2001 Ford F-150 Problems

The contact owned a 1996 N/A Ford F-150. The contact stated that while the vehicle was parked and turned off, the firewall located on the driver's side had caught on fire. The fire was extinguished by the Fire Department. A fire report was filed, and a fire report number was not provided. The origin of the fire was not yet determined. A Police report was not filed. The dealer was contacted. The vehicle was not diagnosed or repaired. The vehicle was destroyed. The manufacturer was made aware of the failure. The failure mileage was approximately 249,000.

The contact owns a 2001 Ford F-150. The contact stated that the rear doors failed to open due to a fractured cable. The contact added WD-40 to the doors. The contact stated that the battery was draining while the door was opened. The contact stated that the resonator connecting the engine and muffler was rusted. The contact added putty to the area. Additionally, the check engine warning light was illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 145,000.

The contact owned a 2001 Ford F-150. The contact stated that he parked the vehicle on the street in front of the residence, and ten minutes later, the contact heard the horn abruptly sounding. His son looked out the window and discovered the vehicle in flames. No warning light was illuminated. The contact called 911 about the failure. There were no injuries sustained. The police and fire departments arrived on the scene, and the firefighters extinguished the fire. The fire consumed and destroyed the entire vehicle. The origin of the fire was in the engine compartment of the driver's side. Police and fire department reports were filed. The vehicle was not towed and remained at the residence. The insurance company was notified of the failure; however, pending an inspection. The contact related the failure to NHTSA Campaign Number: 05V017000 (VEHICLE SPEED CONTROL), which was associated with the VIN, and upon research, believed that the recall consequence was related to the fire. The manufacturer was not made aware of the failure and opened a case. The failure mileage was unknown.

The contact owned a 2001 Ford F-150. The contact stated that while the vehicle was parked and unoccupied, the vehicle caught on fire. The contact stated that a bystander driving by became aware of the fire underneath the hood of the vehicle and used a fire extinguisher to extinguish the fire. The contact stated that failure was caused by brake fluid leaking onto a faulty brake pressor sensor switch, also called a speed control deactivation switch under the hood, and caused the switch to corrode, causing the fire. No injuries were sustained. The contact stated that the Fire Department was not notified of the fire. The vehicle remand at the residence. The vehicle was destroyed. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 05V388000 (VEHICLE SPEED CONTROL); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 283,000.

The contact owns a 2001 Ford F-150. The contact received notification of NHTSA Campaign Number: 01V227001 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the front passenger’s seat belt loosened independently, and the front driver’s side seat belt occasionally loosened independently. The local dealer informed the contact that parts for recall repairs were not on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 242,000. Parts distribution disconnect.

The contact owns a 2001 Ford F-150. The contact stated while driving at an undisclosed speed, the driver's side seat belt unbuckled independently. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number: 00V348000 (Seat Belts) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 293,000.

The contact owns a 2001 Ford F-150. The contact stated that while the vehicle was parked and turned off the vehicle suddenly caught on fire and was destroyed. The fire department was called to the impoundment lot and extinguished the flames which came from the engine compartment. A fire report was taken at the scene. The cause of the fire was not determined. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 190,000.

The contact owns a 2001 Ford F-150. The contact stated that while the vehicle was parked in the driveway flames were suddenly present coming from the engine compartment. The fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed. The cause of the failure was not determined. The local dealer and manufacturer were not notified. The contact indicated that prior to the fire the vehicle had not been driven or turned on for two days. The failure mileage was 89,000.

The contact owns a 2001 Ford F-150. The contact stated that upon entering the vehicle one day, there was an abnormal fuel odor outside the vehicle. The contact’s husband inspected underneath the vehicle and discovered that the fuel tank had detached from the subframe. The contact stated that prior to becoming aware of the failure, the low fuel warning light was occasionally illuminated. The vehicle was not taken to a local dealer. The local dealer was contacted, and the contact was informed that there were no open recalls on the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 93,000.

ONE OF THE STRAPS HOLDING UP MY FUEL TANK HAD RUSTED AND BROKE AWAY FROM TANK.THE OTHER STRAP IS RUSTING TOO.

n/a

The contact's associate owns a 2001 Ford F-150. The contact stated while his associate was driving approximately 35 MPH, the vehicle experienced a braking failure. The ABS warning light was illuminated on the instrument panel. The vehicle was taken to the local dealer where it was diagnosed that the braking system had failed and the failure was related to NHTSA Campaign Number: 05V017000 (Vehicle Speed Control). The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 190,000.

TAKATA RECALL

IN 2006 I WAS IN A REAR END COLLISION WHERE I WAS STRUCK FROM BEHIND AND FORCED INTO THE VEHICLE IN FRONT OF ME AND WE WERE FORCED INTO A THIRD VEHICLE IN FRONT OF US. IT RESULTED IN SEVERAL PEOPLE BEING SENT TO THE HOSPITAL WITH SERIOUS INJURIES. I WAS IN THE MIDDLE OF TWO VEHICLES AND MY AIR BAGS DID NOT DEPLOY! I HAD A BROKEN RIB FROM THE STEERING WHEEL AND SEVERE WHIPLASH RESULTING IN A SURGERY THAT LEFT ME IN SERIOUS LIFE LONG PAIN. THE SURGERY CONSISTED OF 12 PINS, 10 SCREWS, 4CADAVOR DISKS AND FUSION OF 5 LEVELS OF MY NECK. MY DRIVERS AIRBAG DID NOT DEPLOY AND I BELIEVE IF IT HAD WORKED PROPERLY I WOULD NOT HAVE BEEN SO SERIOUSLY INJURED. THE VEHICLE HIT ME FROM BEHIND AT A HIGH RATE OF SPEED AS I WAS AT A STOP IN A ON THE HIGHWAY. THE IMPACT FORCED ME INTO THE VEHICLE IN FRONT OF ME BUT THE AIR BAGS DID NOT DEPLOY. THE ESTIMATED SPEED OF THE VEHICLE THAT HIT ME FROM BEHIND WAS BETWEEN 65 AND 75 MPH.

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT AFTER PULLING INTO THE DRIVEWAY AT THE RESIDENCE, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE CONTACT BECAME AWARE THAT THE SPARE TIRE CABLE WAS FRACTURED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE INSPECTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 173,000.

HELLO: MY FORD 150 EXTENDED CAB REAR DOOR DO NOT OPEN. I TOOK IT TO A FORD DEALERSHIP AND THEY TOLD ME THE LATCHES ARE BROKEN. I DID NOT HAVE IT FIXED DUE TO A POSSIBLE RECALL ISSUE. THANK YOU. *TR

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE THE VEHICLE WAS SLOWING DOWN TO STOP, THE ENGINE RPMS WOULD INCREASE, THE GEAR ENGAGED AND THE VEHICLE LUNGED FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE REMEDY DID NOT REPAIR THE FAILURE. THE FAILURE RECURRED AT 11,000 MILES AND THE DEALER STATED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED AGAIN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED HIM TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 37,000 AND THE CURRENT MILEAGE WAS 48,000.

(FORD F150 XLT V-8 / 4.6 LIT.) PARKED IN PARKING SPACE AT WAL-MART CAME OUT OF STORE CRANKED UP MY TRUCK PUT IT INTO REVERSE AND IT WOULD NOT MOVE FORWARD OR BACK UP. THE TRANSMISSION WITHOUT WARNING COMPLETELY BAD NEEDED TO BE REPLACED. NEVER PULLED A TRAILER OR TREATED HARD IN ANYWAY. BOUGHT THE TRUCK NEW AND HAD IT 9 YEARS 49,000 MILES. I HAVE HEARD OF THIS PROBLEM WITH OTHER F-150 OWNERS. FORD NEEDS TO OWN UP TO A DEFECT. *TR

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT AFTER PULLING INTO THE DRIVEWAY AT THE RESIDENCE, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE CONTACT BECAME AWARE THAT THE SPARE TIRE CABLE WAS FRACTURED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE INSPECTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 173,000.

WHILE DRIVING ON THE FREEWAY HERE IN SAN DIEGO, CA. ON DEC. 31, 2018 AT 11:15 AM, AT 65 MPH I NOTICED A CAR IN FRONT OF ME SWERVE AND BEFORE A COULD DODGE THE OBJECT I HIT IT WITH MY LEFT FRONT TIRE. A DELFINITY, DAKOTA, A/T 2, LT265/75 R16. WITH ONLY 28,880 MILES ON THEM. WAS NOT LONG BEFORE MY STEERING BECAME WOBBLY. AFTER MANAGING TO GET OVER TO THE RIGHT SIDE OF THE SHOULDER OF THE ROAD IN HEAVY TRAFFIC I OBSERVED MY TIRE WAS FLAT AND DESTROYED BEYOND REPAIR. AFTER REPLACING IT WITH THE SPARE IN THE RAIN. I RETURNED HOME TO CHECK FOR ANY DAMAGE TO MY TRUCK, BUT FOUND NONE. AFTER A CALL THE THE PEPBOYS STORE WHERE I PURCHASED THEM ON APR. 30, 2013, AS WELL AS THE ROAD HAZARD SERVICE PLAN, I LEARNED THEY DO NOT CARRY THESE TIRES ANY MORE. I WAS OFFERED A DIFFERENT BRAND TIRE AS A REPLACEMENT. CAN YOU IMAGINE DRIVING YOUR PRIDE AND JOY WITH THREE TIRES OF ONE BRAND AND ONE OF A DIFFERENT BRAND. UNACCEPTABLE!! AS OF NOW READING THE OTHER MANY COMPLAINTS ABOUT THESE TIRES I CAN ONLY ACCEPT THEM REPLACING ALL THE TIRES UNDER WARRANTY.

GAS TANK FELL OUT OF VEHICLE,TEARING FILLER HOSE. TANK STRAPS AND SUPPORTING STRUCTURES RUST THRU, FAILURE. DRIVERS' SIDE REAR SHOCK DROPPED FROM VEHICLE BECAUSE METAL BRACKET IT WAS ATTACHED TO ROTTED THRU. BED RAILS COMPLETELY RUSTED THRU. FRAME HAS RUSTED THRU HOLES. COMPLETE RUST FAILURE. VEHICLE HAS ONLY 90K MILES ALWAYS MAINTAINED, WASHED UNDERNEATH WEEKLY IN WINTER. VEHICLE IN MOTION WHEN PARTS FELL ON RTE 58 AND THE SHOCK ON TOWN STREET..$900 TO REPAIR GAS TANK. SHOCK INCIDENT HAPPENED TODAY 11/26/2017, GAS TANK 9/12/2016

THERE HAS BEEN NO INCIDENT AS YET BUT THE FRAME OF THIS VEHICLE HAS SUCH EXTREME CORROSION THAT CERTIFIED MECHANICS ARE RELUCTANT TO WORK ON THIS VEHICLE SINCE THEY ARE CONCERNED ABOUT A FAILURE OCCURRING AT CONNECTION POINT WHERE THE STEERING AND SUSPENSION CONNECTS TO THE FRAME OF THE VEHICLE. THEIR CONCERN IS A LOSS OF CONTROL OF THE VEHICLE IF ANY OF THE STEERING OR SUSPENSION CONNECTION POINTS FAIL DUE TO THE SEVERELY CORRODED FRAME. THIS IS NOT SURFACE CORROSION, THE METAL IS FLAKED AND SEPARATED AND IT IS THE ENTIRE FRAME OF THE VEHICLE. I HAD JUST SPENT $4,000 TO REPLACE THE ENTIRE EXHAUST SYSTEM FROM THE EXHAUST MANIFOLD BACK TO THE TAIL PIPE AND THE MECHANIC IS WARNING ME ABOUT THE SAFETY OF THE SUSPENSION AND STEERING COMPONENTS BECAUSE OF THE EXTREME CORROSION. THE VEHICLE ONLY HAS 77, 000 ORIGINAL MILES AND HAS NEVER BEEN IN SEVERE WEATHER CONDITIONS.

THE TRUCK WAS PARKED IN MY DRIVEWAY FOR AT LEAST 24 HOURS WITHOUT BEING USED OR TURNED ON. THE FRONT OF THE TRUCK SUDDENLY WENT ON FIRE. THE FIRE DEPARTMENT CAME AND PUT IT OUT. THE FIRE BURNED ONLY THE FRONT UP TO THE WINDSHIELD LEAVING THE CAB PARTIALLY MELTED AND MY DAUGHTERS CAR SEAT UNSAFE. NOW THIS MESS SITS IN MY DRIVEWAY AS I WAIT FOR INSPECTOR. AS IT FALLS APART MORE AND MORE EACH DAY AS MY FAMILY AND NEIGHBORS SMELL THE BURNT RUBBLE AND ARE REMINDED OF THAT FRIGHTENING AFTERNOON. *TR

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING, THE STEERING WHEEL ABRUPTLY SEPARATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE STEERING WHEEL WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 180,000.

The contact owns a 2001 Ford F-150. The contact stated that while the vehicle was parked and shut off at the residence, the vehicle caught fire, with flames coming from underneath the hood. No injuries were sustained. The fire department arrived on the scene and extinguished the fire. A fire department report was filed. The vehicle was towed to a body shop and was not yet deemed totaled by the insurance company. The insurance company was made aware of the failure and informed the contact that the failure was related to NHTSA Campaign Number: 11V385000 (Fuel System, Gasoline) associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was approximately 250,0000.

2001 Ford F-150 Consumer writing to inform of a the fire that occurred while stopped in traffic. Description of incident and pictures attached.

I WAS DRIVING TO WORK THIS MORNING AND AROUND 7:00 AM. IT WAS APPROXIMATELY 20 DEGREES OUTSIDE AND I TRIED THE REAR DEFROSTER. THE REAR DEFROSTER HAS WORKED ONLY ABOUT 20% OF THE TIME FOR THE LAST FEW MONTHS AND NOT AT ALL FOR THE LAST 3 WEEKS; SO NEEDLESS TO SAY I WAS VERY SURPRISED WHEN IT ACTUALLY TURNED ON TODAY. 10 MINUTES AFTER TURNING ON THE DEFROST I WAS DRIVING APPROX 30MPH THROUGH TOWN WHEN I HEARD A LOUD BANG INSIDE THE TRUCK. IT WAS LOUD ENOUGH THAT I SWERVED AND LOOKED AROUND TO SEE IF PEOPLE WERE THROWING ICE CHUNKS AT CARS OR SHOOTING BB GUNS. A FEW MINUTES LATER I NOTICED THAT THE REAR WINDSHIELD ON THE DRIVER SIDE OF THE TRUCK HAD COMPLETELY SHATTERED. THE ONLY THING HOLDING THE GLASS TOGETHER IS THE TINT TAPE. THE WINDOW WILL NEED A COMPLETE REPLACEMENT.

THE HEATER CORE LEAKS COOLANT INTO THE INTERIOR COMPARTMENT FOGGING THE WINDOWS AND PREVENTING USE OF THE HEATER SYSTEM TO DEFOG/DEFROST WINDOW PROVIDING AN UNSAFE DRIVING CONDITION DURING FROSTY OR RAINY DAYS. CORE HAS BEEN REPLACED NOW 4 TIMES USING MANUFACTURER PARTS OR AFTERMARKET PARTS. ALL TECHNICAL BULLETINS HAVE BEEN FOLLOWED TO TRY AND COMPLETE THE REPAIR SUCCESSFULLY. THE FIX HAS NOT LASTED. DATE LISTED BELOW FOR WHEN OCCURRED IS DATE OF LAST OCCURANCE.

The contact owns a 2001 Ford F-150. The contact stated that the rear doors failed to open due to a fractured cable. The contact added WD-40 to the doors. The contact stated that the battery was draining while the door was opened. The contact stated that the resonator connecting the engine and muffler was rusted. The contact added putty to the area. Additionally, the check engine warning light was illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 145,000.

HELLO: MY FORD 150 EXTENDED CAB REAR DOOR DO NOT OPEN. I TOOK IT TO A FORD DEALERSHIP AND THEY TOLD ME THE LATCHES ARE BROKEN. I DID NOT HAVE IT FIXED DUE TO A POSSIBLE RECALL ISSUE. THANK YOU. *TR

n/a

The car will randomly go forward while shifted in reverse I smashed into my boat trying to back up and when foward

WE PURCHASED OUR 2001 F150 SUPERCREW USED. I AM A MECHANIC, SO THE FIRST THING I DO WHEN BUYING A USED VEHICLE IS INSPECT IT THOROUGHLY. THERE WERE A FEW MINOR ISSUES, BUT ONE STOOD OUT AS A MAJOR SAFETY HAZARD. UPON FURTHER RESEARCH, IT SEEMS TO BE EXTREMELY COMMON TO ALL 1997-2003 F-150S. SYMPTOMS - THIS ISSUE MAINLY AFFECTS THE REAR LEFT AND RIGHT BRAKE LIGHTS, TURN SIGNALS, AND HAZARD LIGHTS. THESE LIGHTS, PARTICULARLY BRAKE LIGHTS, CAN CEASE TO FUNCTION ENTIRELY, INTERMITTENTLY AND UNKNOWN TO THE DRIVER. CAUSE - THERE IS A WIRE HARNESS WHICH CONNECTS TO THE "MULTI - FUNCTION SWITCH". THIS WIRE HARNESS IS PULLED WHEN THE STEERING WHEEL IS TILTED DOWN. AS A RESULT, THE CONNECTOR OR INDIVIDUAL TERMINALS CAN BECOME LOOSE OR DISCONNECTED. THIS PROBLEM IS MOST PREVALENT WITH THE STEERING WHEEL IN THE DOWN POSITION, BUT ONCE LOOSE CAN HAPPEN AT ANY POSITION AND ANY DRIVING SITUATION. SOLUTION - REPAIR OR REPLACE WITH MOTORCRAFT PART# WPT607, AND ENSURE THE HARNESS HAS ENOUGH SLACK TO ALLOW STEERING WHEEL TILT WITHOUT TENSION ON THE HARNESS. IN OUR CASE, I REPLACED THE CONNECTOR AND PULLED THE WIRES ENOUGH TO ALLOW SLACK FOR STEERING WHEEL TILT. THERE ARE NUMEROUS REPORTS OF THIS ISSUE ONLINE, AND IT IS WELL DOCUMENTED BY F150 OWNERS. I HAVE PICTURES BUT THE FILE SIZES ARE OVER 5MB.

TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING APPROXIMATELY 70 MPH, THE LOW BEAM HEADLIGHTS WENT OUT AND THEN ILLUMINATED AGAIN AFTER A FEW SECONDS. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE SAME FAILURE OCCURRED TWICE PREVIOUSLY. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

CONSUMER COMPLAINED ABOUT LOSS OF FREON DUE TO AN ERUPTED HOSE ROUTED AROUND THE OUTSIDE OF THE RF PLASTIC INNER WHEEL FENDER. THE DEALER WAS NOTIFIED. *AK THE VEHICLE'S WARRANTY HAD EXPIRED TWO MONTHS PRIOR TO THIS FAILURE, THEREFORE THE REPAIR WAS NOT COVERED. *NM

CONSUMER STATES THAT THERE ARE FUMES COMING FROM THE A/C MAKING THE CONSUMER SICK. CAUSE UNKNOWN. DEALER NOTIFIED.*JB