2005 Ford Explorer Electrical Problems

SEVERAL TIMES OVER THE PAST TWO YEARS WHILE DRIVING AT HIGH SPEEDS ALL THE ELECTRICAL TURNS OFF LIKE THE KEY IS TURNED OFF. IT IS ALMOST IMPOSSIBLE TO STEER AS THERE IS NO POWER STEERING. IT ALMOST CAUSED AN ACCIDENT AS THE CAR SLOWED QUICKLY. I AM CONCERNED AS THIS HAS BEEN REPORTED SEVERAL TIMES AND NOTHING HAS BEEN DONE TO SOLVE THIS ISSUE. EITHER FORD SHOULD FIX THE ISSUE OR PULL THIS CAR OUT OF SERVICE BEFORE SOMEBODY IS KILLED.

NHTSA ID

11361210

Incident

Sep 25, 2020

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT SHORTLY AFTER REFUELING, THE VEHICLE FAILED TO ACCELERATE WITH THE ACCELERATOR PEDAL DEPRESSED. THE CONTACT STATED THAT THE VEHICLE THEN ABRUPTLY ACCELERATED AT A HIGH RATE OF SPEED WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. ALSO, THE LOW OIL PRESSURE WARNING LIGHT AND CHECK TRANSMISSION WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT THEY WERE CLOSE TO HOME SO THEY PULLED INTO THE DRIVEWAY TO CHECK THE OIL LEVEL, WHICH WAS LOW. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE ENGINE BEARING NEEDED TO BE REPAIRED DUE TO DAMAGE CAUSED BY A DEFECTIVE OIL SENSOR NOT PROPERLY INFORMING THE CONTACT WHEN THE OIL LEVEL WAS LOW. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CONTACTED THE DEALER CAPITAL CITY FORD LOCATED AT 8623 E. WASHINGTON ST, INDIANAPOLIS, IN 46219) WHO INFORMED THE CONTACT THAT THERE WERE NO RECALLS ON THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 250,406. INVALID VIN.

NHTSA ID

11350238

Incident

Jul 12, 2020

Mileage

250,406 mi

ABS LIGHT AND ADVANCE TRACKING LIGHT AND 4X4 LIGHT AND CAR WITH TRACKING LIGHT ALL COMES ON AND THE BRAKING JERK WHEN STOPPING. ALSO LOW OIL PRESSURE LIGHT COMES ON EVEN AFTER OIL CHANGE

NHTSA ID

11090267

Incident

Apr 1, 2018

MY EXPLORER TRANSMISSION JUST STOPPED WORKING GOING DOWN THE HIGHWAY, ALMOST GOT HIT BY A TRUCK. ELECTRICAL SYSTEM KEPT GOING IN AND OUT. CHECKED WITH A FORD DEALERSHIP THEY SAID IT WAS A COMMON PROBLEM WITH EXPLORERS AND THERE WAS NO RECALL. I CHECKED ONLINE AND THERE WAS OVER 10,000 COMPLAINTS MADE. I AM IN THE MILITARY HAVE 14 COMBAT TOURS, AND COME HOME TO HAVE MY LIFE PUT IN DANGER AGAIN ON SOMETHING THAT YOU ALL KNOW ABOUT. WHEN ARE YOU GOING TO STEP IN?

NHTSA ID

11047135

Incident

Nov 18, 2017

Mileage

87,000 mi

WHILE DRIVING DOWN THE INTERSTATE AT NIGHT MY VEHICLES DASHBOARD BEGAN TO ACT ERRATIC. THEN THE BATTERY GAUGE RAPIDLY DROPPED INTO THE RED ZONE. WITHIN ABOUT 3 MILES I LOST MY INTERIOR POWER, HEADLIGHTS, TAILLIGHTS, AND SIGNALS INCLUDING MY HAZARD LIGHTS. WHEN LIMPING OFF THE INTERSTATE MY TRUCK HAD LOST ENOUGH POWER TO WHERE IT DIED OUT. ONCE AT THE DEALERSHIP IT WAS FOUND THAT THE ALTERNATOR FRIED OUT CAUSING A SURGE THAT WIPED OUT THE PCM AND UTILITY CLUSTER ALL WITHOUT WARNING.

NHTSA ID

11020712

Incident

Aug 25, 2017

Mileage

162,000 mi

MY GAUGES GO HAYWIRE THE NEEDLES SHAKE WHILE DRIVING AND WHEN CAR IS OFF NO KEY IN IGNITION. THE LIGHTS FLASH AS WELL. CAR WILL STALL IN TRAFFIC AT A STOP, THE RPM WON'T GO ABOVE 2 EVEN WHEN HWY GOING 60 MPH. MECHANIC SAID IT'S ELECTRICAL, THE DEALER TOOK OUT TOP COUNSEL AS A WORK AROUND FOR THIS ELECTRICAL ISSUE CLAIMING IT WAS NOT A RECALL.

NHTSA ID

11019486

Incident

Aug 23, 2017

WHILE PARKED IN THE DRIVEWAY, WE FOUND THAT THE BACK WINDOW OF THE HATCH WAS COMPLETELY BROKEN AND THE BODY IN THE BACK WAS LIFTED OFF THE CAR. IT LOOKS AS IF THE HYDRAULIC ARM MALFUNCTIONED OVERNIGHT.

NHTSA ID

10870598

Incident

May 24, 2016

Mileage

103,597 mi

CAR STALLED WHILE DRIVING AT HIGHWAY SPEEDS. BRAKES AND STEERING BECAME IMPAIRED. LUCKY, I WAS IN THE RIGHTMOST LANE AND WAS ABLE TO NARROWLY AVOID COLLISION. INCIDENT OCCURRED AFTER A ~3HR DRIVE AS I WAS EXITING THE HIGHWAY (I.E. SLOWING DOWN). UPON RESTART, ENGINE TURNED OVER, BUT WAS UNDRIVEABLE DUE TO ITERATIVE SURGE/STALL CYCLES.

NHTSA ID

10862482

Incident

May 2, 2016

Mileage

95,000 mi

DEFECTIVE THROTTLE BODY ASSEMBLIES AND SENSORS. RANDOMLY ENGINE GOES INTO FAIL SAFE MODE AND HAS STALLED WHILE DRIVING, AT TRAFFIC LIGHTS, AND DURING TURNS. INSTRUMENT PANEL IS NOW GOING HAYWIRE. MESSAGE CENTER REPORTS LOW OIL PRESSURE, CHECK CHARGING SYSTEMS, TIRE SENSOR FAILURE FAULT, CHANGE OIL SOON, AND OIL IS FINE. BATTERY HAS BEEN CHECKED. TIRE SENSORS, ALTERNATOR...ALL FINE. IT'S ALL I HAVE AND I MUST DRIVE IT TO WORK EACH DAY! BOUGHT USED IN NOVEMBER 2013. HAD 69K MILES AT PURCHASE. NOW HAS 103K MILES. IT DOESN'T FEEL SAFE :O( PLEASE HELP!

NHTSA ID

10806635

Incident

Feb 1, 2014

THE VEHICLE SHUTS OFF WHILE DRIVING CAUSING LOSS OF POWER STEERING, POWER BRAKES WITH A COMPLETE LOSS OF POWER. THIS IS AN ONGOING PROBLEM AND HAS HAPPEND DURING HIGHWAY HIGH SPEED DRIVING. IT HAPPENS ON CARS BUILT 11/24/04 AND PRIOR. THE CODES ARE P2106 AND P2135. IT'S CAUSED BY A FAULTY THROTTLE POSITION SENSOR AND REQUIRES A POWERTRAIN CONTROL MODULE RESET B36.11, B37.2 OR HIGHER. THIS HAS BEEN AN ONGOING PROBLEM THAR FORD READILY ACKOWLEDGES. THEY HAVE UGRADED THE THROTTLE POSITION SENSOR TWICE WITHOUT SOLVING THE PROBLEM.

NHTSA ID

10748493

Incident

Aug 5, 2013

Mileage

124,000 mi

MISFIRES, COILS KEEP FAILING. *TR

NHTSA ID

10641322

Incident

Oct 7, 2013

Mileage

78,000 mi

CONSUMER WRITES TO REQUEST AN INVESTIGATION CONCERNING THE BUSINESS PRACTICES OF A LOCAL AUTO REPAIR CENTER. *TGW THE CONSUMER DID NOT THINK, THE REPAIR FACILITY WAS ACTUALLY PERFORMING THE SERVICES ON HIS VEHICLE. THE CONSUMER STATED THE VEHICLE FAILED INSPECTION, DUE TO LOW TIRE TREAD. HE STATED HE WAS JUST IN THE REPAIR FACILITY ONE MONTH PRIOR, AND NO MENTIONED TO HIM, THERE WAS A PROBLEM WITH THE TIRES. ALSO, THE ALTERNATOR WAS REPLACED. HOWEVER, IT WAS DETERMINED THE NEW ALTERNATOR WAS DEFECTIVE. *JB

NHTSA ID

10638957

Incident

Nov 1, 2011

ELECTRIC WINDOWS WON'T WORK. ALL FUSES ARE WORKING. SOME WIRES THAT GO FROM THE VEHICLE FRAME TO THE DRIVERS SIDE DOOR ARE SEVERED AND MELTED. THE WIRES ARE IN A PROTECTIVE RUBBER BOOT THAT IS BETWEEN VEHICLE FRAME AND DOOR. *TR

NHTSA ID

10630956

Incident

Sep 5, 2014

Mileage

134,000 mi

BODY ISSUES: I HAVE A 2005 FORD EXPLORER AND HAVE NEVER BEEN IN A CAR ACCIDENT. MY TAILGATE SOMEHOW DEVELOP A CRACK THAT GOES THROUGH WHERE THE FORD LOGO IS. NOTHING HAPPENED TO THE SUV TO CAUSE THE CRACK. IT JUST SOMEHOW HAPPENED ON IT'S OWN. I BELIEVE THE VEHICLE IS DEFECTIVE OR AT LEAST THE MATERIALS USED TO MAKE THE VEHICLE. ELECTRICAL ISSUES: ANOTHER ISSUE I HAVE IS WITH THE ELECTRICAL. MY TURN SIGNALS (MOST TIMES) DO NOT WORK. I HAVE TO MANUALLY MOVE IT UP AND DOWN WHEN TURNING. WHEN IT DOES WORK, IT GOES REALLY FAST. MY REVERSE NOTIFICATION NO LONGER WORKS FOR SOME STRANGE REASON. ALSO, MY RADIO GOES LOUDER WHEN I TURN IT DOWN. I HAVE TO TURN IT OFF FOR A LITTLE WHILE, TURN IT BACK ON THEN TRY TO LOWER THE VOLUME. *TR

NHTSA ID

10588964

Incident

Mar 3, 2014

BECAUSE OF THE RECENT GM RECALL IGNITION ISSUE, I THOUGHT I SHOULD LET SOMEONE KNOW ABOUT THE SERIOUS SIMILAR ISSUE I HAD 3 TIMES BEFORE I TRADED MY CAR IN. THE CAR WOULD JUST SHUT OFF WHILE DRIVING. AND ALL 3 TIMES, I PULLED TO THE SIDE OF THE ROAD AND RESTARTED THE CAR AND CONTINUED ON MY WAY. I WAS LUCKY TO HAVE A PLACE TO PULL OVER SAFELY. I TOOK IT TO MY MECHANIC TWICE, FOUND NOTHING WRONG. TOOK IT TO FORD AND THEY FOUND NOTHING WRONG. I TRADED THE 2005 FOR A 2011. I ALSO TOLD THE DEALER THAT I TRADED IT INTO ABOUT THE ENGINE JUST SHUTTING OFF FOR NO REASON AND TO CHECK OUT THE PROBLEM BEFORE THEY SOLD IT AGAIN. *TR

NHTSA ID

10575830

Incident

Mar 18, 2011

Mileage

80,000 mi

HAD FUELED (FULL) 2 HOURS BEFORE. GAS GAUGE DROPPED TO EMPTY. MILES TO EMPTY SHOWS DASHES. SERVICE ENGINE SOON LIGHT IS ON. *TR

NHTSA ID

10560784

Incident

Jan 16, 2014

Mileage

165,000 mi

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE ENGINE CAUGHT ON FIRE. THE FIRE EVENTUALLY DIED WITHOUT BEING EXTINGUISHED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO THE DEALER, BUT WAS NOT YET DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

NHTSA ID

10542332

Incident

Sep 6, 2013

Mileage

94,000 mi

TRAVELING ON 459 NORTH, AROUND THE GRANTS MILL ROAD EXIT, I ENCOUNTERED THE POORLY PAVED ROAD/POT HOLES AND MY STEREO/CD SYSTEM NO LONGER WORKS. THIS PROBLEM HAD NEVER OCCURRED UNTIL DRIVING ON THE POORLY MAINTAINED ROADS IN THIS STATE. PLEASE CONTACT ME AS SOON AS POSSIBLE IN REGARDS TO HANDLING THIS PROBLEM. *TR

NHTSA ID

10511610

Incident

May 13, 2013

WHILE STOPPED AT A TRAFFIC LIGHT I SWITCHED ON MY TURN SIGNAL TO INDICATE A RIGHT TURN AND NOTICED THE NORMAL CLICK OF THE TURN SIGNAL WAS NOT OCCURRING. I LOOKED DOWN AT MY INSTRUMENT PANEL AND SAW THE RIGHT TURN LIGHT WAS LIT BUT NOT FLASHING. THE REST OF THE TRIP I HAD TO CONTINUALLY TURN ON AND TURN OFF THE TURN SIGNAL TO LET OTHERS NOW MY INTENTIONS SINCE THE SIGNALS WOULD NO LONGER FLASH. FINALLY I RAPIDLY WORKED THE SWITCH UP AND DOWN AND WAS ABLE TO GET THE TURN SIGNALS TO OPERATE CORRECTLY AGAIN. ALSO ON OTHER OCCASIONS THE SIGNAL WOULD CLICK VERY FAST WHICH AND THE ACTUAL SIGNAL LIGHT WOULD NOT FLASH OR LIGHT BUT WOULD EVENTUALLY START WORKING AGAIN. I ASSUMED IT WAS A BURNED-OUT BULB BUT WHEN IT CAME BACK ON AGAIN I KNEW THAT WAS NOT THE CASE. I SAW A RECALL RECENTLY FOR THE TURN SIGNAL SWITCH ON RANGER PICKUPS AND EXCURSION SUVS IN THE AGE RANGE OF MY VEHICLE AND THIS SEEMS TO BE EXACTLY WHAT IS HAPPENING WITH MY EXPLORER.

NHTSA ID

10417248

Incident

Jun 24, 2011

Mileage

95,120 mi

DASHBOARD - WARNING LIGHT FOR OIL CHANGE REQUIRED WILL NOT GO OFF - HAD OIL CHANGE 500 MILES AGO - NOT DUE FOR 2 MORE MONTHS - WILL NOT RESET. DEALER SAID IT WAS A BAD OIL GAUGE SENSOR. *TR

NHTSA ID

10398641

Incident

Apr 4, 2011

Mileage

51,000 mi

ELECTRICAL SYSTEM , BODY STRUCTURE , GAS PEDAL. *TR

NHTSA ID

10378795

Incident

Dec 20, 2010

Mileage

53,000 mi

JUST DRIVING ALONG TAKING A MILD CORNER AND MY 2005 FORD EXPLORER JUST DIED AND THE STEERING WHEEL LOCKED UP. TOOK TO THE LOCAL AUTO REPAIR AND THEY GOT TWO CODES P2104 AND P2112. WHICH HAS SOMETHING TO DO WITH THE THROTTLE ACTUATOR. AFTER SPEAKING WITH FORD LOCALLY THE PART(S) FOR THIS PROBLEM HAVE BEEN ON BACK ORDER SINCE AT LEAST AUGUST AND THEY ARE SAYING THEY MAY NOT BE AVAILABLE UNTIL JAN. 2010 OR LATER. *TR

NHTSA ID

10291826

Incident

Nov 10, 2009

Mileage

78,000 mi

2005 FORD EXPLORER FUEL GAUGE MALFUNCTION: STARTED ABOUT A YEAR AGO. WAS INTERMITTENT AT FIRST, BUT IS NOW CONSTANT. FUEL GAUGE REGISTERS EMPTY UNTIL TANK IS ABOUT HALF FULL, AFTER WHICH THE GAUGE WORKS PROPERLY. SERVICE ENGINE LIGHT STAYS ON. A SCAN OF THE INTERNET INDICATES THIS IS A VERY COMMON PROBLEM AND FORD HAS NO PROGRAM IN PLACE TO FIX IT. SINCE THE GAUGE IS CAUSING THE SERVICE ENGINE LIGHT TO STAY ON, THAT LIGHT CANNOT ALERT ME TO OTHER POTENTIAL FAILURES. COST TO REPAIR IS APPROXIMATELY $500+. *TR

NHTSA ID

10279615

Incident

Jun 1, 2007

ON THREE OCCASIONS WITHIN THE PAST THREE WEEKS, MY CAR HAS LOST ALL POWER. ON TWO OF THESE OCCASIONS, I WAS SLOWING DOWN TO MAKE A TURN IN THE ROAD AND ON THE THIRD TIME, I WAS DRIVING ON A STRAIGHT-AWAY. EACH TIME I WAS DOING LESS THAN 40 MPH. ONLY ONE TIME WAS ANYONE ELSE IN THE VEHICLE BUT IT WAS STILL VERY SCARY AND VERY UPSETTING, CONSIDERING I HAVE ONLY HAD THE VEHICLE FOR 8 MONTHS. I AM JUST AFRAID THAT THIS IS GOING TO HAPPEN WHEN I AM GOING FASTER OR IN HEAVY TRAFFIC. SO FAR, I HAVE BEEN LUCKY AND HAVE NOT BEEN IN ANY TRAFFIC WHEN THIS HAS OCCURRED. *TR

NHTSA ID

10269892

Incident

May 25, 2009

Mileage

37,007 mi

05 FORD EXPLORER HAS REPEATED (ENGINE THROTTLE CONTROL) LIGHT WARNINGS. THE VEHICLE, WHILE MOVING, LOSES POWER AND THEN STALLS. I SHUT THE VEHICLE OFF, THE PROBLEM SEEMS TO RESET AND THE VEHICLE THEN RUNS FINE. THIS HAS HAPPENED ON (2) OCCASIONS AND NOW FEEL THE VEHICLE MAY NOT BE SAFE. *TR

NHTSA ID

10261973

Incident

Mar 3, 2009

Mileage

47,000 mi