2016 Ford Explorer Steering Problems

Hello. I purchased my car in 2018. 2-3 years later, the power steering would randomly go out while driving - on the highway and city roads. This could happen once and then not again for 6+ months. When this happened a message would display about a "steering assist fault, service now". I found that if I pulled over, turned the car off and then on, it would generally work again. We had the vehicle in to 3 separate repair shops between 10/2022 and 10/2025 and no one could diagnose the issue as they needed it to replicate the condition. (In hindsight find this strange (concerning!!) as a simple google search shows what I am describing is a very common issue with a number of Ford models and also other vehicles.) In June 2026, while on vacation with my family (on a mountain) it happened again. We turned the car on and off several time, disconnected/reconnected the battery and could not get the car to start working again and this time the steering wheel was completely locked. We had the vehicle towed and rented a car to drive home. The dealership was able to diagnose and repair the issue by replacing the entire steering rack assembly. No issues since then.

NHTSA ID

11755766

Incident

Jun 25, 2026

2016 Ford Explorer, VIN [XXX]. Filing against Planet Ford Dallas regarding incomplete Regional Program 21R01 (Rear Toe Link Replacement), tied to Federal Safety Recall 21V537. May 11, 2026: Vehicle presented for 21R01 service. May 15: Returned with recall marked complete in Ford's system. 21R01 mandates replacement of both rear toe links, alignment check, and rear toe adjustment. None of these steps were correctly completed. Dealer has since acknowledged to me that the toe link was not replaced correctly, but instead with the incorrect part and that rear suspension hardware was left loose upon vehicle release. The vehicle was driven approximately one month in this condition. Progressive symptoms followed: steering pull, steering wheel offset, tire screeching, and vehicle instability. Rear toe was subsequently found approximately 3 degrees out of specification — consistent with loose hardware shifting during normal driving. Dealer is attributing front suspension wear to natural causes while providing no investigation demonstrating the incomplete recall did not contribute to or accelerate that damage. Ford Motor Company Head Office has confirmed 21R01 as applicable (Corporate Case [XXX]). Dealer has declined to accept responsibility. The recall was marked complete in Ford's system despite mandatory work not being performed. I am requesting NHTSA investigate dealer compliance with 21R01/21V537 and whether a reimbursement claim was submitted to Ford for work not performed. This matter may also be referred to the Texas AG Consumer Protection Division and FTC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11745716

Incident

May 15, 2026

The electronic power steering failed Yes its available for inspection My child and my safety were put at risk when I warning came up and said "steering loss, stop safely" and the steering wheel was locked. The problem was still there when it was brought into Ford service center Nothing prior to the warning

NHTSA ID

11743933

Incident

Jun 3, 2026

The steering on my Explorer has seized up making it very dangerous to drive because you can not hardly get the steering wheel to turn.

NHTSA ID

11734930

Incident

Apr 20, 2026

The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 35 MPH, the steering wheel became difficult to turn to the left or to the right. The contact stopped and turned the vehicle off and restarted the vehicle, and the power steering functionality returned. The contact stated that the failure had occurred twice and during the second failure the check engine warning light illuminated. The contact had not taken the vehicle to a local dealer or an independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 79,000.

NHTSA ID

11694477

Incident

Oct 2, 2025

Mileage

79,000 mi

The car had ongoing issues with a warning sensor that stated Steering Fault - Service Now. There was also a clinking noise when driving straight and then turning right. Took car to dealer repair show and they ran a diagnosis report (I assume they did). It was reported that it was an internal fault with strut bearings and installed a bracket that was suppose to remedy the issue. Since then I would get the Steering Fault warning but it would happen and then not show up for several months. Recently 8/2025 the error message showed up again while driving about 30 mph. At that time my steering locked. I turned off the car and started it again and it seemed fine. My husband and I test drove it short distances and there was no issues. Then I drove it down the road that I was on when it happened a couple days earlier (since it was a hilly road I thought it caused something to come loose thence the warning). I stopped at a vegetable stand and when restarting the car I received the steering warning again. I turned the car off and then on and proceeded down the road. Within a few feet the warning flashed on and also warning that said Service Advance Trac and Hill Start Assist Not Available and Terrain warnings. I took the vehicle back to the dealership again 9/4/2025 at this time I had 93,300 miles on it. They ran a diagnosis report on it and said I needed to replace the Steering Rack at a cost of over $4000.00 plus fees for alignment, etc. FIRST OF ALL - I think this should have been diagnosed when the car was in for steering issues in 2022 - Especially since Ford was aware of issue with the Steering Rack and it is a serious safety issue. SECOND - There should have been a safety recall for Steering Racks on these vehicles. I'm only fortunate that this did not happed when driving on a highway higher speed.

NHTSA ID

11685961

Incident

Aug 2, 2022

Dear NHTSA, I am submitting a formal safety complaint regarding my 2016 Ford Explorer (VIN: [XXX] .) Build Date: (08/15.), Mileage (115,262.). My vehicle has experienced a steering rack failure, which poses a serious risk of loss of steering control. I am aware of multiple recalls (such as 20v-675 / Ford 20S62 and 21V-537 / Ford 21S32) Addressing rear suspension toe link fractures in 2016 ford explorers. These recalls cover vehicles built in the same timeframe as mine, but my VIN is not included. This exclusion is concerning, as both the steering rack and suspension defect involve loss of steering control and directly impact driver and passenger safety. I respectfully request that NHTSA investigate: 1. Why certain VIN's, including mine, were excluded despite being manufactured in the recall window. 2. Whether steering rack failures in the 2016 ford explorer should also be subject to an official safety recall. Thank you for your attention to this urgent safety matter. I look forward to hearing from somebody. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11683234

Incident

Aug 12, 2025

The contact owns a 2016 Ford Explorer. The contact stated that the vehicle lost power steering assist functionality, and the steering wheel was stuck while attempting to turn the steering wheel to the left or the right. There were no warning lights illuminated. The contact spoke with the dealer and was informed that the power steering assist had failed and needed to be repaired. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 97,000.

NHTSA ID

11680362

Incident

May 13, 2025

Mileage

97,000 mi

The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 35 MPH, the steering wheel became stiff and did not drive as intended. The contact stated that the next morning, she observed a sound emanating from the steering column. The check engine warning light was illuminated before the failure. The vehicle was not diagnosed or repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 20V675000 (Suspension). The manufacturer was not notified of the failure. The failure mileage was approximately 156,580.

NHTSA ID

11678846

Incident

Aug 5, 2025

Mileage

156,580 mi

The contact owns a 2016 Ford Explorer. The contact stated that while in reverse(R), the vehicle failed to turn to the left or right, and the steering wheel was stiff. The contact stated that when the vehicle was shifted into drive(D) and pulling into a parking spot, the steering wheel was stiff. There was no warning light illuminated. The contact stated that the vehicle was turned off and restarted without the failure recurring. The vehicle was taken to a dealer for maintenance on the brakes, and the vehicle was diagnosed, and it was determined that the steering rack assembly needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 93,500.

NHTSA ID

11678283

Incident

Jul 17, 2025

Mileage

93,500 mi

I was driving the family and about to enter the highway when my steering started to feel like there may be a problem. The steering started to feel like it was sticking. I turned around and headed back home (about 4 miles) by the time I entered my street, steering failure warning lights started on the dashboard. I had to come to an abrupt stop because the steering wheel would not turn to pull in my driveway. We had to dolly the rear of the car over so i can pull straight into my driveway. I can not even imagine what would have happened if I did not turn around to head home. If this happend on the highway or on a ramp, I could have become devestating.

NHTSA ID

11676611

Incident

Jul 25, 2025

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The power steering unit failure warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with a failed electronic power steering rack. The contact was informed that the electronic power steering rack needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic where it was diagnosed with a failed electronic power steering rack. The contact was informed that the electronic power steering rack needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 75,000. The VIN was unavailable.

NHTSA ID

11670517

Incident

Jun 26, 2025

Mileage

75,000 mi

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to maneuver the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic and was diagnosed with electronic power steering control module failure. The contact was informed that that the independent mechanic found that the EPS control module was water damaged. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V286000 (Steering), but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 135,000.

NHTSA ID

11668745

Incident

Jun 23, 2025

Mileage

135,000 mi

The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign numbers: 24V031000 (Structure) and 25V347000(Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. Additionally, the contact stated that while driving 40 MPH and making a right turn, the vehicle lost power steering functionality. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the steering wheel had failed. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The failure mileage was approximately 105,000. VIN tool confirms parts not available.

NHTSA ID

11666637

Incident

May 12, 2025

Mileage

105,000 mi

Steering gets really hard and jerks acts like the steering isn't working

NHTSA ID

11665943

Incident

Jun 9, 2025

I was at Apple Ford of Lynchburg, VA when I grabbed the steering wheel to exit the vehicle when the steering wheel came loose and began to wobble up and down, making the car impossible to control safely. The Service Department and I came to the conclusion that this may represent an apparent safety issue that must be addressed.

NHTSA ID

11665209

Incident

May 30, 2025

The contact owns a 2016 Ford Explorer. The contact stated while driving 60-65 MPH, the vehicle experienced a loss of power steering functionality. The contact stated that the message “Power Steering Failure - Stop Driving Vehicle” was displayed. The traction control warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed with internal steering gear head failure. The dealer performed the steering gear replacement and realignment. The vehicle was repaired. The manufacturer was notified of the failure, and a case was filed. The manufacturer later informed the contact that no assistance would be provided. The failure mileage was 65,964.

NHTSA ID

11659814

Incident

Apr 1, 2025

Mileage

65,964 mi

The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, while attempting to make a left or right turn, there was a popping sound coming from the steering wheel. Additionally, while driving on the highway at 70 MPH, the vehicle failed to exceed 70 MPH. The contact stated that there was an abnormal burning odor entering the cabin of the vehicle with the TPMS warning light illuminated. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 121,000.

NHTSA ID

11658930

Incident

Sep 30, 2024

Mileage

121,000 mi

The contact owns a 2016 Ford Explorer. The contact stated that while reversing out of the driveway at approximately 1-2 MPH, there was a loud, abnormal humming sound coming from the vehicle. The contact stated that the vehicle was pulling to the side. Additionally, while driving at an undisclosed speed, the vehicle was vibrating abnormally. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 29,000.

NHTSA ID

11656006

Incident

Apr 21, 2025

Mileage

29,000 mi

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. No warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 144,337.

NHTSA ID

11652478

Incident

Feb 1, 2025

Mileage

144,337 mi

Water pump

NHTSA ID

11651128

Incident

Mar 27, 2025

The contact owns a 2016 Ford Explorer. The contact stated that while turning the steering to the left or right while driving at various speeds and while the vehicle was idling, the steering wheel seize approximately a quarter way into the turn. The driver had to manually turn the steering wheel to continue the turn or to merge. The failure occurred intermittently but became more persistent. There were no warning lights illuminated. The contact called the dealer who confirmed that the VIN was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

NHTSA ID

11646191

Incident

Feb 4, 2025

Mileage

140,000 mi

Vehicles steering is extremely difficult to turn, power steering fluids have been checked and changed out as well. Issue persists in high and low speeds

NHTSA ID

11640716

Incident

Feb 1, 2025

I was driving 55mph (speed limit) down a curvy country road when the steering wheel became stiff and wouldn’t turn. A red light flashed and said I had lost steering. I was barely able to get stopped before going of a steep embankment. I was stoped in a dangerous spot with no way get out of oncoming traffic. My vehicle flashed a yellow light that said Terrain management system failure. No only was my life risk everyone that traveled down that road that morning. This included a school bus full of children and several other people that were trying to make it so work just like me.

NHTSA ID

11636708

Incident

Jan 15, 2025

When driving the steering would loose power and would not respond. Warning message said power steering failed. Dealer checked and verified that the steering rack and pinion are bad.

NHTSA ID

11635916

Incident

Nov 20, 2024