Owner-reported complaints naming the other system, filed with NHTSA
Data refreshed
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above. Every record below is an owner-reported complaint about the 2021 Ford Explorer submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
All 4 tire TPMS sensor have failed. 2 at 67,057 on ~ 2/20/26, 2 at 71,024 miles on ~6/10/26. Car is a 2021. Sensors should not have failed within 5 years of owing the car. I have a 2012 Ford F50m only 1 has failed in over 14 years. Asking consideration for a recall to cover costs.
my son is rear facing and puts his arm in the forward facing belt path then can not get his arm back out. he starts screaming and crying and i have to pull the car over to the side of the road to help him get his arm out and even i struggle getting his arm free. no sooner than i start driving again, he puts his arm back through and it’s the same cycle. i have contacted britax and have unfortunately not gotten any solution for this issue.
We bought this in 2022 from clek, and a few months before we were transferring our daughter from the infant seat to a convertible seat, our infant seat became stuck on the base. Absolutely impossible to get off and my husband and I both tried many times. I reached out to Clek because I was very concerned that in an emergency situation it would take much longer to unstrap and get baby out instead of just grabbing the seat and going. I mean in a car fire, if we went in any body of water- anything it’s extremely concerning to me that this could happen. I have bought cheaper car seats than this for our other children and never once had this issue. They ended up emailing me with a video showing me to break the base, pull a strap and remove the seat from the base - that’s great besides it still won’t detach and you could never do this in an emergency. They also said this happens often which clearly it does if they have a video showing how to remove it. The car seat has been inspected by the hospital and police prior to this and we have had other friends/ family who are in those professional fields who were very concerned. We actually were told by Albee baby to report clek because they said they should refund us. They aren’t even offering us a new seat and we are due in less than 2 months with baby number 3. We have no seat and to be truthful I don’t want one like this where it may get stuck again. They also told me in an email, police and ems could help save my child- sometimes you can’t wait for that- that’s a horrible excuse to me. I should be able to save my children myself and I will never rely on anyone else.
The contact owned a 2021 Ford Explorer. The contact stated that the vehicle was parked in the driveway for over three hours before the vehicle caught on fire. The origin of the fire was unknown, however, the contact believes the fire originated from faulty electrical wiring. The vehicle was unoccupied during the fire. The location of the fire was the rear end of the vehicle. The fire department arrived to extinguish the fire. A fire department report was filed. A police report was not filed. The vehicle was destroyed. The local dealer was contacted, and the vehicle was not diagnosed as it was determined to be a complete loss. The manufacturer was notified of the failure. The approximate failure mileage was 75,000.
While driving down the interstate, the tires (rear passenger?) suddenly locked/stuck. This caused vehicle to lose control, 360, and slam into the guardrails. Prior to this incident, when the car was turned on, it stalled a bit like it was about to turn off. This lasted for a few seconds, but returned to normal. So may be a component of electrical and/or directly related to the rear tire. There were no warning messages. Driver was thankful injuries did not occur. Could have flipped, or slammed into other cars, trees, etc. This is a serious issue. While the vehicle was being loaded onto the wrecker, in neutral, the rear passenger tire was visibly stuck. This was observed by owner, husband, police officer and tow company. When offloading from the tow truck, the tire made a loud pop and movement returned to normal. Vehicle is currently at the shop (ford dealership). Will have more information next week from their diagnostic studies. It is available for inspection upon request.
Two TPMS sensors have failed on this vehicle. Although these sensors are required under the TREAD act, Ford has advised through their dealer that this is not a safety issue and the TPMS sensor batteries failing less than 3 years from date of vehicle manufacture falls in the category of normal wear and tear. Note that the vehicle has 27,243 miles on it, and these are the original TPMS sensors/wheels/tires that the vehicle came equipped with from Ford.
It is extremely difficult to tighten the harness on this seat. As we have used the seat more, the harness has gotten nearly impossible to get snug enough to be safe. I am a CPST, so I am sure the seat was adjusted properly for my child. I also talked to a CPST at Britax to make sure I wasn’t missing something that could help. I was sent a new harness to see if it would help, but it did not make any difference. We have since stopped using this car seat and replaced it.
On October 25, 2021; my wife and I were driving across country when we experienced a blow-out at 75 MPH in New Mexico (about 80 miles west of Amarillo. The blow-out was caused by body cladding, which came off the right rear door of our 2021 Ford Explorer - apparently attributable to 19+ MPH desert cross winds at highway speeds of 75 MPH. The trim lodged in the right rear wheel well; slicing the tire and cutting a gash from the aluminum rim. We had to get to California for a scheduled closing on our new home and were therefore unable to stay in Amarillo or Albuquerque for the three days required to receive a matching rim and tire, so I had a nearby tire store install a wheel of a different size with an offsetting tire size to approximate the circumference of the stock wheels and tires. Ford has thus far neglected to acknowledge the obvious defect that would allow a body part to blow off the car and has offered no assistance in repairing the car or reimbursing me for the wheel and tire I had to purchase to meet personal legal obligations. I've seen evidence in online forums indicating other incidents of body trim blowing off Ford Explorers at highway speeds. Ford must take responsibility for this defect and reimburse other owners and me for costs incurred to resolve implications of their defective body parts.
THE WHEEL WELLS OF THE VEHICLE COLLECT LARGE AMOUNTS OF SNOW AND ICE. THIS BUILD UP CONSTRICTS THE WHEELS OF THE VEHICLE CONTACTING THE TIRES RESTRICTING ROTATION AND STEERING. THIS IS AN EXTREMELY DANGEROUS POTENTIALLY DEADLY SITUATION. WE HAVE CONTACTED FORD MOTOR COMPANY AND THE DEALERSHIP. NO REMEDY TO THIS SITUATION HAS BEEN OFFERED. PLEASE INVESTIGATE AND ANY ASSISTANCE IS APPRECIATED. I BELIEVE THIS IS A WIDE SPREAD PROBLEM FORD IS UNWILLING TO DEAL WITH. THIS CONDITION OCCURS IN COLD WEATHER AND SNOWY ICY CONDITIONS. THE BUILD UP HAZARD HAPPENS EVEN DRIVING SHORT HIGHWAY DISTANCES.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .