Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 65 NHTSA owner-reported complaints for the 2005 Ford Excursion. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 65 · page 1 of 3
Several times I’ll be driving and the steering wheel will jerk in one direction and wobble violently I will grab it to correct it and basically fight to keep it in the lane so I have to pull over and try again. I checked all steering components had it looked at by a mechanic and cannot figure out what could be the issue. It is very dangerous and terrifying to drive since it happens out of nowhere at random.
LT275/65/R18 Tire developed a massive approximately 18in x 3in bubble on the inner section of tread causing significant vibration and excessive wear in that area in less than 50 miles
WHILE DRIVING, THE ENGINE JUST QUITS AND LOSES ALL POWER. I HAVE TO SHIFT INTO NEUTRAL, TURN THE KEY ALL THE WAY TO OFF, AND RESTART THE ENGINE. SOMETIMES IT STARTS RIGHT UP, OTHER TIMES IT TAKES SEVERAL (MANY) TRIES TO GET THE ENGINE TO RESTART. IT CAN GO 200 MILES WITHOUT KILLING, AND THEN KILL 5 TIMES IN 5 MILES. THE ISSUE APPEARS TO BE SIMILAR TO THE RECALL 05S34 (NHTSA CAMPAIGN NUMBER: 05V270000), BUT THAT'S SPECIFIC TO DIESEL ENGINES, AND MY TRUCK HAS A GASOLINE ENGINE.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. WHILE UNDERGOING ROUTINE SERVICE BY AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE COOLANT LEAKING THROUGH THE ENGINE CYLINDER AND THE HEAD GASKETS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE CONTACT CALLED A LOCAL DEALER (CHAPMAN FORD, 9371 ROOSEVELT BLVD, PHILADELPHIA, PA 19114) AND WAS ADVISED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 192,000.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED, SHUT OFF, AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS CONTACTED (BUSS FORD, IN MCHENRY, IL) WHO STATED THAT THERE WAS NO RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
DURING A SINGLE VEHICLE ACCIDENT DUE TO LOSING CONTROL AT, ACCORDING TO THE POLICE REPORT, 65 MPH AND RUNNING FRONT-END FIRST IN TO A ROCKY MOUNTAIN BANK THEN BOUNCING OFF SAID BANK ROTATING THE VEHICLE, AGAIN ACCORDING TO THE ACCIDENT REPORT, ROUGHLY 120-DEGREES THE FACTORY AIRBAG FAILED TO DEPLOY. EVEN WITH THE SEATBELT ON MY CHEST, STERNUM AND RIBS STILL MANAGED TO EITHER BE INJURED BY THE SEATBELT (NO VISIBLE SEATBELT MARKS OR TRAUMA) OR BY IMPACTING THE STEERING WHEEL. BASED ON THE FRONT END DAMAGE, DAMAGE TO THE FRONT SUSPENSION SPRINGS AND THE TRANSFER CASE ALONG WITH THE FRONT AND REAR DRIVESHAFTS COMPLETELY DETACHING THE WRECKER/TOW COMPANY ALSO QUESTIONED WHY THE AIRBAG DID NOT DEPLOY. SAID VEHICLE HAS NOW BEEN ACQUIRED BY COPART AT THE REQUEST OF MY INSURANCE COMPANY DUE TO THE VEHICLE BEING TOTALED. PEOPLE REPOT IS AVAILABLE THOUGH THERE IS NO MENTION OF AIRBAG DEPLOYMENT OR NON-DEPLOYMENT.
WHILE DRIVING THE TRUCK THE ACCELERATOR BECOMES NONRESPONSIVE AND SOON AFTER THE TRUCK SHUTS DOWN, COMPLETE POWER LOSS. VERY DIFFICULT TO STEER AND BRAKE. IT WILL START BACK UP MOST OF THE TIME, BUT ON OCCASION IT WILL TAKE 20 TO 30 MINUTES TO RE-START. FORD HAS A RECALL FOR THIS # 05S34. MY VIN INDICATES THAT MY EXCURSION ISN'T UNDER THIS RECALL, BUT THIS IS EXACTLY WHAT IS HAPPENING. THIS EVENT HAPPENS ON CITY STREETS AND HIGHWAYS, WHILE DRIVING OR SITTING AT A STOP SIGN OR STOP LIGHT. THIS EVENT HAS BECOME MORE FREQUENT AS MY WIFE WILL NO LONGER DRIVE IT DO TO THE VEHICLES HANDLING/BREAKING ISSUES WITHOUT POWER SO I ONLY DRIVE IT ON WEEKENDS. IT HAPPENS AT LEAST ONCE A DAY SOMETIMES REPEATEDLY WITHIN SECONDS AFTER RESTARTING AND SOMETIMES NEVER AGAIN DURING THE WEEKEND. IT ALSO IS NOT TIME OR DISTANCE RELATED. IT HAS HAPPENED LEAVING OUR HOUSE AND IT HAS HAPPENED 20 MINUTES INTO A DRIVE. VERY SPORADIC
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT THE EXTERIOR LIGHTS WOULD NOT FUNCTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 11V352000 (EXTERIOR LIGHTING). THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS ABLE TO START ON THE FIRST ATTEMPT. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL AND THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 70 MPH. THE CONTACT WAS ABLE RESTART THE ENGINE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE COULD BE RELATED TO THE FUEL INJECTOR. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 146,000.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS CONFIRMED THAT THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 61,000.
