATE THE NATURAL GAS FUEL TANK FROM A LOCALLY DIRECTED FLAME PROJECTING FROM THE INTERIOR OF THE VEHICLE.INSULATORS WILL BE INSTALLED BEHIND THE BACK SEAT ON SUBJECT VEHICLES TO PREVENT FUTURE FAILURES OF THIS TYPE. FORD'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.

AN EXPLOSION OF A COMPRESSED NATURAL GAS (CNG) TANK SHOULD NOT BE ABLE TO OCCUR, AS THE TANK IS FITTED WITH A PRESSURE RELIEF DEVICE (PRD). THIS PRD SHOULD RELEASE THE CNG IN THE TANK, PRIOR TO THE PRESSURE REACHING THE TANK BURST PRESSURE.THE PRD DID NOT RELEASE IN THE SUBJECT WISCONSIN POLICE CRUISER EXPLOSION.NHTSA HAS RECOVERED THE PRD VALVE FROM THE TANK THAT EXPLODED AND TESTING WILL BE NECESSARY TO ESTABLISH WHY THIS TANK SAFETY VALVE DID NOT RELEASE IN THE VERY HIGH TEMPERATURE FIRE THAT OCCURRED IN THE POLICE CRUISER.THERE IS ONLY THE SINGLE KNOWN EVENT, BUT DUE TO THE CATASTROPIC FORCE OF SUCH AN EXPLOSION AND THE POTENTIAL FOR INJURY AND LOSS OF LIFE, THIS INVESTIGATION IS BEING UPGRADED.

..

NHTSA ID

11682007

Incident

Jul 31, 2025

Driving down the roadway at 55 mph a spark plug in cylinder 2 blow out. The car started making a popping noise and started to lose power. After a while the car shut off. The car was able to restart and be driven home. Upon inspection by a mechanic they found the spark plug had came dislodged and shot out of the cylinder and caused damage to the cylinder head the ignition coil and fuel rail. A new Heli coil was installed. A year later while in Texas driving down the road around 35 mph car made a pop noise and shot a spark plug out of cylinder 5 cause the car to lose power and start smoking with a heavy smell of fuel. Car was stopped and inspected. Found a spark plug was blown out of cylinder 5 with damage to the ignition cylinder and fuel rail. repaired the heli coil and placed with new spark plug ignition coil and fuel rail. 2019 while driving down road at 75 mph vehicle makes a loud pop and starts to lose power. Upon inspection by mechanic find spark plug blown out of cylinder 1 with damaged ignition coil. Having mechanic is now replacing both cylinder heads on the engine.

NHTSA ID

11448585

Incident

Jun 12, 2019

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH AND ATTEMPTING TO MAKE A TURN, THE TURN SIGNALS AND HEADLIGHTS FAILED TO WORK, EXCEPT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO NOTICED THAT THE TAIL LIGHTS DID NOT WORK AND THE DASHBOARD WAS BLACKED OUT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS UNABLE TO SCHEDULE THE VEHICLE FOR A DIAGNOSTIC EVALUATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000. UPDATED 10/06/16*LJ ** UPDATED 10/19/16*LJ *TR

NHTSA ID

10899549

Incident

Aug 25, 2016

Mileage

38,000 mi

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE HEADLAMPS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LIGHTING CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 197,000.

NHTSA ID

10892934

Incident

Jul 28, 2016

Mileage

197,000 mi

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING 35 MPH AND PROCEEDING TO STOP AT A RED LIGHT, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MANIFOLD WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,218.

NHTSA ID

10818444

Incident

Dec 29, 2015

Mileage

81,218 mi

I HAD DRIVEN UP A STEEP MOUNTAIN DIRT ROAD TO SERVE SOME LEGAL PAPERS, AFTER REACHING THE TOP, I CONTINUED DOWN THE OTHER SIDE TO THE ADDRESS I WAS LOOKING FOR. I THOUGHT I STARTED SMELLING SOMETHING BURNING, IT SMELLED ELECTRICAL. WHEN I ARRIVED AT THE ADDRESS, I STOPPED THE CAR AND SHUT IT OFF WHILE I WAS SPEAKING WITH THE RESIDENT. MY WIFE YELLED AT ME THAT THE CAR WAS ON FIRE, IT STARTED FILLING UP WITH SMOKE FAST, MY WIFE AND DOGS WERE STILL IN THE CAR. I OPENED THE DRIVERS DOOR TO POP THE HOOD WHILE MY WIFE STARTED GETTING THE DOGS OUT, I THEN NOTICED IT WAS MY FLOOR THAT WAS BURNING, JUST ABOUT UNDER THE GAS PEDDLE, A HOLE HAD BURNED THROUGH AND THE METAL WAS GLOWING RED WHERE THE PADDING HAD BURNED AWAY. I POURED A CUP OF COFFEE TO PUT THE FIRE OUT WHILE THE RESIDENT GOT SOME WATER FOR ME. THE PADDING AND RUBBER MAT HAD BURNED AWAY AND A HOLE ABOUT 3 INCHES LONG HAD MELTED AWAY FROM THE FLOOR BOARD. THE CATALYTIC CONVERTER IS DIRECTLY BENEATH THE HOLE BUT THERE DOESN'T SEEM TO BE ANY HOLES IN THE CONVERTER AND THERE IS A EMPTY SPACE ABOUT 1.5 - 2 INCHES FROM THE MELTED HOLE TO THE CONVERTER. WE LET EVERYTHING COOL DOWN BEFORE DRIVING HOME, HOWEVER THE ENTIRE WAY HOME, (49 MILES) WE WERE AFRAID THE CAR WAS GOING TO BURST INTO FLAMES. ONCE WE WERE BACK ON THE PAVED ROADS AND WERE ABLE TO DRIVE THE NORMAL SPEED LIMIT, THERE WERE NO MORE ISSUES NOR ANY FURTHER BURNING, JUST THE LINGERING SMELL. I LOOKED UP AND FOUND A RECALL FOR AN ISSUE IN THE SAME LOCATION HOWEVER THAT WAS FOR 2003 - 2005 VEHICLES. *JS

NHTSA ID

10669204

Incident

Dec 30, 2014

Mileage

132,421 mi

TL** THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT DRIVER AND PASSENGER SEAT BELT BECAME UNLATCHED SPORADICALLY. THE CONTACT MENTIONED THAT THE FAILURE COULD HAVE BEEN DIRECTLY RELATED TO NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS). THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

NHTSA ID

10653386

Incident

Jan 2, 2006

Mileage

50,000 mi

BOUGHT THE CAR FROM A FELLOW FRIEND HE ADVISED ME THAT THE CAR HAS HAD A ISSUE WITH THE STEERING WHERE THE STEERING WHEEL HAS PLAY TO IT AND ITS VERY DANGEROUS WHEN I DRIVE OVER 50MPH IM SCARED I MAY CRASH CAUSE THE CAR MOVES LEFT TO RIGHT, AND THE ABS BRAKES HAVE A PROBLEM THE BRAKE JUMP WHEN I HIT THEM IDK WHAT TO DO IM LOW ON FUNDS AND I WANT TO KNOW IF THIS IS A DEFECT THESE CARS ARE KNOWN FOR STEERING AND BRAKES DEFECTS..... *TR

NHTSA ID

10631810

Incident

Jul 17, 2013

Mileage

120,898 mi

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT