1994 Ford F-150 Owner Complaints

The contact owns a 1994 Ford F-150. The contact stated while driving 55 MPH, several unknown warning lights illuminated, and the rear brakes locked up. The contact lost control of the vehicle and crossed three lanes. The contact stated he bumped the curb which caused the vehicle to stop. The vehicle was not drivable. The contact towed the vehicle to his residence. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was unknown.

NHTSA ID

11492855

Incident

Oct 28, 2020

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE

NHTSA ID

11405829

Incident

Mar 9, 2021

Mileage

200,000 mi

SEPTEMBER 13TH I GOT INTO A SMALL ACCIDENT. I WAS PULLING MY TRAILER AND MY TRUCK RAN INTO A CONCRETE BARRIER. JUST RIGHT SIDE WAS MINOR. TRUCK JUMP ON TOP ON A ANGLE. I WAS FREAKING OUT COULD NOT GET THE SEAT BELT OFF. SOMEBODY HAD TO CUT IT. IM GLAD I WASNT BURNING IN THE TRUCK. I LOVE THESE 94 MODELS. BUT [XXX]. I WAS GETTING OFF THE INTERSTATE TO HWY 190 BUT HIT A CONSTRUCTION PIECE. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11361351

Incident

Sep 13, 2020

Mileage

250,000 mi

TRUCK JUST WENT UP IN FLAMES ,NEXT TO MY HOUSE. STARTED ON DRIVERS SIDE AND BURNT FROM SEATS TO THE FRONT BUMPER BURNING THE WINDSHIELD DASH AND THE ENGINE. TOTAL LOOSE.THE TRUCK WAS PARKED AND NOT RUNNING.

NHTSA ID

11350582

Incident

Jun 13, 2020

Mileage

127,000 mi

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE SHIFTED GEARS INDEPENDENTLY WITHOUT WARNING. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE VEHICLE FUEL PUMPS WERE DEFECTIVE AND REPLACED THEM. THE CONTACT THEN STATED THAT WHILE TRAVELING AT 50 MPH, THE CONTACT SMELLED A BURNING ODOR COMING FROM THE VEHICLE. THE VEHICLE STARTED TO LOSE MOTIVE POWER WHILE ABS, BATTERY, AND CHECK ENGINE WARNING LIGHTS BECAME ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER AND HAD THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC SINCE THE VEHICLE FAILED TO RESTART. THE MECHANIC DIAGNOSED THE VEHICLE WITH A DEFECTIVE COMPUTER SYSTEM WHICH WAS REPLACED. THE CONTACT SPOKE WITH KING COTTON FORD 965 US-51, COVINGTON, TN 38019 WHERE HE WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

NHTSA ID

11308242

Incident

Mar 1, 2019

Mileage

130,000 mi

THE GAS FROM THE FRONT TANK GOES TO THE BACK THING AND THE TRUCK HESITATES AND CUTS OFF. AND THE AIR BAG LIGHT KEEPS BLINKING

NHTSA ID

11302394

Incident

Jan 15, 2020

Mileage

385,000 mi

THROTTLE WON'T RETURN. ONCE PEDAL IS PUSHED IT STAYS AT HIGH REVVING. PEDAL WILL STAY ON FLOOR. CABLE WILL PULL BUT WON'T RETURN SO IDLE IS STUCK HIGH.

NHTSA ID

11300684

Incident

Jan 20, 2020

Mileage

201,057 mi

TL* THE CONTACT OWNS A 1994 FORD F-150. WHEN THE VEHICLE WAS STARTED, THE BRAKE PEDAL TRAVELED STRAIGHT TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE CONTACT'S HUSBAND REPLACED THE BRAKE LINES ON THE VEHICLE; HOWEVER, THE VEHICLE WOULD NOT MANEUVER OUT OF THE PARKING GEAR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS 136,000.

NHTSA ID

11253268

Incident

Jul 15, 2019

Mileage

136,000 mi

FUEL IS PUMPING OUT OF REAR TANK TO FRONT TANK CAUSING FUEL TO PUMP OUT OF FRONT FILLER CAP AND DOWN SIDE OF TRUCK CAUSING FIRE HAZZARD

NHTSA ID

11065432

Incident

Jan 22, 2018

Mileage

190,000 mi

THIS IS AN A SERIOUS ONGOING PROBLEM. THIS FORD F-150 HAS DUAL GAS TANKS, FRONT AND REAR. IN THIS TRUCK THE FRONT TANK IS SOMEHOW GETTING OVER FILLED AS YOU DRIVE ALONG AND SPEWS FUEL. REMOVE THE CAP AND GAS GUSHES OUT. A LITTLE GOOGLING SHOWED THAT THIS HAS HAPPENED TO A LOT OF F-150S. HAVING HAPPENED TO A NUMBER OF THESE TRUCKS THERE MUST BE A RECALL OR AT LEAST A TECHNICAL SERVICE BULLETIN THAT SAID WHAT NEEDED TO BE DONE TO FIX IT. THIS MUST BE COVERED BY A SAFETY RECALL. MOST RECALLS SEEM TO BE FOR RELATIVELY MINOR ISSUES. THIS IS A SERIOUS ISSUE. MOST RECALLS DON'T FIX PROBLEMS THAT APPROACH THE HAZARD TO LIFE AND PROPERTY THAT WOULD BE ENDANGERED IF THE VEHICLE BURST INTO FLAME. [XXX] [XXX] OR TEXT TO [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

NHTSA ID

11052591

Incident

Jan 16, 2017

Mileage

230,000 mi

MY DAD NOTICED THE AIR BAG WARNING LIGHT FLASHING ON AND OFF AT RANDOM SHORTLY BEFORE HE DIED. ONCE I WAS GIVEN IT AS A GIFT BY HIM IN HIS LAST WILL, I EXPERIENCED THE SAME ACTIVITY WITH THE LIGHT, "AND" NOW HAVE NO HORN AND THE HEADLIGHTS SOMETIMES FLASH ON AND OFF LIKE THEIR IS A SHORT IN THE ELECTRICAL SYSTEM...NOT SURE IF THE AIRBAG CURRENTLY FUNCTIONS OR NOT!

NHTSA ID

11013301

Incident

Sep 10, 2015

TL* THE CONTACT OWNS A 1994 FORD F-150 WITH A DUEL GAS TANK. THE CONTACT CALLED ON BEHALF OF HER SPOUSE AND STATED THAT AS HE PULLED INTO A FUEL STATION, HE WAS MADE AWARE BY BYSTANDERS THAT FUEL WAS LEAKING FROM THE FUEL TANK. THE CONTACT STATED THAT UPON HER HUSBAND EXITING THE VEHICLE, HE NOTICED FUEL LEAKING FROM THE REAR TANK AND UPON OPENING THE FUEL CAP A SIZZLING NOISE WAS HEARD AS FUEL SPEWED OUT THE TANK. THE CONTACT STATED THAT THE FRONT FUEL TANK WAS LEAKING INTO THE REAR FUEL TANK. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSES OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT DID NOT OFFER ANY FURTHER ASSISTANCE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 01I008000 (FUEL SYSTEM,GASOLINE) BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 152,000.

NHTSA ID

11010724

Incident

Jul 8, 2017

Mileage

152,000 mi

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT WHILE FUELING THE REAR TANK, APPROXIMATELY ONE GALLON OF FUEL STARTED EMERGING FROM THE FRONT TANK. THE CONTACT STOPPED FUELING AND CALLED THE FUEL STATION ATTENDANT TO REPORT THE FUEL SPILL. THE CONTACT ALSO STATED NOTICING THE SMELL OF FUEL EMERGING OUT OF THE FRONT TANK WHEN REFUELING THE REAR TANK TWICE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT DID NOT TAKE THE VEHICLE TO GET IT DIAGNOSED BUT CONTACTED THE DEALER BUTCH OUSTALET IN GULFPORT, MISSISSIPPI BY PHONE. THE DEALER ADVISED TO BRING THE VEHICLE IN FOR A DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,524.

NHTSA ID

11001609

Incident

Jun 27, 2017

Mileage

100,524 mi

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE VEHICLE DID NOT START WHEN CRANKED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE DEALER DIAGNOSED THAT THE CLOCK SPRING NEEDED REPLACEMENT. THE VEHICLE FAILED AT LEAST TWENTY TIMES INTERMITTENTLY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 192,000.

NHTSA ID

10957211

Incident

Feb 13, 2017

Mileage

192,000 mi

1994 FORD F-150. CONSUMER WRITES IN REGARDS TO SERVICE DEPARTMENT UNABLE TO REPAIR DRIVER AIRBAG INDICATOR LIGHT THAT HAS BEEN BLINKING FOR SEVERAL YEARS. *SMD

NHTSA ID

10939328

Incident

Jan 2, 2017

TRUCK LEAKS GASOLINE WHEN BOTH TANKS ARE FULL. TOOK TO AN INDEPENDENT MECHANIC WHO DETECTED A PROBLEM WITH THE FUEL PUMP. REAR TANK PUMPS ITS FUEL TO THE FRONT TANK. WHEN THE FRONT TANK IS FULL, THE GAS LEAKS IN THE ENGINE COMPARTMENT IN AN AREA BENEATH THE BATTERY. THE 1993 FORDS WERE RECALLED FOR THIS ISSUE. BUILD DATE ON THIS TRUCK IS 01/94

NHTSA ID

10871975

Incident

Mar 1, 2016

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE DUAL FUEL TANKS WERE LEAKING FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT WHEN BOTH FUEL TANKS WERE FULL, THE FRONT TANK WOULD PUMP FUEL INTO THE REAR FUEL TANK DUE TO MALFUNCTIONING CHECK VALVES CAUSING FUEL TO OVER FLOW FROM THE FUEL GAP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 02/09/15*LJ UPDATED 9/11/17*CN

NHTSA ID

10667647

Incident

Aug 20, 2014

Mileage

200,000 mi

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE WHILE SITTING IN A RESIDENTIAL DRIVEWAY. THE VEHICLE HAD NOT BEEN DRIVEN FOR TWO WEEKS PRIOR TO THE FIRE. THE CONTACT BELIEVED THAT THE FIRE STARTED NEAR THE ANTI-LOCK BRAKING SYSTEM BUT THE ORIGIN OF THE FIRE WAS NOT DETERMINED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10663056

Incident

Dec 8, 2014

Mileage

250,000 mi

THIS VEHICLE HAS DUAL FUEL TANKS. THE FRONT TANK SUPPLIES GAS TO THE MOTOR. THE REAR TANK DOES NOT SEEM TO FUEL THE MOTOR. GAS FROM THE FRONT TANK IS FORCED INTO THE REAR TANK UNTIL IT IS PRESSURIZED TO THE POINT OF COMING OUT THROUGH THE CAP. IF THE CAP IS REMOVED, BOTH FUMES AND GAS SPILL OUT OF THE FILLER NECK. I AM READING NOW THAT THIS IS A PROBLEM WITH THIS VEHICLE DURING OR AROUND THE 1994 TIME FRAME. IS FORD ATTEMPTING TO CORRECT THIS PROBLEM? THIS IS NOT THE FIRST TIME I HAVE HAD THIS PROBLEM. IT HAS HAPPENED IN 2011, 2012, 2013 AND NOW IN 2014, BUT I'VE NEVER KNOWN THIS COULD BE A FACTORY DEFECT. *TR

NHTSA ID

10611217

Incident

Jul 10, 2014

Mileage

170,000 mi

TL* THE CONTACT OWNS A 1994 F-15. THE CONTACT STATED THAT GASOLINE FUEL WAS LEAKING FROM THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER WAS ALERTED OF THE FAILURE BUT STATED THAT THERE WAS NOT A RECALL FOR THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 141,000.

NHTSA ID

10569404

Incident

Mar 14, 2014

Mileage

141,000 mi

ON MONDAY I NOTICED A STRONG GASOLINE SMELL COMING FROM THE REAR TANK (DUAL TANK SYSTEM) OF MY TRUCK. TUESDAY AFTER SWITCHING GAS USE FROM THE FRONT TO REAR WHEN I STOPPED AT A LOCAL STORE, GAS WAS DRIBBLING AT A HIGH RATE OF SPEED OUT OF THE GAS CAP AREA FROM MY REAR TANK. BY THE TIME I GOT HOME PRESSURE CAUSED THE GAS TO PRACTICALLY EXPLODE OUT OF THE GAS CAP BY THE GALLONS. THE FIRE DEPARTMENT HAD TO BE CALLED TO ENSURE THAT MOVING THE TRUCK DID NOT START A FIRE AND TO CLEAN THE SPILL. AFTER RESEARCHING THE ISSUE, IT APPEARS THAT THERE WAS A RECALL THROUGH FORD FOR EARLIER DUAL TANK MODELS FOR THE SAME ISSUE (NHTSA CAMPAIGN ID NUMBER :93V125000). MANY OTHER 1994 F-150 OWNERS ARE HAVING THIS SAME ISSUE BUT A RECALL HAS NOT YET BEEN ISSUED (EXAMPLE: NHTSA COMPLAINT # 10533605). I ASSURE YOU THAT THIS WAS INDEED A HUGE FIRE HAZARD! ACCORDING TO YOUR FILES, IN 1993, FORD IS WELL AWARE OF THIS ISSUE THROUGH RECALL 93V-125. WHY HAVEN'T OTHER OWNERS WITH DUAL TANKS BEEN NOTIFIED? IN ADDITION, WHY HASN'T THERE BEEN ANOTHER RECALL FOR LATER FORD MODELS? *TR

NHTSA ID

10561085

Incident

Jan 21, 2014

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED HIS VEHICLE HAD DUEL FUEL TANKS AND WHILE IT WAS PARKED HE NOTICED FUEL LEAKING. THE CONTACT STATED WHEN THE BOTH FUEL TANKS WERE FULL THE FRONT TANK WOULD PUMP FUEL INTO THE BACK TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,000. THE CURRENT APPROXIMATE MILEAGE IS 163,000. UPDATED 9/17/13*CN THE CONSUMER STATED WHEN BOTH TANKS WERE OVER HALF FULL, WHILE DRIVING, THE FRONT TANK WOULD RUN THE TRUCK AND AT THE SAME TIME, PUMP EXTRA FUEL INTO THE REAR TANK, CAUSING GAS TO OVER FLOW FROM THE GAS GAP, AND ONTO THE GROUND. UPDATED. 11/6/13

NHTSA ID

10533605

Incident

Dec 25, 2012

Mileage

163,000 mi

WHILE DRIVING MY SEAT RECLINER BOLTS BROKE FROM THE SEAT FRAME CAUSING THE SEAT TO RECLINE ALL THE WAY TO THE BACK SEAT IN MY EXTENDED CAB. I WAS ABLE TO NOT LOSE CONTROL OF MY TRUCK THANKFULLY HOWEVER I HAVE IT TEMPORARILY FIXED WITH A BOLT STUCK THROUGH IT TO KEEP IT FROM RECLINING. UPON CALLING FORD THEY TOLD ME THAT EVEN THOUGH I FOUND A RECALL FOR THIS ISSUE; IT HOWEVER DID NOT AFFECT MY VIN #. I BELIEVE THIS IS A SAFETY ISSUE AND SHOULD BE ADDRESSED. UPON SPEAKING WITH FORD DIRECTLY FOR REPLACEMENT PARTS TO FIX IT, I WAS TOLD THE PARTS/BOLTS ONLY COME IN A BIG QUANTITY PACK AND WOULD BE ALMOST $200 BUT I WOULD ONLY NEED ONE OR TWO BOLTS TO FIX IT. THIS IS RIDICULOUS AND SHOULD BE HANDLED BY THE DEALER FREE OF CHARGE AND INCLUDED AS A RECALL DUE TO THE SAFETY HAZARD THIS COULD HAVE POSED TO MYSELF AND OTHER CITIZENS DRIVING! *TR

NHTSA ID

10472007

Incident

Aug 22, 2012

Mileage

181,100 mi

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT REPLACED THE COIL PACK AND THE VEHICLE RESUMED NORMAL OPERATION TEMPORARILY. THE FAILURE RECURRED TWO MONTHS LATER. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 200,000 AND THE CURRENT MILEAGE WAS 226,000.

NHTSA ID

10456324

Incident

Feb 15, 2012

Mileage

200,000 mi

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CONTACTED AND NO INJURIES WERE REPORTED. THE FIRE DEPARTMENT ADVISED THE CONTACT THAT THE FLAMES BEGAN NEAR THE FIRE WALL. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 160,000.

NHTSA ID

10450387

Incident

Mar 2, 2012

Mileage

160,000 mi