CAR STEERS SIDE TO SIDE AND EXTREMELY DIFFICULT TO KEEP WITHIN THE LANES.YOU HAVE TO HOLD STEERING WITH 100 % CONCENTRATION AND CONSTANTLY MANEUVER IT TO KEEP IT STRAIGHT.ALSO TEND TO VEER TO THE LEFT.LOT OF STEERING PLAY.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. AFTER SEVERAL ATTEMPTS, THE VEHICLE WAS ABLE TO RESTART, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. ....UPDATED 07/22/15 *BF THE CONSUMER STATED AFTER THE VEHICLE WAS REPAIRED THE FAILURE RECURRED. UPDATED 9/22/2015 *JS
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. WHILE DRIVING APPROXIMATELY 10 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE SPARK PLUGS DETACHED FROM THE CYLINDER HEAD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE HELICOIL WAS INSTALLED AND THE SPARK PLUGS WERE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
6.0L DIESEL ENGINES TO ADDRESS REPORTED INCIDENTS OF ENGINE STALLING WHILE DRIVING OCCURRED UP TO 9 TIMES IN ONE DAY. ON JUNE 25 TOOK VEHICLE TO CERTIFIED DIESEL TECH, NO COMPUTER ERRORS. D & S SERVICE TECHS TROUBLE SHOT FOR 5 DAYS TO NO AVAIL. MANUFACTURE HAS NO ADVICE FOR REPAIR. AFTER 1 WEEK BEING SERVICED AND OVER $1,800 OF WORK IT STALLED AGAIN ON JULY 3RD. THIS IS A SERIOUS SAFETY CONCERN FOR MYSELF AND MY FAMILY. PLEASE HELP IN ADDRESSING THIS MATTER. THANK YOU. *TR
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT WAS DRIVING 5 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 125,165.
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED AS THE BATTERY WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT BOTH OF THE BATTERIES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED SEVERAL TIMES LATER. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 69,900.
WHILE TOWING A CAMPER, THE ENGINE OVERHEATED ABOUT 4 HOURS INTO THE TRIP. THE TRUCK AND TRAILER HAD TO BE TOWED HOME. THE TRUCK WAS BROUGHT TO FORD AND IT WAS DETERMINED THAT THE HEAD GASKETS BLEW OUT. THE DEALER SAID THIS WAS COMMON WITH THE 6.0 DIESEL ENGINES. HE STATED THAT IT WAS CAUSED BY THE HEAD BOLTS STRETCHING. HE REPAIRED IT, BUT, TOLD ME I WOULD BE BACK AGAIN UNLESS I PURCHASED ARP RACING HEAD BOLTS($600). I RESEARCHED IT ONLINE AND FOUND HE WAS CORRECT. I PROVIDED THE BOLTS AND FORD DID THE REPAIR UNDER WARRANTY. IN 2008, THE EGR COOLER/OIL COOLER RUPTURED AND HAD TO BE REPLACED (UNDER WARRANTY). IN 2009, THE FICM MODULE MALFUNCTIONED. SINCE THE TRUCK WAS NOW OUT OF WARRANTY, FORD WANTED $700 FOR THE PART, PLUS LABOR. IN 2010, THE EGR COOLER/OIL COOLER RUPTURED AGAIN. SINCE THE TRUCK WAS OUT OF WARRANTY, I WAS TOLD IT WOULD BE $4000 TO REPAIR. I RESEARCHED ONLINE AGAIN AND FOUND THE WHOLE EGR DESIGN WAS FLAWED. I PURCHASED AN AFTERMARKET DESIGNED COOLER AND, SINCE THEN, HAVE HAD NO MORE PROBLEMS. *JS
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE VEHICLE FAILED TO ACCELERATE WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS WHERE IT WAS ADVISED THAT THE INJECTOR PRESSURE SYSTEM NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. *TR
IN DECEMBER AFTER I FILLED UP MY GAS TANK ABOUT 3/4 OF THE WAY. I DROVE HOME, AND WHEN I STEPPED OUT OF MY VEHICLE I STARTED TO SMELL A STRONG GAS ODOR. EVERY TIME I FILL UP MY GAS TANK HALF WAY OR MORE, THEN DRIVE ANY. I START SMELLING A STRONG GAS ODOR. THE SMELL SEEMS TO BE COMING FROM BETWEEN THE FRONT OF THE LEFT SIDE PASSENGER DOOR , AND THE BACK LEFT SIDE WHEEL. *TR
TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED WHILE DRIVING 20 MPH, THE VEHICLE STALLED AND POWER TO THE HEADLIGHTS, DOOR LOCKS, AND RADIO WAS LOST. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 25,000.
WHILE MERGING ONTO 75MPH HIGHWAY, WITHOUT WARNING, VEHICLE LOST ALL POWER MAKING STEERING NEARLY IMPOSSIBLE. WE WERE ABLE TO MOVE ONTO SHOULDER JUST AT THE POINT WHERE HIGHWAY AND ON RAMP MET. WE COULD NOT RESTART VEHICLE AND HAD WE MADE IT ONTO HIGHWAY, COULD HAVE VERY EASILY BEEN REAR ENDED BY ONCOMING TRAFFIC. THIS IS THE SECOND TIME WE HAVE LOST COMPLETE POWER WITH THIS VEHICLE. WE HAD SAME SITUATION IN JULY AND HAD PAID OVER TWO THOUSAND DOLLARS TO HAVE FUEL SYSTEM REPAIRED. FORD HAD RECALL ON THIS BUT OUR TRUCK'S VIN DID NOT FALL UNDER RECALL. HOWEVER, HAVE CONCERNS FOR OTHERS WHO HAVE VEHICLES WHOSE VINS ARE NOT PART OF THE RECALL. ANOTHER FAMILY MAY NOT BE AS FORTUNATE AS WE WERE YESTERDAY. FORD IS AWARE OF THESE ISSUES AND I HOPE FORD DOES NOT WAIT UNTIL LIVES ARE LOST DUE TO THEIR FAULTY VEHICLES! *TR
WE HAVE HAD NUMEROUS INCIDENTS WITH OUR EXCURSION DATING BACK TO ONE WEEK AFTER WE PURCHASED IT USED FROM A LOCAL FORD DEALERSHIP IN JULY 2009 UNTIL NOW - SEPT. 2012. WE BEGAN EXPERIENCING ACCELERATION ISSUES AFTER THE FIRST WEEK. WE RETURNED THE VEHICLE TO THE DEALERSHIP FOR A DIAGNOSTIC EVALUATION. THEY REPLACED THE IPR AND FUEL PUMP. THIS SEEMED TO FIX THE PROBLEM UNTIL JANUARY 2011. IN JANUARY 2011, THE ACCELERATOR BEGAN FAILING AGAIN. IT WOULD JUST STOP WORKING. THE CAR WOULD CRANK INITIALLY AND THEN FAIL TO RECRANK IF TURNED OFF WITHIN A SHORT AMOUNT OF TIME (I.E. DRIVING TO THE STORE). WE WERE TOLD THAT WE NEEDED A NEW FUEL SENSOR. THAT DIDN'T FIX THE PROBLEM. WE THEN HAD THE CATALYTIC CONVERTER REPLACED. THAT DIDN'T FIX IT. YESTERDAY, WHILE DRIVING IN AFTERNOON TRAFFIC WITH MY CHILDREN, EVERYTHING ONCE AGAIN SHUT OFF. I BARELY MANAGED TO MAKE IT TO THE SIDE OF THE ROAD. I CAN NOT EVEN COUNT THE NUMBER OF TIMES IN THE PAST 3 YEARS THAT I HAVE PULLED OUT INTO AN INTERSECTION ONLY TO HAVE MY ACCELERATOR NOT WORK. IT HAS PROGRESSIVELY GOTTEN MORE EXTREME. TODAY I FOUND OUT ABOUT RECALL THAT TOOK PLACE FOR THE SAME MODEL/YEAR, BUT ACCORDING TO THE FORD PEOPLE, MY VEHICLE DIDN'T QUALIFY. *TR
I PURCHASED A 2005 FORD EXCURSION LIMITED USED IN MAY OF 2011. THE VEHICLE WAS PURCHASED WITH NEW BCT RADIAL A/P LT265/75R16 TIRES. AFTER APPROXIMATELY 2 MONTHS THE VEHICLE WOULD SHAKE AND VIBRATE AT HIGHWAY SPEEDS. ONE OF THE TIRES WAS FOUND TO BE OUT OF ROUND AND WAS REPLACED WITH A BF GOODRICH TIRE. NOW 13 MONTHS AFTER PURCHASE ONE OF THE OTHER BCT TIRES HAS SIDEWALL SEPARATION IN SEVERAL LOCATIONS. I AM NOW REPLACING ALL OF THE BCT TIRES TO PREVENT A SUDDEN AND CATASTROPHIC TIRE FAILURE. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .