2015 Ford F-150 Electrical Problems

The timing belt/chain is failing on F-150 trucks and multiple people have sent in issues. i think from 2015-2018. It looks like you are already looking at other Fords with same issue. what i was told is that there could be sudden stalling: If the timing is thrown off or the chain snaps, the engine cuts out instantly. Losing power steering and engine power while driving in traffic creates an immediate crash hazard. Severe Misfires and Power Loss: A slipping chain causes rough idling, violent shaking, and an inability to accelerate which happened to the truck. Due to this i had to get mine fixed in June of 2024 i have attached the invoices. I tried to upload invoice but said there was an error

NHTSA ID

11754650

Incident

Jun 20, 2024

A/C shuts off after 30-45 minutes of running cold. It’s clear from the amount of condensation after I park, that the evaporator core is freezing due to a faulty temperature sensor

NHTSA ID

11752041

Incident

Jul 22, 2026

The clock spring in the steering has failed causing the airbag to no longer work on the driver side. The cruise control turns on and shuts off on its own. Sometimes won’t even let you set it. Volume controls no longer work. Horn no longer works. Steering has a clicking catching sound now when turning. Steering controls no longer light up and none of the buttons work.

NHTSA ID

11751383

Incident

Jul 15, 2026

The active recall and still no remedy for ..no ford dealer will assit with a loaner vehicle or pay for a rental. My truck has been exhibiting the sudden shifting issues and putting myself and family at risk. Need help before something happens this is not a risk any one should take driving everyday.

NHTSA ID

11748711

Incident

Apr 24, 2026

Transmission is making a grinding noise in gear from 5 to 6 and sometimes from 3 to 4

NHTSA ID

11747921

Incident

Jun 30, 2026

Truck does not shift the gears when in drive but will in manual mode. No communication to the transfer case. Wrench light on.

NHTSA ID

11746083

Incident

Jun 12, 2026

I was on the highway and my truck suddenly decreased speed rapidly. Luckily I was able to pull onto a side road and get to safety but it was extremely dangerous and scary situation. The dealer has confirmed the symptoms fit the issue with the recall. Since Ford does not have a fix for this solution yet until July 1 my vehicle is unable to be driven or repaired leaving me stranded without a vehicle. However, this is a very concerning safety issue and my family could have been severely impacted traveling on the highway.

NHTSA ID

11743643

Incident

Jun 9, 2026

The vehicle lost power rolling from a stop sign, felt like it was trying to shift but wouldn’t then went into limp mode, drove fine the next day. The faulty lead frame is failing, it has no other cause. I refuse to drive and put myself and others in danger to prove it. The dealer said they couldn’t cover it because the code is not covered in the recall, they recommended a new valve body or transmission, they didn't even say why. They were able to recreate it wrench light. P2704 is the code they claimed with the 2 leading causes are valve body, they said my fluid was clean and the vehicle has up to date service with no previous sign of wear, or the lead frame going out, the ACTIVELY recalled part. I tried contacting ford directly and they refused assistance beyond “tow it to a different dealer” and then ended the conversation. It is a safety issue that I will not wait to have break if there is clear signs of it happening.

NHTSA ID

11743376

Incident

Jun 1, 2026

My 2015 Ford F-150 experienced a sudden, dangerous loss of throttle power while driving, forcing an emergency stop on the side of the road. The vehicle is now locked in a hard electronic no-start/no-crank condition. We diagnosed the vehicle and pulled active, stored trouble codes P0706 and P0707 for the Transmission Range Sensor (TRS).This failure matches the exact defect described in NHTSA Campaign 26V237 / Ford Recall 26S28. However, Ford Corporate and the local dealership (Washington Ford in PA) are actively refusing to provide an emergency diagnostic scan, towing, or physical parts replacement, claiming they will not honor the remedy until June 30th. This has left a hazardous, disabled vehicle stranded on my property. They have acknowledged this meets the criteria of the safety recall but want me to pay for the towing of the disabled vehicle, diagnostics, and repair upfront including the lead frame which the recall notice specifically states should be replaced because the codes were thrown before reprogramming.

NHTSA ID

11742652

Incident

Jun 7, 2026

Exhaust manifold bolt broke cause extra heat coming from that broken bolt cause the crank shaft position sensor wires to melt cause the vehicle to stall while driving down the road and it not to restart just cranks and throws the code for crank shaft position sensor

NHTSA ID

11737583

Incident

Apr 1, 2026

Ford has acknowledged the defect (recall 26S28). · my truck experienced the dangerous downshift and wheel lockup. · Ford has no fix available until June 30th, leaving me without a safe vehicle. · Ford is refusing to provide a loaner or rental. The wheel locked on me and causing the vehicle to be uncontrollable, in wet condition. Causes a near fatal accident. I do have a dash Camera recording to prove my case.

NHTSA ID

11735848

Incident

May 4, 2026

Molded lead frame sudden downshifts to first third or fifth gear would have to pull over to the side of the road/highway and shut the truck off and restart it to get it to go away it went from happening every 50-75 miles to the point where it would happen every 1-5 miles or less when it would down shift to first gear it would lock the rear wheels and almost caused me to get in multiple accidents happened right after I bought the truck 1/27/26 all the way until 3/02/26 when I was forced to get it fixed so I could drive the truck properly

NHTSA ID

11728550

Incident

Jan 30, 2026

My electronic shift on the Fly four wheel system keep dropping in gear while I'm operating the vehicle and it's dragging my back tires this is happening without me operating it

NHTSA ID

11728121

Incident

Mar 17, 2026

Vehicle unexpectedly down shifting while driving causing vechile to jerk. After parking truck, truck presents a no start condition and unlit gear selector lights. While driving truck will go in and out of limp mode. I have scheduled a appointment to bring the truck in for a diagnostic test 03/31/2026.

NHTSA ID

11727793

Incident

Mar 27, 2026

1. System Failed: Power Train (Transmission). Component Failed: The 6R80 6-speed automatic transmission, specifically the internal lead frame and the direct drum. Inspection: No, the failed unit was replaced on December 19, 2025, but itemized diagnostic reports and repair invoices from both a Ford dealer and an independent shop are available for inspection. 2. The vehicle experienced sudden, unexpected downshifting and a temporary loss of power while in motion. These incidents occurred frequently and randomly, particularly while accelerating or traversing inclines, creating "unsafe driving scenarios" where the vehicle could have been rear-ended or lost traction due to abrupt gear changes. Furthermore, the vehicle eventually entered "limp mode," where it would "buck" during shifts and fail to accelerate under load, leaving the driver vulnerable in traffic. 3. Yes, by both. Independent Center: Super Tech Automotive confirmed on December 11, 2025, that the transmission line pressure dropped from 158 psi to 20 psi under load, causing the vehicle to go into "limp mode". Dealer: South West Ford Service Department verified the concerns on December 16, 2025, documenting a "torque converter shudder" and "direct drum failure" with "excessive metal debris in fluid". 4. Yes. The vehicle was inspected by a manufacturer-authorized dealer, South West Ford Service Department, on December 16, 2025 (Service Advisor Ryan Forbis; Transmission Specialist 'Dietrich'). 5. Yes. Symptoms: The symptoms first appeared in August 2025 as a "sudden, temporary loss of power or unexpected down-shifting". Warning Lamps: Initially, no warning lights or error codes were produced, which prevented early detection during multiple diagnostic attempts. Later Symptoms: On December 11, 2025, the SES (Service Engine Soon) Light finally appeared when the truck entered "limp mode". Prior to the total failure, the transmission also exhibited "harsh/jerky downshifts" and would "hang up in gear".

NHTSA ID

11719640

Incident

Dec 19, 2025

Truck began reviving at high idle after throwing a check engine light, then wrench light as I was driving. I was able to safely get off the road. Shut it down wouldn't restart. I let it sit for 4 hrs, it started then I began driving again as there was no indication of an issue before. At 50mph it happened again. Truck began reviving at recline, check engine and wrench light. Shut it down again, and this process of restarting again hours later as nothing was wrong is still going on, 3 yrs of it. Check engine codes that do come up when it begins again all point to speed sensor and leadframe. Someone said check cam sensors but have no check engine on them at all, only leadframe issues that abruptly occur out the blue. When it happens I can driving at any speed and first thing that happens is the throttle revs to redline and Truck begins shifting abnormal, check engine, wrench, shutdown(thankfully), then hours again now indication of an issue! When i get the truck shut off and off the road, which i had it towed 7 times, show p705,706,707 codes all pertaining to leadframe. Please for the sake ny family and many others recall the 2015-2017 F150s for this $2000 electrical sensor replacement that is putting lives in jeopardy.

NHTSA ID

11719529

Incident

Jan 25, 2026

Experiencing sudden hard shifting with the 6r80 transmission. Have had wheels lock up once. Issues with the lead frame as well

NHTSA ID

11717241

Incident

Dec 12, 2025

Odometer Fraud. The contact's husband purchased a 2015 Ford F-150. The contact stated that while researching the VIN online a day later, the contact discovered that there was a mileage discrepancy. The contact discovered that an auction had previously sold the vehicle to the seller. The vehicle was a private sale. The contact contacted the auction, and it was confirmed that the vehicle was sold to the private seller at 480,000, but at the time of purchase, the mileage was 114,000. The contact made several attempts to contact the private seller, but the private seller ended the communications.

NHTSA ID

11716827

Incident

Feb 4, 2026

Mileage

480,000 mi

Transmission downshifting at highway speed, started to stall, went to limp mode had to manual shift to get to exit

NHTSA ID

11716701

Incident

Jan 27, 2026

Back up camera has stopped working - It does work very rarely. I contacted the dealer but my 2015 is not included in any recalls even though Ford has a 15-year warranty on some cameras.

NHTSA ID

11713454

Incident

Oct 1, 2025

Odometer Fraud. The contact purchased a 2015 Ford F-150. The contact discovered a mileage discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 85,000. The vehicle was taken to a dealer for a trade-in, and it was later discovered that the mileage on the title was 185,000. Upon further investigation, the contact found out that Sheridan Motors had bought the vehicle from the original owner and that the dealer was the one who had rolled back the odometer. The contact contacted the Department of Transportation Bureau of Investigation and Identity Protection.

NHTSA ID

11708822

Incident

Jan 5, 2025

Mileage

185,000 mi

Dashboard blackout while driving.

NHTSA ID

11705785

Incident

Aug 11, 2022

mY TRUCK HAS TWO ISSUES . BACK UP CAMERA IS FAULTY AND THE DEALER REFUSED TO REPAIR. iT WAS GOING ON AND OFF AT TIMES WHICH IS A PROBLEM WHEN YOU ARE TRYING TO BACK UP AND NOT HAVE AN ACCIDENT. THE TRUCK BRAKE PEDAL GOT STUCK AND IT WAS CAUSING MY TRUCK TO REV UP AND DOWN I WAS ABLE TO GET IT HOME AND IT COST ME THOUSANDS TO FIX AT THE DEALER. RED MCCOMBS DEALERSHIP ON I 10 IN SA TEXAS IS WHERE I GO THEY DONT WANT TO FIX ANYTHING ON A RECALL AND YOU HAVE TO PAY EACH TIME AND THEN THEY DONT FIX. I COULD HAVE HAD A SERIOUS ACCIDENT EACH TIME BUT I FEEL BLESSED THAT I DIDNT

NHTSA ID

11693786

Incident

Dec 31, 1969

Ford F150 1FTEW1CPXFFC58647, caught fire while parked and unoccupied. PRINCETON, TX Fire Dept was not able to identify cause and origin of ignition / fire. Vehicle is available for inspection. Vehicle caught firer while we where asleep. Vehicle was looked at by fire dept and origin of fire was undetermined.

NHTSA ID

11689552

Incident

Sep 7, 2025

Started driving, about 2 minutes in, I noticed an electrical burn smell, and turned to look in the backseat, and it was filling with smoke, and my two young kids started coughing. I rolled all windows down and pulled over as quick as possible, unloaded both kids from rear driver side door. Saw smoke billowing out from behind the car seat on the passenger rear side, so I circled around to that door and went to inspect, right before removing the car seat I heard a loud pop and took off running just to be safe. After about 5 minutes I returned to the truck to notice the entire back windshield was shattered, chunks of glass inside and outside of the truck.

NHTSA ID

11689253

Incident

Sep 22, 2025