Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 488 NHTSA owner-reported complaints for the 2007 Ford F-150. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 488 · page 1 of 20
The metal cables on the car seat that attach it to base, one of them is fraying. I noticed this today when I brought the car seat inside to remove the car seat cover to wash.
I have had a coolant leak but haven't been able to find it until now. It is below the thermostat housing, between the manifolds and the metal tube that hooks the bottom of the thermostat to the manifold. I know there is a recall issued for this but it doesn't seem to come up on my truck. In my opinion it should.
After making a sharp right turn tie rod came loose from steering rod. After inspection the threads on the steering rod seem to be too small for the tie rod. The truck has been taken care of and only has 75000 miles on it. The new tie rod I installed was also loose on the steering rod. The threads were not stripped, rusty or damaged in anyway. This truck has never had any work or been damaged. I have never had front end lined up because tires have not had any wear indicating misalignment.
The contact owned a 2007 Ford F-150. The contact stated that when depressing the accelerator pedal while in reverse, the vehicle suddenly accelerated, crossing a field, and crashing into a nearby building, where the vehicle came to a stop. The contact sustained neck injuries, and the front passenger sustained neck injuries as well. The contact did not seek medical attention; however, they intended to do so in the future. The air bags did not deploy. A police report was filed. The rear end of the vehicle was damaged. The vehicle was driven home. The vehicle was taken to Collision Center who diagnosed that the rear of the vehicle needed extensive bodywork and determined the vehicle was totaled. The manufacturer was not informed of the failure. The failure mileage was approximately 300,000. The VIN was not available.
The contact owns a 2007 Ford F-150 The contact stated while driving at an undisclosed speed, the vehicle stalled and jerked. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred, with the check engine warning light illuminated. The vehicle was taken back to the mechanic where it was diagnosed and determined that the spark plugs, and torque converter had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 126,963.
Transmission and rear end jerking when putting in or taking out of park, reverse or drive and now doesn't want to go forward when putting it in drive and I can't get it to shift out and transmission fault light came on and I re set it by taking black cable off battery and put transmission fluid in it and it still does it and also headlights doesn't work on bright and power steering pump makes noise and it's full of fluid I don't know if it is leaking or what small stuff I can deal with but major transmission and engine stuff on truck I can't.
Frame has rotted away
The contact's daughter owns a 2013 Ford Focus. The contact stated that the vehicle had failed to shift properly and shuddered. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the clutch assembly needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to another local dealer, #1 Cochran Ford Boardman (7955 Market St., Youngstown, OH 44512); where it was diagnosed and determined that the clutch assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 17,000.
The contact owns a 2007 Ford F-150 equipped with Cooper Tires, Tire Line: Discovery ATP, Tire Size: 265/70/R17, DOT Number: (N/A). The contact stated that while performing a tire rotation, the contact discovered sidewall bulges and tread separation on both rear tires. The vehicle was taken to the tire retailer, where it was determined that the rear tires were defective and needed to be replaced. The contact replaced both rear tires. The tire manufacturer was made aware of the failure, but no assistance was provided. The tire failure mileage was unknown. The vehicle failure mileage was 220,000. The VIN was unavailable.
The contact owns a 2007 Ford F-150. The contact stated while making a right turn from a complete stop at 7-10 MPH, the vehicle shuddered significantly. The contact pulled over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the driveline assembly had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 120,000.
The contact owns a 2007 Ford F-150. The contact stated that while the vehicle was parked, she became aware that the sub frame, underneath the vehicle, was cracked. The contact stated that the frame was loose and was visible by standing in front of the vehicle. The vehicle was taken to an independent mechanic who confirmed that the frame was cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was approximately 190,000.
The contact owns a 2007 Ford F-150. The contact stated that while her husband was driving at an undisclosed speed, there was an abnormal knocking sound coming from the vehicle. The contact's husband turned off and restarted the vehicle and the vehicle was driven to the residence. The contact stated that the vehicle failed to start the next two days. The contact stated that when the vehicle was started, the knocking sound had returned, and the vehicle was shaking abnormally. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 106,614.
The ABS CONTROL MODULE has gone out therefore there isn’t any all wheel braking control for the vehicle. I know of my vehicle and several more that have this same problem. They range from 2007 up to 2012. With this problem also they will not pass State Emissions Inspection. I just inherited my vehicle. I was the owner of a repair shop and had several pickups with this very problem. This repair cost from Ford is over $1,000.00. This seems to be a recurring failure with the brake system.
I’m wondering why there is no recall on the frames my truck has 96k and the frame is almost gone 2007 f-150
While driving lost power from 70 mph to 45 mph drove it slow home Once I parked check engine light and noticed smoke coming from behind and lower part of engine after checking for heat source noticed glowing areas it was the insulation between engine and floor I had to use extinguisher in 4 areas to extinguish I disconnected battery power
275/65/R18 116T First purchased 4 Cooper Adventurer H/T tires mileage was currently 199201 on May/2020. Only driven for work commute of 25miles. Cooper Adv H/T brand first replacement on front tires only due to one of the tires having bulging on the side wall of the tire, was informed possible defect and then it was changed to being worn out by possible construction/bad roads. 24450 mileage at the time of replacement on Aug/2022. There was a replacement of the second front tire In between the time period and was told by a different manager it was not a defect whom seemed hostile when I mentioned the first manager mentioned the last tire had a possible bulge defect. Paid normally price no discount. Currently now have the same bulging on front driver side wall from those replacements along with a watermark lining on the wall of the tire and mileage now is just around 255120.
The phasers and the timing chain and tensioners is failing. This is premature failure due to engineering mistakes in the design. This is a safety critical walk home failure. Failure will destroy the engine (interference engine). Complete loss of all power and lock up of engine. Mechanic said the only remedy is a rebuilt engine. A reputable engine rebuilder states in their ad on the internet that they have corrected the Ford Motor Company engineering design mistakes in the 5.4l Triton engine.
The fuel module failed and the 5,4l Triton engine stopped running. There was no power steering or power brakes in the middle of the fast lane on the interstate. This was a safety critical walk home. The component was disposed of. The vehicle stopped in the fast lane. Possibility to be hit from behind, Ford denied my claim. There were no warnings of the failure. Galvanic corrosion.
The contact owns a 2007 Ford F-150. The contact stated while driving 70 MPH, the vehicle lost motive power and stalled with the power steering and braking functions inoperable. There was no warning light illuminated. The vehicle was towed to the residence. The contact stated that after retrieving the vehicle, he became aware that the fuel module was defective. The vehicle was repaired. The contact stated that the vehicle also experienced a premature timing belt failure. The vehicle was diagnosed by an independent mechanic and the contact was informed that the engine needed to be repaired or replaced. The engine was not repaired or replaced. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was 108,000. The consumer stated the fuel module and timing chain/phasers fail without warning.
Shifting the automatic transmission from gear to gear with the shifting lever has become extremely difficult. can this be rectified with lubrication at some point? Thankyou
The contact owns a 2007 Ford F-150. The contact stated that while driving at an undisclosed speed, the gear shifter was difficult to shift. The contact stated that the gear shifter was stuck in park(P). There were no warning lights illuminated. The local dealer was not contacted. The vehicle was diagnosed or repaired. The contact stated that the transmission shifter cable was repaired several times by an independent mechanic. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 171,639. The VIN was not available.
The contact owns a 2007 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle experienced rough driving. The vehicle was taken to an independent mechanic who diagnosed that there was a cylinder #1 misfire and that the spark plugs and coil pack needed to be replaced. The dealer was made aware of the failure and referred the contact to the manufacturer for assistance. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately over 100,000.
We are having constant problems with cylinders misfiring. Once we get one fixed, another one breaks. It’s a constant issue.
Vehicle reports “check charging system” which has an associated TSB but no recall. My understanding is that the AC drips water on the alternator harness causing degradation and shorting of the wires. A new wiring harness as well as a drain relocation kit are required. I do not believe the customer should be responsible for this repair.
Spark plug blow out. Yes it is available for inspection. Ongoing very common issues with triton engines blowing out spark plugs making a fire hazard because fuel vapor coming out of plug hole could be ignited by coil pack. All ford dealerships are very aware of this issue and have repaired many by rethreading and installing a helicoil thread repair kit at a very high price of 800 dollars and most repairs are temporary because the aluminum is weak and very thin at the spark plug hole. Ford is very aware of this ongoing issue and denies any liability experts don’t agree with fords arguments. No warning the plugs start to blow out at around 140000 miles well after the warranty. This problem started in the 90s all triton engines are affected. As in the photo the dealers attempt to repair was unsuccessful the spark plug is tightened to deep into the head and is broken off. They said at the end of the day I need a new head. 5000 dollars.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .