2004 Ford Escape Fuel system Problems

The contact owns a 2004 Ford Escape. The contact stated while driving 45 MPH, he heard an abnormal noise coming from the rear of the vehicle and started to smell fuel in the vehicle. The contact stated no warning light was illuminated. The contact was able to park on the side of the road and noticed the fuel tank straps were corroded and had caused the fuel tank to detach from the vehicle. The contact stated he manually taped the fuel tank straps and drove to his destination. The contact took the vehicle to the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA ID Number: 10183774, however his year, make and model were not included. The manufacturer had been informed of the failure. The failure mileage was approximately 160,000.

NHTSA ID

11450444

Incident

Feb 1, 2022

Mileage

160,000 mi

MY 04 FORD ESCAPE HAS A 4 CYLINDER AND IS A MANUAL. IT HAS BEGUN TO ACCELERATE BY ITSELF. IT WILL ACCELERATE WHETHER IT IS IN GEAR OR IN NEUTRAL. I ASSUMED THERE WOULD RECALL FOR THIS PROBLEM, AS I KNOW OTHER VEHICLES HAVE BEEN IN SERIOUS ACCIDENTS WITH SIMILAR PROBLEMS. I CAN TAKE MY FOOT OFF OF THE PEDAL AND IT WILL STAY AT A STEADY SPEED, OR ACCELERATE, ON ITS OWN. OFTEN WHEN I'M SWITCHING GEARS, PUT IT IN NEUTRAL, IT WILL SELF-REV ITSELF UP TO 4000+ RPMS! I WILL HAVE TO WAIT AND COAST FOR ABOUT 10 TO 30 SECONDS FOR IT TO BRING ITSELF BACK DOWN TO A REASONABLE RPM TO GET IT INTO THE NEXT GEAR. SO, IT IS INTERMITTENT, BUT HAPPENS ABOUT 50% OF THE TIME YOU ARE DRIVING IT, AND AT TIMES CAN BE VERY DANGEROUS. I ASSUMED FORD MIGHT PAY FOR THE REPAIR AS THIS IS A DANGEROUS SITUATION, HOWEVER MY DEALER SAYS "NO" BECAUSE THERE IS NO RECALL.

NHTSA ID

10994399

Incident

Jun 12, 2017

Mileage

120,000 mi

DRIVING 25 TO 30 MILES PER HOUR THROTTLE STICKS AT 3 RPMS . I HAD TO RIDE BRAKE TO PULL OVER SAFELY. I SHUT CAR OFF AND RESTARTED, IDLE WENT UP TO 3 RPMS AND SLOWLY WENT TO 1 RPM I DROVE CAR HOME WITH NO PROBLEM. I STARTED CAR TODAY WITH IDLE STICKING ON 2 TO 3 RPM BEFORE GOING BACK TO 1.

NHTSA ID

10725099

Incident

Jun 5, 2015

Mileage

282,000 mi

THE CAR STALLS AFTER PUTTING IT IN GEAR / *TR

NHTSA ID

10705155

Incident

Apr 18, 2013

Mileage

52,000 mi

I FIRST NOTICED A SURGING AND SQUEAL TYPE NOISE WHILE COMING TO A STOP. SPOUSE HAD REPAIRED 3 TIMES YET IT CONTINUES. DURING THIS TIME I ALSO HEARD A CLANKING NOISE FROM REAR END AS IF HATCH (WINDOW/DOOR) WAS NOT SECURELY CLOSED BUT THEN ASSUMED IT MAY BE RELATED TO THE AFOREMENTIONED ISSUE. I MENTIONED NOISE INCREASED, LOUD, FRIGHTENING (STEERING DIFFICULTIES). HE CONTACTED FORD BY PHONE (X3) AND EMAILED HOWEVER THEIR REPLY WAS NO FATALITIES OR INCIDENTS HAD BEEN REPORTED THEREFORE WE HAVE 2 OPTIONS. 1) TAKE IT TO A FORD DEALER FOR REPAIR AT OUR EXPENSE, 2) TRADE IN FOR A NEW FORD VEHICLE. BOTH SCHOOL/CITY/GOVT EMPLOYED AND CANNOT AFFORD 2000.00 TO REPAIR. YESTERDAY MY HUSBAND REMOVED THE ENTIRE RIGHT SHOCK WHEN I RETURNED HOME FROM WORK AFTER A 12 HR DAY & TOLD HIM I FELT AS IF THE BACK END WAS GOING TO FALL OFF & CLANKING SOUND INTENSIFIED. AT 8PM HE WAS LAYING UNDER CAR ON GARAGE FLOOR AND FOUND THE SHOCK HANGING! HE WAS FORCED TO REMOVE AS I HAD TO WORK THE NEXT DAY AT 6AM. I AM DRIVING WITHOUT ONE SHOCK, NEW TIRES, RUSTED REAR FRAME AND SURGE CONTINUES. I WOULD APPRECIATE ANY SUGGESTIONS AS TO OTHER AVENUES FOR REPORTING. I HAVE 2 COWORKERS WITH SIMILAR ISSUES, BOTH ESCAPES. THE REMOVED SHOCK IS RUSTED, NEAR CRUMBLING OF SORT BUT SAVED ALONG WITH SEVERAL PHOTOS. THANK YOU IN ADVANCE FOR REVIEWING MY LENGTHY EMAIL AND LOOK FORWARD TO ANY INPUT AND RECOMMENDATIONS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 1/21/15 *JS

NHTSA ID

10598270

Incident

Jun 5, 2012

WHILE DRIVING, THE THROTTLE STUCK. APPLIED THE BRAKES, BUT VEHICLE WAS DIFFICULT TO SLOW AND TACHOMETER INDICATED HIGH ENGINE SPEED. SHIFTING TO NEUTRAL, THE ENGINE RPMS PUT THE NEEDLE IN THE RED BEYOND THE GAUGE. AFTER SHUTTING OFF THE VEHICLE, AND OPENING THE HOOD THE PROBLEM DID NOT PERSIST, BUT RETURNED AFTER DRIVING AGAIN. *TR

NHTSA ID

10563755

Incident

Feb 7, 2014

Mileage

142,000 mi

ALL THREE OF THE CATALYTIC CONVERTERS FAILED TO OPERATE IN THE CAR. WE WERE INITIALLY TOLD THAT THE CONVERTERS WERE UNDER WARRANTY BOTH FOR MILEAGE AND TIME (8 YEAR/80,000 MILE WARRANTY). DEALERSHIP REQUESTED CAR BE BOUGHT, WHICH WE DID. AFTER THE CAR ARRIVED, WE WERE TOLD THAT THE CAR WAS MANUFACTURED IN JANUARY 2004 AND THAT THE WARRANTY EXPIRED IN JANUARY 2012. ADDITIONALLY, THEY WANT TO CHARGE US OVER $3,000 FOR THE REPAIRS. I ALSO ADVISED THEM THAT WE PURCHASED AN EXTENDED WARRANTY IN NOVEMBER 2007 WHEN THE CAR WAS PURCHASED FROM CARMAX. WE WERE ADVISED THAT THE EXTENDED WARRANTY WOULD NOT COVER EITHER. MY CAR REMAINS AT THE DEALERSHIP BECAUSE WE CAN NOT AFFORD TO REPAIR IT, HOWEVER, WE ARE STILL MAKING THE CAR PAYMENTS ON IT. I CONTACTED FORD MOTORS, FILED A REPORT AND WAS LATER ADVISED THAT THEY COULD NOT DO ANYTHING FOR ME. *TR

NHTSA ID

10474182

Incident

Mar 1, 2012

Mileage

58,000 mi

AS I WAS ACCELERATING TO PASS A SLOW MOVING VEHICLE, I PRESSED ON THE GAS PETAL AND AFTER I WAS BACK IN MY PROPER LANE, MY VEHICLE KEPT SPEEDING AND NOT BACKING OFF ON THE GAS. I THEN PUT THE CAR IN NEURAL AND THE ENGINE CONTINUED TO KEEP RACING. I TRIED TO STOMP LIGHTLY ON THE GAS PETAL TO SEE IF IT WOULD COME BACK UP BUT IT DIDN'T. I THEN SHUT OFF THE ENGINE AND CALLED THE TOW TRUCK COMPANY. *TR

NHTSA ID

10466470

Incident

May 3, 2012

Mileage

157,100 mi

I WOULD LIKE TO ADD MY COMPLAINT TO THE ACCELERATION PROBLEMS OF THE 2001-2004 FORD ESCAPES WHICH MY 2004 HAS ALSO EXPERIENCED. THERE HAVE BEEN A FEW SITUATIONS OVER THE LAST 2-3 YEARS WHERE MY CARS ENGINE WOULD SUDDENLY START RACING WHILE PARKED AT IDLE. WHEN THE ISSUE FIRST BEGAN I WAS ABLE TO TAP THE GAS PEDAL WITH MY FOOT AND THE CAR WOULD RETURN TO A STANDARD IDLE. THE MORE RECENT INSTANCES NOW REQUIRE TURNING THE VEHICLE OFF AND IT WOULD IDLE NORMAL AGAIN AFTER BEING RESTARTED. I BELIEVE THIS PROBLEM IS CONNECTED TO A CURRENT INVESTIGATION AND THE LETTER DATED 7/10/12 WRITTEN TO FORD FROM THE CENTER FOR AUTO SAFETY. THIS MAY ALSO BE CONNECTED TO A PRIOR RECALL 04V-574 THAT I WAS RECENTLY MADE AWARE OF. PLEASE KEEP ME ADVISED OF YOUR EFFORTS OR ANYTHING I CAN DO TO HELP. THANK YOU *TR

NHTSA ID

10466369

Incident

May 15, 2012

Mileage

76,000 mi

AT FIRST, MY ESCAPE ONLY STARTED HESITATING ON RAINY DAYS WHEN I GOT TO ABOUT 45-55 MPH. AT FIRST I THOUGHT I HAD BAD GAS SO I STOPPED AT AUTO ZONE TO GET DRY GAS FOR IT. THIS SEEM TO WORK LIKE A CHARM AND I THOUGHT THE PROBLEM WAS FIXED. THEN IT HAPPENED AGAIN; SPUDERING, NOT ACCELERATING, CAR SHAKING, AND ENGINE LIGHT BEGAN TO FLASH ONCE I REACHED 45MPH. THIS HAD BEEN AN ISSUE FOR A FEW MONTHS ON AND OFF, THEN ONE SUNNY DAY ITS BEGAN HESITATING AND MISFIRING VERY BADLY NOW NOT ONLY IN 5TH GEAR BUT AT IDLE AND 1ST GEAR. IT MISFIRED AND HESITATED EVERY TIME I DROVE IT FOR A WEEK BEFORE THE MECHANIC COULD GET IT INTO THE SHOP. I DID A LOT OF RESEARCH ON THE TWO CODES THAT THE ENGINE WAS PULLING P0305 AND P0316 PENDING. I FOUND OUT THAT THERE WERE A LOT OF PEOPLE WHO HAD THE SAME PROBLEM AS ME WHEN THEIR ESCAPES REACH 90,000 MILES OR HIGHER, SOME EVEN WORSE. PEOPLE ARE SAYING THAT THE ISSUES BEING CAUSED ARE A RESULT OF FORD PUTTING IN THE WRONG SPARK PLUGS WHICH IS CAUSING THE COMPUTER CHIP TO BURN OUT LEADING TO MISFIRES IN THE COIL PACKS. MY MECHANIC JUST INFORMED ME THAT IT WILL COST $400 TO FIX TWO OF THE COILS AND THERE IS ONLY A 50/50 CHANCE THAT IT WILL FIX THE PROBLEM (FOR NOW). HE SAID IT WILL PROBABLY HAPPEN AGAIN BUT THERE IS NO TELLING HOW LONG THAT MIGHT BE, IT MIGHT BE RIGHT AWAY, A WEEK FROM NOW, OR A YEAR. WILL ALL THESE PEOPLE HAVING THE SAME ISSUE WITH NO WAY TO TELL IF IT IS ACTUALLY GOING TO FIX THE PROBLEM THERE SHOULD BE A RECALL OR AT LEAST A WARNING TO OWNERS SAYING WHAT MAY HAPPEN ONCE THE CAR GETS OVER 100,000 MILES. *TT

NHTSA ID

10459090

Incident

Mar 6, 2012

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START HOWEVER, ALL OF THE ELECTRICAL COMPONENTS WERE WORKING NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT HAD THE FUEL PUMP REPLACED. FIVE YEARS PRIOR TO THE MOST RECENT FAILURE, THE SAME FAILURE OCCURRED AND THE VEHICLE WAS TAKEN TO THE DEALER WERE THE FUEL PUMP WAS REPLACED FOR THE FIRST TIME. THE VEHICLE WAS NOT RECENTLY REPAIRED FOR THE SIMILAR FAILURE. THE CURRENT MILEAGE WAS 34,000 AND THE FAILURE MILEAGE WAS 14,659.

NHTSA ID

10450621

Incident

Feb 21, 2012

Mileage

14,659 mi

WHILE BODY WORK WAS BEING CONDUCED AT A DEALER FOR A SCRAPED FENDER, DEALER EMPLOYEE STARTED VEHICLE AFTER PAINT OPERATIONS. THE INTAKE MANIFOLD INSTANTLY AND VIOLENTLY EXPLODED INTO SEVERAL PIECES. THE VEHICLE HAS APPROXIMATELY 80,000 MILE, WAS DRIVEN INTO THE DEALER FOR THE BODY WORK, AND HAS HAD NO SIMILAR PROBLEMS. THE DEALER REPORTS THAT THE VEHICLE STILL STARTS AND WILL HOLD AN ROUGH IDLE. THE TIMING BELT IS INTACT. THIS VEHICLE USES DIRECT FUEL INJECTION AND A DRY INTAKE SYSTEM. THE DEALER STATED THAT ALL PROCEDURES INCLUDING PAINTING PROCESS WERE PROPERLY FOLLOWED LEADING UP TO THE EXPLOSION. CAUSE IS UNKNOWN. THE VEHICLE IS STILL AT THE BODY SHOP FINISHING BODY WORK. NO RESOLUTION HAS BEEN REACHED CONCERNING THE MECHANICAL FAILURE. *TR

NHTSA ID

10273925

Incident

Jun 8, 2009

Mileage

82,000 mi

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH THE VEHICLE STALLED. IT WAS PULLED OFF THE ROAD WITHOUT INCIDENT AND TOWED TO THE DEALER. THE FUEL PUMP AND FILTER WERE REPLACED. THREE DAYS LATER THE VEHICLE STALLED AGAIN WHILE BEING DRIVEN 35 MPH. THE VEHICLE RESTARTED AND WAS DRIVEN TO THE CONTACTS RESIDENCE. THE MANUFACTURER WAS NOT ALERTED.

NHTSA ID

10154854

Incident

Apr 7, 2006

Mileage

49,000 mi

IN NOVEMBER OF '03 I BOUGHT THE ESCAPE. NO PROBLEMS ALL WINTER. LAST WINTER OF '04-'05 I WAS HAVING PROBLEMS WHERE THE TRUCK WOULD NOT START UP RIGHT AWAY. THE DEALERSHIP TOLD ME IT WAS THE WINTER GAS AND THEY COULD NOT DUPLICATE THE PROBLEM. AFTER BRINGING IT BACK TO THE DEALER SEVERAL TIMES, THEY FINALLY GOT IT TO DUPLICATE. THEY REPLACED THE OXYGEN CELLINODE. UNFORTUNETLY THE PROBLEM JUST CAME BACK

NHTSA ID

10121758

Incident

Nov 1, 2004

ON FIVE (5) OCCASIONS OF FILLING UP MY 2004 FORD ESCAPE GAS TANK THERE HAS BEEN GAS SPILLAGE. GAS WILL COME FLYING BACK OUT OF THE TANK AFTER THE PUMP CUTS OFF. I TOOK THE ESCAPE BACK TO THE DEALERSHIP AND WAS TOLD NOTHING WAS CLOGGING OR IMPEDING THE FLOW OF GAS. I WAS TOLD NOT TO USE THE AUTOMATIC PUMP BECAUSE THE FLOW OF GAS MIGHT BE TOO FAST. I DO NOT USE THE AUTOMATIC PUMP ANYMORE AND THE PROBLEM STILL OCCURS. WHEN THE PUMP SITS IN THE OPENING FOR THE TANK THE PUMP IS AT AN UNEVEN LEVEL AND EVEN WHEN I PUMP SLOWLY SPILLAGE STILL OCCURS. (IT TAKES 5 MINUTES FOR ME TO GET 8 GALLONS OF GAS. I'VE TIMED IT.) THE PROBLEM HAS OCCURRED AT SEVERAL DIFFERENT GAS STATIONS. I HAVE ALSO TALKED WITH ANOTHER OWNER OF A FORD ESCAPE AND HE/SHE DOES NOT HAVE THIS PROBLEM. I HAVE TO KEEP A FULL BOTTLE OF WATER IN MY CAR TO RINSE OFF THE SPILLED GAS BEFORE IT DRIES ON THE SIDE OF MY CAR. THIS IS AN ANNOYING PROBLEM AND I'M TIRED OF DEALING WITH IT. *NM

NHTSA ID

10106265

Incident

Oct 8, 2004

WHEN FILLING THE GAS TANK, THE AUTOMATIC SHUT OFF WHEN THE TANK IS FULL DOES NOT FUNCTION. THIS LEADS TO EXCESS GAS SPILLING OUT. THIS HAS OCCURED AT NUMEROUS SELF-SERVE AND FULL SERVE GAS STATIONS INDICATING THAT IT IS NOT A PROBLEM WITH THE PUMP BUT A PROBLEM WITH THE DESIGN OF THE GAS TANK/INTAKE MECHANISM.*AK

NHTSA ID

10104838

Incident

Dec 21, 2004

PURCHASED 2/04. HESITATION PROBLEMS SINCE FIRST MONTH- FOUND NOTHING WRONG. CHNAGED OIL AT 5000K MILES, CHECKED AGAIN, FOUND NOTHING WRONG. NOW HAS 7000K MILES, STILL HESITATING AT VARIOUS SPEEDS AND HAS BEGUN NOT STARTING. TOWED TO DEALER, FUEL PUMP REPLACED DUE TO WEAK PRESSURE. TWO DAYS LATER, WOULD NOT START AND HESITATING STILL. TOWED BACK AGAIN DID START, SMELLED BAD, BUT NO CODES OR PROBLEMS FOUND.*AK

NHTSA ID

10096425

Incident

Oct 25, 2004

Mileage

2,000 mi