1994 Ford Explorer Owner Complaints

I LOOKED UP MY VEHICLE AND IT HAS A RECALL AND I WANT IT FIXED. *TR

NHTSA ID

11337134

Incident

Jun 2, 2020

PURCHASED VEHICLE TRANSMISSION OUT,CAME WITH REBUILT TRANSMISSION,INSTALLED,LASTED ABOUT 1 YEAR.KEPT BLOWING FRONT SEALS.ALWAYS HEATED UP GOING UPHILL.NEXT TRANSMISSION,SAME STORY.SERVICED REGULAR,WITH FILTER CHANGE.CURRENT TRANSMISSION IN TRANS. SHOP,BURNT UP,NEW CLUTCHES,BANDS,SEALS,YOU NAME IT.IT STILL WILL NOT SHIFT CORRECTY DUE TO SERVO PISTON FAILURE,THAT ALSO NEEDS FIXED.A4LD TRANSMISSION IN TOO SMALL FOR THE EXPLORER VEHICLE.I LIKE THE VEHICLE IN GENERAL,EVEN INSTALLED MANUAL LOCKOUTS TO HELP THIS SIDUATION.THIS VEHICLE HAS HAD GOOD CARE,BUT TO NO AVAIL.I BELIEVE THAT THE FORD MOTOR COMPANY SHOULD BE HELD ACCOUNTABLE FOR PRESENTING THE AMERICAN CONSUMER WITH SUCH BAD DRIVETRAIN SIDUATIION,THAT I AM SURE THAT THEY BOTH KNEW ABOUT,AND JUST DID NOT CARE.IT LEFT ME,A SERVICE CONNECTED DISABLED VETERAN,ON THE SHOULDER OF THE HIGHWAY,MANY TIMES.EVEN ON MY WAY TO THE VA HOSPITAL.REGUARDS

NHTSA ID

11104957

Incident

Oct 4, 2017

Mileage

180,000 mi

HIGH BEAMS ACT AS LOW BEAMS ALL THE TIME, UNLESS YOU PULL THE BRIGHTS TOWARDS YOU AND HOLD WHICH IS ALSO A FATALITY. *TR

NHTSA ID

10627689

Incident

Aug 19, 2014

TL* THE CONTACT OWNS A 1994 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, AN ODOR OF GASOLINE FUMES EMITTED INSIDE OF THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. IN ADDITION, THERE WAS SMOKE COMING FROM UNDER THE HOOD. THE CONTACT EXPERIENCED BRONCHIAL HEALTH ISSUES THAT REQUIRED MEDICAL ATTENTION AS A RESULT FROM INHALING THE FUMES. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE FUEL LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10614481

Incident

May 13, 2013

Mileage

190,000 mi

APRIL, 1996 I, MY EX WIFE, AND MY DAUGHTER WERE COMING BACK FROM PALMDALE, LA COUNTY, TRAVELING EAST ON 138 HIGHWAY BACK TO ONTARIO, SAN BERNARDINO COUNTY, WHERE I USED TO RESIDE. WHILE I WAS PASSING SLOW TRUCK IN TWO HIGHWAY TRYING TO GET BACK IN THE FRONT OF THE TRUCK ONE OF THE FRONT TIRES EXPLODED I LOST CONTROL OF THE 1994 FORD EXPLORER GOT ON THE DIRT THE CAR WAS AIRBORNE LANDED TURN GOD KNOWS HOW MANY TIMES AND LANDED ON THE SIDE. *TR

NHTSA ID

10551694

Incident

Apr 10, 1996

Mileage

24,000 mi

MY TENANT'S VEHICLE - A 1994 FORD EXPLORER - SPONTANEOUSLY CAUGHT FIRE WHILE PARKED IN MY PROPERTY'S GARAGE IN THE MIDDLE OF THE NIGHT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES AND DETERMINED THAT THE CAUSE OF THE FIRE WAS THE CAR ITSELF - LIKELY A FAULTY CRUISE CONTROL VALVE ACCORDING TO THEM. THE INSURANCE COMPANY WILL CONDUCT ITS OWN INVESTIGATION. *TR

NHTSA ID

10447825

Incident

Feb 11, 2012

I WAS SITTING AT A STOP LIGHT ALL OF A SUDDEN THE TRUCK ACCELERATED FORWARD. THE NEXT EVENT I WAS TRAVELING ABOUT 40 MILES AN HOUR AND THE TRUCK ACCELERATED OUT OF CONTROL AND I WAS UNABLE TO STOP IT, THE BRAKES WOULDN'T STOP IT, FINALLY I TURNED THE KEY OFF AND IT SHUT DOWN. IT'S BEEN HAPPENING ON AND OFF SINCE THEN. IT DOESN'T HAPPEN ALL THE TIME, BUT, I NEVER KNOW WHEN IT WILL HAPPEN AGAIN. I CONTACTED FORD SEVERAL TIMES ABOUT THIS PROBLEM AND THEY TOLD ME IT COULD BE ALOT OF DIFFERENT REASONS, THEY NAMED OFF SOME PARTS AND I REPLACED ALOT OF THEM AND AM STILL HAVING THE SAME PROBLEM. THEY DID SAY THEY HAVE HEARD OF OTHER PEOPLE HAVING THE SAME PROBLEMS, BUT THEY WERE NOT ALL FOR THE SAME REASONS. *TR

NHTSA ID

10436124

Incident

Jul 11, 2011

Mileage

171,000 mi

INVESTIGATION OF A MOTOR VEHICLE TRAFFIC COLLISION REVEALED THAT THE ACCELERATOR PEDAL ON 1994 FORD EXPLORER (UNKNOWN MILES) MAY BECOME STUCK IN THE "FULL OPEN THROTTLE" POSITION. CONDITION OCCURS WHEN THE ACCELERATOR PEDAL ARM WEARS A SLIT IN THE RUBBER SOUND/HEAT INSLUATION ON THE FLOOR BOARD. AFTER THAT OCCURS, WHEN THE ACCELERATOR IS FULLY DEPRESSED, THE ARM CAN BECOME STUCK IN THE RUBBER. CONDITION WAS DISCOVERED DURING INVESTIGATION OF A FATAL CRASH. AFTER THE CONDITION WAS DISCOVERED, IT COULD BE EASILY AND REPEATEDLY REPLICATED. NOTE: FATALITY OCCURRED WHEN THE DRIVER, FOR UNKNOWN REASONS, EXITED THE VEHICLE WHILE IT WAS STILL IN MOTION AT UNKNOWN SPEED. DRIVER DIED UPON IMPACT WITH ROAD. VEHICLE CONTINUED OFF ROAD AND CAME TO REST, MOSTLY UNDAMAGED, IN A FIELD WELL OFF ROAD SURFACE. *TT

NHTSA ID

10427754

Incident

Sep 26, 2011

WHILE DRIVING I TURNED ON AIR CONDITIONER AND IMMEDIATELY LIGHT SMOKE BEGAN OUT OF AIR CONDITIONING VENTS AND THEN THE NEXT MOMENT THE SMOKE WAS EXTREMELY HEAVY OUT OF THE VENTS AND THEN VISIBLE FIRE UNDERNEATH FRONT PASSENGER SIDE DASHBOARD. I IMMEDIATELY PULLED THE VEHICLE OFF THE SIDE OF THE ROAD AND EXITED, 10 MINUTES LATER IT WAS FULLY ENGULFED IN FLAMES. *LN

NHTSA ID

10379515

Incident

Jan 26, 2011

Mileage

286,000 mi

1994 FORD EXPLORER HAD SMOKE COMING OUT OF THE AIR-CONDITIONER VENTS INTO THE PASSENGER COMPARTMENT, SLIGHT AT FIRST, THEN SO HEAVY THAT FORWARD VISIBILITY WAS OBSCURED. AFTER STOPPING THE VEHICLE, A SMALL FIRE WAS SEEN BURNING THE PLASTIC EVAPORATOR COVER WHERE THE BLOWER MOTOR RESISTOR ASSEMBLY IS MOUNTED IN THE EVAPORATOR COVER. SOME SNOW THROWN ON THE FIRE PUT IT OUT. THE BLOWER MOTOR APPEARS TO BE SHORTED OR MAYBE JAMMED FROM ROTATING, CAUSING THE RESISTOR TO GET HOTTER THAN NORMAL, IGNITING THE PLASTIC COVER. MAYBE LEAVES OR OTHER FLAMMABLE DEBRIS CONTACTED THE RESISTOR, BUT I CAN'T TELL AS THE FLAMES BURNED UP ANYTHING IN THE AREA AROUND THE RESISTOR ASSEMBLY. FORTUNATELY, I WAS ABLE TO BRING THE VEHICLE TO A SAFE STOP, IN SPITE OF VERY LIMITED VISIBILITY IN THE HEAVY SMOKE. I WAS ON A SLOW SPEED, LOW TRAFFIC CITY STREET. THE RESULTS WOULD HAVE BEEN MUCH WORSE IF THE FIRE OCCURRED AT HIGHWAY SPEEDS. THE BLOWER MOTOR WILL BE AVAILABLE FOR INSPECTION WHEN I REMOVE AND REPLACE IT TO TRY AND GET THE AIR SYSTEM WORKING FOR HEAT AT LEAST. *TR

NHTSA ID

10374872

Incident

Jan 5, 2011

Mileage

185,876 mi

LIGHT CONTROL SWITCH HEATS UP SO HOT THAT WIRES AND PLUG IN MELT,BURN AND CRACK CAUSING LIGHT SWITCH FAILURE THAT COULD GO UNKNOWN CAUSING A CRASH OR FIRE. *TR

NHTSA ID

10332098

Incident

Mar 23, 2010

TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHEN THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH, DARK SMOKE BEGAN EMITTING FROM THE INSTRUMENT PANEL. THE CONTACT TURNED THE VEHICLE OFF WHICH IMMEDIATELY BECAME ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENT WERE NOTIFIED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 200,000.

NHTSA ID

10323374

Incident

Mar 25, 2010

Mileage

200,000 mi

WHILE DRIVING, THE SUV CAUGHT FIRE FROM UNDER THE HOOD. THE VEHICLE WAS CONSUMED BY FLAMES IN LESS THAN 5 MINUTES. ALTHOUGH MANY MAKES AND MODELS OF FORDS HAVE BEEN RECALLED ( FAULTY CRUISE CONTROL - POTENTIAL FIRE HAZARD), THE 1994 FORD EXPLORER HAS NOT BEEN RECALLED. *TR

NHTSA ID

10308714

Incident

Jan 7, 2010

Mileage

150,000 mi

TL* THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE PARKED, THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE FIRE INSPECTOR WAS UNABLE TO DETERMINE THE CAUSE OF FIRE. THE VEHICLE WAS SEVERELY DAMAGED. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 175,000.

NHTSA ID

10288536

Incident

Oct 13, 2009

Mileage

175,000 mi

THE GAS PEDAL GOT STUCK CAUSING MY VEHICLE TO ACCELERATE AT A HIGHER THAN NORMAL SPEED IN AN APARTMENT PARKING LOT, WHICH CAUSED MY VEHICLE TO RUN INTO THE APARTMENT BUILDING AND CAUSED STRUCTURAL DAMAGE AND FRONT END DAMAGE TO THE EXPLORER. IT IS INOPERABLE AT THIS TIME DUE TO THIS INCIDENT. A POLICE REPORT WAS MADE AND INSURANCE COMPANY NOTIFIED. *TR

NHTSA ID

10287417

Incident

Oct 6, 2009

I DRIVE A 1994 FORD EXPLORER 4X4. MY COMPLAINT IS WITH THE FRONT BRAKES. WHEN THE INNER BRAKE PADS WEAR TO A CERTAIN POINT, THEY FALL OUT OF THE CHANNELS THAT THEY SLIDE IN CAUSING BRAKE FAILURE. WHEN THIS HAPPENS, ALL THAT IS LEFT TO STOP THE VEHICLE IS THE PISTON OF THE BRAKE CALIPER. THERE IS NO WEAR INDICATOR TO WARN THE DRIVER THAT DISC PADS ARE WORN OUT. PLEASE LET ME KNOW IF THERE IS A RECALL ON THIS PROBLEM. *TR

NHTSA ID

10287088

Incident

Sep 28, 1999

Mileage

150,000 mi

MY VEHICLE WAS PURCHASED AS IS AND I HAVE HAD SOME PROBLEMS WITH IT . I NEED ROCKER PANELS , 3 BALL JOINTS AND A NEW MUFFLER. *TR

NHTSA ID

10273856

Incident

Jun 10, 2009

TL*THE CONTACT OWNS A 1994 FORD EXPLORER. THE CONTACT STATED THAT THE LIFTGATE BRACKETS FRACTURED AND THE GLASS FELL OUT AND STRUCK HER ON THE HEAD. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V310001 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE CONTACT WOULD HAVE TO PAY $200 FOR THE REPAIR. CURRENTLY, THE WINDOW CAN NO LONGER BE OPENED. THE FAILURE AND CURRENT MILEAGES WERE 170,000.

NHTSA ID

10260565

Incident

Feb 28, 2009

Mileage

170,000 mi

RECALLED FIRESTONE ATX AND WILDERNESS TIRES. **NAR** *NJ THE CONSUMER WAS TRAVELING AT 70 MPH WHEN THE LEFT REAR TIRE SUFFERED A CATASTROPHIC TREAD BELT SEPARATION. THE VEHICLE BECAME UNCONTROLLABLE AND SUBSEQUENTLY ROLLED WHICH CAUSED A FATAL HEAD INJURY TO A RESTRAINED 12 YEAR OLD OCCUPANT. IT WAS ALSO STATED THAT THE SPARE TIRES WERE ALSO DEFECTIVE AND THEY TOO SHOULD BE REMOVED FROM VEHICLES. *JB

NHTSA ID

10260108

Incident

May 24, 2006

WHILE DRIVING 60 MPH ON THE HIGHWAY, DRIVER'S SIDE FRONT TIRE HAD COMPLETE TREAD-SEPARATION, CAUSING DAMAGE TO THE FRONT END OF THE VEHICLE, LEFT SIDE OF VEHICLE, AND FLATTENING THE REAR LEFT TIRE. ALTHOUGH THE DRIVER'S SIDE FRONT TIRE HAD COMPLETE TREAD SEPARATION, IT REMAINS INFLATED. THE DEFECTIVE TIRE, AS WELL AS ALL TIRES ON THE VEHICLE, HAD PLENTY OF TREAD LEFT, PASSING BOTH THE PENNY AND QUARTER TEST, WERE PROPERLY INFLATED, AND SHOW NO CRACKING OR WEARING. ALL THE TIRES WERE PURCHASED AT THE SAME TIME AND ARE TOYO RADIAL OPEN COUNTRY P235/75R15. A STEVENS COUNTY POLICE OFFICER WITNESSED THE TREAD SEPARATION AND STOPPED TO HELP. *TR

NHTSA ID

10233642

Incident

Jul 8, 2008

TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE DRIVING BETWEEN 25-30 MPH, WHITE SMOKE APPEARED FROM THE AIR CONDITIONING VENTS. THE CONTACT PULLED OVER AND EXITED THE VEHICLE. THE VEHICLE CONTINUED TO SMOKE AND THEN CAUGHT FIRE ON THE FRONT PASSENGER SIDE UNDERNEATH THE VEHICLE. THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 150,000.

NHTSA ID

10230920

Incident

Apr 24, 2008

Mileage

150,000 mi

TL*THE CONTACT OWNS A 1994 FORD EXPLORER. AFTER MAKING A RIGHT TURN AT 5 MPH, THE VEHICLE SLOWLY GAINED SPEED AND THEN UNEXPECTEDLY ACCELERATED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE SLOWED DOWN MOMENTARILY, BUT DID NOT STOP COMPLETELY. THE SPEEDOMETER DISPLAYED 80 MPH AND THE REAR WHEELS BEGAN TO SMOKE, DUE TO THE FACT THAT THE BRAKE PEDAL WAS DEPRESSED WHILE THE VEHICLE WAS STILL ACCELERATING. HE MANAGED TO TURN THE KEY AND SHUT OFF THE ENGINE. THE CONTACT ATTEMPTED TO RESTART THE ENGINE, BUT THE RPM DIAL WAS IN THE RED ZONE. HE WAS ABLE TO DRIVE THE VEHICLE BACK TO HIS RESIDENCE AND DISCOVERED THAT THE THROTTLE PLATE WAS STUCK IN THE OPEN POSITION. HE REPAIRED THE FAILURE ON HIS OWN, WITHOUT THE DEALER'S ASSISTANCE. HE BELIEVES THAT HAD HE NOT BEEN KNOWLEDGEABLE OF THE FAILURE, IT COULD HAVE BEEN A LOT MORE SEVERE. THE CURRENT AND FAILURE MILEAGES WERE 90,000. UPDATED 07/15/08

NHTSA ID

10228545

Incident

May 19, 2008

Mileage

90,000 mi

TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 10 MPH, THE ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED MINUTES LATER, BUT QUICKLY RESTARTED. SMOKE APPEARED UNDER THE HOOD AND THEN THE VEHICLE BURST INTO FLAMES. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE VIN, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 90,000.

NHTSA ID

10211900

Incident

Dec 14, 2007

Mileage

90,000 mi

I WAS BROWSING FOR A USED CAR AND CAME ON AN ADD SELLING CARS I HAD NO VEHICLE I ASKED IF THEY CAN PICK ME UP ON THE OTHER SIDE OF THE CLINTON FERRY. THEY SAID YES THEY WILL PICK ME UP. SO CHECKED OUT THEIR INVENTORY. I PICKED A 1994 FORD EXPLORER LITTLE DAMAGE TO THE BODY, TIRES NEEDED CHANGING, THE FRONT WINDSHIELD HAS DAMAGE, AND REAR VIEW MIRROR WAS GONE. I ACCEPTED THESE AND ASKED FOR A TEST RIDE PROCEEDED OFF THE LOT THERE WAS NO GAS MAKING A TEST DRIVE SHORT. IT WAS AS IF THEY RUSHED ME THROUGH THE DEAL NOTHING WAS SAID ABOUT THE PROBLEMS. RETURNING HOME IS WHEN I BEGAN RUNNING INTO PROBLEMS THAT WERE SAFETY ISSUES. THE RPMS HAD GONE TO THE LIMITS OF SAFE OPERATION EXCEEDING 6,000 RPMS AND NOT SHIFTING TO A HIRE GEAR MAKING THE MOTOR SCREEN NEARLY EXPLODING THE MOTOR THIS IS CONSISTENT EVERY TIME YOU OPERATE. SO DROVE HOME WITH THIS PROBLEM. I ACCELERATED AND THEN LET OFF THE GAS AND IT THEN SHIFTED UP. I GAVE IT THE GAS IT SCREAMED AND I LET OFF THE GAS AND IT SHIFTED INTO THE HIGHER GEAR I ALSO HAVE STEERING PROBLEMS IT PULLS TO THE LEFT PULLING ME INTO ON GOING TRAFFIC, SHIMMIES AND THE TIE RODS CONNECTED TO THE STEERING HAD SOME PLAY IN THEM. SO WHEN I TURNED LEFT OR RIGHT I HAD NO STEERING UNTIL IT GOT TO CERTAIN POINT WHERE IT STEERED. THE VEHICLE FLOATS LIKE A BOAT A STRUT PROBLEM. NOW WHEN I WENT TO ESTIMATES FOR THE REPAIRS ITS PARTS AND LABOR CAME TOO ABOUT THE SAME AMOUNT I PAID FOR THE TRUCK APPROXIMATELY 4,400.00. SO NOW I HAVE THIS TRUCK I REFUSE TO DRIVE. I TOLD THEM TO COME AND GET IT AND NO WAY WAS I GOING TO DRIVE AN UNSAFE TRUCK SO IT SITS IN MY DRIVEWAY. I REFUSE TO PAY THEM ANY MONEY. THEY HAVEN'T CALLED ME, NOR MADE ANY DEAL.

NHTSA ID

10206124

Incident

Sep 27, 2007

Mileage

99,999 mi

THE POWER CONTROL FOR SIDE VIEW MIRROR SHORTED OUT AND CAUSED ELECTRICAL SMOKE AND ORANGE GLOW/FIRE FROM SIDE CONSOLE. CHECKING YOUR SITE, YOU ALREADY LIST THIS BUT DEALERSHIP AND FORD DO NOT HAVE A RECORD OF THIS RECALL (97V083000).

NHTSA ID

10190807

Incident

May 14, 2007

Mileage

61,000 mi