2007 Ford F-150 Problems

I have had a coolant leak but haven't been able to find it until now. It is below the thermostat housing, between the manifolds and the metal tube that hooks the bottom of the thermostat to the manifold. I know there is a recall issued for this but it doesn't seem to come up on my truck. In my opinion it should.

The contact owns a 2007 Ford F-150. The contact stated that while her husband was driving at an undisclosed speed, there was an abnormal knocking sound coming from the vehicle. The contact's husband turned off and restarted the vehicle and the vehicle was driven to the residence. The contact stated that the vehicle failed to start the next two days. The contact stated that when the vehicle was started, the knocking sound had returned, and the vehicle was shaking abnormally. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 106,614.

The ABS CONTROL MODULE has gone out therefore there isn’t any all wheel braking control for the vehicle. I know of my vehicle and several more that have this same problem. They range from 2007 up to 2012. With this problem also they will not pass State Emissions Inspection. I just inherited my vehicle. I was the owner of a repair shop and had several pickups with this very problem. This repair cost from Ford is over $1,000.00. This seems to be a recurring failure with the brake system.

Speedometer sticks at 60 mph on idle or when it’s turned off. Does not Reflect actual speed of car. There are multiple cars with F150 with the similar complaint

The contact owns a 2007 Ford F-150. The contact stated while driving 70 MPH, the vehicle lost motive power and stalled with the power steering and braking functions inoperable. There was no warning light illuminated. The vehicle was towed to the residence. The contact stated that after retrieving the vehicle, he became aware that the fuel module was defective. The vehicle was repaired. The contact stated that the vehicle also experienced a premature timing belt failure. The vehicle was diagnosed by an independent mechanic and the contact was informed that the engine needed to be repaired or replaced. The engine was not repaired or replaced. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was 108,000. The consumer stated the fuel module and timing chain/phasers fail without warning.

TRANSMISSION COOLING LINE GOING THROUGH RADIATOR FAILED CAUSING COOLANT TO MIX WITH TRANSMISSION FLUID. RESULTING IN TRANSMISSION FAILURE. TRANSMISSION HAD TO BE ENTIRELY REBUILT AND RADIATOR ALSO HAD TO BE REPLACED. THIS OCCURRED AT HIGHWAY SPEED.

The contact owns a 2007 Ford F-150 equipped with Cooper Tires, Tire Line: Discovery ATP, Tire Size: 265/70/R17, DOT Number: (N/A). The contact stated that while performing a tire rotation, the contact discovered sidewall bulges and tread separation on both rear tires. The vehicle was taken to the tire retailer, where it was determined that the rear tires were defective and needed to be replaced. The contact replaced both rear tires. The tire manufacturer was made aware of the failure, but no assistance was provided. The tire failure mileage was unknown. The vehicle failure mileage was 220,000. The VIN was unavailable.

275/65/R18 116T First purchased 4 Cooper Adventurer H/T tires mileage was currently 199201 on May/2020. Only driven for work commute of 25miles. Cooper Adv H/T brand first replacement on front tires only due to one of the tires having bulging on the side wall of the tire, was informed possible defect and then it was changed to being worn out by possible construction/bad roads. 24450 mileage at the time of replacement on Aug/2022. There was a replacement of the second front tire In between the time period and was told by a different manager it was not a defect whom seemed hostile when I mentioned the first manager mentioned the last tire had a possible bulge defect. Paid normally price no discount. Currently now have the same bulging on front driver side wall from those replacements along with a watermark lining on the wall of the tire and mileage now is just around 255120.

The contact owned a 2007 Ford F-150. The contact stated that when depressing the accelerator pedal while in reverse, the vehicle suddenly accelerated, crossing a field, and crashing into a nearby building, where the vehicle came to a stop. The contact sustained neck injuries, and the front passenger sustained neck injuries as well. The contact did not seek medical attention; however, they intended to do so in the future. The air bags did not deploy. A police report was filed. The rear end of the vehicle was damaged. The vehicle was driven home. The vehicle was taken to Collision Center who diagnosed that the rear of the vehicle needed extensive bodywork and determined the vehicle was totaled. The manufacturer was not informed of the failure. The failure mileage was approximately 300,000. The VIN was not available.

Transmission and rear end jerking when putting in or taking out of park, reverse or drive and now doesn't want to go forward when putting it in drive and I can't get it to shift out and transmission fault light came on and I re set it by taking black cable off battery and put transmission fluid in it and it still does it and also headlights doesn't work on bright and power steering pump makes noise and it's full of fluid I don't know if it is leaking or what small stuff I can deal with but major transmission and engine stuff on truck I can't.

The ABS CONTROL MODULE has gone out therefore there isn’t any all wheel braking control for the vehicle. I know of my vehicle and several more that have this same problem. They range from 2007 up to 2012. With this problem also they will not pass State Emissions Inspection. I just inherited my vehicle. I was the owner of a repair shop and had several pickups with this very problem. This repair cost from Ford is over $1,000.00. This seems to be a recurring failure with the brake system.

STARTED TO DRIVE MY VEHICLE BUT IT IS STUCK IN PARK

The fuel module failed and the 5,4l Triton engine stopped running. There was no power steering or power brakes in the middle of the fast lane on the interstate. This was a safety critical walk home. The component was disposed of. The vehicle stopped in the fast lane. Possibility to be hit from behind, Ford denied my claim. There were no warnings of the failure. Galvanic corrosion.

Vehicle reports “check charging system” which has an associated TSB but no recall. My understanding is that the AC drips water on the alternator harness causing degradation and shorting of the wires. A new wiring harness as well as a drain relocation kit are required. I do not believe the customer should be responsible for this repair.

Frame has rotted away

The contact owns a 2007 Ford F-150. The contact stated that while the vehicle was parked, she became aware that the sub frame, underneath the vehicle, was cracked. The contact stated that the frame was loose and was visible by standing in front of the vehicle. The vehicle was taken to an independent mechanic who confirmed that the frame was cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was approximately 190,000.

After making a sharp right turn tie rod came loose from steering rod. After inspection the threads on the steering rod seem to be too small for the tie rod. The truck has been taken care of and only has 75000 miles on it. The new tie rod I installed was also loose on the steering rod. The threads were not stripped, rusty or damaged in anyway. This truck has never had any work or been damaged. I have never had front end lined up because tires have not had any wear indicating misalignment.

Transmission and rear end jerking when putting in or taking out of park, reverse or drive and now doesn't want to go forward when putting it in drive and I can't get it to shift out and transmission fault light came on and I re set it by taking black cable off battery and put transmission fluid in it and it still does it and also headlights doesn't work on bright and power steering pump makes noise and it's full of fluid I don't know if it is leaking or what small stuff I can deal with but major transmission and engine stuff on truck I can't.

The contact owns a 2007 Ford F-150. The contact stated that while his son was driving out of a parking lot under 5 MPH, the air bags inadvertently deployed without impact. The air bag warning light illuminated. The contact had not taken the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure an opened a case. The approximate failure mileage was 143,000.

The airbag warning light stays on.

THE FRAM IS EAT UP ON MY TRUCK AND FORD WONT FIX IT AT ALLI CALL AND THEY KEEP GIVING ME THE RUN AROUND I THINK THAT THE TRUCK WILL BREAK INTO AND CAUSE A SERIOUS WRECK BECAUSE OF IT

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 45 MPH, THE VEHICLE DECELERATED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS AND THE COIL SPRINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT TO CALL NHTSA TO CHECK FOR ANY OPEN RECALLS. THE FAILURE MILEAGE WAS 88,000.

The metal cables on the car seat that attach it to base, one of them is fraying. I noticed this today when I brought the car seat inside to remove the car seat cover to wash.

CAMPAIGN NUMBER: 18E069. I AM UNABLE TO GET ANYONE TO ANSWER THE NUMBER PROVIDED IN THE LETTER AT LRG. I HAVE THE EFFECTED RIMS AND THEY ARE NOW LEAKING AIR. I WOULD LIKE TO FILE A COMPLAINT.

The contact owns a 2007 Ford F-150 The contact stated while driving at an undisclosed speed, the vehicle stalled and jerked. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred, with the check engine warning light illuminated. The vehicle was taken back to the mechanic where it was diagnosed and determined that the spark plugs, and torque converter had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 126,963.

FOR THE SECOND TIME MY F-150 WILL HAVE TO HAVE THE TRANSMISSION REPLACED. IT IS AN 2007 MODEL. THE CAR WENT INTO THE PROTECT MODE. IT IS NOW IN THE FORD DEALER. THEY WANT 3600 TO REPLACE IT. I HAD A SIMILAR INCIDENT IN 2008 WHERE THEY FIXED THE TRANSMISSION FOR FREE. *TR

TL* THE CONTACT OWNED A 2007 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING AT 73 MPH, HE ATTEMPTED TO DEPRESS THE BRAKE PEDAL AND THE BRAKE PEDAL BROKE WITHOUT WARNING. AS A RESULT OF THE BRAKE FAILURE, THE CONTACT REAR ENDED AN 18-WHEELER TRUCK. THE AIR BAG DEPLOYED UPON IMPACT HOWEVER, THE SEAT BELT FAILED TO RETRACT. THE CONTACT RECEIVED MEDICAL ATTENTION AT THE SCENE AND WAS LATER TRANSPORTED TO A HOSPITAL. THE OTHER DRIVER WAS ALSO TREATED AT THE SCENE BUT HIS INJURIES WERE UNKNOWN. THE CONTACT SUSTAINED A BROKEN RIGHT ARM AND A BROKEN RIGHT FEMUR. A POLICE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED TO A LOCAL JUNK YARD. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 141,000.

TL* THE CONTACT OWNED A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 99 MPH, THE VEHICLE STRUCK AN EMBANKMENT AND ROLLED OVER TWO AND A HALF TIMES. THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS WEARING A SEAT BELT; HOWEVER, HE WAS EJECTED FROM THE VEHICLE THROUGH THE REAR DRIVER SIDE WINDOW. THE DRIVER SUSTAINED FATAL INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. THE VIN WAS UNAVAILABLE.

AIR VENT ADJUSTMENT FAILURE, REQUIRED REPLACEMENT OF PLENUM CHAMBER. CAUSE OF THIS PROBLEM WAS THE FAILURE OF THE ADHESIVE ON TWO FOAM PIECES ATTACHED TO TWO AIR BLEND DOORS WHICH JAMMED BECAUSE THE FOAM FELL OFF AND PREVENTED THE DOORS FROM MOVING. IN ORDER TO REPAIR THE PROBLEM THE ENTIRE DASHBOARD NEEDED TO BE REMOVED AT A COST OF JUST UNDER $1000. I HAVE CONTACTED FORD FOR HELP IN COVERING THIS EXPENSE AND THEY HAVE DENIED IT SINCE THERE IS NO RECALL NOTICE OUTSTANDING. ON LINE SITES ABOUT THIS ISSUE AND THE EXTENSIVE REPAIR COST ARE IN THE HUNDREDS. *TR

URETHANE ADHESIVE SEPARATION / PAINT SEPARATION FROM WINDSHIELD FRAME. WINDSHIELD REPLACEMENT AFTER CRACK. WHEN THE WINDSHIELD CAME OUT THE PAINT CAME WITH THE URETHANE ADHESIVE AS A SOLID COATING ON THE ADHESIVE. WINDSHIELD WAS NOT ATTACHED TO THE AUTO BODY FRAME. *TR

The metal cables on the car seat that attach it to base, one of them is fraying. I noticed this today when I brought the car seat inside to remove the car seat cover to wash.

2007 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE PASSENGER ASSIST HANDLE BROKE OFF. *SMD THE CONSUMER STATED HIS WIFE FELL WHILE ATTEMPTING TO ENTER THE FRONT PASSENGER SIDE OF THE VEHICLE. SHE WAS USING THE PASSENGER ASSIST HANDLE LOCATED AT THE POST BETWEEN THE DOOR AND THE WINDSHIELD. SHE HAD ONE FOOT ON THE RUNNING BOARD AND HAD JUST STARTED USING THE ASSIST HANDLE TO ENTER THE VEHICLE WHEN THE ASSIST HANDLE BROKE OFF AND SENT HER BACK FROM THE VEHICLE. FORTUNATELY, SHE STILL HAD ONE FOOT ON THE GROUND AND WAS ABLE TO CATCH HERSELF AND WAS NOT HURT. THE PART WAS REPLACED AT A COST OF $ 213.86. *JB

THE WIRING FOR MAP BURNT OUT IT'S MADE OF PLASTIC AND PARTIALLY MELTED .PASSENGER SIDE AIRBAG LIGHT

BOUGHT THE T07 F150 AT 28K AND AT 61K THIS HAPPENED. WHILE DRIVING AT LOW GEAR 2ND THE ENGING CHUGGED A LITTLE ( LKE AN OLD DIESAL) TOOK IT TO THE DEALER THEY SAID IT WAS PROBABLY THE SMALL OIL SEAL BEHIND THE CAM. THEY WAS GOING TO CHARGE BE 5600 FOR A NEW ENGINE. THEY TRIED LIKE HE11 TO GET ME TO SAY I DIDNT HAVE THE OIL CHANGED REGULARLY. I NEVER BACKED DOWN, THEN REMINDED THEM THAT I HAD BOUGHT THE $2700.00 EXTENDED WARRENTY (WHICH I USUALLY NEVER DID) THEY BAUKED AND CRIED. BUY SAID THAT THEY WOULD FIND ANOTHER USED ENGINE, THEY CALLED ME AND SAID THAT THEY FOUND ONE FOR 3500 (OR SOMETHING LIKE THAT) I BEGAN A LONG SEARCH ONLINE AND FOUND A REBUILD FOR LESS AND GAVE THEM THE INFORMATION. THEY DECIDED TO GO WITH THAT. THEY ORDERED THE ENGINE AND INSTALLED IT ( WELL WHAT DO YOU KNOW THE REPLACEMENT HAD THE SAME PROB) THEY HAD TO PULL THAT ENGINE AND GET ANOTHER FROM THE COMPANY . TOOK AN EXTRA WEEK AND GOT THE TRUCK BACK ITS NOW AT 100K AND STILL RUNS WELL (SO I KNOW IT WASNT MY DRIVING) SO IT HAD TO BE THE INCORRECT PLACEMENT OF THAT SEAL FROM THE DEALER, WHICH WOULD LEAKED HOT OIL ONTO THE ENGINE AND CAUSE A FIRE. I LOOKED AT THE ORIGIONAL PAPER WORK THAT THEY HAD TO REPLACE TH ORIGIONAL WIRING HARNESS BEFORE IT EVEN LEFT THE FACTORY.

THE A/C ON THIS TRUCK HAS ALWAYS BEEN WEAK. THE DEALER SAY IT IS OPERATING NORMALLY, BUT IT DOES NOT COOL THE TRUCK IN THE TEXAS HEAT. DEALER REFUSES TO DO ANYTHING MORE. *TR

THE AIR-CONDITIONER HAS NOT COOLED PROPERLY SINCE DAY OF PURCHASE.THE DEALERSHIP TRIED REPAIRING IT BY FLUSHING THE A/C SYSTEM AND REFILLING IT WITH FREON. IT SEEMED TO COOL A LITTLE BETTER, BUT IT STILL THROWS WARM AIR WHEN TRUCK IS IDLING. BIG PROBLEM WHEN YOU LIVE IN THE DESERT AND A/C IS A MUST, NOT A LUXURY. *TR