2016 Ford Explorer Engine Problems

Truck turns off

NHTSA ID

11753172

Incident

Jul 3, 2026

See attached document for complaint.

NHTSA ID

11746516

Incident

May 20, 2026

Vehicle: 2016 Ford Explorer 2WD V6-3.5L VIN: [XXX] rchase: January 20, 2026 Odometer at Purchase: 70,929 miles (fraudulent — true mileage approximately 123,779 miles) Dealer: Drive Time Car Sales Company LLC, DBA Drive Time, 8805 E Adamo Dr, Tampa, FL 33619-3525 Narrative — Copy and Paste Into NHTSA Online Form: On January 20, 2026, I purchased a 2016 Ford Explorer 2WD V6-3.5L (VIN: [XXX] ) fr [XXX] Sales Company LLC, located at 8805 E Adamo Dr, Tampa, Florida 33619-3525. At the time of sale, the vehicle had three open, unrepaired federal safety recalls: 1. NHTSA Recall 19V435 / Ford 19S17 — Rear Suspension Toe Link Replacement (initiated June 26, 2019, affecting 1,194,173 vehicles). The rear suspension toe links may fracture, causing sudden loss of vehicle handling and risk of crash. 2. NHTSA Recall 21V537 / Ford 21S32 — Rear Suspension Toe Link Cross-Axis Ball Joint (owner notifications mailed March 2022, affecting 644,055 vehicles). The cross-axis ball joint may corrode and seize, causing toe link fracture and loss of steering control. 3. NHTSA Recall 25V347 / Ford 25S53 — B-Pillar Door Trim Detachment (owner notifications mailed June 2025, affecting 492,145 vehicles). B-pillar trim may detach while driving, creating a road hazard for other motorists. None of these recalls were repaired prior to sale. The dealer had documented actual knowledge of all three open recalls. Drive Time provided me with copies of the recall notices as part of the purchase paperwork at the time of sale. Additionally, the recall documentation included a printout from the NHTSA recall lookup website for this specific VIN, timestamped January 19, 2026, at 5:28 PM — the day before the sale — proving that Drive Time actively investigated and confirmed the open recalls within hours of delivering the vehicle. Ford's own dealer notice for Recall 19V435/19S17 states: "Federal law requires dealers to complete this recall service before a new vehicle is INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11738362

Incident

Jan 20, 2026

When acceleration hot air blows through dashboard fogging front driver windows. Weather strips in doors are coming apart.

NHTSA ID

11734466

Incident

Feb 16, 2026

Coolant leak in the cylinder head grooves that builds up on the seal and leaking into cylinders. Causing coolant loss, white smoke and engine overheating. This issue has left me stranded on the interstate and in danger with potential engine fires. These incidents have exposed myself and the general public to unnecesary safety hazards.

NHTSA ID

11734112

Incident

Sep 3, 2025

Smoke coming from engine bay area. Vehicle in limp mode. Mechanic says piston broke a hole in engine wall.

NHTSA ID

11732095

Incident

Jan 3, 2026

While driving the crankcase sensor malfunctioned and caused my vehicle to stall without warning, this is a safety issue because of you are driving at highway speeds this will prevent the vehicle from being controlled properly to get to the side of the road. This sensor does not give any engine codes suggesting that it needs replaced until it goes out completely. The check engine light did not come on until after the component failed. I ordered a new part directly through Ford and even they said "yes that part will go out without any warning at all and will shut the engine down completely". When this sensor went out, it also caused pressure to build up in the engine which in turn has led to several other components that now need to be replaced. I have a had a mechanic look at it, and it now requires a turbo intake hose and a new turbo because the pressure that was built up in the engine due to the crankcase sensor going out burst the turbo intake hose and prevented the turbo from working correctly. It's approximately $4,000 in repairs due to a $150 part going out.

NHTSA ID

11710090

Incident

Dec 26, 2025

The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 21V316000 (STRUCTURE), 24V031000 (STRUCTURE), and 25V347000 (STRUCTURE). However, the parts to do the recall repairs were not yet available. The contact stated that while the vehicle was parked, the contact became aware that rainwater was leaking inside the vehicle and standing water had accumulated on the carpet. The water was leaking from the front door, the roof near the dome light, and the glove compartment. The contact was unsure of where the water was entering the vehicle. The contact stated that there was a musty odor inside the vehicle. Most recently, while driving at an undisclosed speed, there was an abnormal burnt odor inside the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The contact stated that the check engine warning light was constantly illuminated since the vehicle was purchased. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11693457

Incident

Oct 7, 2025

The contact owns a 2016 Ford Explorer. The contact stated that while driving in traffic, a trim piece detached from the vehicle. The TPMS and check engine warning light were illuminated. The dealer sent a tech to the contact’s place of employment, but the tech was unable to complete the recall repair due to the bolt not being available. The contact had received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The contact stated that the turbocharger had been replaced on three occasions. Upon investigation, the contact had linked the failure to NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling). The contact called the local dealer, who confirmed the parts for the recall repairs were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a complaint was filed, but no assistance was provided. The failure mileage was unknown.

NHTSA ID

11691665

Incident

Apr 1, 2024

Coolant intrusion in the cylinder walls

NHTSA ID

11690764

Incident

Sep 29, 2025

Torque converter issue causes shuddered, can cause driver to unexpectedly adjust speed rapidly.

NHTSA ID

11690316

Incident

Aug 15, 2025

Good Morning, I’m reaching out in regards to my 2016 Ford Explorer. I’ve been trying to get the necessary recall repairs completed, but unfortunately, I’ve been unable to locate the required pillars for the repairs. I recently brought my vehicle back to the dealership, but was told that no work can be done until both parts are available. I was also advised to try sourcing one of the parts from another Ford dealership on my own, which I’ve had no luck with. To be honest, I’m feeling very overwhelmed. I purchased this vehicle used, back in September 2025, and since then, it has been one issue after another. I’ve already invested more into mechanical repairs than what I currently owe on the vehicle. I’m a [XXX], and this vehicle is our only mode of transportation. I’m growing increasingly concerned for our safety, especially knowing that the recall parts are critical and things could start to fall apart — literally — if they’re not addressed soon. With that said, I would greatly appreciate your help in exploring any other options available through Ford or the dealership. Some specific questions I have are: Is there any way for the dealership to help source the necessary parts through other Ford networks or escalate this to Ford corporate? Can you assist with a temporary vehicle solution while waiting on the parts (loaner or rental)? Would there be any way to explore trading in or transitioning into another vehicle, even with the current issues and financial position I’m in? I understand that supply issues happen, but I’m just trying to keep my kids and myself safe, and right now I’m feeling stuck. I would extremely appreciate any help or direction you can offer. Please feel free to call or email me directly. I look forward to hearing from you. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11674977

Incident

Jan 30, 2025

The contact owns a 2016 Ford Explorer. The contact stated that while operating the vehicle, the engine overheated, and the temperature gauge had increased to high with the check engine warning light remaining illuminated. The vehicle was taken to the local dealer who diagnosed that the water pump was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 116,000.

NHTSA ID

11670869

Incident

Jun 23, 2025

Mileage

116,000 mi

The contact owns a 2016 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the vehicle stalled after coming from a stop. No warning light was illuminated. The vehicle was able to be restarted. The contact stated that the water pump had previously been replaced twice, but the failure persisted. The vehicle was taken to an independent mechanic, who determined that there was coolant intrusion in engine and the water pump needed to be replaced for the third time. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 177,000.

NHTSA ID

11668820

Incident

Jun 1, 2025

Mileage

177,000 mi

The contact owns a 2016 Ford Explorer. The contact stated that upon engaging the parking brake, the parking brake failed to remain engaged. Additionally, the contact stated that upon activating the A/C, the A/C was blowing hot air. The vehicle was taken to a Mazda dealer, where it was diagnosed that there was a blockage in the engine block heater. The dealer informed the contact that no authorization was provided to repair the failure. The vehicle was not repaired. The dealer referred the contact to the NHTSA Hotline for assistance. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ID

11666501

Incident

Jun 2, 2025

I’ve had it twice be an issue where the engine didn’t run quite right. The first time I took it to the mechanic it was determined the timing chain was bad and they also said this is a well known issue with the ecoboost engines in these explorers. Only about a year later after replacing that and the water pump I went to start the explorer and it wouldn’t start. Took it to the mechanic again and they found that the timing chain, again, had failed and this time it also caused damage to a piston rod. They said they were surprised it wasn’t catastrophic damage to the engine because of this. I’ve now had to spend literally thousands of dollars on this vehicle for timing chain related issues alone in just over 3 years of owning it. Searching online finds unending reports of similar issues to this as well as massive issues with the turbos and the cam phasers that also commonly are causing catastrophic engine failures despite routine preventative maintenance being performed. And the a pillar recall issue. I had it inspected December of 2024 and determined it needed them replaced. I was not given a time frame when that would be completed. I got a call over a month ago from the dealer saying to call them to schedule a repair. I did so and then was told that while I was on the list they still are unable to get any parts from Ford to repair this mandated recall and also cannot get a timeline on when said parts would be available. I’m almost six months past them saying it’s been ordered and still no idea when it’ll be repaired. And now a second recall was just announced for the b post coverings and I’m sure this will be just as bad. As many issues as this car is having I think Ford should have to pay for a lot more recalls than they have so far. I also had to have two other recalls fixed that the selling dealer didn’t address before selling to me.

NHTSA ID

11664124

Incident

May 31, 2025

Took the family SUV in for a standard oil change and 100k service to Ford dealership. Upon performing a coolant flush, the water pump began leaking. It was found that the internal water pump was leaking and needed to be replaced along with the primary timing chain and tensioner items. There were no warning lamps or indicators to let us know this was an issue. The dealer service center replaced the internal water pump, refilled system and test drove. It was re inspected and leak has been corrected. However, this cost us $4, 366.80 for an issue Ford knows is a reoccurring issue in this model of SUV and a huge hazard for families.

NHTSA ID

11663144

Incident

May 16, 2025

The contact owns a 2016 Ford Explorer. The contact stated that the vehicle was idling rough while shifted into drive or reverse. The contact stated that the vehicle operated normally while moving. There was no warning light illuminated. The local dealer was not contacted; however, the vehicle was not diagnosed. The vehicle was not repaired. The contact referenced Technical Service Bulletin: 20-2271; as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 111,000.

NHTSA ID

11660491

Incident

May 2, 2025

Mileage

111,000 mi

The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 40 MPH, the accelerator pedal was depressed, and there were exhaust fumes entering the cabin of the vehicle. The contact stated that the exhaust odor entered the vehicle while depressing the accelerator pedal and was constant. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the failure was related to Technical Service Bulletin Number: 17-0044; and the recommended that the repair be performed. The contact was advised that the vehicle was no longer under warranty. The vehicle was not yet repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.

NHTSA ID

11658284

Incident

Jul 3, 2024

Mileage

100,000 mi

The contact owns a 2016 Ford Explorer. The contact stated while driving 68 MPH, the vehicle shut off unintendedly. After the failure, the engine warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was taken to an independent mechanic where it was determined there was water in the engine oil. The local dealer was contacted and confirmed that there was no recall on the VIN related to the failure. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 164,000.

NHTSA ID

11657308

Incident

Apr 26, 2025

Mileage

164,000 mi

The contact owns a 2016 Ford Explorer. The contact stated that while his sister was driving 55-60 MPH, the engine started to overheat, and there was fluid leaking from the vehicle. The contact stated that there was oil in the coolant overflow tank. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who determined that the engine needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 120,000.

NHTSA ID

11655460

Incident

Apr 12, 2025

Mileage

120,000 mi

The contact owns a 2016 Ford Explorer. The contact stated that water had entered the vehicle, and the inside of the windshield was freezing. There was an abnormal sound coming from the vehicle. The contact stated that the defrosted was inoperable. Additionally, the TPMS warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was towed to the local dealer, who blew out the tubes and replaced the water pump. The vehicle was repaired, but the failure recurred. The contact stated that after a rainstorm, water entered the vehicle from the sunroof. The vehicle was taken back to the dealer, where it was diagnosed that the sunroof track needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer referred the contact to the NHTSA Hotline. The approximate failure mileage was 77,000. VIN tool confirms parts not available.

NHTSA ID

11653932

Incident

Sep 1, 2024

Mileage

77,000 mi

Engine stalls out when accelerating, coolant is leaking into the motor. Got it checked out my mechanic, needs new engine due to improper manufacturing issue

NHTSA ID

11653015

Incident

Oct 16, 2024

Water pump

NHTSA ID

11651128

Incident

Mar 27, 2025

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was at a car wash, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted and replaced the A-pillar trim. The contact stated that after leaving the dealer after the repair, the driver's side A-pillar became loosened. The A-pillar trim was replaced. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while the vehicle was parked, the contact noticed coolant leaking from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into the head gasket. The contact was informed that the water pump and timing chain needed to be replaced. The vehicle was not repaired for the most recent failure due to the cost. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 120,000. VIN tool confirms parts not available.

NHTSA ID

11649736

Incident

Jan 21, 2025

Mileage

120,000 mi