Owner-reported complaints naming the visibility system, filed with NHTSA
Data refreshed
Reports naming windshields, glass, wipers, defrosters and mirrors. Every record below is an owner-reported complaint about the 2005 Ford F-150 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 268 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 268, in the owner's own words
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 35 MPH, THE FRONT DRIVER'S SIDE WINDOW LOWERED WITHOUT WARNING. THE CONTACT ATTEMPTED TO ROLL THE WINDOW UP, BUT IT FAILED TO CLOSE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.
REAR PASSENGER SIDE WINDOW REGULATOR BROKE FOR SECOND TIME ALLOWING WINDOW TO FALL AND SHATTER INSIDE DOOR WHILE DRIVING IN TRAFFIC ON INTERSTATE. VERY DANGEROUS, VERY EXPENSIVE.
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 65 MPH, THE SUN ROOF SHATTERED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 141,000.
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 60 MPH, THE SUN ROOF SHATTERED. THE VEHICLE WAS TAKEN TO THE AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 141,740.
THE HOSES FROM THE WINDOW WASHER PUMP TO THE SPRAYERS HAVE DETERIORATED
DRIVER SIDE WINDOW REGULATOR FRAYED. WINDOW INOPERABLE.
I STARTED THE TRUCK AND THEN TURNED ON THE REAR DEFROST, WHICH I RARELY USE. IT WAS ABOUT 55 DEGREES OUTSIDE. AFTER ABOUT 2 MINUTES I HEARD A HISSING NOISE THAT LASTED FOR ABOUT 5 SECONDS AND THEN A HEARD LOUD POP AND THEN THE WINDSHIELD SHATTERED. MANY OTHER ARTICLES ON THE WEB INDICATE THAT THIS IS A KNOWN DEFECT WITH THE REAR DEFROST. I CALLED FORD AND THEY WILL NOT OFFER AND COMPENSATION TO HAVE IT FIXED EVEN THOUGH IT IS A KNOWN ISSUE. MY DAUGHTER WAS IN THE BACK SEAT AND GOT GLASS IN HER HAIR. *TR
THE WINDOW REGULATOR LINKAGE CONTINUALLY BREAK. FIRST INCIDENT WAS THE DRIVER'S SIDE DOOR, AND ON 7/14/14, THE RIGHT REAR DOOR. BY THE NUMBER OF COMPLAINTS ON THE WEB, IT IS OBVIOUS THESE REGULATORS HAVE A MANUFACTURE DEFECT THAT CAUSES PREMATURE FAILURE. THE ONLY WINDOW FALL INTO THE DOOR WHEN THE DEVICE IS OPERATED. *TR
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE WINDOWS DROPPED INSIDE OF THE DOOR PANEL WHILE BEING OPENED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE REGULATORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 114,000. *TR
I HAD JUST ROLLED UP THE WINDOWS ON MY TRUCK, WHEN I HEARD A LOUD POP COME FROM THE PASSENGER DOOR. ABOUT 15 MINUTES LATER THE WINDOW DROPPED DOWN INTO THE DOOR. THIS HAPPENED ABOUT 4 YEARS AGO. THIS IS TWICE IN THE 8 YEARS I HAVE HAD THE TRUCK. NEEDS TO BE A RECALL ON THIS SINCE SEEMS TO BE HAPPENING TO A LOT OF PEOPLE. *TR
WHEN I PULLED OUT OF PARKING LOT AT APPROX. 5 MPH I HEARD A VERY LOUD NOISE IN THE REAR OF THE TRUCK. SOUNDED LIKE SOMETHING HIT MY VEHICLES BACK DOOR. WHEN I LOOKED BACK ALL LOOKED NORMAL. A FEW MINUTES LATER I HEARD AIR BLOWING. LIKE A WINDOW WAS DOWN. REAR WINDOW HAD STARTED TO SLOWLY SLIDE DOWN. MECHANIC INFORMED ME THE WINDOW REGULATOR HAD FAILED. 203.00 JUST FOR THE PART !!!! AND HE SAID MORE WILL BREAK TOO. NICE JOB FORD. *TR
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE FRONT DRIVER'S SIDE WINDOW FELL INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE WINDOW REGULATOR WOULD NEED TO BE REPLACED. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED TWO YEARS PRIOR ON THE FRONT PASSENGER'S SIDE WINDOW. THE VEHICLE HAD BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 40,491.
WHEN DRIVING DOWN THE ROAD A 35 MPH MY DRIVER SIDE WINDOW MADE A LOUD POP SOUND AND THE WINDOW FELL DOWN INTO THE DOOR. I HAD TO BUY A WHOLE NEW WINDOW REGULATOR ASSEMBLY. I HAVE SEEN THIS TO BE A PROBLEM ON THIS SITE AND MANY OTHER ONLINE FORUMS. THERE MUST BE A DEFECT WITH THE REGULATORS. MINE WAS SO BAD THAT THE CABLE ACTUALLY FRAYED AND SNAPPED. THIS IS A SAFETY HAZARD THAT SHOULD BE ADDRESSED. *TR
REAR PASSENGER WINDOW REGULATOR STOPPED WORKING AND WINDOW FELL INTO DOOR. HAD MY WIFE DONE THIS WHILE DRIVING SHE WOULD HAVE BEEN SCARED BY THE LOUD POPPING NOISE AND POTENTIALLY CRASHED INTO OBJECT INJURING HERSELF AND OR OTHERS. THIS IS A COMMON PROBLEM AND FORD NEEDS TO RECALL THE TRUCKS WITH THE PLASTIC PARTS AND FAULTY MECHANISM. SEARCH THE WEB AND THERE ARE HUNDREDS OF VEHICLES WITH THE SAME ISSUE . YEARS 2004-2006. FORD NEEDS TO RECALL! *TR
FRONT PASSENGER WINDOW FELL TO BOTTOM OF DOOR. *TRW
WE HAD JUST LEFT OUR HOUSE AND THE DRIVER SIDE WINDOW FELL DOWN INTO THE DOOR AND WOULD NOT COME BACK UP. I LOOKED ON THE INTERNET AND YOUTUBE TO FIND OUT THIS HAS HAPPENED TO 100'S OF THE F150'S. THIS IS VERY DANGEROUS BECAUSE EVIDENTLY IT CAN HAPPEN TO ANY OF THE WINDOWS ON THE TRUCK. ONE OF MY GRANDCHILDREN COULD HAVE BEEN RIDING WITH US AND POSSIBLE FALL OUT A WINDOW. I UNDERSTAND THERE IS NO RECALL FOR THIS. I EMAILED FORD ABOUT THIS BUT IT STATED THE MIGHT NOT EVEN ACKNOWLEDGE IT. *TR
REAR PASSENGER WINDOW REGULATOR STOPPED WORKING AND WINDOW FELL INTO DOOR. HAD MY DAUGHTER DONE THIS WHILE DRIVING SHE WOULD HAVE BEEN SCARED BY THE LOUD POPPING NOISE AND POTENTIALLY CRASHED INTO OBJECT INJURING HERSELF AND OR OTHERS. THIS IS A COMMON PROBLEM AND FORD NEEDS TO RECALL THE TRUCKS WITH THE PLASTIC PARTS AND FALTY MECHANISM. SEARCH THE WEB AND THERE ARE HUNDREDS OF VEHICLES WITH THE SAME ISSUE . YEARS 2004-2006. FORD NEEDS TO RECALL!! *TR
DRIVING HOME AND SUDDENLY THERE WAS A LOUD BANG. I THOUGHT SOMEONE SHOT OUT MY WINDOW. AFTER ARRIVING HOME I LOOKED AT IT AND REALIZED THAT THE GLASS HAD DROPPED DOWN INTO THE DOOR. I TOOK IT TO THE DEALER AND PAID $350 FOR THE REPAIR. THESE WINDOW REGULATORS NEED TO BE RECALLED OR BANNED!!!!!!!!!!!!!!!!! *TR
ON AUGUST 3, 2012 THE PASSENGER WINDOW DROPPED AND THE REGULATOR ASSEMBLY HAD TO BE REPLACED. YESTERDAY, MARCH 2, 2013 THE DRIVER SIDE WINDOW WOULD NOT GO UP. THE REGULATOR WITH MOTOR HAD TO BE REPLACED. I THINK FORD NEEDS TO RECALL THEIR VEHICLES, AND REPLACE THEIR DEFECTIVE PARTS. *TR
WHEN ACCELERATING SLOWLY FROM A STOP LIGHT, THE DRIVERS SIDE WINDOW FELL DOWN INTO THE DOOR. APPARENTLY THE WINDOW REGULATOR BROKE, AN ISSUE WHICH IS DOCUMENTED ON NUMEROUS INTERNET SITES. THE WINDOW DROPPING INTO THE DOOR CREATED A VERY DISTRACTING DRIVING SITUATION, NOT TO MENTION VISUAL SAFETY HAZARDS AS IN TODAY DURING RAINY, FOGGY, HUMID CONDITIONS AFFECTING THE VISIBILITY THROUGH THE REMAINING GLASS IN THE VEHICLE. *TR
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED WHILE TRAVELING 30 MPH, THE REAR DRIVER SIDE WINDOW COLLAPSED INTO THE DOOR PANEL. THE CONTACT MERGED TO THE SIDE OF THE ROAD AND THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE WINDOW REGULATOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE LATER RECURRED WITH ANOTHER WINDOW. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 66,000. ..UPDATED 09-28-12 *BF THE CONSUMER STATED TWO OF THE WINDOWS FAILED WITHIN TWO DAYS OF EACH OTHER. THE FIRST FAILURE HAPPENED AT 30 MPH AND THE SECOND INCIDENT HAPPENED AT 65 MPH, WHILE HIS WIFE WAS DRIVING ON THE FREEWAY. THE CONSUMER'S WIFE ALMOST LOST CONTROL OF THE VEHICLE, BECAUSE SHE THOUGHT IT WAS A GUN SHOT. THE WINDOW DROPPED INSIDE THE DOOR, LEAVING THE INABILITY TO ROLL UP THE WINDOW. UPDATED 10/01/12
I HAVE POWERED WINDOWS ON MY TRUCK. TODAY WHILE DRIVING TO WORK AND GETTING ON THE HIGHWAY GOING SOUTH ON I-35 IN OKC, OK. I HAD THE DRIVER SIDE WINDOW PARTIALLY ROLLED DOWN AND ONCE I WAS AT HIGHWAY SPEEDS I DECIDED TO ROLL THE WINDOW UP, AS I USUALLY HAVE ALWAYS DONE BEFORE. AFTER THE WINDOW REACHED THE CLOSED POSITION, I HEARD A LOUD POP AS IF A ROCK HIT THE WINDOW AND IMMEDIATELY AFTER THAT, THE WINDOW FELL DOWN AND SLAMMED INTO THE BOTTOM WELL OF THE DOOR PANEL. TO MY AMAZEMENT AND NOT UNDERSTANDING WHAT JUST OCCURRED, I TRIED TO RE-RAISE THE WINDOW BACK UP UNSUCCESSFULLY. SO FAR ITS SITTING IN THE PARKING LOT, TAPED UP WITH PLASTIC OVER IT SINCE ITS ABOUT TO RAIN UNTIL I CAN GET IT TAKEN CARE OF. ON ANOTHER NOTE THE OTHER REAR BACK PASSENGERS WINDOWS SQUEAK WHEN THEY ARE RAISED OR LOWERED. WHAT NEXT!! PROBABLY MORE OF THE SAME. SWEET!! *TR
I HAVE READ MANY COMPLAINTS JUST LIKE MINE, FORD TOLD SOME PEOPLE THEY HAD WAY TOO MANY COMPLAINTS TO DO ANYTHING ABOUT A RECALL ON THIS. LAST YEAR THE DRIVERS WINDOW POPPED AND THE WINDOW DROPPED INSIDE THE DOOR I WENT TO FORD BOUGHT THE CABLE AND REGULATOR AND HAD A WINDOW COMPANY REPLACE IT. 2 WEEKS AGO SAME THING ON THE PASSENGERS FRONT WINDOW, NEXT DAY THE PASSENGERS BACK WINDOW DROPPED WHILE I WAS IN MY HOUSE, THE DRIVERS BACK WINDOW IS THE ONLY ONE LEFT. THIS TRUCK IS A 2005 THE PARTS ARE NOT THAT OLD. *TR
PARKING MY TRUCK IN MY GARAGE, STOPPED, PUT TRANSMISSION IN PARK, CLOSED DRIVERS DOOR POWER WINDOW, HEARD LOUD POP, SOUNDED AS IF GLASS BROKE, BUT IT DID NOT. WINDOW FELL DOWN INTO DOOR, WOULD NOT RAISE UP. PRESSING POWER BUTTON, I COULD HEAR MOTOR RUNNING, BUT WINDOW WOULD NOT MOVE. *JS
DRIVING OUT OF A PARKING LOT, ONLY 10 MPH OR SO, LOUD POP ON PASSENGER SIDE DOOR. STOPPED THE VEHICLE, AND PASSENGER WINDOW DROPPED DOWN INTO THE DOOR. GRATEFUL I WAS NOT GOING FAST AND HAD THE ABILITY TO STOP QUICKLY, OTHERWISE POTENTIAL ACCIDENT. LOOKING ONLINE, CAN SEE THIS IS A FREQUENT PROBLEM WITH THIS YEAR, MAKE, MODEL TRUCK. A MATTER OF TIME BEFORE SOMEONE GETS HURT FROM THIS. *JS
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .