Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2020 Ford Escape Hybrid submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
While filling the gas tank with fuel the fuel spits back causing an unsafe condition. There is a technical service bulletin for this by Ford (number 22-2433), but no recall. Many people have complained about this condition.
I have received 2 letters from manufacturer, than I had appointment dealer service, I went there and worker sad to me we don't have it, than I tried another services , they same answer, than I contacted ford, ford told to me car is good condition don't need replacement
The contact owns a 2020 Ford Escape. The contact stated while refueling the vehicle at the gas station, fuel was splashing out of the fuel filler neck. The contact stated that upon attempting to refuel the vehicle again, the gas pump nozzle unintendedly stopped several times and fuel splashed onto the contact; however, the fuel tank was not full. Additionally, the check engine warning light was illuminated. The message "Service Engine Soon" and other unknown messages were displayed on the Ford Mobile App. The vehicle was taken to the dealer, where it was diagnosed and determined that the canister purge valve was blocked and was obstructing the fuel circulation. The dealer determined that the fuel lines, the fuel system valves, and the canister purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 43,578.
My vehicle is continuously triggers a check engine light, which goes on and off. It states on the FORD APP that the engine is detecting that the exhaust gas recirculation system flow is higher than expected for the operating conditions. I have repeatedly requested that this be evaluated but every time I go in for service they tell me that they will not look at it unless the check engine light is on (Which it goes on and off all the time with the same record) and they refuse to go off the check engine history on my APP. There is also a sound coming from my driver side tailpipe that is low sound at idle but increasing whines/chirps during acceleration. I can't say for sure, but I believe these are tied together and the dealership tells me that i have to leave my car with them for at least 4 weeks for them to even take a look. I supposedly got an OTA update to resolve this issue, but it hasn't worked. Check engine light is still on and off.
Recall came out in May. Still no remedy....
The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that there was an abnormal gasoline odor inside the cabin of the vehicle. The failure mileage was approximately 19,000. VIN tool confirms parts not available.
The contact owns a 2020 Ford Escape. The contact stated that while refueling the vehicle, fuel started to spill out of the filler pipe onto the ground. The contact stated that during the failure, no fuel had entered the fuel tank. The vehicle was taken to the local dealer who diagnosed that the fuel tank filler pipe had failed and needed to be replaced. The fuel tank filler pipe was replaced, and the vehicle was fixed. The manufacturer was not notified of the failure. The failure mileage was 15,400.
MY CAR HAS SUFFERED A SUDDEN AND COMPLETE LOSS OF ENGINE POWER WHILE DRIVING AT FULL SPEED ON THE HIGHWAY. THIS HAS HAPPENED ON TWO OCCASIONS. THESE WERE VERY, VERY DANGEROUS SITUATIONS. EACH TIME IT WAS ONLY THROUGH GOOD LUCK THAT WE WERE ABLE TO MAKE IT ACROSS TWO LANES OF SPEEDING TRAFFIC IN A CAR WITH NO ENGINE POWER TO PULL OFF ON THE SHOULDER OF THE HIGHWAY. AFTER THE CAR WAS SHUT DOWN FOR A FEW MINUTES, IT RESTARTED EACH TIME. THE FIRST OCCURRENCE HAPPENED IN JUNE, 2020, WHILE DRIVING WITH MY CHILD. I NOTICED RIGHT AFTER THAT FORD HAD ISSUED A RECALL/UPDATE NOTICE FOR MY CAR THAT SEEMED TO BE ABOUT THE PROBLEM THAT CAUSED THE LOSS OF POWER. IT WAS DESCRIBED AS A "20B14 POWERTRAIN CONTROL MODULE UPDATE". I HAD THIS RECALL/UPDATE DONE BY A FORD DEALER ON JULY 24TH, 2020. I ASSUMED THAT THERE HAD BEEN A DEFECT IN THE CAR'S OPERATING SYSTEM, BUT THAT THE RECALL/UPDATE HAD FIXED THE PROBLEM. THEN, YESTERDAY, APRIL 9TH, 2020, THE SAME THING HAPPENED AGAIN. MY WIFE AND CHILD WERE DRIVING ON THE HIGHWAY AND THE CAR HAD A SUDDEN AND TOTAL LOSS OF POWER, AND IT WAS ONLY THROUGH GOOD LUCK THAT THEY AVOIDED A TERRIBLE ACCIDENT AND GOT THE SHOULDER OF THE ROAD. I NOTICED THAT NIGHT THAT FORD HAD SENT ME AN AUTOMATIC MESSAGE TO MY PHONE SAYING "THE HYBRID POWERTRAIN CONTROL MODULE HAS DISABLED THE GASOLINE ENGINE FUNCTION DUE TO AN ADDITIONAL CONCERN BEING DETECTED." I BROUGHT THE CAR INTO THE FORD DEALER TODAY AND THEY TELL ME THAT THEY UPDATED THE OPERATING CODE OF THE VEHICLE TO ADDRESS THIS KNOWN PROBLEM WITH "OPERATION NO. 212080A" TO SUM UP, MY CAR HAS NOW STOPPED DEAD ON THE HIGHWAY AT FULL SPEED ON TWO SEPARATE OCCASIONS BECAUSE OF AN OPERATING SYSTEM ERROR. THERE MUST BE A DEFECT IN EITHER MY INDIVIDUAL CAR OR IN THIS MODEL OF CAR FOR A PROBLEM THIS SERIOUS TO HAPPEN TWICE.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .