2006 Ford Escape Owner Complaints

I was in a major high speed frontal crash on April 4th. I hydroplaned on 204 and I almost died and none of my airbags deployed. I have several videos from the tow yard showing that they were still intact and didn't deploy, but this firm won'tlet me upload them. This car has never been in a wreck before, and my airbags were never recalled like other Takota ones around that time period. The wreck so serious that none of the first responders knew how I survived or on crawled out of the car to get help. The only savageable things for parts in that entire car were two floorboards and my airbags didn't deploy at all. I have suffered many lacerations and bruising all over my body.

NHTSA ID

11729724

Incident

Apr 4, 2026

Sunroof on the vehicle just shattered. No impact related cause. Maybe heat.

NHTSA ID

11664348

Incident

Jun 2, 2025

I was driving on the highway, when the car steering started to pull to the left, and an alarm chime was heard from the dash, and a wrench light on the dash came on, as well as a service steering system soon message appeared on the message display. This happened multiple times. I contacted the local Midland Ford Dealer about this issue, as they had replaced the Electronic Rack & Pinion Assembly previously. The same dealer diagnosed the problem as a corroded electrical connection in the harness connector, to the Electronic Rack & Pinion Assembly. I was hoping that they would have covered this issue under a warranty, seeing as they replaced the Rack & Pinion, and that did not fix the original problem. I was charged $624.00 to have the problem diagnosed and the Electronic Rack & Pinion electrical harness connector replaced. The problem has not reoccurred since this repair was done. I am wondering if other 2006 or after Ford Escape vehicles have experienced this same dangerous condition?.

NHTSA ID

11662328

Incident

Aug 1, 2023

The idler pulley on the subject vehicle has failed numerous times, with the mounting bolt shearing at the connection to the timing cover. Upon failure of the pulley the serpentine belt will either fail or become dislodged; when this occurs the steering, alternator, and water pump all stop operating. The vehicle becomes difficult to handle due to the loss of power steering, and is subject to shutting off due to the lack of an alternator and water pump. This particular issue has happened to me on four separate occasions in the last two years; the first time occurred while operating in traffic; the subsequent occasions were noted during startup and were detected before driving. New replacement pulleys will only last approximately 4000-5000 miles before they fail. The power steering pump and air conditioning compressor have been replaced due to concerns that they could be placing extra strain on the serpentine belt, however the issue has occurred even after replacing these components. Internet research notes that this is a common problem of the 2.3L engine in the Escape and other Ford/Mercury models of the same time frame. Nobody has reported a permanent solution; later model vehicles using the same or similar issue came equipped with electric power steering, which likely reduced the load on the pulley and its undersized mounting bolt. The idler pulley on this vehicle has proven to be an Achilles heel and should have been addressed by Ford via a recall and redesigned pulley.

NHTSA ID

11638533

Incident

Sep 11, 2023

Like so many others, I was making a sharp right turn when the vehicle stopped without warning causing cars behind me to slam on their brakes to avoid a chain rear end collision event on a busy intersection. Another driver offered help and got it restarted but the power steering stopped functioning. He pulled it off the road and I then had to drive it home. The light came on after saying "power steering service" and a wrench light. There were no codes to be read and I have been unable to get a straight answer from mechanics. The last said I need the power steering module and the rack and pinion. I finally got him to give me the specific part numbers, both of which are DISCONTINUED. Last week, I told another mechanic the problems and parts I needed and he gave me a total guestimate under $2000, so I decided to go with them and they ordered the parts. When I looked at the estimate, they did not match the part numbers I had been given, and I just found out they didnt include the module because it's discontinued. I cancelled the work. I have no options left that I can afford. THIS PROBLEM IS PERVASIVE IN THESE FORD ESCAPE MODELS AND YEARS, yet they haven't recalled any before 2008. This needs to be addressed because Ive also had the intermittent engine shutdown on the road saying "STOP NOW". Luckily, no accidents or injuries yet, but I wouldn't trust this to travel beyond my area. Shame on Ford!

NHTSA ID

11619631

Incident

Jan 20, 2024

The rear shock tower has rusted out and broken away from the frame which was conformed at a local body shop. The passenger side went first then the driver side went about a year later. There was no warning that this was happening until it broke while driving which made us lose control of the car. When we took it to a repair shop and said it was 2006 escape they responded what side did the shock tower break on this was before we told them it was a shock tower they said it's always that part on a escape I personally know 2 other people who have had the same problem all different years of escapes.

NHTSA ID

11589912

Incident

May 18, 2024

Both rear shocks, mounts, wheel wells, entire length of body door panels passenger seats are just absolutely rusted beyond repair. I've gone to a couple different shops and each one said that there is nothing they can do to fix the issue. Now the vehicle when ridden in just bounces horribly wearing out bearing springs and tires are being worn out. There is only 110759 miles on it and bought this for my wife/ kids cause I've had 3 other escapes in the past so since I work on the road this is prefect sized for then not to big or too small. I've had so many issues this last year with repairs parts and now worried about safety issues.

NHTSA ID

11579065

Incident

Mar 23, 2024

Transmission Stirring pump Spark plugs

NHTSA ID

11562480

Incident

Dec 11, 2023

The contact owns a 2006 Ford Escape. The contact stated while driving at an undisclosed speed, the vehicle inadvertently merged into the right lane without warning. As a result, the contact decelerated to approximately 10 MPH, when the CV axle detached from the vehicle. The contact was able to navigate the vehicle off the roadway. The vehicle was towed to an independent mechanic where it was diagnosed that the front passenger’s side subframe had rusted and needed to be replaced. The vehicle had not yet been repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 170,000.

NHTSA ID

11547406

Incident

Sep 25, 2023

Mileage

170,000 mi

My steering started locking up and now my vehicle will stall and shut completely down while doing 65 miles an hour and now it won't run at all

NHTSA ID

11533572

Incident

Jul 17, 2023

This 2006 Ford Escape Hybrid, and all first and second generation (2001-2012) Escape models, were designed and built with a significant, known defect in the mating area and materials used for the rear floor pan, rear sub-assembly/rails, and rear inner fender liners/upper shock absorber mounts, all made of pressed steel. The design of the components renders them subject to trapping road debris/salt/contaminants, and the inferior steel used oxidizes quickly, resulting in perforated areas of substantial rust. In our 2006 model, the right rear inner fender liner was completely replaced, and the rear subassembly/rails were welded, in 2013 with new Ford parts. By May, 2018, it had to be repaired and welded again. As of May, 2013, five years almost to the day, it has again rusted and separated. As this hybrid Escape carries a 600 pound battery between the rails in the rear of the vehicle, this is a substantial, dangerous defect affecting potentially millions of cars manufactured over a decade. The current status of the oxidation, corrosion, rot and decay affecting our Ford Escape has rendered it incapable of being repaired per the auto mechanic shop we visited first, followed by the body shop we visited next. Both indicated that the poor design combined with the steel used contributed to the dangerous vehicle it has become.

NHTSA ID

11527007

Incident

May 29, 2023

The contact owns a 2006 Ford Escape. The contact stated while driving approximately 40 MPH, the accelerator pedal was depressed; however, the vehicle started to lose motive power. Additionally, the contact stated that the accelerator pedal remained floored after being depressed. The contact drove to a parking lot and turned off the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 118,199.

NHTSA ID

11523503

Incident

Mar 23, 2023

Mileage

118,119 mi

The contact owns a 2006 Ford Escape. The contact stated that while pulling into the driveway, the check engine warning light illuminated and there was smoke coming from under the hood. The contact parked the vehicle and noticed that the smoke had increased. The contact stated that as he exited the vehicle, the smoke became darker. The contact stated that upon looking through the passenger's side wheel well, he saw flames under the engine compartment. The contact then walked away from the vehicle. The contact stated that the entire front end of the vehicle and dash had significantly burned and melted. The contact was able to extinguish the fire with the assistance of the fire department. A fire department report was filed. There was no injury sustained. The vehicle remained at the residence. The dealer was not notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 164,000.

NHTSA ID

11521257

Incident

May 9, 2023

Mileage

164,000 mi

2006 FORD ESCAPE. CONSUMER WRITES IN REGARD TO RUSTED OUT REAR SHOCK MOUNTS.

NHTSA ID

11513957

Incident

Mar 27, 2023

Well to put it lightly my rear axial the whole rear end is a mess this did not happen from normal were there is not that many miles I am very confident that if I was mot train on how to control a car if it were to go out of control at a high speed this would be a whole different story just thank how many are still on the road this year 2006 escape is a ticking time 💣

NHTSA ID

11499721

Incident

Jan 2, 2023

About a week after i bought this car and i bought it used but the abs light came on i took it to have it check out and was told the complete suspendtion system front and back was shot and that it all had to be fix i don't have the money for that i am a disabled veteran and i am scraping by as it is

NHTSA ID

11499472

Incident

Nov 15, 2022

The contact owns a 2006 Ford Escape. The contact stated that the accelerator pedal was sticking while being depressed. The contact had to continually depress the pedal to release the accelerator pedal. The failure occurred mostly during cold temperatures. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.

NHTSA ID

11497035

Incident

Feb 1, 2020

THE REAR SHOCK MOUNT RUSTS OUT NOT LONG AFTER MANUFACTURE AND WE THE CONSUMER ARE LEFT WITH THE PILE OF POOP. FORD IS HIGHLY AWARE OF THIS PROBLEM, AND AS I TRANSPORT MY CHILDREN DAILY I WONDER IF THIS WILL BE THE DAY WE DIE. UPON THE SHOCK MOUNT RUSTING OUT, HOPE YOURE RELIGIOUS AND GOD IS YOUR CO PILOT BECAUSE AS THAT POINT THE SPRING IS WHAT YOU'RE LEFT WITH! ITS SO HORSE [XXX] FORD LEAVES THIS TO THE LITTLE GUY (THE CONSUMERS) TO RECTIFY THEIR PROBLEM DUE TO THEIR INFERIOR MANUFACTURING. I WAS GOING OVER THE I280 BRIDGE IN OREGON OHIO WHEN IT DECIDED IT WAS TIME TO FAIL. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11495034

Incident

Nov 1, 2022

06 Ford Escape , 4 cylinder, front wheel drive. The gas pedal sticks and won’t accelerate when the vehicle is colder. Today I was on the road in traffic and went to hit the gas and gain some speed as I was still under the speed limit after slowing down behind a car that was turning and the pedal was stuck, couldn’t go! People driving behind and at me and I’m just stuck! It took a good 15-20 pumps of the foot to get the thing unstuck and moving again. It’s happened and was easier to get going a couple other cold mornings seems to stop once car is warmer and has been moving for a while. Looked online and there are numerous complaints about the same problem all the way back to 2009 with this cars make and model for both 05 and 06. Seems Ford never recalled it and some ppl online are even saying they ended up in accidents and stranded.

NHTSA ID

11491231

Incident

Oct 27, 2022

The contact owns a 2006 Ford Escape. The contact stated that after stopping at a traffic light and attempting to drive off, the accelerator pedal was depressed however, the vehicle failed to respond, almost causing another vehicle to crash into the rear of the vehicle. The contact turned off and restarted the vehicle to correct the issue however, the failure recurred. The contact stated that the vehicle was towed back to her residence. The local dealer and manufacturer were notified of the failure. The manufacturer referred the contact to NHTSA for assistance. The vehicle was not repaired. The failure mileage was unknown.

NHTSA ID

11451954

Incident

Feb 14, 2022

The contact owns a 2006 Ford Escape. The contact stated that upon the depression of the accelerator pedal, the front passenger’s side subframe collapsed without warning. Due to the failure, the contact had the vehicle towed to an independent mechanic where it was discovered that severe corrosion on the passenger’s side subframe had caused the collapse. Neither the dealer nor the manufacturer had been notified of the failure. The vehicle was not repaired and remained in the possession of the independent mechanic. The failure mileage was approximately 72,000.

NHTSA ID

11439162

Incident

Oct 23, 2021

Mileage

72,000 mi

Code P0351, P0352, P0353, P0354, P0355, P0356. Vehicle shut down on the interstate on the way home for work, 2½ hours from home. And will not restart. Pcm most likely the problem.

NHTSA ID

11429061

Incident

Aug 11, 2021

On Sunday May/23/2021 my car shut off suddenly with out warning after 3m of driving, the wrench orange lite came on, i was able to pull aside on the curb, turned off the car and waited a few minutes, i was able to turn the car back on, and the car restarted with out problem but the incident was there. when i got home i start looking on line for an explanation of what went wrong and i encounter that the 2006 Ford scape hybrid has been recall for stalling problems, somehow my car is not part of the recall according with the VIN number, but my car is a 2006 Ford Scape Hybrid, i don't understand why my car its not part of the recall and i hope that it did not fall under the cracks and i hope more that my car will not get stall in the freeway and cause an accident. please let me know if any additional information is need it

NHTSA ID

11418514

Incident

May 23, 2021

DASH LIGHTS GO OUT AT A FILL TANK OF GAS AND WHEN THE VEHICLE IS WARMED UP AND SOME TIMES. STAY OFF FOR A LONG TIME VEHICLE STAY RUNNING AND GOES DOWN THE ROAD .

NHTSA ID

11406351

Incident

Jan 25, 2021

Mileage

226,230 mi

KNOCKING, KNOCKING WHEN ACCELERATING, HESITATION.

NHTSA ID

11387327

Incident

Jan 8, 2021

Mileage

168,522 mi