1994 Ford F-150 Problems

The contact owns a 1994 Ford F-150. The contact stated while driving 55 MPH, several unknown warning lights illuminated, and the rear brakes locked up. The contact lost control of the vehicle and crossed three lanes. The contact stated he bumped the curb which caused the vehicle to stop. The vehicle was not drivable. The contact towed the vehicle to his residence. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was unknown.

TL* THE CONTACT OWNS A 1994 FORD F-150. WHEN THE VEHICLE WAS STARTED, THE BRAKE PEDAL TRAVELED STRAIGHT TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE CONTACT'S HUSBAND REPLACED THE BRAKE LINES ON THE VEHICLE; HOWEVER, THE VEHICLE WOULD NOT MANEUVER OUT OF THE PARKING GEAR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS 136,000.

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE SHIFTED GEARS INDEPENDENTLY WITHOUT WARNING. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE VEHICLE FUEL PUMPS WERE DEFECTIVE AND REPLACED THEM. THE CONTACT THEN STATED THAT WHILE TRAVELING AT 50 MPH, THE CONTACT SMELLED A BURNING ODOR COMING FROM THE VEHICLE. THE VEHICLE STARTED TO LOSE MOTIVE POWER WHILE ABS, BATTERY, AND CHECK ENGINE WARNING LIGHTS BECAME ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER AND HAD THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC SINCE THE VEHICLE FAILED TO RESTART. THE MECHANIC DIAGNOSED THE VEHICLE WITH A DEFECTIVE COMPUTER SYSTEM WHICH WAS REPLACED. THE CONTACT SPOKE WITH KING COTTON FORD 965 US-51, COVINGTON, TN 38019 WHERE HE WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

THE GAS FROM THE FRONT TANK GOES TO THE BACK THING AND THE TRUCK HESITATES AND CUTS OFF. AND THE AIR BAG LIGHT KEEPS BLINKING

MY DAD NOTICED THE AIR BAG WARNING LIGHT FLASHING ON AND OFF AT RANDOM SHORTLY BEFORE HE DIED. ONCE I WAS GIVEN IT AS A GIFT BY HIM IN HIS LAST WILL, I EXPERIENCED THE SAME ACTIVITY WITH THE LIGHT, "AND" NOW HAVE NO HORN AND THE HEADLIGHTS SOMETIMES FLASH ON AND OFF LIKE THEIR IS A SHORT IN THE ELECTRICAL SYSTEM...NOT SURE IF THE AIRBAG CURRENTLY FUNCTIONS OR NOT!

TRUCK JUST WENT UP IN FLAMES ,NEXT TO MY HOUSE. STARTED ON DRIVERS SIDE AND BURNT FROM SEATS TO THE FRONT BUMPER BURNING THE WINDSHIELD DASH AND THE ENGINE. TOTAL LOOSE.THE TRUCK WAS PARKED AND NOT RUNNING.

MY DAD NOTICED THE AIR BAG WARNING LIGHT FLASHING ON AND OFF AT RANDOM SHORTLY BEFORE HE DIED. ONCE I WAS GIVEN IT AS A GIFT BY HIM IN HIS LAST WILL, I EXPERIENCED THE SAME ACTIVITY WITH THE LIGHT, "AND" NOW HAVE NO HORN AND THE HEADLIGHTS SOMETIMES FLASH ON AND OFF LIKE THEIR IS A SHORT IN THE ELECTRICAL SYSTEM...NOT SURE IF THE AIRBAG CURRENTLY FUNCTIONS OR NOT!

VEHICLE CAUGHT ON FIRE AFTER TURNING THE IGNITION OFF. I WAS IN HARRYS ARMY AND NAVY STORE, 691 ROUTE 130 ROBBINSVILLE, NJ 08691 (609) 585-5450, WHEN I HEARD OVER THE INTERCOM THAT THERE WAS A GREEN F150 ON FIRE IN THE PARKING LOT. I IMMEDIATELY WENT OUTSIDE AND SOMEONE FROM THE PLAZA WAS TRYING TO PUT OUT. SHORTLY THEREAFTER THE FIRE DEPARTMENT SHOWED UP ALONG WITH THE POLICE AND EXTENGUISHED THE MOTOR UNDER THE HOOD COMPLETELY. I HAD THE TRUCK TOWED TO PINE HILL, NJ WHICH COST 200.00 ON TOP OF LOSING MY TRUCK WITH IS MY FINANCIAL STABILITY DUE TO BEING A SELF CONTRACTOR. ALL OF THE HOSED, BELTS AND WIRING IS MELTED, HOWEVER, THE FIRE WAS CONTAINED TO UNDER THE HOOD. I IMMEDIATELY HAD TO PURCHASE ANOTHER VEHICILE DUE TO THE HEAVY DAMAGE AND MY LIVELY HOOD. SOMEONE ADVISED ME THAT THERE ARE RECALLS REGARDING THE WIRING IN THE TRUCK WHICH CAUSES FIRE DAMAGE UNDER THE HOOD. THE FOLLOWING ARE RECALLS IN REGARDS TO THIS MATTER: 05S28, EA5005, 05V017, 06V206, 05V388, 06V286. *TR

TL*THE CONTACT OWNS A 1994 FORD F-150. WHILE THE VEHICLE WAS PARKED AND TURNED OFF, IT CAUGHT FIRE AND WAS DESTROYED. THE FIRE DEPARTMENT WAS DISPATCHED TO EXTINGUISH THE FIRE. THE VEHICLE HAD NOT BEEN TAKEN TO AN AUTHORIZED DEALERSHIP BUT THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS UNDER RECALL 05V388000 (VEHICLE SPEED CONTROL). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 170,000. THE VIN WAS UNAVAILABLE.

TRUCK JUST WENT UP IN FLAMES ,NEXT TO MY HOUSE. STARTED ON DRIVERS SIDE AND BURNT FROM SEATS TO THE FRONT BUMPER BURNING THE WINDSHIELD DASH AND THE ENGINE. TOTAL LOOSE.THE TRUCK WAS PARKED AND NOT RUNNING.

TL* THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE VEHICLE DID NOT START WHEN CRANKED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE DEALER DIAGNOSED THAT THE CLOCK SPRING NEEDED REPLACEMENT. THE VEHICLE FAILED AT LEAST TWENTY TIMES INTERMITTENTLY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 192,000.

DT: THE CONTACT STATED PICKUP TRUCK WAS PLACED IN THE GARAGE, AND IN THE EARLY MORNING HE DISCOVERED THE HOUSE WAS ON FIRE ALONG WITH THE TRUCK. HE CALLED THE FIRE DEPARTMENT IMMEDIATELY. THE FIRE CAUSED SIGNIFICANT DAMAGE TO THE HOUSE. THE VEHICLE WAS TOTALED. THE INSURANCE INVESTIGATOR DETERMINED THAT THE FIRE WAS CAUSED BY AUTOMATIC TRANSMISSION :CONTROL MODULE (PCM). THERE WERE NO PREVIOUS PROBLEMS ASSOCIATED WITH THE VEHICLE. *AK

EFOD TRANSMISSION - 3RD ONE CURRENTLY INSTALLED, ALONG WITH SECOND CONTROL MODULE. RADIATOR SEPARATED AT TANK SIDE JOINTS CAUSING LEAKS. IDLER AND TENSION PULLEYS FAILED. TIRES WERE ORIGINALLY FIRESTONES- TWO HIGH SPEED BLOWOUTS BEFORE IT BECAME NATIONAL NEWS. REPLACED A/C COMPRESSOR IN FIRST YEAR OF OWNERSHIP. SECOND CLOCK MECH. INSTALLED IN STEEERING WHEEL, CAUSED LOSS OF AIRBAG, HORN, CRUISE CONTROL WHEN IT WENT OUT BOTH TIMES. REPLACED U-JOINTS. FRONT BRAKE ROTORS WARP EVERY 20,000 MILES. REPLACED FAILED MASS AIR SENSOR AND COOLANT TEMP. SENSOR. REPLACED CRUISE CONTROL MODULE.

TL*THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE LEAF SPRINGS ON THE VEHICLE FAILED. THE TECHNICIAN AT THE DEALER STATED THAT THE OIL PAN WAS EXCESSIVELY RUSTED . THE VEHICLE WAS NOT REPAIRED DUE TO THE REPAIR COST. THE CONTACT CALLED FORD, BUT NEVER RECEIVED A RESPONSE. HE STILL HAS POSSESSION OF THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 87,000. UPDATED 5/13/08 *CN THE CONSUMER STATED THE HANGERS THAT ATTACH TO THE LEAF SPRINGS TO THE FRAME OF THE TRUCK HAVE RUSTED, LEAVING THE REAR LEAF SPRINGS TO RIDE ON THE UNDERSIDE OF THE TRUCK BED. UPDATED 05/13/08

DRIVER SIDE REAR LEAF SPRING HANGER PREMATURELY DISINTEGRATED. CAUSING SPRING TO HIT BED WHILE DRIVE AT SPEED OF APPROXIMATELY 50 MPH. DEALER SAY NOT A RECALL ITEM. *TR

TL* THE CONTACT OWNS A 1994 FORD F-150 WITH TBC VANDERBILT TURBO TECH GT TIRES, SIZE 265/70R15. THE CONTACT STATED THAT THREE OF THE FOUR TIRES FAILED WITHIN 70 MILES. THE CONTACT STATED THAT THE BEADING FAILED AROUND THE SIDEWALL. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS TOLD THAT THE FAILURE WAS CAUSED WHEN THE TIRES WERE INSTALLED ON THE VEHICLE. THE FAILURE MILEAGE WAS 158,000 UPDATED 10/18/11*LJ UPDATED 11/04/11

I WAS DRIVING ON A BUSY INTERSTATE WHEN MY COOPER TRENDSETTER SE TIRE SHREDDED FOR NO REASON. DOT NUMBER 3DHLC2T4106. I HAVE NOT BEEN ABLE TO REPAIR THE TIRE AT THIS POINT. *TR

TRUCK JUST WENT UP IN FLAMES ,NEXT TO MY HOUSE. STARTED ON DRIVERS SIDE AND BURNT FROM SEATS TO THE FRONT BUMPER BURNING THE WINDSHIELD DASH AND THE ENGINE. TOTAL LOOSE.THE TRUCK WAS PARKED AND NOT RUNNING.

TL*THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE PARKING BRAKE WOULD NOT HOLD THE VEHICLE, WHICH CAUSES IT TO ROLL FREELY. SECONDLY, THE BUMPER IS ABNORMALLY LOOSE AND RATTLES. AS A RESULT, THE BUMPER COULD SEPARATE FROM THE VEHICLE. THIRDLY, THE SEAT BACK RECLINES SUDDENLY. LASTLY, THE FRONT DRIVER'S SIDE AIR BAG WARNING LIGHT CONSISTENTLY ILLUMINATES ON THE INSTRUMENT PANEL. THE LIGHT INDICATES A FAILURE WITHIN THE AIR BAG SYSTEM. THE MANUFACTURER WOULD NOT ASSIST WITH THE REPAIRS BECAUSE THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBERS 93V184000, 94V018000, 94V169001, AND 96E010000. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND CURRENT MILEAGE WAS 100,009. UPDATED 6/2/09 *CN UPDATED 06/04/09.*JB

WHILE DRIVING MY SEAT RECLINER BOLTS BROKE FROM THE SEAT FRAME CAUSING THE SEAT TO RECLINE ALL THE WAY TO THE BACK SEAT IN MY EXTENDED CAB. I WAS ABLE TO NOT LOSE CONTROL OF MY TRUCK THANKFULLY HOWEVER I HAVE IT TEMPORARILY FIXED WITH A BOLT STUCK THROUGH IT TO KEEP IT FROM RECLINING. UPON CALLING FORD THEY TOLD ME THAT EVEN THOUGH I FOUND A RECALL FOR THIS ISSUE; IT HOWEVER DID NOT AFFECT MY VIN #. I BELIEVE THIS IS A SAFETY ISSUE AND SHOULD BE ADDRESSED. UPON SPEAKING WITH FORD DIRECTLY FOR REPLACEMENT PARTS TO FIX IT, I WAS TOLD THE PARTS/BOLTS ONLY COME IN A BIG QUANTITY PACK AND WOULD BE ALMOST $200 BUT I WOULD ONLY NEED ONE OR TWO BOLTS TO FIX IT. THIS IS RIDICULOUS AND SHOULD BE HANDLED BY THE DEALER FREE OF CHARGE AND INCLUDED AS A RECALL DUE TO THE SAFETY HAZARD THIS COULD HAVE POSED TO MYSELF AND OTHER CITIZENS DRIVING! *TR

TL*THE CONTACT OWNS A 1994 FORD F-150. THE CONTACT STATED THAT THE PARKING BRAKE WOULD NOT HOLD THE VEHICLE, WHICH CAUSES IT TO ROLL FREELY. SECONDLY, THE BUMPER IS ABNORMALLY LOOSE AND RATTLES. AS A RESULT, THE BUMPER COULD SEPARATE FROM THE VEHICLE. THIRDLY, THE SEAT BACK RECLINES SUDDENLY. LASTLY, THE FRONT DRIVER'S SIDE AIR BAG WARNING LIGHT CONSISTENTLY ILLUMINATES ON THE INSTRUMENT PANEL. THE LIGHT INDICATES A FAILURE WITHIN THE AIR BAG SYSTEM. THE MANUFACTURER WOULD NOT ASSIST WITH THE REPAIRS BECAUSE THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBERS 93V184000, 94V018000, 94V169001, AND 96E010000. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND CURRENT MILEAGE WAS 100,009. UPDATED 6/2/09 *CN UPDATED 06/04/09.*JB

INCIDENT DATE 7/24/2007; MILEAGE 158,487. PRODUCT FAILURE OF THE CIRCULAR STEERING SWITCH ON MY 1994 FORD F150 TRUCK. FAILURE OF THIS SWITCH DEACTIVATES THE AIRBAG DEPLOYMENT AND THE HORN. TWO PRIOR INCIDENTS OF SAME FAILURE ON 4/4/2001 MILEAGE 105,900 AND AGAIN ON APPROXIMATELY 5/11/2001. THESE FAILURES MAY INDICATE AN SYSTEMIC ISSUE POSSIBLY REQUIRING A VEHICLE RECALL PROGRAM. *TR

EFOD TRANSMISSION - 3RD ONE CURRENTLY INSTALLED, ALONG WITH SECOND CONTROL MODULE. RADIATOR SEPARATED AT TANK SIDE JOINTS CAUSING LEAKS. IDLER AND TENSION PULLEYS FAILED. TIRES WERE ORIGINALLY FIRESTONES- TWO HIGH SPEED BLOWOUTS BEFORE IT BECAME NATIONAL NEWS. REPLACED A/C COMPRESSOR IN FIRST YEAR OF OWNERSHIP. SECOND CLOCK MECH. INSTALLED IN STEEERING WHEEL, CAUSED LOSS OF AIRBAG, HORN, CRUISE CONTROL WHEN IT WENT OUT BOTH TIMES. REPLACED U-JOINTS. FRONT BRAKE ROTORS WARP EVERY 20,000 MILES. REPLACED FAILED MASS AIR SENSOR AND COOLANT TEMP. SENSOR. REPLACED CRUISE CONTROL MODULE.

FORD F150 TRANSMISSION. *BF AT IDLE WHEN THE GEAR WAS PLACED IN REVERSE, THE VEHICLE WOULD JERK HARD, THE IGNITION SWITCH WOULD GET REALLY HOT, THE HORN WENT OUT, THE AIR BAG LIGHT ILLUMINATED, THE ENGINE IDLER PULLEY HAD TO BE REPLACED, THE ORIGINAL NYLON BUSHING HAD WORN OUT, THE WIPER SWITCH ONLY DISPLAYED TWO SPEEDS, THE WIPER WASHER STOPPED WORKING, THE ANTI LOCK BRAKES STOPPED WORKING, THE DOME LIGHT HAD A SHORT AND THE ALTERNATOR HAD GONE BAD. *SC

ALL OF INTERMITTENT WINDSHIELD WIPER SETTINGS DO NOT WORK ALL OF THE TIME. ADDITIONALLY, SOMETIMES I MUST "JIGGLE" THE TURN SIGNAL ASSEMBLY TO ACCTIVATE THE HEADLIGHTS. MORE THAN ONCE I HAVE BEEN DRIVING FOR AN UNDETERMINED AMOUNT OF TIME BEFORE I REALIZE MY HEADLIGHTS ARE NOT WORKING. I HAVE HAD THIS PART REPLACED BEFORE FOR HE SAME PROBLEMS. MY WIFE OWNS A '98 FORD EXPLORER, SAME PROBLEM. A FRIEND OWNS A '98 FORD TAURUS, SAME PROBLEM. IS THIS A SAFETY RELATED ITEM THAT THE MANUFACTURER MUST KEEP REPLACING FREE OF CHARGE? *AK

EFOD TRANSMISSION - 3RD ONE CURRENTLY INSTALLED, ALONG WITH SECOND CONTROL MODULE. RADIATOR SEPARATED AT TANK SIDE JOINTS CAUSING LEAKS. IDLER AND TENSION PULLEYS FAILED. TIRES WERE ORIGINALLY FIRESTONES- TWO HIGH SPEED BLOWOUTS BEFORE IT BECAME NATIONAL NEWS. REPLACED A/C COMPRESSOR IN FIRST YEAR OF OWNERSHIP. SECOND CLOCK MECH. INSTALLED IN STEEERING WHEEL, CAUSED LOSS OF AIRBAG, HORN, CRUISE CONTROL WHEN IT WENT OUT BOTH TIMES. REPLACED U-JOINTS. FRONT BRAKE ROTORS WARP EVERY 20,000 MILES. REPLACED FAILED MASS AIR SENSOR AND COOLANT TEMP. SENSOR. REPLACED CRUISE CONTROL MODULE.

THE FRAME AND COMPLETE UNDERCARRIAGES HAVE RUSTED.*JB

SEPTEMBER 13TH I GOT INTO A SMALL ACCIDENT. I WAS PULLING MY TRAILER AND MY TRUCK RAN INTO A CONCRETE BARRIER. JUST RIGHT SIDE WAS MINOR. TRUCK JUMP ON TOP ON A ANGLE. I WAS FREAKING OUT COULD NOT GET THE SEAT BELT OFF. SOMEBODY HAD TO CUT IT. IM GLAD I WASNT BURNING IN THE TRUCK. I LOVE THESE 94 MODELS. BUT [XXX]. I WAS GETTING OFF THE INTERSTATE TO HWY 190 BUT HIT A CONSTRUCTION PIECE. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

SEAT BELT RETRACTOR STUCK/JAMMED, AND THE BELT IS INOPERABLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *AK

ON MONDAY I NOTICED A STRONG GASOLINE SMELL COMING FROM THE REAR TANK (DUAL TANK SYSTEM) OF MY TRUCK. TUESDAY AFTER SWITCHING GAS USE FROM THE FRONT TO REAR WHEN I STOPPED AT A LOCAL STORE, GAS WAS DRIBBLING AT A HIGH RATE OF SPEED OUT OF THE GAS CAP AREA FROM MY REAR TANK. BY THE TIME I GOT HOME PRESSURE CAUSED THE GAS TO PRACTICALLY EXPLODE OUT OF THE GAS CAP BY THE GALLONS. THE FIRE DEPARTMENT HAD TO BE CALLED TO ENSURE THAT MOVING THE TRUCK DID NOT START A FIRE AND TO CLEAN THE SPILL. AFTER RESEARCHING THE ISSUE, IT APPEARS THAT THERE WAS A RECALL THROUGH FORD FOR EARLIER DUAL TANK MODELS FOR THE SAME ISSUE (NHTSA CAMPAIGN ID NUMBER :93V125000). MANY OTHER 1994 F-150 OWNERS ARE HAVING THIS SAME ISSUE BUT A RECALL HAS NOT YET BEEN ISSUED (EXAMPLE: NHTSA COMPLAINT # 10533605). I ASSURE YOU THAT THIS WAS INDEED A HUGE FIRE HAZARD! ACCORDING TO YOUR FILES, IN 1993, FORD IS WELL AWARE OF THIS ISSUE THROUGH RECALL 93V-125. WHY HAVEN'T OTHER OWNERS WITH DUAL TANKS BEEN NOTIFIED? IN ADDITION, WHY HASN'T THERE BEEN ANOTHER RECALL FOR LATER FORD MODELS? *TR

EVER SINCE MY CRUISE CONTROL WAS REPAIRED ON MY 1994 F150 THE BATTERY KEEPS LOSING ALL ITS POWER. AS I DON'T DRIVE THE TRUCK THAT MUCH ANYMORE I JUST CHARGE THE BATTERY WHENEVER I USED MY TRUCK. MY TRUCK WAS REPAIRED AT ALL STAR FORD IN OLYMPIA WASHINGTON. *TR

DASH ON RIGHT SIDE MOVES UP AND DOWN WHEN DRIVING DOWN THE ROAD,FOUND THE MOUNTING TAB (MADE OF PLASTIC) BROKEN ON THE RIGHT SIDE BY DOOR. WHEN DRIVING WITH HEADLIGHTS ON THEY WILL GO OFF AND THEN COME BACK ON SOMETIMES IN A SECOND OR TWO,OTHER TIMES IF THE LIGHTS ARE TURNED OFF AND THEN BACK ON THEY WILL WORK FOR AWHILE. HAVE CHECKED THE WIRING AND BULB SIZE AND IT ALL SEEMS TO BE ALRIGHT. ANY HELP WITH THIS WILL BE GREATLY APPRECIETED. *AK

ALL OF INTERMITTENT WINDSHIELD WIPER SETTINGS DO NOT WORK ALL OF THE TIME. ADDITIONALLY, SOMETIMES I MUST "JIGGLE" THE TURN SIGNAL ASSEMBLY TO ACCTIVATE THE HEADLIGHTS. MORE THAN ONCE I HAVE BEEN DRIVING FOR AN UNDETERMINED AMOUNT OF TIME BEFORE I REALIZE MY HEADLIGHTS ARE NOT WORKING. I HAVE HAD THIS PART REPLACED BEFORE FOR HE SAME PROBLEMS. MY WIFE OWNS A '98 FORD EXPLORER, SAME PROBLEM. A FRIEND OWNS A '98 FORD TAURUS, SAME PROBLEM. IS THIS A SAFETY RELATED ITEM THAT THE MANUFACTURER MUST KEEP REPLACING FREE OF CHARGE? *AK

NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK

A FIRE IGNITED IN THE AREA OF THE AIR CONDITIONING COMPRESSOR OR BLOWER MOTOR.