Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 249 NHTSA owner-reported complaints for the 1999 Ford F-250 Sd. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 249 · page 1 of 10
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. WHILE DRIVING 55 MPH, THE CABLE SNAPPED IN THE REAR OF THE VEHICLE, DAMAGED THE REAR AXLE, AND CAUSED THE TRAILER TO FRACTURE. THE MANUFACTURER WAS NOTIFIED AND SUGGESTED THAT THE VEHICLE BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT THE STRAPS FOR THE FUEL TANK WERE RUSTED ALL THE WAY THROUGH. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. HOWEVER, THE REFUSED TO PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS UNKNOWN....UPDATED 06/03/15 *BF UPDATED 7/7/2015*JS
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT 65-70 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT DRIVER'S SIDE WHEEL. THE CONTACT DISCOVERED THAT THE FRONT DRIVER'S SIDE TIRE HAD BLOWN OUT. AS A RESULT, THE ABS WARNING LIGHT ILLUMINATED. THE TIRE WAS REPLACED WITH A SPARE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07E106000 (WHEELS).THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 163,000.
TRAVELING SOUTHBOUND ON FLORIDA TURNPIKE TOWING 5TH WHEEL TRAILER, RIGHT LANE, 65MPH, 80PSI TIRE PRESSURE CHECKED BEFORE DEPARTURE. HAD TRAVELED APPROX 50 MILES WHEN TREAD PARTIALLY SEPARATED FROM RIGHT FRONT TIRE. NO LOSS OF TIRE PRESSURE, WHICH ALLOWED SAFELY STEERING OFF HIGHWAY. TREAD REMAINING ON TIRE DID EXTENSIVE DAMAGE TO RF FENDER AND CUSTOM FIBERGLAS RUNNING BOARD/ WHEEL FLARE. FENDER BOTTOM PUSHED BACK AND DAMAGED RF DOOR. SECOND TREAD FAILURE FROM SAME SET OF TIRES IN FOUR MONTHS. ALREADY A RECALL ON SAME MODEL, OTHER SIZE TIRES WE FOUND ONLINE TODAY. *TR
2014 LEXUS PULLED OUT IN FRONT OF ME SLAMMED ON BRAKES HIT DRIVERS SIDE REAR DOOR AND BACK PANEL. MY AIRBAG DID NOT DEPLOY. *TR
UNIROYAL LIBERATOR LT265/75-16 LOAD E TREAD SEPARATED CAUSING DAMAGE TO RIGHT REAR BED OF TRUCK. TRUCK BED WAS DAMAGED AS WELL AS TAILPIPE, MUD FLAP RIPPED OFF, BRACING TORN OFF, BRAKE SHIELD BENT. *TR
TREAD SEPARATION EXPERIENCED WHILE VEHICLE WAS BEING DRIVEN ON HIGHWAY. *TR
DIESEL FUEL TANK FELL DOWN BECAUSE OF RUSTED TANK STRAPS AND LEAKED 30 GALLONS OF FUEL ONTO ROADSIDE. 13 YARDS OF SOIL HAD TO BE ABATED FROM THE CONTAMINATED SITE. *TR
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE DISPLAYED A REDUCTION IN POWER AND EXHIBITED A LOUD, ABNORMAL NOISE FROM THE ENGINE WITHOUT WARNING. THE SMELL OF GASOLINE WAS EMITTED INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC, WHO INSTALLED A NEW INSERT, CYLINDER HEAD, SPARK PLUG AND COIL. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. UPDATED 05/28/14*LJ
