2020 Ford E350 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Ford E350, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical150.0%
- Powertrain (other)150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2022 Ford E-350. The contact stated while driving approximately 25 MPH the check engine warning light illuminated. The vehicle was taken to the dealer who diagnosed the failure to be a misfire on cylinder #3 and the spark plugs were faulty. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 2,486. The VIN was invalid.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The component that failed was the transmission system, specifically the CDF clutch cylinder, the torque converter, and the front support structure. The transmission was found to contain metal debris, burned clutch components, and damage to internal bushings and supports. 1. These parts were replaced under warranty by Central Ford in South Gate, CA. I do not have possession of the damaged components, and I cannot confirm whether they remain available for inspection. 2. The failure resulted in loss of power while driving — particularly during gear shifts into 10th gear at highway speeds. The truck also began to shudder violently, and a “Powertrain Malfunction / Power Reduced” message appeared on the dash. This put me and others at risk, especially in high-speed traffic where sudden deceleration or power loss can lead to collisions, particularly for heavy-duty trucks like mine that are often used for towing or hauling. 3. Yes, The issue was diagnosed, reproduced, and confirmed by Central Ford. A full teardown of the transmission confirmed internal damage including: A shifted and burned CDF clutch cylinder Torque converter damage Front support wear and metal transfer Metal debris inside the transmission All affected components were replaced, and the transmission was reassembled and reinstalled. The vehicle was inspected by a Ford-certified dealership (Central Ford). There was no involvement by police or insurance representatives, as the failure did not lead to a crash or claim. Yes. The vehicle displayed a “Powertrain Malfunction / Power Reduced” warning. This occurred in conjunction with loss of acceleration, shuddering, and hesitation when shifting into higher gears (particularly 10th). These symptoms appeared shortly before I brought the truck in for service on [XXX]. This failure happened at relatively low mileage for a heavy-duty truck that is used primarily for regular driving and light commercial use. I am concerned that this is part of a bro INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .