Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2020 Ford Escape Hybrid submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 41 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 41, in the owner's own words
Changed 12V battery because liftgate was inconsistently opening. Would click but not release. I have tried the resetting the system with accessory mode, pressing brake and flashing highbeams, have disabled liftgate and reenabled liftgate, have even tried the emergency release under access panel and it still will not open but clicks.
The vehicle is just under 37K miles. I was operating the vehicle normally, and the wrench icon came on, indicating a powertrain issue. There are recalls for this for some vehicles but not all, and it seems to occur just after warranties expiring. I am concerned my vehicle falls under this service bulletin but has not been properly added: SSM 49157 - 2020 Escape - Illuminated MIL With DTCs U0100, U0401, P166B, P1753, P0929, And/Or P0919 Some 2020 Escape vehicles may exhibit an illuminated malfunction indicator lamp (MIL) and diagnostic trouble codes (DTCs) U0100, U0401, P166B, P1753, P0929, and/or P0919. The vehicle may also exhibit an illuminated powertrain malfunction (wrench) indicator lamp. This may be due to the software in the gear shift module (GSM). To correct the condition, reprogram the GSM using the latest software level of the appropriate Ford diagnostic scan tool. For claiming, use causal part number 7P155 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual. APPLICABLE VEHICLES 2020 CAR: TC CX482N ESCAPE 2020 CAR: TC CX482N ESCAPE 2020 CAR: TC CX482N ESCAPE
The hybrid battery coolant line has a leak and is available for inspection. Driving the vehicle with this leak can compromise the battery resulting in overheating which could cause the vehicle to break down, fire, or burn. The dealer confirmed the leak. The dealer was a manufacturer dealer and they inspected the vehicle. There were no indications of a leak.
Whenever I shut off my 2020 Ford Escape Hybrid or when I am about to turn it on, a message appears on the touchscreen that says: "System off to save battery, please turn ignition off or start engine." I have replaced the battery but I get the same error message. When I took the car to Firestone, they performed a Diagnostic which did not indicate that there was anything wrong with the battery. When I spoke to a Hybrid Battery Specialist, he told me that the error message was for my "12 volt battery. It is a fairly common problem with your Escape. The Ford dealership may have a fix for it. It is possible that you just need to replace the 12 volt battery." My local Ford Dealership did not have a fix for it. Since this is a fairly common problem with the Ford Escape, I think a recall should be issued to have Ford rectify the issue.
I have received 2 letters from manufacturer, than I had appointment dealer service, I went there and worker sad to me we don't have it, than I tried another services , they same answer, than I contacted ford, ford told to me car is good condition don't need replacement
Upon purchasing and receiving the car from a dealership, I attempted to drive it around my neighborhood and after about 1 minute received a warning saying "safely stop now!" and the steering wheel locked and the power shut off in the middle of the street. The car would not turn back on and had to be towed to the dealership. The dealership (not Ford) already replaced the battery and that did not fix the issue. They are having to take it to Ford service to get it looked at. This poses a very significant safety risk because it could have happened on the highway, as some Ford Escape users have reported on forums. Before purchasing the car, all available recalls were addressed and "resolved", but clearly not all issues have been fixed.
We were traveling to Springfield MO and just before Strafford our 2020 Ford Escape Hybrid SE flashed a wrench warning on our screen and immediately went into limp mode in rush hour traffic on I-44. We were in the passing lane going up a hill at the time passing a commercial truck and our speed dropped significantly. Luckily the vehicles behind us to were able slow down in time.
The contact owns a 2020 Ford Escape. The contact stated while the vehicle was parked, the display screen on the instrument panel intermittently went black. No warning light was illuminated. The vehicle was driven to the dealer to be diagnosed. The contact was informed that the sync system needed to be replaced. The vehicle was repaired. The contact researched online and became aware of Customer Satisfaction Program Number: 24B47; however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 65,000.
My escape continues to shut down after parking and will not restart. Push button light will sometimes turn green but will not come on , dial to P flashes but will not move . Sometime I can quickly jump it off and it restarts but most recently and to get someone to disconnect both batteries and reconnect and it will start … it acts like it has to restart the electrical system . I have seen many examples of others having the same issues
Was driving the car when it suddenly went dead with the following message on the screen: “Vehicle network communication error”. By chance I happened to be able to coast off the road otherwise i would have been stranded on a very busy road. The vehicle was towed to a Ford dealer where the problem was reproduced, the car has been at the dealer for 1 week now with no idea what the problem is. There was no warning prior to the error appearing and the vehicle completely stopping. Reviewing Ford forums there are at least two other instances of this happening. Do not have any repair information yet as it is not fixed and the solution is unknown at this time.
The contact owns a 2020 Ford Escape. The contact stated that while trying to turn the inside vehicle lights, she accidently pushed the sunroof button. The sunroof cover broke. The vehicle was taken to the dealer, where it was diagnosed with the entire sunroof needing replacement. The vehicle was not repaired. The contact states that is a safety hazard because the vehicle gets extremely hot without the sunroof cover. The manufacturer was made aware of the failure and advised the contact to call the dealer. The failure mileage was approximately 34,500.
A software update to the SYNC 3 system was sent out to my vehicle after the update took place the radio system as well as navigation, backup camera, and self parking all failed to work. And the system never turned back on again. After diagnosis from Ford dealership it was declared that the APIM needs to be replaced. I tried to voice my problem to ford corporate via phone calls, emails, and letter and they did not acknowledge that the problem was from the update.
entertainment system needs to be reset multiple times a day. bluetooth does not connect to the same cell phone i have been using and needs to be re-connected manually every time I start the car. stereo and gps are non-responsive and require restart to properly operate. Bluetooth needs to connect automatically to my phone.
Driving the 2020 Ford Escape it completely shut down during a rain storm requiring us to pull off the main road coasting to a stop. Very concerned with the fact that The emergency flashers did not function and the rest of the dash and LCD panel went black. After 20 minutes I was able to get the vehicle started but the check engine light was illuminated and I was able to drive the 1/2 mile home. The car is in our driveway and I have a service appointment on 3/6. With this potential problem in place I do not want to drive it if it will shut down in the middle of the interstate highway.
The contact owns a 2020 Ford Escape. That contact stated that upon entering the vehicle, the driver's side door opened abnormally wide, after which the driver's side door became jammed. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed failures with the high-low voltage converter and the door check arm attachment point. The voltage converter was repaired, but the door check arm attachment point was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure, and a case was opened. The failure mileage was 21,500.
I was driving home in my 2020 Escape Hybrid, a 2 1/2 hour trip. All of a sudden, 40 miles from home and as I was driving on a busy expressway just before nightfall, my info screen and the main screen went black. The info screen said there was a connectivity error. I had no idea what was going on, but I was terrified that my headlights would go out. Luckily, there was an exit coming up, and I took it and parked at the gas station right off the exit. I called AAA for a tow. They had to put the car on a flatbed truck, as once I had turned the car off it wouldn’t start again, so I couldn’t put it into neutral. I got towed home, as the dealership was closed; and the next morning I got towed to the dealership. I was told by the service advisor that the battery had a bad cell. Since this was the second battery that died within a year, the dealership replaced it for free. I’m on a Ford Escape Hybrid forum, and there are many people who have had the same problem with the 12 volt battery. It was suggested to replace the battery with a larger AGM battery. I was lucky there was an exit right there. If I had driven the car any longer, I probably would have lost my headlights and the whole car would have died. And I could have been killed. This is a life-threatening issue that Ford should fix by replacing the battery with a larger one that has enough power to run the car and thus won’t fail prematurely. I’m scared to drive my car now.
This recall is very serious, I do not feel safe driving my car as it could explode and kill me, and or others. No eta on a serious recall, even though I am being forced to pay for repairs, and possibly cause more damage to my engine for this serious recall.
I purchased the vehicle brand new in February 2020 and it has had persistent battery/electrical issues. In May 2022 the battery was malfunctioning and I was driving it to the dealership to be examined and it completely died while I was driving. The electrical system failed while I was driving. I have had the battery replaced at least 3 times in less than 4 years and, despite the battery being replaced less than a year ago, it needs to be replaced again. Ford is not willing to cover the replacement battery despite it being less than 1 year ago. Ford is not standing by their vehicle and refusing to accommodate the repeated battery issues, including catastrophic failure while driving.
There is an issue with the instrument gauge cluster upon ignition start-up. The digital gauge cluster screen suddenly turns off and restarts after a full minute of turning on the car's ignition. After an automatic software restart of the gauge cluster and driving on the highway through Northbound Mopac Loop 1 in Austin, the cluster shows a frozen black background with the blue normal drive mode. The gauge cluster works fine but intermittently goes blank after starting the car.
2020 Ford Escape hybrid titanium: Complete electrical shut down of every electrical component, all interior/exterior systems inoperable, including inability to start engine. Manual key required to open door. Initial attempts to jump start do not work - takes numerous attempts to jump start until car by chance ‘wakes up’. Battery charging will not help and low charge on starter batter is not the issue. Parking brake release not possible for towing since no electrical to release parking brake. Car is not equipped to manually disengage parking brake - contrary to what is written in manual. Therefore is a problem for towing company if they do not have dolly's to place on flat bed. Software update is required at dealership to solve issue. In the meantime, you can get seriously stranded with a dead car. Also far too many recalls placing ever going time consuming burden on owners to deals with problems after shipping from the manufacturer.
1) Head unit not powering up. No backup camera no cross traffic alert. 2) Power train light has come on three times. Dealership is unable to find any issues 3) Starting battery keeps failing. Fourth battery in three years getting installed today.
Vehicle lost power steering and acceleration in the middle of a busy intersection
Vehicle has gone stone dead on two occasions with no electrical response of any kind. Physical key was required to unlock. First was 11/21/22 at 9,733 miles. Vehicle spent 10 or so days in the shop while problem was traced and some warranty work was done. Second was 3/11/23 with same symptoms. Dead first thing in the morning. Mileage was 12,470. Based on first experience, purchased a robust charger and brought the car to 100 charge and problem solved for the short term. Online forums mention this as a common problem for this and the 2021 Escape hybrids. Fix seems to be getting a larger AGM battery which, with its greater capacity and faster charging capacity can better handle the parasites in the electrical system. In the runup to both 'deaths' the vehicle's computers began shutting down accessories such as remote start, handle touch unlocking, etc. All I ask is a replacement of the 12 volt battery with the larger 70aH AGM battery (Ford part BAGM48H6760). My wife and I have one car. She has a disability. I purchased this car to give her easier entrance and exit. It never occurred to me that it would not start reliably.
Vehicle enters deep sleep mode within minutes of parking and won’t start again until it is jump started. This software problem has left me stranded three times.
Reoccurring simultaneous failures of safety systems "Cross Traffic System Fault ", "Blind Spot System Fault", complete climate panel failure (defroster, heater, ventilation, ...), accompanying failures of power windows, power seats and most recently the ability to open the rear hatch of the SUV. Warnings about intermitent "Drive Mode Not Available". All of the above can occur suddenly when driving or at starting. Windows fog suddenly.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .