1990 Ford E350 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1990 Ford E350, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes1354.2%
- Body & structure312.5%
- Engine28.3%
- Fuel system28.3%
- Tires & wheels28.3%
- Electrical14.2%
- Seat belts14.2%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THE FRONT DISC BRAKE CALIPERS DO NOT RETRACT AFTER APPLYING THE BRAKES, FRICTION FROM THE BRAKE PADS CAUSES THE BRAKE FLUID TO BOIL EFFECTIVELY RESULTING IN NO BRAKE OPERATION, THIS HAPPENS EVERYTIME THE VEHICLE IS LEFT SITTING FOR ABOUT A MONTH, RUST DEVELOPS ON THE SLIDER BARS WHICH PREVENTS THE CALIPERS FROM RETRACTING TO THE RESET POSITION. NLM
CONSUMER WAS COMING DOWN A HILL IN IN DRY WEATHER CONDITION WHEN PROCEEDING TO STOP AND THERE WERE NO BRAKES .CONSUMER WAS ABLE TO GRADUALLY STOP VEHICLE BEFORE A CRASH. *AK
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
HAND RAIL FAILED ON BUS NUMBER 147. (TWELFTH VEHICLE ON 503019) *DSH
HAND RAIL FAILED ON BUS NUMBER 146. (ELEVENTH VEHICLE ON 503019) *DSH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
GASKET O-RING FAILURE RESULTING IN LEAK WHICH CAUSED FUEL FILTER TO BECOME OBSTRUCTED AND GASOLINE TO LEAK VEHICLE.
CATALYTIC CONVERTER FAILED WHILE DRIVING AT 45 MPH.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL FROM REAR TANK OVERFLOWED TO FRONT TANK WHICH LEAKED OUT EXCESS FUEL. OCCURRED ONCE BEFORE REPAIRS. DID A SEARCH FOR THE ISSUE AND FOUND THAT THERE WAS A SECRET OPEN WARRANTY COVERING THE ISSUE, CALLED FORD AND GOT 'PERMISSION' TO HAVE IT REPAIRED. THE FIRST REPLACEMENT WAS WORSE ACCORDING TO THE SERVICE MANAGER AT FRANK JACKSON IN SANDY SPRINGS GA. SO I HAD TO WAIT A COUPLE MORE DAYS TO GET THE NEW ONE. IT SEEMS FINE NOW. BUT HOW MANY MORE OF THE SENSORS OR WHATEVER IT'S CALLED ARE BAD THAT THEY HAVE IN STOCK TO REPLACE EXISTING FAULTY ONES? *TR
ENGINE STALLED FOUR TIMES DUE TO POOR DESIGN OF FUEL PUMP.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TWO OF THE FIRESTONE STEELTEX RADIAL R4S LT 215/85R16 MS TIRES EXPERIENCED TREAD SEPARATION, FIRST TIME TIRE WRAPPED AND DAMAGED ADJOINING TIRE ON LEFT REAR DUAL, SECOND TIRE UNWRAPPED AND BROKE OUT BOTTOM OF THE HOLDING TANK, CONSUMER INSTALLED ARMOR PLAT TO PROTECT NEW TANK. *MJS
FIRESTONE, STEEL TEX R4S, LT235/85R16 SIZE . TREAD ON THREE OF THE TIRES SEPARATED ON SEPARATE OCCASIONS.*AK CONSUMER STATES THAT ON ONE OCCASION, HE ALMOST HIT HEAD ON WITH A TRACTOR TRAILOR. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
THE VEHICLE CAUGHT ON FIRE RIGHT UNDER THE DRIVERS SEAT. PLEASE DESCRIBE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
REPLACED THE MASTER CYLINDER TWICE AND BRAKES FAILED THREE TIMES. REFERS TO RV COACHMEN MINI MOTOR HOME., ALSO MAY RELATE TO RECALL (89V-223), AEROSTAR. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .