2001 Ford Explorer Body & structure Problems

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE LEAKED ANTI-FREEZE AND TRANSMISSION FLUID. THERE WAS ALSO RUST UNDERNEATH THE VEHICLE AND A HOLE IN THE RUNNING BOARDS, WHICH ALMOST CAUSED THEM TO DETACH. THE CONTACT CLAIMED THAT THE GROUND COULD BE SEEN THROUGH THE HOLE. THE VEHICLE ALSO PRODUCED THICK SMOKE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE CONTACT PLANNED TO HAVE THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 170,000.

NHTSA ID

11187507

Incident

Mar 16, 2019

Mileage

170,000 mi

THE VEHICLE ROLLED OVER ON ITS SIDE ON DRY PAVEMENT ON THE FWY AT THE POSTED SPEED LIMIT IN GOOD WEATHER CONDITIONS. NO OTHER VEHICLE WAS INVOLVED, THE CAR SKIDED WHEN I ATTEMPTED TO CHANGE LANES. I WENT INTO A SKID AND THE CAR TURNED ON ITS SIDE.

NHTSA ID

11088800

Incident

Apr 16, 2018

Mileage

251,000 mi

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE THE VEHICLE WAS STATIONARY, THE CHILD SAFETY LOCKS ARE NOT FUNCTIONING ON THE REAR DOORS COULD NOT BE OPENED FROM THE INSIDE, BUT ONLY FROM OUTSIDE THE VEHICLE. MARYSVILLE FORD IN MARYSVILLE, WASHINGTON WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 30. *TT *TR

NHTSA ID

11065729

Incident

Dec 1, 2000

Mileage

30 mi

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING 35 MPH, THE CONTACT HEARD A LOUD THUMP COMING FROM THE REAR HATCH WINDOW. UPON FURTHER INVESTIGATION, THE REAR HATCH WINDOW WAS LOOSE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000. ....UPDATED 07/05/16 *BF UPDATED 07/13/16.*JB

NHTSA ID

10862579

Incident

Feb 7, 2016

Mileage

72,000 mi

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING, THE FRONT DRIVER SIDE SEAT BELT WOULD SUDDENLY UNLOCK. IN ADDITION, THE DRIVER SIDE AND PASSENGER SIDE FRONT SEATS WOULD MOVE FORWARD WHEN MAKING A SUDDEN STOP AND THE PASSENGER SIDE DOOR AND HATCH DOOR WOULD NOT OPEN. THE VEHICLE WAS NOT DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 166,694.

NHTSA ID

10780714

Incident

Oct 2, 2014

Mileage

166,694 mi

FRAME /BODY MOUNTS, CREAK, SQUAWK CRUNCH , THE NOISE IS MOST NOTICEBLE WHEN TURNING OR HITTING BUMPS. SOME PEPLE ALSO DESCRIBE THE NOISE A HAMMER BEATING UNDER THE VEHICLE, THE CAUSE IS DETERIORATE BODY TO FRAME MOUNT CUSHIONS, THESE CUSHIONS APPER TO HAVE BEEN MADE OF SUBSTANDARD MATERIAL, MUCH LIKE CHINESE VALVE STEMS THAT CAUSE SO MUCH TROUBLE AFTER A FEW YEARS THE BODY MOUNTS DRY ROT , CRUMBLE AND LITERALLY FALL APART, THIS A TERRIBLE, THIS CAN PROVOKED A ACCIDENT.

NHTSA ID

10763311

Incident

Sep 15, 2013

Mileage

99,776 mi

REAR END OF CAR THUMPED EVERY TIME YOU WOULD GO OVER THE SMALLEST SEPARATION IN THE ROAD AND ALSO ON A BUMPY ROAD. REPLACED REAR END SHOCKS. STILL HAVE THE SAME PROBLEM OF THUMPING. SOME TIMES IT FEELS LIKE I'M GOING TO LOOSE THE REAR END OF THE VEHICLE. I WAS TOLD POSSIBLY NOW THAT BACK BUSHINGS HOLDING THE BODY TO THE FRAME MAY BE DISINTEGRATED. VEHICLE HAS ALWAYS BEEN WELL MAINTAINED AND GARAGED. I HAVE FOUND OUT THAT THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS OCCURRING NOW WITH THIS 2001 MODEL. YOU WOULD THINK THERE WOULD BE A SAFETY RECALL BY FORD TO FIX THESE BUSHING PROBLEMS. *TR

NHTSA ID

10659595

Incident

Oct 30, 2013

Mileage

107,000 mi

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE BODY MOUNTS CORRODED WHICH CAUSED THE FRAME TO BECOME DETACHED FROM THE BODY OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND THE REAR BODY MOUNTS WERE REPLACED. THE FRONT PARTS WERE NOT REPLACED DUE TO THE PARTS BEING UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10652220

Incident

Aug 14, 2012

Mileage

100,000 mi

BODY MOUNTS DETERIORATE BEFORE THEIR TIME AND BALL JOINT FAIL. *TR

NHTSA ID

10510134

Incident

Apr 30, 2013

Mileage

123,587 mi

CPSC#I12A0111A. 2001 FORD EXPLORER. CONSUMER STATED THAT A DAY AFTER SHE BROUGHT THE CAR IT BROKE DOWN. *LN THE CONSUMER STATED THERE WAS A PROBLEM WITH THE ENGINE, AS WELL AS A HOLE IN GAS TANK, WHICH HAD RUSTED OUT, THE BEARINGS NEEDED TO BE REPLACED, THE TIRE WERE DRY ROTTED, AS THEY KEPT GOING FLAT, THE DRIVER'S DOOR DID NOT LOCK, THE REAR DOORS DID NOT OPEN FROM THE INSIDE, THE REAR DRIVER'S DOOR DID NOT OPEN AT ALL, THE OUTSIDE HANDLE WAS BROKE, THE REAR HATCH WOULD NOT CLOSE, AND MOST OF THE TIME IT HAD TO BE SLAMMED SHUT.

NHTSA ID

10481761

Incident

Aug 5, 2012

TL*THE CONTACT OWNS A 2001 FORD EXPLORER. WHEN THE CONTACT ATTEMPTED TO OPEN THE REAR WINDOW THE LIFT GATE FAILED TO OPEN. THE MANUFACTURER STATED THAT THE VIN WASN'T INCLUDED IN RECALL 04V442000 STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS; THEREFORE THEY WILL NOT OFFER ANY ASSISTANCE. THE VEHICLE WILL BE TAKEN TO THE DEALER TO BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 126,643.

NHTSA ID

10348163

Incident

Aug 8, 2010

Mileage

126,643 mi

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH AND ENCOUNTERED BUMPS IN THE ROAD. THE VEHICLE EXHIBITED A LOUD RATTLING NOISE COMING FROM THE REAR END OF THE VEHICLE. THE FAILURE OCCURRED WHENEVER TRAVELING OVER BUMPS OR UNEVEN ROAD SURFACES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN INFORMED THAT THE FAILURE WAS RELATED TO THE REAR INTERNAL PANEL. THE FRONT AND REAR SHOCKS WERE REPLACED. THE CONTACT STATED THE VEHICLE HAD BEEN TAKEN TO THE DEALER ON NUMEROUS OCCASIONS FOR THE IDENTICAL FAILURE WHICH THERE WERE NO RESOLUTIONS. THE FAILURE CONTINUED TO OCCUR. THE FAILURE MILEAGE WAS APPROXIMATELY 6,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10343139

Incident

Sep 20, 2001

Mileage

6,000 mi

TL*THE CONTACT OWNS A 2002 FORD EXPLORER XLT. THE CONTACT STATED THE COMPOSITE PANEL, WHICH IS ATTACHED TO THE LIFT GATE, BEGAN TO CRACK AND FRACTURE FROM THE VEHICLE. THE DEALER WAS UNABLE TO OFFER REMEDY FOR THE FAILURE AND ADVISED CONTACTING THE MANUFACTURER. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 15,463 AND THE CURRENT MILEAGE WAS 90,438. UPDATED 05/19/10*LJ

NHTSA ID

10325864

Incident

Dec 30, 2003

Mileage

15,463 mi

I HAVE A 2001 EXPLORER AND THE PAINT HAS BEEN PEELING OFF FOR A COUPLE OF YEARS. IF I WASH IT WITH HIGH PRESSURE, THE PAINT WILL BLOW OFF THE HOOD. PAINT HAS BUBBLED AND COME OFF ON THE HOOD, TAILGATE AND BOTH QUARTER PANELS OVER THE REAR WHEELS. I HAND WASH IT AT THIS POINT TO MINIMIZE MORE PAINT LOSS. *TR

NHTSA ID

10240320

Incident

Feb 1, 2006

Mileage

99,000 mi

RUNNING BOARDS HAVE RUTTED OUT AND IF SOMEONE STEPPED ON THEM IT COULD FALL OUT. *TT

NHTSA ID

10021756

NAR 05/21/2003 *MR LOUD POPPING IN FRONT END,PASSENGER SIDE WINDOW DEFECTIVE, BACK DOORS BREAKING FROM IN SIDE HANDLES. *CB

NHTSA ID

10020384

Incident

Mar 25, 2003

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH WATER LEAKING. ALSO STATED THAT IS MORE THAN JUST A LEAKAGE BECAUSE EVERYTIME THE CONSUMER MAKES A LEFT OR RIGHT TURN YOU CAN HERE A REAL LOUD SOUND OF WATER MOVING ON THE ROOF. DEALER WAS CONTACTED AND STATED THAT TO KEEP THE WINDOWS OPEN SO THE WATER CAN DRY. TS

NHTSA ID

8023720

THE NUMBER THREE BODY MOUNT LOCATED IN THE CAB OF THE VEHICLE HAS CRACKED THROW THE METAL WHICH CAUSES THE BODY TO BE DISCONNECTED FROM THE FRAME OF THE VEHICLE. THE MANUFACTURER HAS A SERVICE BULLETIN 122-25 FOR THIS PART,BUT THE REPAIR SOLUTION DOSE NOT FIX THE PROBLEM PER CONSUMER. PLEASE PROVIDE MORE DETAILS. TS

NHTSA ID

8023335

CUSTOMER STATES, THE COVER FOR DOOR LOCK AND WINDOW SWITCHES ON THE DRIVER SIDE AND FRONT DOOR IS LOOSE AND WILL NOT STAY SNAPPED IN PLACE, ALSO THE DOOR HINGES WERE REPLACED.*SCC *YH

NHTSA ID

567425

Incident

Sep 25, 2001

STRAPS FAIL TO HOLD SCOOTER SECURELY, BOLTS HOLDING ROLLERS IN PLACE BEND, SCREWS HOLDING PLATFORM TOGHETHER COME LOOSE,THE LIFT FAILS TO REMAIN IN THE UP POSITION WITH THE SCOOTER SECURED TO IT AFTER HITTING MILD BUMPS.

NHTSA ID

765362

Incident

Sep 30, 2001

CONSUMER STATES THAT WHILE DRIVING AT OVER 50 MPH THE SLIGHTEST BUMP ON THE ROAD WILL CAUSE THE VEHICLE TO SWAY. CONTACTED DEALER AND THE DEALER IS NOT WILLING TO DO ANYTHING.*JB

NHTSA ID

8009977

Incident

Jan 1, 2001

CONSUMERS DAUGHTER WAS DRIVING THE VEHICLE WHEN SOME ONE CUT IN FRONT OF HER. TAKING EVASIVE ACTIONS TO AVOID A CRASH THE VEHICLE ROLLED OVER TWICE. THE VEHICLE WAS PURCHASED WITH FIRESTONE TIRES ON THEM. AS A PRECAUTION, CONSUMER HAD ALL 4 TIRES REPLACED. THE ROLL OVER WAS NOT CAUSED BY TIRE DELAMINATION. CONSUMER STATES BECAUSE OF THE ROLLOVER RISKS INVOLVED WITH THE FIRESTONE TIRES ON THIS PARTICULAR SUV IS THE REASON CONSUMER REPLACED THE FIRESTONE TIRES AS A PREVENTIVE MEASURE. DESPITE THE PRECAUTION THE VEHICLE ROLLED OVER. CONSUMER WOULD LIKE NHTSA TO RECONSIDER ITS DECISION NOT TO INITIATE A SAFTEY INVESTIGATION OF THE FORD EXPLORER. *JG

NHTSA ID

564668

Incident

Mar 16, 2001

CONSUMER STATED DURING A ROLLOVER THE SEAT BELTS DID NOT WORK PROPERLY, AND PASSENGER WAS EJECTED FROM VEHICLE, VEHICLE WAS HIT AND ROLLED OVER, CONSUMERS WIFE WAS EJECTED RESULTING IN A FATALITY. *JG *AK ODI SPOKE TO HUSBAND AND HE ASSUMED HIS WIFE WAS WEARING THE SEATBELT. WIFE WAS DRIVING AND DURING EVENT WAS THROWN OUT THE PASSENGER'S SIDE WINDOW. THERE WAS NO WITNESS TO THE WIFE WEARING THE BELT.CW

NHTSA ID

8005377

Incident

Dec 10, 2001

VEHICLE HESITATES UPON ACCELERATION AND HAS ALSO STALLED ON 5 OCCASIONS, THE DEALER HAS REPAIRED/REPLACED VARIOUS COMPONETS ON THE VEHICLE, HOWEVER CONSUMER STILL EXPERIENCES THE SAME PROBLEMS.*JB

NHTSA ID

564277

Incident

Oct 11, 2001

CONSUMER IS CALLING TO REPORT A DEFECT ON THE RUNNING BOARDS. CONSUMER SUSTAINED A FRACTURED HAND FROM FALLING OFF OF SLIPPERY RUNNING BOARDS. DEALER HAS YET TO BE CONTACTED. PLEASE PROVIDE FURTHER DETAILS.*AK

NHTSA ID

8001336

Incident

Dec 21, 2001