2019 Ford Ecosport Electrical Problems

The contact owns a 2019 Ford Escape. The vehicle was initially taken to the local dealer for NHTSA Campaign Number: 26V011000 (Equipment). The vehicle was taken back to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The contact stated that the engine had overheated. A diagnostic scanner was used to determine that the head overheat protection was active and there was no coolant in the coolant reservoir. The hose was not connected to the heater cooler. The donut gasket was not attached to the exhaust. There were no warning lights illuminated. The contact stated that the O-ring had failed to snap in place. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

NHTSA ID

11723324

Incident

Mar 10, 2026

Mileage

80,000 mi

I bought a used 2019 Ford Ecosport SE in January 2022. I received a recall notice (#23S64: “ENGINE OIL PUMP BELT AND TENSIONER REPLACEMENT FINAL REPAIR”). A paper notice I received from Ford dated June 2024 mentioned a remedy expected in Q1 2025. The estimation was pushed back, and parts were eventually ready in Q3, some time in August. Before I could take my vehicle to a dealership, on [XXX], while driving my vehicle it stalled, smoked, and smoldered. I made no collisions with any other object, person, or vehicle. I called my insurance and the fire department (incident number: [XXX]). I believe the damage was related to the recall. It was described to me that there was even damage to some wiring, as a result of the fire. I called my insurance, and they towed my vehicle to Larry H. Miller Ford Dealership on September 30, 2025. It was scheduled for its first service on October 1, 2025, but technicians inspected it on October 16, 2025. The repair cost exceeded the vehicle’s value, as I needed a new engine and transmission. After long periods without progress and updates, on January 7th, I was informed by the dealership that I’d either be paid or my vehicle would be repaired, but the final decision rested with Ford Motor Company. The dealership had submitted everything, as a service manager with Larry H. Miller told me on January 7, 2026. I called Ford Motor Company and asked for specific repair dates, but I received no more information than from the dealership. I was told by the dealership that I should have an answer on repairs “by the end of the week”on January 26, 2026, but it’s now February 3, 2026. I’ve been without a vehicle for four months, impacting my flexibility and affecting my vehicle loan. I accepted a loaner vehicle on January 7, 2026. I seek a prompt and fair resolution, whether it’s a payment or a repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11715191

Incident

Aug 29, 2025

my ford EcoSport had to get a new motor due to teh recall issue but since they put a new motor my ac and heater had to be replaced. my battery. my sensors pop on and off. My car won't go over 65 and when it does it jerks. Ford did replace the motor but ive asked for them to buy the car back and they have refused my car has completely shut off and ive taken to ford and they don't know. i have the poofe code and my gas could be full and driving it 5 minutes im on e. they dont know if its the sensor or the tank. i always smell something burning. ive asked they said thats normal, but the smell gets stronger and stronger.

NHTSA ID

11708617

Incident

Nov 9, 2024

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The contact stated that the vehicle failed to start. No warning lights were illuminated. A mobile mechanic stopped by the residence, removed the battery, and took the battery to a specialty shop to be tested. The mobile mechanic returned to the residence and tested the vehicle, and diagnosed that the alternator had failed and needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,500.

NHTSA ID

11687322

Incident

Sep 8, 2025

Mileage

31,500 mi

Vehicle is 5 years old and the APIM went. Expensive part/repair and a main function of the vehicle. Cannot fix, update, or even reset the radio now.

NHTSA ID

11653100

Incident

Jan 1, 2025

Powertrain Malfunction/ reduced power Vehicles emission control system The service light has been 3 months after car was purchased in 2023. Dealer claim to fix recall but a week later same light same issues. They fixed car with recalled parts.

NHTSA ID

11651985

Incident

Nov 26, 2023

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the main control screen had blacked out and the safety features including the back-over prevention camera was inoperable. The contact stated while driving 60 MPH, the message that the vehicle was overheating was displayed on the dashboard and the vehicle decelerated to 9 MPH. The contact was able to exit the highway and pull over. The vehicle was towed to the dealer and the contact was informed that the recall repairs would begin in 2025. The manufacturer was made aware of the issue. The failure mileage was 73,000. VIN tool confirms parts not available.

NHTSA ID

11630573

Incident

Aug 13, 2023

Mileage

73,000 mi

ABIM MODULE FOR THE TOUCHSCREEN AND RADIO WENT OUT. CAR BROKE DOWN DUE TO RECALL 23V905 04/2024. RADIO WORKED AT THIS TIME. TOWED TO FORD AND THEY REPLACED THE PART. BUT NOW RADIO DOESN'T WORK AND BATTERY WAS DEAD. CAR WAS JUMPED OFF AT FORD DEALERSHIP AND DRIVEN 3 MILES DOWN THE ROAD, GOT BATTERY REPLACED. RADIO STILL DIDN'T WORK AND CHECK ENGINE LIGHT CAME ON. TOOK BACK TO FORD DEALERSHIP. THEY KEPT CAR AND SAID TIMER ON THE MOTOR WAS OFF AND THAT STILL WAS COVERED UNDER THE RECALL 23V905. BUT THEY TOOK ZERO RESPONSIBILITY FOR THE RADIO GOING OUT. CAR HAS < 90K MILES ON IT. FORD IS NOW TELLING ME THE ABIM MODULE WENT OUT AND WILL BE $3K TO FIX. THE CAR IS JUNK!!!!!!

NHTSA ID

11607310

Incident

Aug 8, 2024

Unknown While i was driving on the highway my car stopped in the middle and a load noise was coming low engine oil pressure i got the car home safe since it was Saturday the dealership was closed i Was with my elderly mom in the car at the time i had to wait Monday morning i called ford and was told to Tow it or bring it in couldn’t drive it so i had it towed I towed the car to a ford dealership and paid out of pocket for the tow the service rep at ford service rep Santiago try to assist me i was advise to contact Ford Customer service program which i did and spoke to 4 different reps and a supervisor requested a manager i was hung up 3 times i don’t mind my car takes time to be worked on but i don’t have a car to drive to work or take my elderly mother that’s really sick to her appointments . I just purchased this car late November 2023 i haven’t had the car for only 8 month has 55,000 miles when purchase it still paying for the loan and insurance and now without this i don’t have a car it can take 5-7 Bds for the issue to be inspected i can’t wait that long i contacted ford and i was told there’s nothing they can do for me at the moment and i would have to wait . This is so frustrating and annoying and disrespectful and disgusting that i am not getting anyway .

NHTSA ID

11605192

Incident

Jul 27, 2024

On April 2nd, my cars dash said “low oil engine pressure” with a severe dinging noise. I got an oil change and they said to take it to a mechanic, my local mechanic said the oil pump belt drive was at a loss of pressure, resulting in damage to my engine and oil pump. On 4/2/24 My local mechanic refused to fix it due to the recall and said that it should be fixed at Fords expense. On 4/14/24 I got my car towed to the Ford Dealer with my AAA membership, by the next day 4/15 I talked with service and we did not agree to a diagnosis because I knew parts would be out regardless of the diagnosis due to the Letter I received. The dealership was insisting on a diagnosis but I could not afford it out of pocket and Ford agreed that regardless of what the diagnosis said, parts for the low oil engine pressure are not available and could not be expedited because my vehicle doesn’t run. They said my car could only sit for two weeks at the dealership since it is not actively seeking parts. They are looking for me to pay out-of-pocket until the program becomes available when the second part of the issue for recall is noticed. Ford issued a recall but said parts wouldn’t be available until approximately August/24 or possibly later. Ford has not offered me any solution to this matter and they are not taking accountability for putting a defective product on the road. I have seen over 136k Ford Ecosport models 2018-2022 have been reporting this issue. My car is unsafe to drive.

NHTSA ID

11584227

Incident

Apr 2, 2024

The contact owns a 2019 Ford EcoSport. The contact stated that while driving at 45 MPH, the vehicle jerked and stalled. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that an unstated wiring needed to be replaced. The vehicle was repaired. The manufacturer was contacted, but no assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The failure mileage was unknown.

NHTSA ID

11581857

Incident

Apr 9, 2022

I was driving down the highway and lost complete power. Luckily was able to pull on shoulder before being hit by other vehicles on the road. Ecosport would no longer power on. Had towed and learned that the timing belt had failed due to lack of oil pressure. According to ford, the only way to fix the issue was by replacing the entire motor which took over 3 months to repair. The new motor sounds terrible and scares me every day now. I’m just waiting for a repeat.

NHTSA ID

11563942

Incident

May 11, 2023

After a few near death experiences and being stranded several times, my 2019 Ford EcoSport has had a new Sync 3 system, EVAP, and 2 “new” engines. And it’s still not functioning properly. (Was shooting out black smoke, jerking, stalling, screen blackout.) Jerking and the screen blacks out. But according to Ford, it’s ok to drive. Might be the transmission -after a complete diagnostic test and test drive. The car cuts off (not from the start/stop feature).

NHTSA ID

11563353

Incident

Oct 31, 2023

Mileage

124,000 mi

My cars low engine oil light came on suddenly and then the engine started making noises. Full on oil and not leaking. Mechanic says it’s an internal issue and will be $5600 to repair. I already have an electrical issue with the A-pin that Ford said was $3000. It never got repaired because they never contacted me saying the part was in. The engine issue has a recall for the year make and model of my car but my car was built 7 days after the cut off. That date needs to be changed to include my car since it’s the same exact issue according to the mechanic.

NHTSA ID

11535528

Incident

Jul 28, 2023

It began with having issues with power window sometimes not going up or down, then I started to have problems with the compass on the car always pointing north, then the car lost access to bluetooth and the sync 3 system refused to update. From there the issue with the radio not coming on started and was advised to do master reset, soft reset, then hard reset. Did this multiple times and now the display no longer comes on at all. I have lost the ability of my rear camera, cannot use USB ports and 12v. I have no access to radio, bluetooth, carplay of any kind, went to the dealer about it and they said the APIM module is bad and it will cost around $4,000 to replace. That is ridiculous. This car has been nothing but trouble since about 2 weeks after the warranty expired. I cannot afford to get the thing repaired and am too underwater on the loan to trade it in for a new car. I will never buy a ford again and I've been buying cars from ford for 13 years. This issue needs to have a recall because I have read thousands of reviews about this same issue.

NHTSA ID

11527413

Incident

Sep 20, 2022

Since I leased this car, I’ve had three transmission replacements, a full wiring harness replacement, numerous electrical issues with the display, and now can’t drive it due to engine low oil pressure. This car is nothing but a nightmare.

NHTSA ID

11475496

Incident

Jul 23, 2022

The contact owns a 2019 Ford Ecosport. The contact stated that while driving at an undisclosed speed, the brakes seized and the vehicle lost motive power. The check engine, battery, and ABS warning lights were illuminated. The contact replaced the battery; however, the failure recurred. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with NHTSA. The failure mileage was approximately 55,000.

NHTSA ID

11463937

Incident

Apr 9, 2022

Mileage

55,000 mi

I WAS A STOP LIGHT AND THE VEHICLE SUDDENLY SHUT OFF AND WOULD NOT LET ME RESTART IT. AFTER AWHILE AND A FEW WARNING SYSTEMS THE VEHICLE FINALLY TURNED OVER. AFTER THAT THE ENGINE LIGHT CAME ON AND THE VEHICLE STARTED TO RUN A DIAGNOSTICS WHICH I WAS UNABLE TO SEE. AS I BEGIN TO DRIVE AGAIN THE VEHICLE STABILITY CONTROL CUTS OFF AND CAUSES ME TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. AS I'M REGAINING CONTROL OF THE VEHICLE THE TRACTION CONTROL TAKES OVER AGAIN AND HELPS ME OUT. I'M NOT SURE AS TO WHAT HAPPENED TO MY VEHICLE STILL WAITING FOR THE DEALER TO GET BACK TO ME. BUT WHATEVER IT WAS IT WASN'T SAFE AND PUT ME IN A DANGEROUS SPOT DURING RUSH HOUR TRAFFIC

NHTSA ID

11298833

Incident

Jan 8, 2020

Mileage

21,000 mi