1993 Ford F-150 Powertrain (other) Problems

The contact owns a 1993 Ford F-150. The contact stated while driving downhill in 4WD, and letting off the accelerator pedal, the transmission unintendedly shifted into neutral. The contact pulled over and placed the vehicle in park(P) before shifting into to drive(D) for the vehicle to operate as needed. No warning lights were illuminated. The contact stated that the failure recurred. The vehicle was not taken to the dealer and was not repaired. The contact referenced NHTSA Campaign Number: 93V089000 (Power Train) as a possible solution however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.

NHTSA ID

11580079

Incident

Nov 15, 2010

Mileage

200,000 mi

Regarding Ford Safety Recall 93S65 4X4 Transfer Case comes out of gear while in 4X4 High and will roll away, pops out of gear while in reverse, shift indication lights fail to report proper placement of the transfer-case, at start up the Vehicle shifts on its own, Shift from 2H to 4H results in Chatter, the Vehicle is currently stuck in 4L. I found a recall publication (TSB 92-01-08 (Excerpt) Touch-Drive ESOF Operation) that is specifically related to this problem Safety Recall 93S65. Affected Vehicles: 1993 Model F- Series and Bronco 4x4 Vehicles. I went to DCH Ford in thousand Oaks for direction, I spoke with [XXX] (Service Director) [XXX], [XXX] regarding this recall. Ford and NTSB do not show this Recall. Ford must address this safety recall first. Please advise INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11434541

Incident

Sep 7, 2021

Mileage

186,000 mi

THE VEHICLE EXPERIENCED THREE BLOWOUTS, ONE WHICH DAMAGED THE FRONT END AND RIM. NLM

NHTSA ID

561679

DEFECTIVE SPEEDOMETER HEAD CAUSES SPEEDOMETER TO BOUNCE AROUND NOT ACCURATELY READING THE SPEED. PLEASE PROVIDE FURTHER INFORMATION. *AK

NHTSA ID

849371

Incident

Aug 14, 1999

THE 4WHEEL DRIVE, U/JOINTS AND DRIVE TRAIN HAVE GONE OUT ON THE TRUCK 4 TIMES, THE ELECTRICAL SYSTEM HAS NEVER WORKED RIGHT FROM DAY ONE AND HAS BEEN TAKEN INTO DEALER SEVERAL TIMES WITH COMPLAINTS BUT NEVER FIXED (AUTOLOCKS ON DOORS AND WINDOWS DON'T WORK AFTER HEAVY RAIN OR WET, HEAVY SNOW STORM) THE LAST TIME THE 4WHEEL DRIVE WENT OUT, THE FRONT DRIVERS WHEEL FLEW OFF THE TRUCK WHILE TRAVELING ON THE HIGHWAY. LUG NUTS AND POSTS WERE NOT LOOSE NOR SHEARED OFF. UPON CONTACTING FORD CUSTOMER SERVICE EACH TIME TRUCK TAKEN IN, HAVE BEEN TOLD THAT THERE HAVE BEEN "NO" RECALLS OF ANY TYPE ON OUR VEHICLE EXCEPT FOR ONE TO CHECK THE BOLTS ON THE FRONT BUMPER. THE FOLLOWING HAVE SHOWN OCCASSIONAL PROBLEMS SINCE 1993, BUT HAVE CONSISTENTLY BECOME WORSE WITH THE AGE/MILEAGE OF TRUCK: INTERMITTEN WIPERS DO NOT WORK, DIMMER LIGHT AND OTHER GAUGES DO NOT WORK IN DASH. THE TRANSMISSION HAS A LOT OF BACKLASH/KICK WHEN PUTTING INTO GEAR. THE IGNITION AND ALTERNATOR ARE CONSISTENTLY GETTING WORSE, SOMETIMES IT TAKES TURNING THE KEY UP TO TEN OR MORE TIMES TO GET THE TRUCK TO START. CURRENTLY, ONCE THE ENGINE GETS HOT, THE TRUCK SPITS AND SPUTTERS, ALMOST KILLING WHEN YOU SLOW DOWN AND THEN ATTEMPT TO ACCELERATE AGAIN. THE TRUCK RECENTLY HAD A COMPLETE TUNE-UP AND REPLACEMENT OF ALL PARTS WITH FORD AUTHORIZED PARTS.

NHTSA ID

709476

Incident

Nov 22, 1994

TRANSMISSION REPLACED.

NHTSA ID

515387

Incident

Feb 25, 1997

SLAVE CYLINDER LEAK.

NHTSA ID

504063

Incident

Feb 13, 1996

CLUTCH SLAVE CYLINDER LEAKED, CAUSING A NO-SHIFT CONDITION. *TW

NHTSA ID

489227

Incident

Dec 31, 1994