Owner-reported complaints naming the interior system, filed with NHTSA
Data refreshed
Reports naming seats, latches, locks, linkages and interior fittings. Every record below is an owner-reported complaint about the 2005 Ford F-150 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 12 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
THE TRUCK WAS NOT RUNNING. WHEN THE DOOR WAS OPENED THE FLAMES , FROM THE BURNING SEAT SHOT UP AND BURNT THE CARPET AND DOOR PANEL , BEFORE IT COULD BE PUT OUT. THE CONTROLS ON THE SEAT WERE COMPLETELY MELTED. IT STILL HAS A SMELL OF AN ELECTRICAL FIRE. *TT
LIGHT BULB ATTACHED TO TRANSMISSION PLACEMENT WINDOW IN CONSOLE, DETACHES AND BURNS OTHER WIRES AND WHAT EVER ELSE IT CAN INSIDE CONSOLE, THEN BURNS THROUGH SIDE OF CONSOLE RELEASING SMOKE INTO CAB OF VEHICLE ,IN THE END YOU HAVE AN EXTRA LIGHT STICKING OUT THE SIDE OF THE CONSOLE BETWEEN THE DRIVERS SEAT. *TR
PASSENGER WINDOW IN MY 2005 FORD F-150 FELL INSIDE THE DOOR CREATING A LOUD BANG WHILE DRIVING. CAUSED ME TO JUMP AND PULL STEERING WHEEL TO ONE SIDE NEARLY CAUSING AN ACCIDENT. INVESTIGATION LED TO A BROKEN PLASTIC CLIP IN THE DOOR THAT RELEASED THE CABLE THAT HOLDS THE WINDOW IN THE UP (OR DOWN POSITION). I HAVE SEEN NUMEROUS COMPLAINTS ABOUT THIS EVENT. FORD HAS NOT RECALLED THE PROBLEM AS OF THIS DATE. *TR
EASY ACCESS INTO FORD TRUCKS HAVING PLASTIC DOOR HANDLES AND BACK PLATES. WHILE THE BREAK IN IS NOT A DIRECT SAFETY ISSUE, IT COULD POTENTIALLY BE. IT TAKES UP VALUABLE POLICE RESOURCES INVESTIGATING THESE CRIMES, WHICH MAY BE NEEDED ELSEWHERE. THE THIEF HAS THE POTENTIAL TO REMOVE INSURANCE CARDS, REGISTRATIONS, ETC. CONTAINING PERSONAL INFORMATION THAT ARE GENERALLY STORED IN GLOVE BOXES. THERE SHOULD BE A REASONABLE AMOUNT OF SECURITY THAT ONE CAN EXPECT WHILE IN OR AWAY FROM A VEHICLE. THE DOOR HANDLE AND BACK PLATE DESIGN ARE FAULTY AND ALLOW FOR EASY, RAPID ENTRY INTO THE VEHICLE. *TR
I HAVE A 2005 F150 AND THE DOME LIGHT COMES ON BY ITSELF. I HAVE TO CUT THE DASHLIGHT DIMMER ALL THE WAY OFF FOR IT TO STAY OFF. I CAN BUMP THE DASH AND IT GOES OUT, BUT COMES BACK ON. WITH THIS I DO NOT HAVE ANY DASH LIGHTS AT NIGHT. IT HAS BEEN IN THE SHOP TWICE FOR THIS AND NOT BEEN FIXED. I BOUGHT EXTENDED WARRANTY FOR THESE TYPE THINGS AND PAID A $100 DEDUCTIBLE. IT IS VERY DANGEROUS TO DRIVE AT NIGHT WITHOUT DASH LIGHTS. ANY SUGGESTIONS? *TR
TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED HIS VEHICLE CAUGHT FIRE. THE LIGHT BULB IN THE CONSOLE WHERE THE SHIFT LEVER IS LOCATED FELL OUT ON THE INSIDE AND BURNED A HOLE THROUGH THE SIDE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED AND THE BULB WAS REPLACED. CONTACT DID NOT KNOW HIS VIN NUMBER. THE FAILURE MILEAGE WAS 53,000. BL
DRIVING AROUND WITH WINDOWS DOWN IN MY 2005 FORD F-150 SUPERCREW WHEN I TRIED TO ROLL UP THE FRONT PASSENGER WINDOW I HEARD AN EXTREMELY LOUD BANG THAT MADE ME THINK THAT I HAD BEEN HIT BY ANOTHER VEHICLE. TOOK THE DOOR PANEL APART AND FOUND THE POWER WINDOW REGULATOR CABLE WAS MANGLED AND IT HAD BROKEN FREE FROM ONE OF THE WINDOW SLIDES. WHEN I TRIED TO FIND THE PARTS ONLINE I CAME ACROSS A FORUM ON COMPLAINTS.COM. APPARENTLY HUNDREDS OF PEOPLE ARE HAVING THE SAME PROBLEM, WITH THE SAME LOUD POP OR BANG WHICH IS VERY STARTLING AND COULD POTENTIALLY CAUSE AN ACCIDENT. SEVERAL OF THE PEOPLE WROTE THAT THEY HAVE HAD THIS SAME PROBLEM WITH MORE THAN ONE DOOR AND EVEN SEVERAL TIMES WITH EACH DOOR. LOCAL FORD DEALERSHIP TOLD ME IT IS BECAUSE OF THE HEAT IN LAS VEGAS AND THEY KEEP LOTS OF THEM IN STOCK BECAUSE IT IS A VERY COMMON FAILURE. I THINK IT IS MORE THAN THE HEAT THOUGH BECAUSE PEOPLE ALL OVER THE COUNTRY ARE REPORTING THE SAME PROBLEM. *TR
WINDOW CONTROLLER FAILS WITH A LOUD BANGING NOISE. THE NOISE IS SO DISTRACTING THAT IT CAUSES A POSSIBLE ACCIDENT SITUATION. I WAS PULLING A TRAILER AT THE TIME AND THE SWERVING CAUSED FISH TAILING. THERE ARE THOUSANDS OF DOCUMENTED FAILURES OF THE FORD WINDOW CONTROLLER IN 2005 VEHICLES AND FORD WON'T RECALL WITHOUT NHTSA REQUIRING IT. *TR
NORMAL USE OF MY 2005 FORD F-150 IN THE PAST TWO YEARS HAS LEAD TO A FEW ITEM I BELIEVE CAN BE A SAFETY ISSUE. THE LATEST IS THE DRIVERS SEAT BREAKING ITS LOWER FRAME AND SEAT PAD TRAY. FORD HAS YET TO FIX THIS ISSUE AS THEY CLAIM PARTS ARE NOT AVAILABLE AT THIS TIME. THE SEAT IS "ROCKING" DURING NORMAL DRIVING AND IS A CONCERN OF MINE IF IT SHOULD TOTALLY FAIL WHILE THE VEHICLE IS IN USE LEADING TO A CRASH. IT IS ALSO AT A SLIGHT TILT CAUSING ME TO SIT IN A VERY UNCOMFORTABLE POSITION. IT HAS BEEN A MONTH SINCE I TOOK THE TRUCK IN TO HAVE IT REPAIRED, BUT THE PARTS ARE STILL ON ORDER TO FIX IT. THIS IS A UN-REASONABLE AMOUNT OF TIME TO HAVE TO WAIT. ALSO 3 OUT OF THE FIVE WINDOWS OF MY TRUCK HAVE BROKEN, THIS RESULTS IN THE WINDOW REGULATOR BREAKING CAUSING THE WINDOW TO DROP TO THE BOTTOM OF THE DOOR. THIS LEAVES ME AND MY VEHICLE OPEN TO THE WEATHER AND/OR BEING UNSECURED IF DRIVING IN A LESS THAN SAFE AREA. THE WINDOWS HAVE BEEN FIXED IN THE SAME DAY WITHOUT HAVING TO WAIT FOR PARTS AS THE DEALER HAS STATED "WE KEEP THE PARTS AVAILABLE AS IT IS A KNOWN PROBLEM". BUT THEY CAN NOT FIX THE OTHER TWO UNTIL THEY BREAK AS FORD WILL NOT ALLOW THEM TO UNLESS THEY BREAK. AS THIS IS A KNOWN PROBLEM IT SEEMS TO ME THE ISSUE SHOULD BE FIXED BEFORE ANY OTHER WINDOWS FAIL. *NM
DT*: THE CONTACT STATED THE VEHICLE'S FACTORY KEY WAS DEFECTIVE AND DOES NOT START THE VEHICLE. THE VEHICLE INCLUDED 3 KEYS; 2 GOOD AND 1 DEFECTIVE. ANY TIME A GOOD KEY WAS USED TO LOCK THE DOOR, THE DEFECTIVE KEY DOES NOT WORK AT ALL WHEN ATTEMPTING TO START THE VEHICLE. THE DEFECTIVE KEY WORKED IF IT USED TO LOCK THE DOOR BEFORE STARTING UP. THE VEHICLE WAS TAKEN TO A DEALER, WHO PROGRAMMED ANOTHER KEY, BUT THE PROBLEM PERSISTED. THE VEHICLE WAS BROUGHT BACK TO THE DEALER WHO EXPRESSED THAT ANOTHER KEY COULD NOT BE REPROGRAMMED BECAUSE OF THE WAY THE VEHICLE WAS MANUFACTURED. THE MANUFACTURER WAS CONTACTED THREE TIMES AND SUGGESTED THAT THE VEHICLE BE TAKEN TO ANOTHER DEALER. THE OTHER DEALER COULD NOT DUPLICATE THE PROBLEM, AND OFFERED NO RESOLUTION.
MY PAINT JOB WAS DEFECTIVE AND THIN, MY WINDSHIELD WAS NOT SEALED PROPERLY, THERE ARE TICKING NOISES FROM UNDER THE DASHBOARD, THE FRONT END IS TOO HEAVY FOR THE ADDED WEIGHT TO THE TRUCK, THE TRANSMISSION STALLS THE TRUCK WHEN IT ROLLS BACKWARDS IN DRIVE, THE TRUCK SHAKES AT HIGH SPEEDS AND HAS EXCESSIVE TIRE WEAR, WHICH IS THE ONLY THING THAT FORD HAS ALL BUT ADMITTED TO BY EXTENDING THE EXCESSIVE TIRE WEAR/RIDE HARSHNESS WARRANTY FROM 1YR/12,000 MILES TO 3YRS/36,000 MILES. HAVE YOU EVER HEARD OF A CAR COMPANY GIVING AWAY SOMETHING UNLESS THERE WAS A SERIOUS PROBLEM WITH THIS VEHICLE. *NM
ON JUNE 4, 2005 AT ABOUT 6:30 PM I HAD LOADED UP SOME SCRAP ALUMINUM (FROM A SMALL SHED WE HAD TOOK APART) INTO THE BED OF MY TRUCK. AFTER FINISHING LOADING THE SCRAPS, I WENT TO SHUT THE TAILGATE WHICH STRUCK A THIN 1- 1 1/2 INCH WIDE PIECE OF SCRAP HANGING OFF THE END OF THE BED PART OF THE TRUCK ABOUT 1-2 INCHES AND THE TAILGATE CAME OFF IT'S HINGES FALLING ONTO MY RIGHT KNEE. I HAVE HAD TO GO TO THE ER 2 TIMES THIS WEEKEND. SATURDAY NIGHT I HAD X-RAYS THAT HAVE SHOWN THAT THE IMPACT OF THE TAILGATE FALLING ON MY KNEE FRACTURED MY KNEE CAP, I HAVE A TOMATO HEMATOMA IN MY KNEE, AND TORE A LIGAMENT IN MY KNEE. SUNDAY JUNE 5TH I HAD TO HAVE THE FLUID DRAINED OFF MY KNEE. TODAY (MONDAY JUNE 6) I WENT TO SEE MY DOCTOR AND WAS GIVEN A DATE TO HAVE AN MRI DONE FOR THIS COMING THURSDAY AND ALSO SET UP AN APPOINTMENT TO SEE AN ORTHOPEDIC DOCTOR.THIS WAS A BAD EXPERIENCE, BUT IT COULD HAVE BEEN ALOT WORSE IF IT HAD INVOLVED A CHILD BECAUSE THOSE TAILGATES ARE VERY HEAVY AND CAN CAUSE SOME SERIOUS DAMAGE. I TOOK MY TRUCK INTO THE DEALERSHIP TODAY TO HAVE THEM MAKE SURE THE HINGES ARE NOT FLAWED OR THE HINGES ARE IN PROPER WORKING ORDER AND THIS IS A DESIGN FLAW. THE DEALERSHIP I PURCHASED THIS VEHICLE WAS NORTH POINT FORD IN NORTH LITTLE ROCK AR. THE PHONE NUMBER TO THIS DEALERSHIP IS 501-945-1200.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .