Owner-reported complaints naming the other system, filed with NHTSA
Data refreshed
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above. Every record below is an owner-reported complaint about the 2011 Ford Explorer submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 18 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Power steering assist fault, and power steering EPS system failed while driving! Was replaced by Ford in 2015 and has already locked up while driving! Tire pressure sensor constantly stays on even after replacement.
The contact owns a 2011 Ford Explorer. The contact stated that while the windshield wipers were in the on position, the wipers went off the vehicle and had to be pushed back into place. There was an unknown yellow warning light illuminated. The contact stated that while making a turn, the driver's and passenger's front wheels detached on two occasions. The vehicle was taken to an independent mechanic and the vehicle received an unstated repair. There was an abnormal sound while driving at various speeds. While shifting gear, the vehicle jumped. The vehicle was taken to the local dealer however, the result of the diagnostic test was unknown. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 104,000.
My car show me warning Power steering assist fail Now my car not drive because cant turn right or left is too hard Engine and transmission is ok Power steering recall was in past Now I try get help from dealer they say not recall for steering is weird Epas 15N01 recall Still original parts on my car Please what I need to do Thanks
The contact owns a 2011 Ford Explorer. The contact stated that the vehicle was recently repaired under an unknown steering recall. The contact stated that while driving at various speeds, the vehicle lost power steering functionality. The steering assist, traction control, and an unknown warning light were illuminated during the failure. The contact stated that the vehicle would regain power steering functionality a day or two after the failure. The failure had recurred three times within the month. The contact had contacted the dealer who diagnosed that the power steering rack needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The manufacturer confirmed that the vehicle was out of warranty and referred the contact to NHTSA for assistance. The approximate failure mileage was 142,000.
ON FEBRUARY 14, 2021 WHILE CHECKING TIRE PRESSURES OF MY 4 COOPER ADVENTURER H/T CUV 245/60R18 TIRES. I NOTICED NUMEROUS SPLITTING OF THE LOWER SIDEWALL, AROUND THE BEADS OF ALL 4 TIRES. THIS IS NOT NORMAL DRY ROT / CRACKING OF THE LOWER SIDEWALL. THE SPLITTING OF THE SIDEWALLS HAVE GAPS FROM 1/16TH TO 1/8TH OF AN INCH WIDE. THE GAPS ARE 2 - 3/32NDS OF AN INCH DEEP. THE DOT #'S OF ALL 4 TIRES ARE UP83 1HT 4117. THE TIRES WERE INSTALLED AROUND THE BEGINNING OF 2018. THE TIRES HAVE APPROX. 25K MILES ON THEM. COOPER TIRES / PEP BOYS HAVE A 65K WARRANTY ON THESE TIRES. THERE IS APPROX. 7 - 9/32NDS OF THREAD LEFT ON ALL 4 TIRES. JUNE 5, 2019 COOPER TIRES ISSUED A SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 235/65R18. FEBRUARY 26, 2021 COOPER TIRES HAS ISSUED YET ANOTHER SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 275/65R18. BOTH, JUNE 5, 2019 AND FEBRUARY 26, 2021 RECALLS OF THE COOPER ADVENTURER H/T CUV TIRES WERE ISSUED DUE TO MANUFACTURING DEFECTS OF THE LOWER SIDEWALL. THE 4 COOPER ADVENTURER H/T CUV 245/60R18 INSTALLED ON MY VEHICLE HAVE VERY SIMILAR LOWER SIDEWALL DEFECTS, AS BOTH OF THE ISSUED RECALLS FOR THIS EXACT SAME TIRE MODEL. I FEEL THAT THE SPLITTING OF MY TIRES ARE A SAFETY HAZARD DUE TO MANUFACTURING DEFECTS. I WOULD LIKE TO HAVE MY 245/60R18 COOPER ADVENTURER H/T CUV TIRES, AS WELL AS ALL OF THE OTHER SIZES OF THIS MODEL TIRE MADE BY COOPER, ADDED TO SAFETY RECALL TIRE LIST.
ON FEBRUARY 14, 2021 WHILE CHECKING TIRE PRESSURES OF MY 4 COOPER ADVENTURER H/T CUV 245/60R18 TIRES. I NOTICED NUMEROUS SPLITTING OF THE LOWER SIDEWALL, AROUND THE BEADS OF ALL 4 TIRES. THIS IS NOT NORMAL DRY ROT / CRACKING OF THE LOWER SIDEWALL. THE SPLITTING OF THE SIDEWALLS HAVE GAPS FROM 1/16TH TO 1/8TH OF AN INCH WIDE. THE GAPS ARE 2 - 3/32NDS OF AN INCH DEEP. THE DOT #'S OF ALL 4 TIRES ARE UP83 1HT 4117. THE TIRES WERE INSTALLED AROUND THE BEGINNING OF 2018. THE TIRES HAVE APPROX. 25K MILES ON THEM. COOPER TIRES / PEP BOYS HAVE A 65K WARRANTY ON THESE TIRES. THERE IS APPROX. 7 - 9/32NDS OF THREAD LEFT ON ALL 4 TIRES. JUNE 5, 2019 COOPER TIRES ISSUED A SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 235/65R18. FEBRUARY 26, 2021 COOPER TIRES HAS ISSUED YET ANOTHER SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 275/65R18. BOTH, JUNE 5, 2019 AND FEBRUARY 26, 2021 RECALLS OF THE COOPER ADVENTURER H/T CUV TIRES WERE ISSUED DUE TO MANUFACTURING DEFECTS OF THE LOWER SIDEWALL. THE 4 COOPER ADVENTURER H/T CUV 245/60R18 INSTALLED ON MY VEHICLE HAVE VERY SIMILAR LOWER SIDEWALL DEFECTS, AS BOTH OF THE ISSUED RECALLS FOR THIS EXACT SAME TIRE MODEL. I WOULD LIKE TO HAVE MY 245/60R18 COOPER ADVENTURER H/T CUV ADDED TO THE SAFETY RECALL TIRE LIST. THIS MODEL TIRE SHOULD BE UNDER REVIEW FOR ALL SIZES THAT ARE MANUFACTURED.
ON FEBRUARY 14, 2021 WHILE CHECKING TIRE PRESSURES OF MY 4 COOPER ADVENTURER H/T CUV 245/60R18 TIRES. I NOTICED NUMEROUS SPLITTING OF THE LOWER SIDEWALL, AROUND THE BEADS OF ALL 4 TIRES. THIS IS NOT NORMAL DRY ROT / CRACKING OF THE LOWER SIDEWALL. THE SPLITTING OF THE SIDEWALLS HAVE GAPS FROM 1/16TH TO 1/8TH OF AN INCH WIDE. THE GAPS ARE 2 - 3/32NDS OF AN INCH DEEP. THE DOT #'S OF ALL 4 TIRES ARE UP83 1HT 4117. THE TIRES WERE INSTALLED AROUND THE BEGINNING OF 2018. THE TIRES HAVE APPROX. 25K MILES ON THEM. COOPER TIRES / PEP BOYS HAVE A 65K WARRANTY ON THESE TIRES. THERE IS APPROX. 7 - 9/32NDS OF THREAD LEFT ON ALL 4 TIRES. JUNE 5, 2019 COOPER TIRES ISSUED A SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 235/65R18. FEBRUARY 26, 2021 COOPER TIRES HAS ISSUED YET ANOTHER SAFETY RECALL ON THIS EXACT MODEL TIRE BUT IN A DIFFERENT SIZE. THE TIRE SIZE IN THIS RECALL IS 275/65R18. BOTH, JUNE 5, 2019 AND FEBRUARY 26, 2021 RECALLS OF THE COOPER ADVENTURER H/T CUV TIRES WERE ISSUED DUE TO MANUFACTURING DEFECTS OF THE LOWER SIDEWALL. THE 4 COOPER ADVENTURER H/T CUV 245/60R18 INSTALLED ON MY VEHICLE HAVE VERY SIMILAR LOWER SIDEWALL DEFECTS, AS BOTH OF THE ISSUED RECALLS FOR THIS EXACT SAME TIRE MODEL. I WOULD LIKE TO HAVE MY 245/60R18 COOPER ADVENTURER H/T CUV TIRES ADDED TO THE SAFETY RECALL TIRE LIST. THIS MODEL TIRE SHOULD BE UNDER REVIEW FOR ALL MANUFACTURED SIZES.
I WAS DRIVING ON A MAJOR STREET DURING HEAVY AFTERNOON TRAFFIC. THE STEERING BECAME EXTREMELY DIFFICULT AND I COULD BARELY TURN THE WHEEL. THE WARNING LIGHTS FOR ADVANCED TRACTION FAILURE AND POWER STEERING ASSIST FAULT CAME ON. I ALSO NOTICED THE TERRAIN MANAGEMENT CONTROL WAS NO LONGER ILLUMINATED. I TRIED TO TURN OFF THE ROAD INTO THE DRIVEWAY BUT IT WAS EXTREMELY DIFFICULT. I AM A REASONABLY STRONG ADULT WOMAN AND HAD TO USE ALL MY STRENGTH TO TURN THE WHEEL EVEN SLIGHTLY WHILE SLOWLY MOVING. WHEN I MANAGED TO GET THE CAR INTO A SAFE PLACE I PUT THE CAR IN PARK AND TURNED IT OFF. WHEN THE CAR WAS STARTED AGAIN, IT RETURNED TO NORMAL AND I WAS ABLE TO DRIVE IT. THREE DAYS LATER, THE SAME THING HAPPENED WITH ANOTHER DRIVER WHILE I WAS A PASSENGER. THE OLDER MALE DRIVER HAD SIMILAR DIFFICULTY STEERING AND TURNING THE VEHICLE. I TOOK THE VEHICLE TO THE FORD DEALERSHIP FOR SERVICE. THEY REPAIRED THE RACK AND PINION STEERING FOR AN ESTIMATED COST OF OVER $2000. THE MILEAGE ON THE VEHICLE WAS APPROXIMATELY 36,400 MILES SO ABOUT 400 MILES PAST THE WARRANTY. WE WERE ABLE TO GET FORD TO REDUCE THE COST TO APPROXIMATELY $750, SOME OF WHICH WAS FOR THE ALIGNMENT THAT WAS NECESSARY FOLLOWING THE REPAIR. THIS INCIDENT COULD HAVE BEEN FAR WORSE WITH DEVASTATING RESULTS. I AM A MOM AND GIRL SCOUT LEADER AND TRANSPORT CHILDREN FREQUENTLY THROUGHOUT THE DAY. AT THE TIME OF THE INCIDENT I HAD 4 CHILDREN IN MY VEHICLE. *TR
I WAS GETTING READY TO TURN INTO THE PARKING LOT .. WHEN 2 SETS OF LIGHTS CAME ON ..THE SYSTEM INDICATORS CAME UP .. ONE INDICATING THE POWER STEERING ERROR AND ANOTHER INDICATING THE POWER STEERING LOCKED ... THEN THE STEERING WHEEL BECAME VERY HARD TO TURN .. MAKING SO VERY HARD TO TURN INTO A PARKING SPACE .. SOMEONE HAD TO PUSH ME INTO THE PARKING LOT OUT OF THE WAY .. LATER TO CALL FORD DEALERSHIP DOESN'T WANT TO ASSIST ME WITH THIS PROBLEM ... I DRIVE A 2011 FORD EXPLORER .. THE CAR IS 2 YEARS OLD . I REVIEWED OTHER CONCERNS OF THIS MATTER .. IS THERE A RECALL ... *TR
I WAS TRAVELING AT 40 MPH ON A BUSY CITY STREET WHEN ALL OF THE SUDDEN I HEARD A WARNING BING SOUND AND SAW THE POWER STEERING FAULT AND ALL TERRAIN MANAGEMENT FAILURE WARNINGS ON MY INSTRUMENT PANEL. LOST TOTAL ABILITY TO STEER THE VEHICLE AND HAD TO PUT ON EMERGENCY LIGHTS, STOP ON SIDE OF THE ROAD, TURN THE VEHICLE OFF AND ON (HOPING THAT IT WOULD RESET AND RESOLVE THE ISSUE) AND DOING THIS CLEARED THE WARNINGS AND I WAS ABLE TO STEER AGAIN. HOWEVER, TWO DAYS LATER THE PROBLEM HAPPENED AGAIN AFTER STARTING THE VEHICLE IN A PARKING LOT AND BEFORE STARTING TO BACK OUT OF THE PARKING SPACE. ONCE AGAIN TURNING THE VEHICLE OFF AND ON AGAIN RESET THE WARNING AND REGAINED STEERING ABILITY AGAIN. *TR
I OWN A 2011 FORD EXPLORER, I HAVE HAD NUMEROUS FAILURES TO THE ELECTRONIC POWER STEERING ASSIST. FIRST TIME THIS HAPPENED I WAS ALONG AT ABOUT 65 MPH AND THE STEERING WHEEL LOCKED UP AND THE WARNING LIGHTS STARTED FLASHING "TRACTION CONTROL" "POWER STEERING ASSIST FAILURES" . STEERING WHEEL BECOMES VERY DIFFICULT TO MOVE AND STEER CAR. THIS HAS HAPPENED 1/2 DOZEN TIMES, EACH TIME I SLOWLY STEER THE CAR TO A SAFE STOP TURN OFF THE CAR AND RESTART THE CAR AND ERROR CLEARS OUT. THIS LAST TIME IT OCCURRED AS I WAS TURNING LEFT FROM A LEFT TURN LANE WHEN SUDDENLY IN THE M IDLE OF THE TURN MY POWER STEERING LOCKED UP. FORTUNATELY I WAS TRAVELING AT VERY LOW SPEED, BUT I WAS NOT ABLE TO STEER CAR AND WENT ONTO ONCOMING LANE AGAIN I WAS FORTUNATE NOT TO HIT ANYONE. HOWEVER, THIS TIME THE PROBLEM DID NOT CLEAR ITSELF AND THE CAR IS AT THE LOCAL FORD DEALER FOR 8 DAYS NOW. THE SERVICE MANAGER SAYS ITS A GEAR AND FORD DOES NOT HAVE IT IN STOCK!!! *TR
2011 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO ISSUES WITH A "MY FORD TOUCH" VOICE ACTIVATED SYSTEM. *TGW THE CONSUMER STATED THE "MY FORD TOUCH" IS A VOICE OR TOUCH SCREEN ACTIVATED SYSTEM THAT CONTROLLED ENTERTAINMENT, CLIMATE, NAVIGATION AND HANDS FREE CELL PHONE FUNCTIONS. WHEN THE SYSTEM STOPPED WORKING, THERE WAS NO CONTROL OVER ANY OF THE AFOREMENTIONED DEVICES. THE CONSUMER HAD TO TAKE THE VEHICLE TO THE DEALER THREE TIMES, BECAUSE OF THE MALFUNCTIONING SYSTEM. A TYPICAL PROBLEM WAS THE SYSTEM LOCKING UP, THE SCREEN WOULD FREEZE AND THERE WAS NO CONTROL OVER THE HEATER/AIR CONDITIONER OR RADIO VOLUME. USUALLY AFTER 10-12 MINUTES THE SCREEN WOULD GO BLANK AND A MESSAGE APPEARED THAT READ PERFORMING SCHEDULE MAINTENANCE. WHEN THE SYSTEM WAS FINALLY RESTORED, EVERYTHING WORKED AGAIN. SOMETIMES WHEN USING THE NAVIGATION TO FIND AN ADDRESS, THE CAR ICON WOULD WANDER OFF THE PRESCRIBED ROUTE EVEN THOUGH THE CONSUMER WAS DRIVING THE PRESCRIBED ROUTE. WHEN THAT HAPPENED, THE SCREEN WOULD OFTEN DISPLAY A LARGE YELLOW QUESTION MARK. THE FIRST TIME THE CONSUMER VISITED THE DEALER, THEY FLASHED THE MEMORY. IT HELPED, BUT IT STILL FAILED, AT TIMES. THE SECOND TIME, HE RETURNED TO THE DEALER, THEY INSTALLED AN UPDATED PROGRAM FROM FORD THAT WAS SUPPOSED TO CORRECT THE PROBLEMS. BUT, AS TIME WENT ON, THE NEW PROGRAM STARTED TO FAIL IN A SIMILAR WAY AS THE OLD PROGRAM. THE LAST TIME, THE CONSUMER VISITED THE DEALER, THEY DID A MASTER RESET BY DISCONNECTING THE BATTERY, THEREBY REMOVING ALL POWER FROM THE SYSTEM AND REBOOTING IT WHEN THE BATTERY WAS RECONNECTED. THE DEALER INFORMED THE CONSUMER, HE COULD ALSO PULL FUSE 29 AND PUT IT BACK IN AGAIN. HOWEVER, THE CONSUMER STATED HE WAS NOT ABLE TO REACH THE FUSE, AS IT WAS TUCKED WAY UP UNDER THE DASHBOARD, BUT EVEN IF HE COULD REACH IT, IT WOULDN'T FIX THE DEFECTIVE SOFTWARE PROVIDED BY FORD AND MICROSOFT. DISCONNECTING THE BATTERY DIDN'T FIX THE PROBLEM, IT ONLY REBOOTED THE COMPUTER AND EVENTUALLY, THE PROBLEM WOULD RETURN. *JB
2011 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO SYNC MALFUNCTION IN VEHICLE. *SMD THE CONSUMER STATED WHEN THE SYSTEM FAILED, THE SCREEN WENT BLACK AND THE RADIO AND TEMPERATURE CONTROL STOPPED WORKING, AS WELL AS OTHER COMPONENTS. THE SYNC HAS BEEN WORKED ON BY THE DEALERSHIP 13 TIMES.
I WAS SLOWING DOWN AND GETTING INTO THE LEFT TURN LANE. THE LIGHT WAS GREEN SO I STARTED TO TURN LEFT AND THE TRACTION LIGHT SYSTEM CAME ON, BOTH LIGHTS, AND THE STEERING SYSTEM FAILURE ALERT CAME ON AND I LOST ALL POWER STEERING AND ALMOST HIT A POLE. IT WAS A NICE DAY, NO RAIN OR MOISTURE. THE PAVEMENT WAS DRY. *TR
TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH THE POWER STEERING ASSIST FAILED MESSAGE CAME ON THE INSTRUMENT PANEL, IMMEDIATELY AFTER IT BECAME EXTREMELY DIFFICULT TO MAKE ANY TURNS OR MANEUVER THE STEERING WHEEL. THE CONTACT MENTIONED THAT AFTER POWERING OFF AND RESTARTING, THE VEHICLE WAS PERFORMING AS NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO FILED A REPORT AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 28,472 AND THE CURRENT MILEAGE WAS 29,600. UPDATED 09/21/12*LJ THE CONSUMER THE ABS AND TRACTION CONTROL FAILURES AND RELATED MESSAGES APPEARED ON THE INSTRUMENT PANEL'S MESSAGE CENTER. THE DEALER FOUND A DIAGNOSTIC CODE FOR THE SPEED SENSORS. THE VEHICLE WAS REPAIRED. UPDATED 09/27/2012 *JS *TR
LETTER FROM RE FEW DEFECTS IN MY 2011 FORD EXPLORER REMAIN AFTER THE DEALERS REPEATED REPAIR ATTEMPTS. THESE ISSUES DISTRACT ME WHILE DRIVING AND IT IS A CONCERN TO MY SAFETY AS WELL *TGW THE CONSUMER STATED THE MAIN ISSUE WAS THE STEERING; THE STEERING WHEEL WAS NOT STRAIGHT AND WHEN DRIVING, THE VEHICLE PULLED IN THE OPPOSITE DIRECTION. THE SHIFT INCREASED WHEN INCREASING SPEED. ALSO, THE A/C UNIT CHANGED TEMPERATURES BY ITSELF. THE BRAKE WARNING LIGHT ILLUMINATED AND THE TOUCH AND SYNC DID NOT WORK. THE CONSUMER BELIEVED THE SOFTWARE NEEDED TO BE UPDATED AS HIS PHONE AND OR MP3 PLAYER KEPT GETTING DISCONNECTED. WHEN USING THE SYNC SERVICE TO REQUEST DIRECTIONS IT KEPT MISINTERPRETING THE COMMANDS, AS WELL AS DISCONNECTING WHEN DOWNLOADING A ROUTE. ON ONE OCCASIONS, THE ENTIRE SYSTEM FAILED AND THE SCREEN WENT BLANK. *JB
WE HAVE PURCHASED A 2011 EXPLORER, WITH THE BLUETOOTH ACTIVATED, THE PERSON DRIVING CANNOT BE HEARD BECAUSE OF BACKGROUND NOISE. FROM MY INVESTIGATION, I FOUND THAT THE ROOF AREA ABOVE THE WINDSHIELD SEEMS TO NOT HAVE ANY INSULATION, THE WIND NOISE IS BEING PICKED UP BY THE SPEAKER ABOVE THE DRIVERS HEAD. THIS IS NOT THE ONLY PROBLEM, WHEN IT IS RAINING THE NOISE FROM THE RAIN SOUNDS LIKE A TIN ROOF OF AN OLD HOUSE. I REPORTED THIS TO THE DEALERSHIP AND THEY SAID THAT THERE IS NOT ANYTHING THEY CAN DO WITHOUT FORD HAVING MORE COMPLAINTS. *TR
2003 FORD EXPLORER XLT WHEEL BEARING HUBS ARE BAD AND IS A ON GOING ISSUE. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .