2017 Ford Escape Engine Problems

The coolant has been leaking into the cylinders the symptoms were violent shaking, low coolant, white smoke, misfires, and engine light and warning on. My safety and others safety were put at risk because if the motor is not replaced it can become a fire hazard and it could break down on the road endangering mine and others lives. The problem was diagnosed by a ford dealership and cost me $201 to just diagnose where they quoted me $14,000 to replace. It was inspected by the manufacturer (dealership). About 3 weeks ago there was an “Engine Fault Service Now” code on the screen then a couple days later the engine light came on and it was either constant or blinking.

NHTSA ID

11766494

Incident

Aug 25, 2026

The contact owns a 2017 Ford Escape. The contact stated that while driving 25 MPH, a high alert warning light illuminated. The contact pulled over to the right side of the road, turned off the vehicle, and waited for fifteen minutes before restarting the vehicle. However, the failure persisted. An independent mechanic was contacted. The vehicle was taken to the independent mechanic and was diagnosed with cylinder #2 failure. The contact was informed that the engine needed to be replaced. The failure mileage was 70,293.

NHTSA ID

11766207

Incident

Sep 8, 2026

Mileage

70,293 mi

My 2017 Ford Escape starting having issues about a year ago and was losing coolant and then car would read hot. It’s an Ecoboost motor and coolant is leaking into the motor and damaging it. The motor needs replacing and ford knew about this issue but refuses to repair it. I have repaired car 5 times or so trying to fix this but keeps getting worse and now destroyed the engine. It is a known flaw by ford repair and many people but I was not told anything when I bought the car.

NHTSA ID

11765935

Incident

Sep 7, 2026

Vehicle Information: Year/Make/Model: 2017 Ford Escape Titanium Engine: 2.0L EcoBoost 4-Cylinder Drivetrain: All-Wheel Drive (AWD) Current Mileage: Approximately 118,000 miles Description of the Safety Problem: The vehicle experienced a sudden and severe loss of engine coolant with no external leaks visible on the ground. Diagnostic inspection revealed that engine coolant is intruding internally into the engine cylinders due to a known structural defect in the Ford 2.0L EcoBoost engine block/head gasket design.Prior to diagnosing the failure, the vehicle exhibited rough idling, misfires, and white smoke from the exhaust due to coolant burning in the combustion chambers. Unrelated components, including the ignition coils, were previously replaced in an attempt to correct the misfires before the internal coolant intrusion was identified as the root cause.This defect poses an immediate safety hazard. The internal coolant loss causes the engine to overheat rapidly and threatens to force the vehicle into an abrupt emergency "limp mode" or cause complete, sudden engine failure while driving at highway speeds. This creates a severe risk of a rear-end collision or stranding the vehicle in active traffic without warning. Ford has failed to issue a recall for this systemic powertrain defect, leaving consumers to operate unsafe vehicles or face catastrophic out-of-pocket engine replacement costs.

NHTSA ID

11765862

Incident

Sep 4, 2026

It is common knowledge that my particular vehicle has a known engine defect - coolant intrusion - that in effect renders the engine inoperable eventually in models from 2013-19. Mine is a 2017. It was sold to me without anyone referencing the known engine issue. Over the last couple of years, my family was nearly stranded when the car suddenly began to experience shuddering, very rough driving, coolant disappearing and having to be replenished, and the engine coils misfiring and having to be replaced. Now, the engine has failed and is in need of more than $4,000 in repairs. While Ford did not issue a recall, it did alert its dealerships to the known manufacturing defect. As a consumer, I was NOT told of this problem during the sale.

NHTSA ID

11765853

Incident

Sep 4, 2026

well known problem with ford 2,0 Eco boost engines. mine is 2017 escape 2.0 Eco boost. radiator loosing fluid, pep boys checked it and said it was a cracked head gasket and would cost about 5,000.00 to fix.looked up info about this engine and found it is a well known problem and Ford will not fix it.said to call NHTSA and report it and hope you have Ford do a recall to replace engine.

NHTSA ID

11765473

Incident

Sep 11, 2024

Engine problem. Blown head gasket. Common problem among 2017 Ford Escape models.

NHTSA ID

11764524

Incident

Sep 15, 2026

My car has experienced Catastrophic Engine Failure. There is a coolant intrusion into the cylinders and now the car is inoperable. It runs for 2 minutes before shutting the engine off.

NHTSA ID

11764179

Incident

Aug 7, 2026

A coolant intrusion caused the head gasket to fail

NHTSA ID

11763712

Incident

Sep 7, 2026

The contact owns a 2017 Ford Escape. The contact stated that while the vehicle was at the service center for an instrument panel failure, a diagnostic test was performed on the engine. The contact was informed that in addition to the instrument panel failure, there was coolant inside the cylinders, and the engine needed to be replaced. The vehicle was not yet repaired. The failure mileage was 105,000.

NHTSA ID

11763703

Incident

Sep 11, 2026

Mileage

105,000 mi

Coolant leaks internally into the engine cylinders. This is resulting in needing a full engine replacement for $15,000. It has been confirmed by the dealership. The check engine light came on.

NHTSA ID

11762866

Incident

Sep 4, 2026

Head gasket and coolant intrusion issue, requiring complete replacement of engine costing over $7,000.00

NHTSA ID

11762760

Incident

Jul 3, 2026

My Ford Escape Titanium 2.0L 2017 started overheating. The coolant had just disappeared. The car sputtered in the morning with large plumes of white smoke. Due to the overheating my thermostat failed. I brought my car to the Art Hill Ford dealership in Merrilville Indiana for service. After a 5 hour pressure test, Tiffany A Depowski at Art Hill Ford Lincoln brought me to her desk and notified me and confirmed that I need a new engine due to Coolant Intrusion. The check engine light had been on for a couple months. I kept bringing the vehicle to my local mechanic. After he couldn't fix it I brought it to the dealer where they told me my engine needs to be replaced. Fortunately safety wasn't a direct factor. The risk of the engine seizing up while driving was a key factor with safety. The Ford invoice states verified coolant leak, recommend new engine is on the upload I sent under the section J#2

NHTSA ID

11761984

Incident

Aug 29, 2026

The vehicle suffered catastrophic engine failure at 72,000 miles due to a known Ford EcoBoost manufacturing defect where engine coolant leaks internally into the cylinders. Upon starting the vehicle in the parking lot, the engine began misfiring violently with blinking check engine light. The vehicle suddenly began misfiring, lost power, and became completely inoperable, creating a severe driving hazard. Code P0301 indicates Cylinder 1 Misfire detected. A professional mechanic ran diagnostics and confirmed a permanent Cylinder 1 Misfire caused by internal engine failure. The internal heating was so severe it cracked the spark plug on cylinder 1 rendering the car inoperable at 72, 000 miles. The mechanic said evidence of moisture was detected in the chamber.

NHTSA ID

11761752

Incident

Aug 25, 2026

The contact owns a 2017 Ford Escape. The contact stated that during the initial start-up, the vehicle would sputter. The Check Engine Light illuminated. While driving at approximately 45 - 50 MPH, the vehicle displayed the message, "High Heat,' meaning that the engine was overheating. The contact had pulled over and turned on the fan, which allowed the engine to cool off. The contact put antifreeze in the vehicle, and the next morning there was no antifreeze in the vehicle. After completing some research, the contact believes they're experiencing coolant intrusion. The dealer was informed of the issue. The vehicle had not been diagnosed or repaired. The manufacturer was informed of the issue. The manufacturer confirmed that the engine block was no longer covered. The failure mileage was approximately 76,000.

NHTSA ID

11760959

Incident

Aug 26, 2026

Mileage

76,000 mi

Vehicle just hit 70k miles, started abruptly shaking between 30 and 50 mph. Torque converter is needing replaced. PCV hose has cracked and needs replaced. COOLANT DISAPPEARING DUE TO INTRUSION LEAK. Extremely costly repairs for a vehicle that isn't even close to 100k miles. Engine overheating on highway which is an extreme fire risk.

NHTSA ID

11760923

Incident

Jun 1, 2026

2.01 block features a narrow cooling slot machined into the block surface right between the cylinder bores. Under high boost pressure and thermal stress, the narrow metal section around this slot distorts or cracks. This erodes the head gasket clamping force and allows pressurized coolant to bypass the seal, leaking heavily into the combustion chamber. An engine replacement is required to repair.

NHTSA ID

11759402

Incident

Aug 13, 2026

The 'Engine fault, service now' warning came on. Car started sputtering and in reverse engine shuts off. Car shakes while driving and loss of power. Upon further inspection looks like a coolant intrusion.

NHTSA ID

11758594

Incident

Aug 21, 2026

Received P0304 code for 4th cylinder missfire. Appears to be affected by the know coolant intrusion issue with these models

NHTSA ID

11758536

Incident

Aug 13, 2026

Purchased this vehicle in April of this year for my granddaughter. Check engine light came during test drive. Was told it needed some oil added and that took care of the issue. Soon after the check engine light continued so I made an appointment with auto mechanic. Code reads a misfire on 3rd cylinder with coolant leaking into cylinder. Extended warranty will not cover the $8k cost to replace engine. Ford knows of this issue. Many others do not understand why there isn't a recall on the engineering debacle. My granddaughter is pregnant and I'm worried about her driving this vehicle.

NHTSA ID

11757807

Incident

Apr 11, 2026

The 4th cylinder started misfiring due to a coolant leak, which is being caused due to the known engine design flaw with the Ford EcoBoost engines. My local mechanic diagnosed the problem and said that the car needs a new engine.

NHTSA ID

11757782

Incident

Jul 31, 2026

The check engine light came on, indicating a misfire in cylinder one and later cylinder two. The local Ford service center states that Coolant has been leaking into cylinder 2 and that a full engine block replacement is required due to complete failure. The vehicle overheated a couple of times while driving before this diagnosis.

NHTSA ID

11757700

Incident

Aug 10, 2026

Coolant intrusion. Same probably with every other 1.5L engine Ford knew had a problem but shipped anyways.

NHTSA ID

11757332

Incident

Aug 2, 2026

I got coolant into 1 of cylinders due to a faulty long block on my 17 Ford escape 2.0l . This is known to b a common issue on the 1.5 1.6 2.0 l ecoboost engine. Ford refuses to do anything even though they know its a design flaw

NHTSA ID

11757227

Incident

Aug 13, 2026

There was a sudden loss of power/acceleration while driving our [XXX] on the highway. The car would bog down, then briefly accelerate, then lose acceleration again. The car started to shake at this point and then the check engine light came on. No symptoms prior to failure. Very dangerous as the car suddenly slowed down well below speeds for highway, resulting in cars swerving around us. Local mechanic and dealership both confirmed coolant intrusion due to engine block Crack. Car only has 65k miles and has been meticulously maintained. Currently available for inspection INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11756911

Incident

Jun 11, 2026