2006 Ford Escape Fuel system Problems

My steering started locking up and now my vehicle will stall and shut completely down while doing 65 miles an hour and now it won't run at all

NHTSA ID

11533572

Incident

Jul 17, 2023

IN 2013 THE THROTTLE WOULD EITHER STICK AND NOT ALLOW YOU TO GO, OR AS YOUR DRIVING IT WOULD NOT GO TO THE IDLE POSITION. THIS HAPPENS WHEN THE WEATHER GETS COLD. WE HAD THE THROTTLE BODY ASSEMBLY REPLACED AT THE TIME, NOW IN 2016 THE SAME THING IS HAPPENING AGAIN. WE ARE VERY FRUSTRATED WITH FORD MOTORS AND THE DEALERSHIP. THIS IS A COSTLY FIX AND MUST BE DONE AGAIN FOR THE SAFETY OF OURSELVES AND OTHERS. PLEASE HELP US IF YOU CAN.

NHTSA ID

10916265

Incident

Oct 14, 2016

Mileage

128,000 mi

MY FRIEND BORROWED MY 06 FORD ESCAPE, WHICH HAD NOT SHOWN ANY MECHANICAL ISSUES. SHORTLY AFTER GETTING ON THE INTERSTATE HWY, THE GAS PEDAL STUCK TO THE FLOOR AND RAPIDLY EXCELLERATED TO 85 MPH PLUS, WITHOUT WARNING. IT IS A 6 LANE HWY AND WAS SATURDAY. PUTTING THE VEHICLE IN NEUTRAL AND USING BOTH THE BRAKE AND THE E BRAKE, WHILE TRYING TO MANEUVER TRAFFIC TO GET TO THE SHOULDER, AS A TRACTOR TRAILER RIG WAS BARRELING BY UNAWARE. THIS WAS AN EXTREMELY DANGEROUS SITUATION. IT IS MIRACULOUS THAT NO ONE WAS HURT. THE BRAKES SMOKED AND THE FIRE DEPARTMENT WAS CALLED AS A PRECAUTION. IT HAD TO BE TOWED. UPON RESEARCHING FURTHER, WE DISCOVERED ALL THE COMPLAINTS ABOUT THE THROTTLE BODY PROBLEMS. I AM DISAPPOINTED THAT THERE HAVE BEEN NO WARNINGS ABOUT THIS ISSUE. WILL SOMEONE HAVE TO DIE, BEFORE ANY ACTIONS ARE TAKEN? IT SEEMS AS THOUGH PREVENTION WOULD GO FURTHER, RATHER THAN REACTING TO ONLY THE EXTREMES OF DEATH AND DISMEMBERMENT. I AM SUGGESTING THAT FORD TAKE A PROACTIVE POSITION HERE AND NOTIFY FORD ESCAPE OWNERS. FIX THE ISSUE!!!

NHTSA ID

10862373

Incident

Apr 30, 2016

Mileage

130,000 mi

ON SEVERAL OCCASIONS AFTER GETTING OFF THE HIGHWAY ONTO AN EXIT RAMP MY VEHICLE HAS DIED WITH NO CHECK ENGINE LIGHTS, IT ALSO SHUTS DOWN WHEN MAKING A HARD TURN AT SLOWER SPEEDS. I HAVE HAD ISSUES WITH THE ACCELERATOR STICKING WHEN IT IS COLD OUTSIDE (SEVERAL TIMES HAVING TO MANUALLY SHUT OFF ENGINE AND COAST TO A STOP IN SNOW). I HAVE CURRENTLY STARTED EXPERIENCING A #3 MISFIRE AND AM CURRENTLY WAITING FOR PARTS TO COME. I HAVE ALREADY REPLACED ALL SPARK PLUGS AND NUMBER 3 IGNITION COIL. I AM WAITING FOR OTHER 3 COILS TO COME IN. IF STILL SHOOTING WILL TRY REPLACING SEALS. IT ALSO WAS "BURNING" OIL THEN STARTED TO HAVE AN ACTUAL OIL LEAK FROM MAIN SEAL. I DO THE REPAIRS MYSELF AND APPARENTLY THESE ARE KNOWN ISSUES. I COMPLAINED TO FORD ABOUT THE STICKY ACCELERATOR AND GOT NO REPLY. IT ALSO MAKES A TAPPING SOUND FROM THE CAM SHAFT WHICH I FOUND OUT IS TYPICAL OF FORD ESCAPES.

NHTSA ID

10816247

Incident

Dec 17, 2015

Mileage

127,000 mi

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, AN ABNORMAL NOISE EMITTED FROM THE REAR OF THE VEHICLE NEAR THE FUEL PUMP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

NHTSA ID

10723912

Incident

Jun 6, 2015

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 25 MPH, THE COOLANT TEMPERATURE WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE COULD NOT BE REPAIRED BECAUSE THE PART WAS UNAVAILABLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

NHTSA ID

10701192

Incident

Mar 2, 2015

Mileage

80,000 mi

THE GAS PEDAL STICKS AND COULD NOT BE PUSHED DOWN UNLESS YOU SLAMMED ON IT. THIS OCCURRED SEVERAL TIMES, AND EVENTUALLY STUCK COMPLETELY. THE FORD DEALERSHIP IN LYNCHBURG, VA, REPLACED THE THROTTLE BODY. NOW, TWO YEARS LATER, THE SAME PROBLEM HAS OCCURRED. *TR

NHTSA ID

10667028

Incident

Nov 21, 2012

Mileage

90,000 mi

MY 2006 FORD ESCAPE GAS PEDAL IS STICKING DOWN WHEN TEMPERATURE OUTSIDE IS VERY COLD. I COULD NOT ACCELERATE. VERY DANGEROUS. *TR

NHTSA ID

10658711

Incident

Nov 17, 2014

Mileage

134,000 mi

VEHICLE'S GAS PEDAL CONSTANTLY LOCKS WHEN DRIVING NO MATTER THE CLIMATE. *TR

NHTSA ID

10654972

Incident

Nov 14, 2014

Mileage

87,000 mi

WHEN IT GETS BELOW 40 DEGREES OR SO MY GAS PEDAL WILL STICK IN A CLOSED POSITION. YOU HAVE TO PRESS VERY HARD ON THE PEDAL FOR IT TO ALLOW THE CAR TO MOVE HOWEVER THERE IS A LARGE THRUST FORWARD/BACKWARD DUE TO OPENING THE THROTTLE SO QUICKLY. I HAVE NEARLY HIT 2 CARS AND ALMOST BEEN HIT SEVERAL TIMES BECAUSE THE CAR WILL NOT GO. I HAVE SPOKE. WITH FORD AND THEY STATE THAT THERE IS NO RECALLS REGARDING THE ISSUE AND THAT THERE ISN'T ANYTHING THEY CAN DO TO ASSIST. I DO KNOW THAT THERE WAS A RECALL FOR THE SAME ISSUE ON THE 2001-2004 AND 2007 MODEL OF THE ESCAPE FOR THE SAME ISSUE. I HAVE SPOKEN WITH A FEW OTHERS WHO EXPERIENCE THE SAME ISSUE AND THERE ARE SEVERAL COMPLAINTS REGARDING THE SAME PROBLEM. THIS IS A VERY DANGEROUS HAZARD AND COULD COST SOMEONE A LIFE IF THE PROBLEM ISN'T CORRECTED. IT OBVIOUSLY HAS TO BE AN ISSUE WITH THE MODEL ITSELF. IT HAS NEVER HAPPENED TO ME SINCE I PURCHASED THE CAR THIS PAST SPRING FROM MY MOTHER, WHO ALSO SAID SHE EXPERIENCED THE SAME PROBLEM. *TR

NHTSA ID

10651765

Incident

Oct 31, 2014

Mileage

140,000 mi

I WAS DRIVING APPROXIMATELY 45-50 MPH & COULD NO LONGER ACCELERATE. GAS PEDAL WAS STUCK. I REALIZED I WAS ABLE TO RELEASE IT BY STEPPING ON BRAKES OR HITTING THE GAS PEDAL REALLY HARD. THIS WAS UNDER WARRANTY IN OCT 2009 & THE THROTTLE BODY WAS REPLACED (SUPPOSEDLY) THEN AGAIN IN NOV 2011 I HAD TO HAVE IT REPLACED BUT IT WAS NOT UNDER WARRANTY & HAD TO PAY FOR IT. IT WAS ICY OUT & IT'S PRETTY DANGEROUS TO SLAM ON YOUR BRAKES TO RELEASE THE GAS PEDAL. LUCKILY THERE WERE NO CARS BEHIND ME. I WROTE A LETTER TO FORD BUT THEY WOULD NOT REFUND ME NOR WAS THERE A RECALL. I JUST HAD THE SAME PROBLEM JULY 2014 & THE DEALER (SUPPOSEDLY) CLEANED THE THROTTLE BODY BUT CHARGED ME & I CALLED FORD BUT AGAIN THEY SAID THERE'S NO RECALL. I ALSO SPENT 7K IN FEB 2013 FOR A NEW ENGINE.....BEGINNING TO WONDER IF THAT WAS A WISE DECISION. *TR

NHTSA ID

10617982

Incident

Oct 14, 2009

Mileage

75,000 mi

UPON PUTTING CAR INTO GEAR, THE GAS PEDAL WOULD NOT CAUSE THE CAR TO ACCELERATE. CAR HAD NO PROPULSION. IMPORTANT TO NOTE THAT THE GAS PEDAL HAD SEEMED TO STICK BEFORE THIS INCIDENT. FORD MOTOR CO. REFUSES TO COVER THE COST OF FIXING THIS PROBLEM, EVEN THOUGH THEY HAVE KNOWN ABOUT THIS ISSUE FOR SOME TIME. THIS CAR WAS BOUGHT FOR MY 17 YR OLD DAUGHTER. SHE DID NOT HAPPEN TO BE DRIVING AT THE TIME OF THE INCIDENT THANKFULLY BECAUSE SHE WOULD NOT HAVE KNOWN WHAT TO DO IN THIS CIRCUMSTANCE. *TR

NHTSA ID

10572819

Incident

Mar 16, 2014

Mileage

95,000 mi

WHEN FILLING WITH FUEL PRESSURE NOT RELEASED AND FUEL FLEW BACK OUT IN FACE. *TR

NHTSA ID

10561953

Incident

Jan 1, 2014

Mileage

75,000 mi

WHILE DRIVING, I WENT TO ACCELERATE, BUT THE GAS PEDAL WAS STUCK IN THE IDLE POSITION - LIKE IT FROZE UP. I STEPPED ON THE GAS PEDAL A FEW TIMES UNTIL IT LOOSENED UP. THIS HAS HAPPENED MULTIPLE TIMES IN THE PAST FEW YEARS ABOUT ONCE EVERY 2 MONTHS AND TYPICALLY ON COLDER DAYS LESS THAN 32 DEGREES F. AFTER A THROTTLE BODY CLEANOUT BY A LICENSED MECHANIC, IT GOT WORSE. I LOOKED ON LINE FOR REVIEWS ON 2006 FORD ESCAPES, AND SAW THAT MANY, MANY OTHER FORD ESCAPE OWNERS HAVE HAD THE SAME PROBLEM. THERE ARE CURRENTLY NO RECALLS ON THE THROTTLE BODY, BUT THIS IS THE COMMON PROBLEM. *TR

NHTSA ID

10561750

Incident

Jan 28, 2014

Mileage

140,000 mi

COMPLAINT OF NOT BEING ABLE TO START THE CAR IN VERY COLD WEATHER/ GAS PEDAL STICKS INTERMITTENTLY ALTHOUGH FREQUENCY OF CONDITION INCREASES AS TEMPERATURES DECREASE < 25F. FORD DEALER DIAGNOSES ISSUE AS A FAILED AIR BYPASS VALVE (PART NUMBER: 3S6Z-9F715-AA), REPLACED VALVE. CONDITION NOT CLEARED. ENGINE PEDAL STICKS, ENGINE RPM INCREASES WITHOUT DRIVER INPUT. MANUAL TRANSMISSION ONLY REASON THAT DRIVER WAS ABLE TO MAINTAIN CONTROL (JOCKEYING CLUTCH PEDAL TO LIMIT ENGINE RPM). THROTTLE BODY WAS REMOVED, CLEANED AND REINSTALLED. CONDITION NOT CLEARED. SUSPECT FAILED THROTTLE BODY. *TR

NHTSA ID

10561721

Incident

Jan 24, 2011

Mileage

120,000 mi

WHILE DRIVING, MY THROTTLE OR GAS PEDAL STICKS. IT WILL NOT DEPRESS. I HAVE TO TURN THE CAR OFF AND BACK ON AGAIN. SOMETIMES I HAVE TO LET THE CAR SIT A FEW MINUTES BEFORE IT WILL UNSTICK. THIS IS VERY DANGEROUS TRYING TO MERGE INTO TRAFFIC!!! THIS HAS HAPPENED SEVERAL TIMES, AND USUALLY WHEN THE WEATHER IS COLD OR THE ENGINE IS COLD. THAT IS THE ONLY PATTERN I HAVE BEEN ABLE TO FIGURE OUT. *TR

NHTSA ID

10553834

Incident

Jan 18, 2013

Mileage

92,500 mi

GAS PEDAL STICKS WHENEVER TEMPERATURE FALLS BELOW FREEZING. HAD ISSUES SINCE CAR WAS NEW IN 2006, BUT THIS WEEK ISSUE IS MUCH WORSE. NORMALLY YOU CAN PUSH HARD ON THE GAS PEDAL AND GET IT TO WORK. THIS WEEK I HAVE TO WAIT FOR THE CAR TO WARM UP BEFORE I CAN DRIVE, THE GAS PEDAL WILL NOT BUDGE. I'VE READ OTHER COMPLAINTS THAT THIS IS A FAULTY THROTTLE BODY AND WOULD LIKE TO KNOW WHAT FORD PLANS TO DO ABOUT IT. *TR

NHTSA ID

10553506

Incident

Nov 21, 2013

Mileage

120,000 mi

WHILE DRIVING TO WORK AT ABOUT 43 MILES PER HOUR, I WENT TO ACCELERATE, BUT THE GAS PEDAL WAS STUCK - LIKE IT FROZE UP. I WAS ABLE TO PULL INTO A PARKING LOT, STOPPED THE CAR, AND SLAMMED ON THE GAS PEDAL A FEW TIMES UNTIL IT LOOSENED UP. THIS HAPPENED AGAIN A COUPLE OF DAYS LATER, BUT I WAS ABLE TO STOP AT A RED LIGHT, AND AGAIN SLAMMED ON THE GAS PEDAL UNTIL IT GAVE IN. AGAIN THIS HAPPENED 2 DAYS AGO ON MY WAY TO WORK, AND HAD TO PULL OFF THE STREET INTO A PARKING LOT AND SLAMMED ON THE GAS PEDAL UNTIL IT LOOSENED UP. I LOOKED ON LINE FOR REVIEWS ON 2006 FORD ESCAPES, AND SAW THAT MANY, MANY OTHER FORD ESCAPE OWNERS HAVE HAD THE SAME PROBLEM. I BROUGHT IT YESTERDAY MORNING TO AUTONATION FORD IN BROOKSVILLE, FLORIDA AND IT WAS DETERMINED THAT THE BODY ASY - CARBURETOR THROTTLE, CABLE ASY - THROTTLE CONTROL NEEDED TO BE REPLACED. THE SERVICE MANAGER STATED THAT THERE WERE NO RECALLS ON THIS, AND THAT THIS WAS COMMON IN FORD ESCAPES. HE STATED THAT THIS WAS A SAFETY HAZARD AND ADVISED THAT I SHOULDN'T BE DRIVING THE CAR THE WAY IT WAS. THE REPAIRS ARE COSTING ME OVER $600, AND WITH ALL THE COMPLAINTS THAT I READ ABOUT ON LINE, I FEEL THAT THIS SHOULD BE A FORD RECALL, AND CUSTOMERS SHOULD BE REIMBURSED THEIR COSTS TO HAVE THIS REPAIRED. *TR

NHTSA ID

10552635

Incident

Nov 6, 2013

Mileage

50,078 mi

WHILE DRIVING TO WORK AT ABOUT 43 MILES PER HOUR, I WENT TO ACCELERATE, BUT THE GAS PEDAL WAS STUCK - LIKE IT FROZE UP. I WAS ABLE TO PULL INTO A PARKING LOT, STOPPED THE CAR, AND SLAMMED ON THE GAS PEDAL A FEW TIMES UNTIL IT LOOSENED UP. THIS HAPPENED AGAIN A COUPLE OF DAYS LATER, BUT I WAS ABLE TO STOP AT A RED LIGHT, AND AGAIN SLAMMED ON THE GAS PEDAL UNTIL IT GAVE IN. AGAIN THIS HAPPENED 2 DAYS AGO ON MY WAY TO WORK, AND HAD TO PULL OFF THE STREET INTO A PARKING LOT AND SLAMMED ON THE GAS PEDAL UNTIL IT LOOSENED UP. I LOOKED ON LINE FOR REVIEWS ON 2006 FORD ESCAPES, AND SAW THAT MANY, MANY OTHER FORD ESCAPE OWNERS HAVE HAD THE SAME PROBLEM. I BROUGHT IT YESTERDAY MORNING TO AUTONATION FORD IN BROOKSVILLE, FLORIDA AND IT WAS DETERMINED THAT THE BODY ASY - CARBURETOR THROTTLE, CABLE ASY - THROTTLE CONTROL NEEDED TO BE REPLACED. THE SERVICE MANAGER STATED THAT THERE WERE NO RECALLS ON THIS, AND THAT THIS WAS COMMON IN FORD ESCAPES. HE STATED THAT THIS WAS A SAFETY HAZARD AND ADVISED THAT I SHOULDN'T BE DRIVING THE CAR THE WAY IT WAS. THE REPAIRS ARE COSTING ME OVER $600, AND WITH ALL THE COMPLAINTS THAT I READ ABOUT ON LINE, I FEEL THAT THIS SHOULD BE A FORD RECALL, AND CUSTOMERS SHOULD BE REIMBURSED THEIR COSTS TO HAVE THIS REPAIRED. *TR

NHTSA ID

10552634

Incident

Nov 6, 2013

Mileage

150,078 mi

THE FIRST INCIDENT OCCURRED WHILE I WAS DRIVING 65 MPH ON THE EXPRESSWAY. I WENT TO CHANGE LANES AND HIT THE ACCELERATOR AND THE CAR WOULD NOT ACCELERATE AND WAS SHUDDERING. I HAD PULL OFF THE EXPRESSWAY AND TURN THE CAR OFF. I TRIED RESTARTING AND IT JUST SHUDDERED AGAIN. I WAITED FIVE MINUTES AND TRIED AGAIN AND FINALLY IT STARTED AND WAS ABLE TO SHIFT. TWO DAYS AGO I WAS GETTING OFF THE EXPRESSWAY AND MAKING A LEFT TURN WHEN THE CAR DIED AND I LOST STEERING POWER. I WAS ABLE TO FORTUNATELY GET TO THE SIDE OF THE ROAD AND PUT IT INTO PARK. I TRIED RESTARTING THE CAR AND IT WOULD NOT START. I WAITED 3 MINS AND WAS ABLE TO FINALLY GET IT GOING. BOTH TIMES THERE WAS NO CHECK ENGINE LIGHT. I HAD THE ESCAPE READ BY A CODE READER DEVICE MULTIPLE TIMES AND THERE ARE NO ERROR CODES DISPLAYED FROM THE COMPUTER. THIS IS A VERY SERIOUS AND POTENTIALLY LIFE THREATENING ISSUE, AND WOULD LIKE FORD TO ACT UPON IT FOR ITS CUSTOMERS IMMEDIATELY. I AM FILING THIS BECAUSE I HAVE READ THAT THE ISSUE IS WITH A DEFECTIVE THROTTLE BODY, AND THERE IS ALREADY AN INVESTIGATION INTO FORD ON THIS ISSUE (PE13-003). I WOULD LIKE MY VEHICLE TO BE ADDED TO THIS INVESTIGATION FOR MY FAMILIES SAFETY AND ALL OTHERS EXPERIENCING THE PROBLEM. *TR

NHTSA ID

10550511

Incident

Aug 30, 2013

Mileage

160,000 mi

THE GAS PEDAL WAS STUCK IN THE UP POSITION AND MY HUSBAND WAS UNABLE TO ACCELERATE. THIS WAS AN 3:45 IN THE MORNING IN ABOUT 60 DEGREE WEATHER. IN DOING SOME ONLINE RESEARCH, I HAVE FOUND THAT THIS IS A COMMON PROBLEM WITH THE BUTTERFLY VALVE IN THE THROTTLE SYSTEM. LUCKILY THERE ARE VERY FEW PEOPLE ON THE ROAD AT THAT TIME OF THE MORNING. IF THIS HAD HAPPENED IN HEAVY TRAFFIC, HE COULD HAVE BEEN HIT FROM BEHIND.

NHTSA ID

10544266

Incident

Sep 18, 2013

Mileage

97,000 mi

DRIVING ALONG AT VARIOUS SPEEDS, THE GAS PEDAL STICKS IN THE UP POSITION. IF YOU NEED TO SPEED UP THE PEDAL WONT MOVE. IT IS LOCKED IN THE IDLE POSITION. THIS ALMOST CAUSED A MAJOR ACCIDENT WHEN I COULD NOT SPEED UP TO GET OUT OF THE WAY OF AN 18 WHEELER. IT NEARLY RAN OVER ME. THE PEDAL HAS STUCK AT LEAST 15 TIMES SINCE I HAVE OWNED THE VEHICLE. DEALER SAYS NOTHING IS WRONG WITH THIS VEHICLE. I HAVE CHECKED ONLINE AND FOUND MANY PEOPLE ARE HAVING THE SAME PROBLEM WITH THE 2006 ESCAPE. IF THE PEDAL STICKS AT THE WRONG TIME, SOMEONE SOMEWHERE WILL BE INJURED OR KILLED. *TR

NHTSA ID

10535945

Incident

Aug 9, 2010

Mileage

81,000 mi

THE GAS PEDAL WOULD GET STUCK WHEN YOU WERE DRIVING. HAD TO HAVE IT REPLACED. IT COST FOUR HUNDRED DOLLARS (I THINK). WAS TOLD THERE WERE NO OTHER ISSUES LIKE THIS. ITS BEEN A COUPLE OF YEARS NOW. SAW RECENTLY THERE ARE OTHER COMPLAINTS FOR THIS ISSUE (ONLINE). THANKS *TR

NHTSA ID

10504333

Incident

Mar 9, 2010

Mileage

60,000 mi

GAS PEDAL STICKS WHEN COLD. THE GAS PEDAL WILL LOCK UP AND NOT UNLOCK. *TR

NHTSA ID

10493474

Incident

Jan 17, 2013

Mileage

140,000 mi

NOTICED MY GARAGE SMELLED OF GAS. FOUND DRIPS OF GASOLINE UNDER MY 2006 FORD ESCAPE. I FOUND THAT THE FUEL LINE UNDER THE SECOND PLASTIC STRAP FROM THE FUEL TANK, THE LINE HAS A SMALL SLOW LEAK. IT APPEARS THE PLASTIC STRAPS WORE A HOLE IN THE LINE. *TR

NHTSA ID

10475898

Incident

Sep 17, 2012

Mileage

100,000 mi