2002 Ford F-150 Driver assistance Problems

Systems failed. Recalls incomplete

NHTSA ID

11556537

Incident

Nov 1, 2023

The contact owns a 2002 Ford F-150. The contact stated that while driving approximately 45 MPH and attempting to pass a slower vehicle, the vehicle experienced unintended acceleration. The contact stated that while depressing the accelerator pedal, the pedal suddenly extended to the floorboard causing the vehicle to immediately accelerate faster than intended. During the failure the speed increased to over 75 MPH before the contact shifted the transmission into neutral and the vehicle decelerated. The contact stated that the vehicle had experienced the failure on two other occasions and the cruise control feature was never activated during the failure. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 94,000.

NHTSA ID

11539704

Incident

Aug 19, 2023

Mileage

94,000 mi

I went to get a state inspection and a code came up Po174

NHTSA ID

11425809

Incident

Jul 21, 2021

I AM TRYING TO FIND OUT IF THIS TRUCK HAS A RECALL THAT WAS NOT TAKEN CARE OF WITH PREVIOUS OWNER BASED ON REVIEWS.. - THERE APPEARS TO BE IDLE ISSUES.. ENGINE LIGHT INDICATES SENSOR ISSUE. *TR

NHTSA ID

11337092

Incident

Jun 29, 2020

Mileage

190,000 mi

I WAS DRIVING AND THE SPEED WOULD GO UP TO 90 MPH, THE TRUCK WAS NOT GOING THE SPEED IN REALITY. THEN THE RPM'S WOULD GO UP REALLY HIGH, I STOPPED THE TRUCK PUT IT IN PARK AND BACK IN DRIVE TRIED TO DRIVE OFF. THE TRUCK THEN WOULD NOT GO OVER 30 MPH AND THE GAS PEDDLE WAS ALL THE WAY DOWN TRYING TO GO, THE ENGINE STARTED SMOKING AND WHEN I PULLED OVER OPENED THE HOOD IT WAS SMOKING FROM THE DRIVER SIDE UPPER CORNER OF THE TRUCK. AFTER HAVING A MECHANIC LOOK AT IT, HE SAID THE BREAK PRESSURE SWITCH NEEDED TO BE REPLACED BECAUSE IT'S A HOT WIRE AND IT'S LEAKING. AFTER CHECKING THE FORD VIN CHECK IT DIDN'T SAY MY TRUCK WAS APART OF THE RECALL BUT THEY YEAR AND MAKE AND MODEL IS. I'M CONFUSED AND AT THIS POINT DON'T WANT TO PUT MY CHILDREN IN A FIRE BALL LIKE THAT IF IT CATCHES ON FIRE...

NHTSA ID

11270184

Incident

Oct 19, 2019

Mileage

238,500 mi

THIS IS FOLLOW UP ASSESSMENT TO MY 9/22/2019 CLAIM [XXX]- WHERE I FOUND MYSELF IN A VERY DANGEROUS VEHICLE RUN AWAY SITUATION THAT RESULTED IN A REAR END ACCIDENT WITH ANOTHER VEHICLE. MY MECHANIC'S FIRST OBSERVATION WHEN TURN IGNITION KEY, THE ENGINE RACED AT FULL THROTTLE OUT OF CONTROL. AFTER QUICKLY SHUTTING DOWN ENGINE THE SYMPTOMS LEAD MY MECHANIC TO TEST THE IDLE AIR CONTROL VALVE. HAVING NEVER SEEN THIS DANGEROUS SYMPTOM FROM A BAD IACV, HE CONTINUED TO DO FURTHER TEST ON THE IACV ONLY TO DETERMINE THE PART WAS INDEED DEFECTIVE. AFTER DIAGNOSING THE PROBLEM, THE DEFECTIVE IACV PART WAS QUICKLY REPLACED. THE ENGINE IS NOW RUNNING GOOD AGAIN. IF YOU NEED TO CONTACT MY MECHANIC: DUGAN AUTO SERVICE, NARVON PA - DOUG MILLER 464-798-8097 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

NHTSA ID

11257521

Incident

Sep 22, 2019

Mileage

139,400 mi

CAR WAS ON THE HIGHWAY DOING 65 MPH. WHEN I TOOK MY FOOT OFF THE ACCELERATOR, THE CAR CONTINUED TO ACCELERATE ON ITS OWN. WHEN I APPLIED THE BRAKES I WAS ABLE TO SLOW IT DOWN AND CONTROL THE CAR. WHEN I GOT OFF THE EXIT RAMP AND TRIED TO BRING THE CAR TO A STOP, THE ENGINE WAS RUNNING AT HIGH RPMS AND I COULDN'T COMPLETELY STOP CAR UNTIL I REAR ENDED ANOTHER VEHICLE. I'VE TRIED TO START THE CAR AFTER THAT, BUT THE ENGINE IMMEDIATELY STARTS RACING AS IF I HAVE MY FOOT PRESSED ON ALL THE WAY DOWN ON THE GAS.

NHTSA ID

11257244

Incident

Sep 22, 2019

Mileage

139,400 mi

TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING 55 MPH, THE CRUISE CONTROL FAILED TO OPERATE AND THE CROSS CONTROL WENT INTO A LOCKED POSITION. THE CONTACT ATTEMPTED TO BRAKE, BUT THE VEHICLE WOULD NOT STOP. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND WAS ABLE TO SLOW DOWN THE VEHICLE. WHEN THE VEHICLE FINALLY STOPPED, THE CONTACT DISCONNECTED THE CRUISE CONTROL CABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 222,112.

NHTSA ID

11229579

Incident

Jul 4, 2019

Mileage

222,112 mi

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT AN EXPLOSION OCCURRED UNDER THE HOOD AND THE VEHICLE CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE VEHICLE ONLY HAD LIABILITY COVERAGE; THEREFORE, THE FAILURE WAS NOT COVERED BY THE INSURANCE COMPANY. THE VEHICLE WAS TAKEN TO METRO FORD INC (2860 S NOLAND RD, INDEPENDENCE, MO 64055, (816) 254-9800), BUT THEY COULD NOT ASSIST. THE DEALER SUGGESTED HAVING AN INDEPENDENT MECHANIC DIAGNOSE THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL), WHICH COULD HAVE CAUSED THE FIRE. THE FAILURE MILEAGE WAS 204,000. *BF *TR

NHTSA ID

11194582

Incident

Mar 31, 2019

Mileage

204,000 mi

TL* THE CONTACT OWNED A 2002 FORD F-150. WHILE THE VEHICLE WAS PARKED IN FRONT OF THE CONTACT'S HOUSE, IT CAUGHT FIRE WITHOUT WARNING. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE FIRE WAS NOT HEAT RELATED. THE VEHICLE WAS TOTALED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

11165695

Incident

Dec 31, 2018

Mileage

150,000 mi

TL* THE CONTACT'S FATHER OWNED A 2002 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED UNINTENDED ACCELERATION WITHOUT WARNING. WHILE IN A PARKING LOT, THE VEHICLE ACCELERATED AND SPUN OUT OF CONTROL. THE DRIVER STRUCK A CURB TO AVOID CRASHING INTO OTHER VEHICLES IN THE PARKING LOT. AS A RESULT, THE VEHICLE WENT AIRBORNE AND STRUCK A TELEPHONE POLE, BUT CONTINUED TO ACCELERATE AT A HIGH RATE OF SPEED UPON TOUCHING THE GROUND. THE VEHICLE THEN DROVE OVER ANOTHER CURB AND CRASHED INTO SOME BUSHES. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE DRIVER SUSTAINED INJURIES THAT REQUIRED MEDICAL TREATMENT. THE VEHICLE WAS TOWED AND PLACED IN STORAGE. THE CONTACT'S FATHER NO LONGER OWNS THE VEHICLE BECAUSE HE IS DECEASED DUE TO UNRELATED CIRCUMSTANCES. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED LATER OF THE CRASH. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT UPDATED 9/19/18*JB

NHTSA ID

11090071

Incident

Sep 19, 2014

THE RECALL IE AN INLINE FUSE ON SPEED CONTROL DEACTIVATION SWITCH DID NOT WORK IT JUST CAUGHT ON FIRE AND RUINED MY MASTER CYLINDER AND BRAKE SYSTEM.IT WONT HOLD BRAKE FLUID NOW BECAUSE THE SWITCH MELTED INTO IT.FORD SAYS OH WELL RECALLS BEEN DONE

NHTSA ID

11076795

Incident

Feb 28, 2018

Mileage

141,000 mi

TWO ISSUES: 1] BOTH REAR DOORS IN THE EXTENDED CAB (SWING COUNTERCLOCKWISE) DOOR LATCHES JAMMED PREVENTING EXITING OR ENTRY. IF EGRESS WAS NEEDED QUICKLY, IT WAS NOT THERE. THE COST TO REPAIR EACH WAS ABOUT $450. (LOCKED UP WHILE DRIVING) 2]SPEED CONTROL DOES NOT WORK - FORD SAYS IT IS A MALFUNCTIONING CONTROL THAT COST ABOUT $500 TO REPLACE. (WHEN VEHICLE IS IN OPERATION)

NHTSA ID

11047739

Incident

May 7, 2015

Mileage

68,000 mi

GOT HOME FROM WORK PARKED MY VEHICLE IN MY CARPORT AVAILABLE SPACE IN MY APARTMENT. TURN OFF THE TRUCK COMPLETELY, NOTHING LEFT ON OR ANYTHING SUSPICIOUS TO CAUSE A INCIDENT. WHEN TO MY APARTMENT UNIT TOOK A SHOWER AND NOT MORE THAN 20-30MINS WAS ALARMED THAT MY VEHICLE WAS CAUGHT ON FIRE. I IMMEDIATELY RAN OUTSIDE TO THE CARPORT SAW THE ENGINE ON FIRE, TRIED TO STOP IT WITH ANYTHING THAT I COULD FIND (WATER HOLES) OR EXTINGUISHER. MY NEIGHBORS CALLED 911 AS I SAW THE FLAMES GETTING HIGHER AND STRONGER THE FIRE MOVED INTO MY DAUGHTERS VEHICLE WHICH WAS PARKED NEXT TO OUR OTHER CARPORT SPACE AND CAUGHT ON FIRE AS WELL. OVERALL, THERE ARE TWO VEHICLES COMPLETELY DESTROYED. THERE WAS ALSO TWO OTHER VEHICLES INVOLVED THAT HAVE SOME BURNING DAMAGES. AS WELL AS PROPERTY DAMAGES INTO OUR AVAILABLE PARKING SPACES. SOME WINDOWS FROM THE LOWER APARTMENTS WERE CRACKED. MY VEHICLE WAS PARKED INTO MY PARKING PORT, NOT IN MOTION BUT TURNED OFF COMPLETELY.

NHTSA ID

11046072

Incident

Aug 8, 2017

Mileage

190,000 mi

SEED CONTRAL.

NHTSA ID

10955506

Incident

Jun 7, 2016

IN 12-14 AND 1-10-2016 THE BUTTERFLY IN THE THROTTLE BODY STUCK AND VEHICLE WOULDN'T SLOW DOWN. 1ST INCIDENT -10F, CAME FROM WARM GARAGE, INTERSTATE, CRUISE CONTROL IN USE, IN ABOUT 15 MINUTES OF DRIVING EVENTUALLY SPEED GOT TO 85MPH ON ITS OWN, CRUISE SHUT OFF AND VEHICLE MAINTAINED 85 MPH, ONCE STOPPED THROTTLE AND CRUISE CABLE WERE CHECKED AND FREE, BUTTERFLY WAS STUCK PARTIALLY OPEN WHEN MANUALLY MOVED AND BROKE FREE, PROBLEM WENT AWAY; 2ND DATE -5F CAME FROM WARM GARAGE, INTERSTATE, CRUISE ON, 20 MINUTES INTO TRIP, SIMILAR RESULTS, WEATHER CLEAR LOW HUMIDITY, VEHICLE WOULD NOT SLOW DOWN, CRUISE SHUT OFF, NO-LOAD ENGINE SPEED OVER 5000 RPM, VEHICLE SPEED 65MPH ON LEVEL WITH NO THROTTLE INPUT, CABLES WHEN CHECKED WERE FREE, BRAKES WOULD BARELY SLOW VEHICLE, ENGINE OPERATED NORMALLY ONCE BUTTERFLY WAS BROKE FREE BUT PROBLEM REOCCURRED ABOUT 30 MINUTES LATER. FORD F150 XLT 4.6L AUTOMATIC SUPERCREW, NO PROBLEM NOTED WHEN WEATHER IS WARMER

NHTSA ID

10819184

Incident

Jan 10, 2016

Mileage

170,000 mi

THERE WAS A RECALL FOR THE CRUSE CONTROL, IT WAS REPLACED BY FORD, BECAUSE IT COULD CAUSE A FIRE, THE NEW ONE WORKED FOR ABOUT A YEAR AND STOP WORKING, NEVER WORK AFTER THAT. 2ND ITEM IS REAR WINDOW AND DRIVERS PASSANGER WINDOW LEAK RAIN WATER INSIDE THE CAB, LEAKS EVERYTIME IT RAINS IN MOTION OR STATIONARY.

NHTSA ID

10787156

Incident

Feb 7, 2013

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING AT 65 MPH, THE ACCELERATOR PEDAL BECAME STUCK AND THE BRAKES BECAME INOPERABLE. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. ...UPDATED 07-08-15 *BF

NHTSA ID

10722874

Incident

May 29, 2015

Mileage

140,000 mi

I WAS DRIVING TO THE OFFICE, AND APPROACHED A RED LIGHT SO I STARTED SLOWING DOWN. ONCE I REACHED 15 MPH MY 2002 4.2 L F150 ACCELERATED EXTREMELY HIGH. I WAS APPLYING THE BRAKE BUT THE TRUCK WAS STILL SLOWLY MOVING, SO WITH MY FOOT STILL ON THE BRAKE I TURNED INTO THE OFFICE PARKING LOT. I TRIED TO PUT IT IN PARK BUT IT WAS A STRUGGLE, I CALLED MY DAUGHTER OUTSIDE WHEN I WAS IN THE OFFICE PARKING LOT, AND SHE TOLD ME THE REAR TIRES WERE SPINNING. WHEN I FINALLY GOT IT IN PARK I TURNED THE TRUCK OFF. I GAVE IT APPROXIMATELY ONE MINUTE AND TURNED THE TRUCK BACK ON, AND IT WAS STILL ACCELERATING EXTREMELY HIGH SO I TURNED THE TRUCK BACK OFF SO IT WOULDN'T DAMAGE MY ENGINE. AFTER AN HOUR I TURNED THE TRUCK BACK ON, AND THE TRUCK WAS BACK TO NORMAL. AFTER DOING A BIT OF RESEARCH I SAW TONS OF ARTICLES WITH INSTANCES SIMILAR TO MINE, SO I DISCONNECTED THE CRUISE CONTROL SWITCH AND TOOK IT TO THE NEAREST SHOP. *TR

NHTSA ID

10714541

Incident

May 4, 2015

Mileage

702,000 mi

I PARKED THE VEHICLE AND 20 MINUTES LATER DISCOVERED THE VEHICLE ON FIRE. FURTHER INVESTIGATION REVEALED THAT MASTER CYLINDER WAS TOTALLY ENGULFED IN FLAME. THE FIRE DAMAGED THE WIRE HARNESS, AIR FILTER, FUSE BOX AND COMPLETELY MELTED THE CYLINDER. *TR

NHTSA ID

10638832

Incident

Sep 23, 2014

ON MARCH 22, 2014, THE TRUCK WAS PARKED IN A LOCAL PARKING LOT, THE IGNITION KEY WAS REMOVED AND THE TRUCK WAS LOCKED. THE DRIVER RETURNED TO THE TRUCK TO FIND THAT WHILE IT WAS PARKED, A FIRE HAD BEGUN IN THE ENGINE COMPARTMENT OF THE TRUCK, AND THE FIRE DEPARTMENT AND POLICE DEPARTMENT WERE ON THE SCENE PUTTING OUT THE FIRE. BECAUSE OF THE QUICK ACTIONS OF AN INDIVIDUAL PARKED NEARBY WHO USED A FIRE HOSE TO CONTAIN THE FIRE UNTIL THE FIRE DEPARTMENT ARRIVED, THE CABIN AND THE BODY OF THE TRUCK WERE SPARED, AND THE DAMAGE WAS LOCALIZED TO THE ENGINE COMPARTMENT. THE CAUSE OF THE FIRE WAS THE SPEED CONTROL DEACTIVATION SWITCH.

NHTSA ID

10626614

Incident

Mar 22, 2014

Mileage

204,000 mi

WHILE DRIVING ON THE HIGHWAY, I PUSHED THE ON BUTTON FOR THE CRUISE CONTROL AND PUSHED THE SET/EXCEL BUTTON AT 70 MPH. AFTER A MINUTE OR SO I LOOKED DOWN AND WAS GOING 75 AND ACCELERATING. I TAPPED THE BREAK WHICH HAD NO EFFECT. I TAPPED THE BREAK SEVERAL MORE TIME BUT THE TRUCK KEPT ACCELERATING. I PUSHED THE OFF BUTTON SEVERAL TIMES WHILE CONTINUING TO PUMP THE BREAK. THE CRUISE CONTROL FINALLY WENT OFF. SEVERAL MILES DOWN THE ROAD I TRIED TO USE THE CRUISE CONTROL AGAIN WITH THE SAME RESULTS. MY TRUCK IS A 4.2L V6 AND HAS HAD THE RECALL TAKEN CARE OF SEVERAL YEARS AGO. THIS APPEARS TO HAVE HAPPENED TO SEVERAL OTHER PEOPLE AND COULD HAVE HAD A DISASTROUS OUTCOME. *TR

NHTSA ID

10626514

Incident

Aug 16, 2014

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE BURST INTO FLAMES AFTER THE ALARM SOUNDED. THE CONTACT PERSONALLY EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER 05V388000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 138,000.

NHTSA ID

10583166

Incident

Apr 16, 2014

TL* THE CONTACT OWNS A 2002 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED AND NOT OPERATING WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. THE CONTACT INDICATED THAT THE VEHICLE WAS DESTROYED AND ONLY THE BED OF VEHICLE REMAINED. NO ADDITIONAL INFORMATION WAS AVAILABLE REGARDING THE INCIDENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10573475

Incident

Nov 8, 2013

Mileage

150,000 mi

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 60 MPH, HE ATTEMPTED TO INCREASE SPEED VIA THE CRUISE CONTROL STEERING WHEEL CONTROLS. AFTER REACHING THE TARGET SPEED, THE VEHICLE CONTINUED TO ACCELERATE AND THE CRUISE CONTROL FAILED TO DEACTIVATE. THE CONTACT SHUT OFF THE VEHICLE TO REGAIN CONTROL. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 72,899.

NHTSA ID

10537268

Incident

Aug 24, 2013

Mileage

72,899 mi