2024 Ford F-150 Hybrid Electrical Problems

See attached document for complaint.

NHTSA ID

11747742

Incident

May 12, 2026

On Friday, June 12, 2026, the check engine light illuminated on my vehicle. I took it to my local Ford dealer on Saturday, June 13, 2026. The dealer diagnosed the issue as a defective Gear Shift Module (GSM) and quoted approximately $1,000 for replacement. The service advisor informed me that failure to repair this component could result in the vehicle becoming unable to shift into Park or unable to shift out of Park. This defect poses a serious safety risk, as it could prevent the truck from being properly secured when parked, potentially allowing it to roll away, into traffic, or cause injury to persons or property. Ford is aware of this issue, as a Technical Service Bulletin (TSB) has been issued for it. However, the repair is currently being treated as a customer-pay item rather than a warranty or safety-related repair. This condition represents a significant safety concern that could affect many other 2024 F-150 owners. I urge NHTSA to investigate this matter promptly to determine if a recall or mandatory safety fix is warranted. I am available to provide additional details, including the dealership repair order, diagnostic information, and any supporting documentation. Thank you for your attention to this important vehicle safety issue.

NHTSA ID

11744443

Incident

Jun 12, 2026

Dash said look for safe place to pull over. When turned engine off, it would not start again. Had to wait hours to get it towed to dealership. Been there over 5 weeks and they still don't know what's wrong but suspect hybrid battery problem. Only about 21k miles and 18 mo old. No loaner provided.

NHTSA ID

11737445

Incident

Apr 3, 2026

2024 Ford F-150 Platinum PowerBoost Hybrid. Diagnostic codes for power steering loss and CAN bus communication faults documented at 337 miles, well within the 3-year/36,000-mile new vehicle warranty. The vehicle has been at a Ford dealer since March 10, 2026 for symptoms including the truck randomly turning off while driving and loss of power steering communication. As of this report, the truck has been at the dealer 58 days without resolution. Documented diagnostic findings include: Lost Communication with PSCM (U0131), SCP/J1850 Communications Bus Fault (U1028), permanent code P1A42 Propulsion System Status Signal Performance, hybrid-specific High Voltage System Interlock U3523-00, Steering Position Sensor P060A, no communication with Power Steering Control Module, intermittent PCM communication during self-tests, BCMC fuse 69 with no power, and circuit CBB69 with no voltage. A Ford Field Service Engineer was dispatched April 23, 2026. On April 24, 2026 the dealer located damaged wiring inside a harness behind the BCMC bracket. Prior to that, the dealer escalated through R&I of multiple modules (PSCM, PCM, BCMC, Gateway Module access) over 45 days without locating the actual cause. The vehicle is currently subject to NHTSA recall 26V104 / Ford 26C10 (Trailer Module loss of communication at startup) issued 3/18/2026, status Recall Incomplete. The recall describes the same general failure mode (module communication loss at startup) the customer has been experiencing. Power steering loss while driving is a serious safety concern, particularly given the vehicle's hybrid drivetrain and CAN-bus-dependent safety systems.

NHTSA ID

11736301

Incident

Mar 9, 2026

The contact owns a 2024 Ford F-150 Hybrid. The contact stated that while driving 45 MPH and depressing the brake pedal, the vehicle unintendedly accelerated to 85 MPH. The contact continuously depressed the brake pedal until the vehicle decelerated. The contact stated that the failure recurred after releasing the brake pedal, which required the contact to continuously depress the brake pedal until the vehicle decelerated. The message "Brake Reduction" was displayed. The contact pulled over to the side of the road. The contact stated that upon turning off and restarting the vehicle, the vehicle operated as intended. Additionally, the contact stated that the interior eye-tracking camera had failed to register the driver's presence in the vehicle intermittently, causing the vehicle to slam on the brakes while driving 70 MPH. The contact stated that the Lane Keeping System (LKS) occasionally prompted the driver to keep hands on the steering wheel while the driver's hand were already on the steering wheel. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was filed; however, no further assistance was provided. The failure mileage was approximately 80.

NHTSA ID

11706726

Incident

Dec 23, 2024

Mileage

80 mi

I am submitting a formal safety complaint regarding a known but unresolved software defect affecting the oil life monitoring system in the 2024 Ford F-150 (non-Lightning models). Ford has internally acknowledged the issue in Technical Service Bulletin (TSB) 25-2331, dated July 18, 2025, but has not issued a recall or public notification to affected owners. Summary of the Defect: The vehicle's instrument panel cluster (IPC) reduces the reported oil life to 0% in less than 1,000 miles, even under normal driving conditions. Ford attributes this to flawed software logic in the IPC module. The oil life monitor is a critical engine maintenance indicator relied upon by vehicle owners to prevent premature wear or catastrophic engine failure. Faulty or misleading oil diagnostics can result in: Drivers disregarding future oil life warnings, assuming they are incorrect Operators running engines with degraded oil beyond safe limits Loss of trust in onboard diagnostics, affecting broader vehicle safety behavior Avoidable mechanical damage, particularly for owners following the vehicle’s built-in guidance Ford’s TSB instructs dealers to reprogram several modules, including the IPC, APIM, BCM, GWM, and TCU, but only if a customer complains. There is no recall, no public campaign, and no direct owner communication. This leaves potentially thousands of vehicles on the road with faulty maintenance guidance—and owners unaware of it. Why This Warrants Recall Action: This is not a cosmetic or comfort issue. It is a misrepresentation of core engine health diagnostics that, if followed blindly (as owners are instructed to), could cause premature engine wear or failure. The behavior directly undermines the purpose of onboard diagnostics and scheduled maintenance. I urge the NHTSA to investigate TSB 25-2331 and consider elevating this matter to a formal safety recall, or at minimum, compel Ford to issue a customer service campaign notifying all potentially affected owners.

NHTSA ID

11677211

Incident

May 1, 2025

The contact owns a 2024 Ford F-150. The contact stated that while driving at an undisclosed speed, the oil change warning light illuminated. The service warning light was reset but the issue became a regular occurrence. The vehicle was taken to the dealer, and the contact was informed that the service light needed to be reset each time the light became illuminated. The vehicle was not repaired. The manufacturer was notified of the issue, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 10,000.

NHTSA ID

11673717

Incident

Jul 15, 2025

Mileage

10,000 mi

See attached document for complaint.

NHTSA ID

11666587

Incident

May 1, 2025

In efforts to fix my vehicle for engine engineers have reset the odometer on my vehicle by over 1000 miles breaking federal law. They do not know how or why it happened and are not providing any explanations or follow ups.

NHTSA ID

11652924

Incident

Mar 31, 2025

full gauge cluster screen flickering every once in a while.

NHTSA ID

11637257

Incident

Jan 21, 2025

The item currently malfunctioning is the instrument cluster and infotainment display of the vehicle. While driving, the instrument cluster and infotainment display intermittently flashes on and off while the vehicle is in motion, resulting in the speed and other information to disappear while moving. Dealer has not been able to replicate the issue due to it being intermittent. The component was inspected by the dealer but root cause unable to be determined as issue was not able to be replicated. The vehicle is not displaying any warning lights, messages, or DTCs. After some searching online, multiple people are experiencing similar issues with the instrument cluster flickering with driving.

NHTSA ID

11631707

Incident

Oct 24, 2024

Undetermined what part failed I believe maybe an update. The truck lost all power and began to shift to neutral position at 40 mph on the highway. I was forced to get on the axis road. At 5mph the truck shifted violently to park. Dealership is working on it. The event was recorded on video and pictures. Wrench light showing

NHTSA ID

11631160

Incident

Nov 8, 2024

The contact owns a 2024 Ford F-150. The contact stated that the heads-up display reflection caused a line on the windshield at the driver's eye level, reducing the visibility of the roadway while driving. The contact stated that the failure occurred intermittently while driving. The vehicle was taken to the dealer, where it was inspected, and the failure was confirmed. The dealer notified the manufacturer of the failure. The manufacturer informed the dealer that the vehicle was operating as designed. The vehicle was not repaired. The failure mileage was approximately 10.

NHTSA ID

11614164

Incident

Aug 25, 2024

Mileage

10 mi