1994 Ford E-150 Problems

TL*THE CONTACT OWNS A 1994 FORD E-150 ECONOLINE. THE CONTACT STATED THAT THE ABS LIGHT WAS FLASHING AND THE BRAKE FLUID WAS VERY LOW. IN ADDITION, THE SPEED CONTROL LIGHT BEGAN FLASHING AND FAILED WHILE DRIVING 25 MPH. THE GEAR WOULD NOT SHIFT OUT OF PARK WHEN THE VEHICLE WAS STARTED, AND THE ODOMETER AND SPEEDOMETER STOPPED WORKING. THE MECHANIC STATED THAT THE VEHICLE NEED BRAKE FLUID AND THAT THE SPEED CONTROL FAILED DUE TO DEFECTIVE BRAKES. THE DEALER STATED THAT THEY WOULD CHARGE THE CONTACT $110 FOR OVERAGE DIAGNOSTIC TESTING WHILE REPAIRING THE VEHICLE UNDER RECALL. THE CONTACT HAS HANDICAPPED TRIPLETS AND THE BRAKES AND SPEED CONTROL ARE A SAFETY ISSUE. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 08/18/08 *BF THE VEHICLE ALSO HAD AN ELECTRICAL SHORT. UPDATED 08/19/08 *JB

WHILE DRIVING 30 MPH MASTER CYLINDER BRAKE LINE FAILED. AS A RESULT, WHEN APPLYING THE BRAKES, TPEDAL DEPRESSED TO THE FLOOR ,AND VEHICLE CONTINUED TO ACCELERATE. CONSUMER STATES IN ORDER TO SLOW THE VEHICLE DOWN TO A COMPLETE STOP HE HAD TO GO INTO SOME GRAVEL ON THE SIDE OF THE ROAD. NO IMPACT REPORTED. *AK

TL*THE CONTACT OWNS A 1994 FORD E-150 ECONOLINE. THE CONTACT STATED THAT THE ABS LIGHT WAS FLASHING AND THE BRAKE FLUID WAS VERY LOW. IN ADDITION, THE SPEED CONTROL LIGHT BEGAN FLASHING AND FAILED WHILE DRIVING 25 MPH. THE GEAR WOULD NOT SHIFT OUT OF PARK WHEN THE VEHICLE WAS STARTED, AND THE ODOMETER AND SPEEDOMETER STOPPED WORKING. THE MECHANIC STATED THAT THE VEHICLE NEED BRAKE FLUID AND THAT THE SPEED CONTROL FAILED DUE TO DEFECTIVE BRAKES. THE DEALER STATED THAT THEY WOULD CHARGE THE CONTACT $110 FOR OVERAGE DIAGNOSTIC TESTING WHILE REPAIRING THE VEHICLE UNDER RECALL. THE CONTACT HAS HANDICAPPED TRIPLETS AND THE BRAKES AND SPEED CONTROL ARE A SAFETY ISSUE. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 08/18/08 *BF THE VEHICLE ALSO HAD AN ELECTRICAL SHORT. UPDATED 08/19/08 *JB

TL*THE CONTACT OWNS A 1994 FORD E150. THE CONTACT RECEIVED A FORD RECALL NOTICE IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL. THE PARTS WERE UNAVAILABLE FOR THE RECALL REPAIR. WHILE PARKED IN THE GARAGE, THE VEHICLE CAUGHT FIRE. AFTER THE CONTACT EXTINGUISHED THE FIRE, THE VEHICLE WOULD NOT MOVE OUT OF THE PARK POSITION. THE DEALER STATED THAT HE WOULD HAVE TO FIRST INSTALL A FUSE TO MOVE THE VEHICLE OUT OF PARK BEFORE BRINGING IT TO THE DEALER FOR REPAIR. AFTER HE INSTALLED THE FUSE AND TOOK THE VEHICLE TO THE DEALER, THEY REFUSED TO MAKE THE REPAIR. THE MANUFACTURER REFERRED HIM TO HIS STATE'S ATTORNEY GENERAL OFFICE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 110,009.

The contact owns a 1994 Ford E-150. The contact stated that while driving at an undisclosed speed, the contact stated she heard an unusual noise that sounded like something broke. The contact stated she continued to drive and the failure reoccurred. The vehicle was towed to an independent mechanic. The vehicle was diagnosed with a fractured steering box. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000.

ON JAN 21ST 2020, WHILE MANEUVERING AT A GAS STATION, I HEARD A LOUD POP/CRACK. THINKING I HAD HIT A STANCHION, I WALKED AROUND MY VAN BUT - NO STANCHION. NOTHING TO SEE SO I GO ABOUT MY DAY. STEERING PULLED TO THE RIGHT, I CHECKED FOR LOW TIRE PRESSURE - PRESSURE, OK. 40 MILES OF FREEWAY DRIVING LATER, I TAKE THE VAN TO THE GARAGE - STEERING FEELS LOOSE. AFTER INSPECTION, THE DANGER I WAS IN, AND THE THREAT I WAS TO THOSE AROUND ME ON THE ROAD, WAS MOST APPARENT. THE STEERING GEAR BOX WAS LOOSE FROM THE FRAME, ONE BOLT HAVING SHEERED OFF. AND THE FRAME ITSELF CRACKED. IMAGINE MY SURPRISE WHEN FINDING THAT FATIGUE FAILURE AT THIS PART OF THE FRAME WAS WELL DOCUMENTED ON THE INTERNET AND YET, AS AN ORIGINAL OWNER, I HAD NOT BEEN INFORMED OF THIS KNOWN AND DANGEROUS DESIGN DEFECT BY FORD MOTOR CO OR LANDMARK FORD. HOW MANY VANS OF THE SAME VINTAGE ARE STILL ON THE ROAD ?? HOW MANY ARE SAFE TO DRIVE ALONG SIDE?? I GUESS I AM LUCKY TO BE ABLE TO WRITE THIS NOTE, COS HAD MY STEERING BOX BROKEN LOOSE WHILE DRIVING ACROSS THE GLEN JACKSON BRIDGE, (I 205), I COULD EASILY HAVE ENDED UP IN THE COLUMBIA RIVER ALONG WITH OTHER INNOCENTS. DISILLUSIONED CUSTOMER. 1994 FORD E150, 170,289 MLS, FRAME @ STEERING GEAR BOX.

See attached document for complaint

TL*- THE CONTACT STATED THAT WHEN ATTEMPTING TO START THE 1994 FORD E150 HE HEARD A LOUD NOISE. THE CONTACT FELT THAT THIS WAS DUE TO THE OIL RISING TO THE TOP OF THE ENGINE. THE CONTACT HAD TO TURN THE VEHICLE OFF AND WAITED 4 HOURS BEFORE HE ATTEMPTED TO RESTART THE VEHICLE. THE CONTACT WAS THEN UNABLE TO START THE VEHICLE WITHOUT HEARING THE NOISE. HE GENERALLY HAD THIS PROBLEM WITH THE VEHICLE WHEN HE ATTEMPTED TO START THE VEHICLE IN THE MORNING. HE DID NOT TAKE THE VEHICLE TO THE DEALERSHIP TO HAVE IT CHECKED. THE VEHICLE CURRENTLY HAS 190000 MILES. *AK UPDATED 03/19/07. *JB

TL*THE CONTACT OWNS A 1994 FORD E-150. THE CONTACT STATED THAT FUEL BEGAN TO LEAK FROM UNDER THE VEHICLE WHILE HE WAS FUELING THE VEHICLE. THE FUEL CONTINUED TO LEAK UNTIL THE TANK WAS 1/3 FULL AND IT STOPPED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 140,000.

WHILE DRIVING THE MOTOR SHUT DOWN. VEHICLE LOST POWER STEERING AND BRAKES. VEHICLE WILL COAST UNTIL IT STOPS. AFTER WAITING ABOUT 15 MINUTES THE VEHICLE WILL STARTED UP AGAIN, ONLY TO SHUT BACK DOWN. OWNER HAD THE FUEL PUMP/COMPUTER/PICK UP IN THE DISTRIBUTOR/NEW IGNITION SWITCH, AND WIRING HARNESS CHANGED. YET THE VEHICLE'S PERFORMANCE HAD NOT CHANGED. *AK

TL*THE CONTACT OWNS A 1994 FORD E-150 ECONOLINE. THE CONTACT STATED THAT THE ABS LIGHT WAS FLASHING AND THE BRAKE FLUID WAS VERY LOW. IN ADDITION, THE SPEED CONTROL LIGHT BEGAN FLASHING AND FAILED WHILE DRIVING 25 MPH. THE GEAR WOULD NOT SHIFT OUT OF PARK WHEN THE VEHICLE WAS STARTED, AND THE ODOMETER AND SPEEDOMETER STOPPED WORKING. THE MECHANIC STATED THAT THE VEHICLE NEED BRAKE FLUID AND THAT THE SPEED CONTROL FAILED DUE TO DEFECTIVE BRAKES. THE DEALER STATED THAT THEY WOULD CHARGE THE CONTACT $110 FOR OVERAGE DIAGNOSTIC TESTING WHILE REPAIRING THE VEHICLE UNDER RECALL. THE CONTACT HAS HANDICAPPED TRIPLETS AND THE BRAKES AND SPEED CONTROL ARE A SAFETY ISSUE. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 08/18/08 *BF THE VEHICLE ALSO HAD AN ELECTRICAL SHORT. UPDATED 08/19/08 *JB

ON SEPTEMBER 12, 2005 WHILE THE FAMILY WAS AWAY FROM HOME, OUR 1994 FORD E 150(ECONOLINE) VAN SPONTANEOUSLY STARTED ON FIRE. THE VEHICLE WAS PARKED AND NOT RUNNING AS WE WERE NOT HOME. UPON RETURN AND FOLLOWING COMMUNICATION WITH THE FIRE DEPARTMENT AND WITNESSES, THE VEHICLE STARTED SMOKING AND THEN BURST INTO FLAMES WITH NO ONE NEAR THE VEHICLE. THE HOOD AND ENGINE AREA WERE A MASS OF MELTED WIRES AND PLASTIC. THE FOCUS OF DAMAGE WAS ON THE DRIVER SIDE OF THE ENGINE. WE WERE TOLD BY A NEIGHBOR AT THAT TIME ABOUT A RECALL FORD WAS SUPPOSE TO HAVE ON THEIR VEHICLES. AFTER LOOKING UP THE CRUISE CONTROL RECALL AND COMPARING PICTURES, THE BURN EVIDENCE APPEARS TO BE THE SAME. THE VEHICLE IS TOTALED. I WOULD LIKE TO HEAR FROM THE FORD COMPANY AS THEY ONLY RECALLED THE VEHICLES THAT THE MEDIA WAS AWARE OF AND NOT THE OTHER VEHICLES WITH THE SAME FAULTY EQUIPMENT. (RECALLED F 150 NOT E 150 WITH SAME CRUISE CONTROL THAT REMAINS HOT EVEN WHEN THE ENGINE IS OFF AND VEHICLE IS PARKED OVER NIGHT.)

MULTIPLE SYSTEMS FAILURES; CURRENTLY ABS LIGHT STAYS ON, AIR BAG LIGHT FLASHES, FUEL SMELL, SLOPPY STEERING, FRONT SUSPENSION NOISES, POWER DOOR LOCKS INOPERATIVE, CRUISE CONTROL INOPERATIVE, HORN INOPERATIVE. *AK

RIGHT FRONT SHOCK IS LEAKING FLUID-NOTICE THAT THE FEMALE PART OF THE SHOCK IS RUBBING THE FRAME,RIGHT ABOVE THE MOU N TNG BOLT.ALSO THE RIGHT SHOCK IS RUBBING THE FRAME.THIS VEHICLE HASN'T BEEN IN A WRECK-I THINK THERE NEEDS TOA SPACER BETWEEN THE SHOCKS MOUNTING BOLT AND THE FRAME,TO PULL IT AWAY FROM THE FRAME-

FIRESTONE TIRE P235 75 R15 EXPERIENCED BLOW OUT RESULTING IN DAMAGE TO VEHICLE, AN INJURY AND A DEATH, CONSUMER WANTS REIMBURSEMENT. *SLC

I WAS DRIVING HOME FROM WORK GOING SOUTH ON CALIFORNIA HIGHWAY 71. THE LEFT FRONT TIRE BLEW OUT. I CAME WITHIN18 INCHES OF HITTING THE CONCRETE DIVIDER THAT SEPERATES THE NORTH AND SOUTH BOUND LANES. WHEN I GOT OUT OF THE VEHICLE TO CHECK THE TIRE THERE WAS NO TREAD LEFT. I COULD SEE ONLY THE STEEL BELT ALL THE WAY AROUND THE TIRE.( DOT NUMBER: VDHL1PY127 TIRE SIZE: P235/75R15 )

HOPE THIS ISN'T A DUP; I STARTED A REPORT YESTERDAY, BUT DON'T THINK I COMPLETED IT. ASKED TO DO SOME WORK ON MY 1994 CLUB WAGON (167K MI), AN INDEPENDENT MECHANIC FOUND A CRACK ON THE LOWER SIDE OF THE FRAME, BENEATH THE STEERING BOX. HE WOULDN'T DO THE WORK. SUBSEQUENTLY A BODY SHOP FOUND THERE WERE ACTUALLY TWO CRACKS, ONE ON THE INBOARD SIDE OF THE FRAME, RADIATING FROM THE STEERING BOX MOUNTING HOLE, TRAVELING BACK AND DOWN, AROUND THE LOWER CORNER OF THE FRAME, THEN FORWARD ABOUT 3" ON THE LOWER FACE OF THE FRAME ,ALONG THE EDGE. THE LAST 2" OF THE CRACK WERE OPEN, WITH ABOUT A 2MM GAP. THE CRACK ON THE OPPOSITE FACE TRAVELED IN AN ARC OF PERHAPS 60 DEGREES CENTERED ON THE MOUNTING BOLT HOLE, ABOUT 2" FROM THE CENTER, THEN DIAGONALLY DOWN TO THE LOWER EDGE, THEN BACK A COUPLE OF INCHES ALONG THAT LOWER EDGE. BOTH LOOK LIKE FATIGUE DUE TO SB TORQUE ON THE FRAME. FORD WON'T FIX THE PROBLEM, PROVIDE A METHOD TO FIX IT, OR COMMENT ON THE POSSIBILITY OF FIXING IT. THE CORPORATE CONSUMER HELP PHONE LINE SAID I SHOULD BUY A SHOP MANUAL AND READ IT TO DETERMINE IF THERE IS A WAY TO FIX IT. THE LOCAL FORD DEALER RECOMMENDED A BODY SHOP. THAT SHOP OFFERED TO WELD PATCHES OVER THE CRACKS. AFTER READING SIMILAR STORIES, THAT SOUNDS LIKE A PROFOUNDLY BAD IDEA. A SEARCH THIS (NHTSB) SITE FOR SIMILAR PROBLEMS CLAIMS 15 TOTAL PROBLEMS WITH THIS MODEL AND YEAR. HOWEVER, ANOTHER SITE (HTTP://HARRIGILL.NET/FORDVAN/INDEX.HTML) LISTS 39 FOR THE SAME MODEL AND YEAR, COPIED FROM THE NHTSA IN 2007 - AND YET MORE FROM 1993. WHERE ARE THE OTHERS? AND WHAT OF THE PROBLEM WITH THE SAME FRAME IN OTHER YEARS? WHAT IS THE TOTAL NUMBER OF REPORTED PROBLEMS FOR THIS DESIGN, SUMMED OVER ALL YEARS? IT SEEMS TO ME THE NHTSA AND FORD SHOULD HAVE WARNED OWNERS OF THIS PROBLEM. PERHAPS YOU HAVEN'T NOTICED BECAUSE FRAME NOT IN YOUR LIST OF PARTS? *TR

I PURCHASED THIS 1994 FORD E-150 CLUBWAGON FROM A PRIVATE OWNER IN 08/2008, IT WAS AND STILL IS IN BETTER THAN GOOD CONDITION. IT HAD A RECALL TO REPLACE A FUSED JUMPER HARNESS WHICH WAS DONE IN 12/2008. IN EARLY SPRING OF 2009, I JUST BOUGHT A NEW SET OF TIRES AND GOT A FRONT END ALIGNMENT, ABOUT TWO WEEKS LATER, I WAS TRAVELING AT ABOUT 45 MILES AN HOUR ON A BUSY FOUR LANE STREET, WHEN I HIT A BUMP IN THE ROAD AND MY VAN BEGAN TO SHAKE VERY VIOLENTLY. AT THE SAME TIME I WAS PASSING A REPAIR SHOP, I GOT THE VAN UNDER CONTROL AND PULL IN. BEING A CERTIFIED MECHANIC MYSELF I BEGAN TO EXAMINE THE STEERING LINKAGE, EVERYTHING SEEMED FINE, WHEN THE SHOP MECHANIC NOTICED THAT THE LOWER STEERING GEARBOX BOLT HAD WENT THROUGH THE FRAME AND HAD BROKE AT THE THREADS. AFTER PUTTING IT IN THE SHOP A FEW TIMES, WITH SHORT TERM SUCCESS, THAT PARTICULAR AREA OF THE FRAME CONTINUED TO HAVE PROBLEMS. WHAT STARTED OUT AS A SMALL HOLE, AFTER A FEW ATTEMPTS AT THE SHOP, HAS NOW BECOME LARGER. I CHECKED WITH THE LOCAL FORD DEALER ABOUT A RECALL, THERE WAS NONE. I'VE WORKED AS A MECHANIC FOR MANY YEARS, AND HAVE NEVER SEEN THIS HAPPEN BEFORE, I HAVE A FEW THEORIES ON THE SUBJECT, POSSIBLY AN OVER TORQUED GEARBOX AND/OR A VERY WEAK FRAME. BUT NEVERTHELESS FORD SHOULD RECALL THESE VEHICLES AND MAKE THE NECESSARY REPAIRS BEFORE SOMEONE IS SERIOUSLY INJURED OR BECOMES A FATALITY. BECAUSE THIS DEFECT COULD HAPPEN AT ANY GIVEN TIME AND WITHOUT WARNING. *TR

TL*THE CONTACT OWNS A 1994 FORD E-150. THE CONTACT STATED THAT THE CLOCK SPRING IN THE STEERING COLUMN WAS DEFECTIVE AND HAD TO BE REPLACED APPROXIMATELY 6-7 TIMES; THREE TIMES AT A DEALER AND THE OTHER THREE TIMES AT A REPAIR SHOP. HE BELIEVED THAT THE DEFECTIVE SPRING WOULD CAUSE ISSUES WITH THE HORN AND THE AIR BAGS. THE CURRENT MILEAGE WAS 132,500 AND FAILURE MILEAGE WAS APPROXIMATELY 7,000. UPDATED 6/30/08 *CN UPDATED

ENGINE EXPERIENCED FAILURE - WHEN DEALER TRIED TO REPLACE ENGINE TOLD IT WAS NO LONGER MADE. IT WAS REPORTED TO MY FORD DEALER THAT PARTICULAR "HIGH PERFORMANCE" ENGINE IS NOT PLACED IN E-150. HOWEVER, IN THIS CASE IT WAS. HAVE ALSO BEEN INFORMED THAT HE "CLOCK SPRING" IN THE STEERING COLUM NEEDS TO BE REPLACED. THIS WAS AN INTERMITTENT PROBLEM FOR A NUMBER OF YEARS. FINALLY BECAME CONSTANT ISSUE AT ABOUT 95,000 MILES. HORN CEASED TO FUNCTION, AB LIGHT STAYED IN FLASHING MODE, CRUISE CONTROL INOPERABLE. BRAKES HAVE BEEN REPLACED NUMEROUS TIMES ON VAN, STARTING AT LESS THAN 25, 000 MILES. IDLE ASSEMBLY REPLACED 3 TIMES DUE TO CONSTANT SQUEALING. FUEL PUMP HAD TO BE REPLACED AT APPROX 95 000. *AK

AFTER PUTTING VEHICLE INTO PARK AND LEAVING IDLING FOR ABOUT 15 MINUTES, AND THEN WHEN TURNING VEHICLE OFF, IT STARTED TO ROLL BACK. CONSUMER HAD TO APPLY BRAKES. CONTACTED DEALER. *AK

TRANSMISSION SHIFTED OUT OF LAST GEAR & VEHICLE WOULD START TO VIBRATE AS IF GOING OVER RUMBLE STRIPS. HAPPENS WHEN TRYING TO PASS ANOTHER VEHICLE. VIBRATIONS IN TRANSMISSION WOULD LAST ABOUT 15-25 SECONDS. *AK

DRIVER'S/PASSENGERS SEAT BELTANCHOR DETACHED FROM FLOOR PANEL; ALSO, LOOSE TRANSMISSION NOT SHIFTING PROPERLY. *AK

REAR BENCH W/SHOULDER/LAP ON OUTSIDE. LOOSE LONG MATERIAL INTERFERES W/POSITION, IMPROPER FOR CHILDREN. PLEASE DESCRIBE DETAILS. *AK

WINDSHIELD WIPERS WILL TURN OFF INTERMITTENTLY DURING OPERATION, CAUSING POOR VISIBILITY. *AK

VEHICLE WAS PARKED, PASSENGER WINDOW BEHIND THE DRIVER EXPLODED WITHOUT WARNING. TT

1994 E150 REAR A/C LINES HAD BEEN CAPPED OFF. THE A/C LINES UNDER VEHICLE WERE CORRODED. *TS THE VEHICLE HAD NO REAR A/C INSTALLED. *NM

ON MY 1994 E-150 THE BACK DOOR TIRE AREA SECURING THE TIRE TO THE DOOR HAS RUSTED HROUGH THE DOOR, AND AS A RESULT WILL NOT HOLD THE TIRE INPLACE.REAR AC UNIT DOES NOT COOL HAVE HAD REPAIR STATION LOOK AT IT. *AK AND THEY CANNOT FIND THE PROBLEM THE UNIT HAS BEEN CHARGED AND STILL DOES NOT WORK. PROBLEM WITH THE ABS LIGHT ALSO. THE LIGHT REMAINS ON AND HAVE HAD THAT LOOKED AT ALSO.

VEHICLE IS EXPERIENCING PROBLEMS WITH THE WHEEL STUDS. CONSUMER WAS DRIVING AT 30 MPH, AND WHILE SLOWING DOWN TO A STOP SIGN, ALL FIVE WHEEL STUDS ON THE RIGHT FRONT WHEEL BROKE COMPLETELY OFF. THE STUDS WERE NOT RUSTED. ALL FIVE WERE CLEAN BREAKS. *AK

DRIVING VEHICLE, WHEELS WERE LOOSE; TOOK VEHICLE IN TO DEALER TO HAVE NEW BRAKES PUT ON; MECHANIC NOTICED THAT THE BALL JOINTS WERE SHOT AND HAD THEM REPLACED.*AK

THE DRIVESHAFT SEALS KEPT LEAKING AFTER BEING REPAIRED SEVERAL TIMES. THE LEAKAGE ENTERED INTO THE TRANMISSION. DEALER NOTIFIED. *AK

ENGINE FAILED, REPLACED WITH NEW ONE AND FAILED AGAIN, THIRD ENGINE LEAKING OIL AND NEEDS REPLACEMENT.

CENTER ROOF LIGHT CAUGHT ON FIRE. NEVER RECEIVED RECALL LETTER (94V-128). *AK *JB