WE HAVE STARTED TO NOTICE THAT WHEN DRIVING AT A STEADY SPEED THE TRUCK WILL STALL AND LOSE POWER AS IF IT WAS OUT OF GAS. THIS HAS HAPPEN TOO MANY TIMES AND HAS BECOME SUCH A SCARE THAT WE ARE COMPLETELY PARANOID TO DRIVE THE TRUCK WITHOUT THE FEAR OF BEING REAR ENDED. AT TAKE OFF THE TRUCK WILL SOMETIMES JOLT FORWARD VIOLENTLY. WE HAVE NOTICED AND RECORDED THAT THESE PROBLEMS OCCUR ONLY WHEN THE TRUCK GETS TO HALF A TANK. THE PROBLEM HAS GOTTEN SO BAD THAT AFTER A COMPLETE FILL UP THE TRUCK WILL NOW JUST CUT OFF WHILE BEING OPERATED ON THE HIGHWAY AND HAVE TO BE RESTARTED. WE HAVE SEVERAL FORD VEHICLES BOTH PERSONAL AND FOR OUR FLEET VEHICLES. THE FUEL FILTERS ARE BECOMING COMPLETELY CLOG UP DUE TO THE POOR CONDITION OF THE FUEL TANKS THEMSELVES. WE HAVE SPENT COUNTLESS HOURS RESEARCHING THESE PROBLEMS, AND SPENT EXCESSIVE AMOUNTS OF MONEY TRYING TO FIX/REPAIR THESE PROBLEMS. IT SADDENS US THAT WE HAVE BECOME JUST ANOTHER ADDED UNSATISFIED LOYAL CUSTOMER TO FORD, WHOM HAS NO THOUGHT OF CORRECTING THIS PROBLEM. WE HAVE READ SO MANY OTHER COMPLAINTS AND THERE IS STILL NO HELP FOR US. IT JUST LEFT IN OUR HANDS TO TRY TO FIND A SOLUTION TO FIX THIS FAULTY PROBLEM SO WE DON'T GET OUT ON THE HIGHWAYS AND KILL SOMEONE AND OR OURSELVES WHILE OPERATING LOUSY FORD TRUCKS AND VANS! WE THINK IT IS TIME FOR FORD TO GIVE US SOME HELP!!!!!!! *TR
(1999 FORDS SUPER DUTY EXTENDED CAB 4X4 WITH 5.4) DRIVING HOME FROM WORK ON THE FREEWAY AND BANG SO PULLED OVER TO DISCOVER A BLOWN SPARK PLUG AND BROKEN COIL, HAD CAR TOWED HOME FOR $200 AND TAKING IT IN TO HAVE AUTOMOTIVE SHOP FIX THE BLOWN-OUT SPARK PLUG AND CHECK ALL OTHER PLUGS , WIRES, COILS, ESTIMATED AROUND $560 PLUS PARTS. THE SECOND BLOWN-OUT SPARK PLUG HAPPENED 47 DAYS LATER AND HAD TO TOW IT AGAIN NOW JUST SITTING IN THE DRIVEWAY. CAN'T AFFORD TO HAVE IT FIXED. FORD SHOULD HAVE RECALLED THIS DESIGN DEFECT ON THE HEADS. I HAVE READ THOUSANDS OF ARTICLES THAT THIS HAS HAPPENED TOO.BEEN A REAL EXPENSIVE FOR SOMEONE THAT DOE NOT HAVE MONEY FOR THESE KIND OF REPAIRS AND FORD JUST DOES NOT CARE, THEY WOULD RATHER YOU TAKE ITTO THERE SHOP AND CHARGE YOU $2,000 OR MORE TO HAVE IT FIXED. BS. I HAVE A 1972 RANCHERO ALSO AND I'M SO PISSED OFF I'M THINKING OF SELLING ALL MY FORDS AND BUY A MOPAR. I TELL EVERYONE ABOUT THIS DEFECT. *TR
TL* THE CONTACT OWNS A 1999 FORD F-250 SD WITH FEDERAL COURGIA TIRES, LINE SIZE: 35X12.5R20. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE REAR PASSENGER'S SIDE TIRE BLEW, CAUSING THE CONTACT TO LOOSE CONTROL OF THE VEHICLE. THE VEHICLE WAS FLIPPED AND ROLLED OVER THREE TIMES. THE CONTACT SUSTAINED BACK INJURIES AS A RESULT. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE DOT NUMBER WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000 AND THE TIRE FAILURE MILEAGE WAS 8,000.
WHILE BACKING OUT OF MY DRIVEWAY, THE BRAKE PEDAL SLOWLY SANK TO THE FLOOR. I PUT THE TRUCK IN PARK AND GOT OUT OF THE VEHICLE. I NOTICED AN EXPANDING POOL OF HYDRAULIC FLUID FORMING UNDERNEATH THE TRUCK, JUST FORWARD OF THE REAR, DRIVER'S SIDE TIRE. UPON INVESTIGATION, THE RIGHT REAR BRAKE LINE HAD CHAFFED A HOLE ON THE FRAME RAIL RESULTING IN A LOSS OF BRAKES. HAD THIS BRAKE LINE FAILED AT ANY OTHER TIME, RATHER JUST BACKING OUT OF MY DRIVEWAY, IT COULD HAVE RESULTED IN DIRE CONSEQUENCES.
WHILE DRIVE THE ENGINE MADE A LOUD POPPING SOUND AND SHUT DOWN ENABLE TO START! *TR
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH HE HEARD A LOUD NOISE. HE NOTICED THAT THE FUEL TANK DETACHED FROM THE VEHICLE AND BOTH STRAPS WERE CORRODED. THERE WAS NO FUEL SPILLING OUT OF THE VEHICLE ONCE THE TANK FELL OFF. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000.
THE REAR TIRES ON MY PICK UP TRUCK FAILED - THE TREAD SEPARATED - WHILE I WAS OPERATING ON A ROUTE 81 IN VA. THE TIRES FAILED WITHIN 100 MILES OF EACH OTHER AND THEY BOTH FAILED THE SAME WAY. I WAS TOWING A TRAILER, BUT ALL LOADS WERE WELL BELOW THE MAXIMUM CAPACITY RATINGS. THE FIRST TIRE ALSO RUPTURED/DEFLATED. THE OTHER TIRE DID NOT DEFLATE - ONLY LOST THE TREAD. THE TREAD WOUND AROUND THE AXLE DAMAGING THE PARKING BRAKE CABLE. BOTH WHEEL WELLS AND REAR FENDERS WERE DAMAGED. *TR
1999 FORD F250 SUPERDUTY PICKUP GAS TANK STRAPS RUST AND FAIL FORD HAS RECALLED OVER 1 MILLION TRUCKS BUT NOT MINE EVEN HERE IN VT WHERE MY DEALER SAYS THE TRUCK IS UNSAFE FORD WILL NOT FIX IT. *TR
FRONT PASSENGER SIDE LOWER TRACK BAR BRACKETS WILL SHEAR OFF AND BREAK LEAVING TRACK BAR FLOATING IN FRONT END. THIS CAN OCCUR ON LOW MILEAGE VEHICLES AND IS REPORTED MANY TIMES ON THE INTERNET BUT NO ONE SEEMS TO DO ANYTHING ABOUT IT. THIS IS VERY DANGEROUS AND CAN LEAD TO A ROLLOVER OF THE VEHICLE. IT HAS HAPPEND SO MANY TIMES THAT AFTERMARKET COMPANIES ARE MAKING AFTERMARKET KITS TO REPAIR THE BROKEN BRACKETS NOW. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
TL* THE CONTACT OWNS A 1999 FORD F-250 EQUIPPED WITH COPPER DISCOVER A/T TIRES, 285/75/16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, A NOISE WAS HEARD COMING FROM OUTSIDE OF THE VEHICLE. AFTER REACHING A SAFE LOCATION, THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER TIRE EXHIBITED A SUBSTANTIAL AMOUNT OF TREAD SEPARATION. THE TIRE WAS REPLACED WITH A SPARE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. THE DOT NUMBER WAS UPYUC722503. THE VIN WAS NOT AVAILABLE.
1999 FORD 250 SUPER DUTY (NO INCLUDED IN CURRENT RECALL) FRONT FUEL TANK STRAP FAILED (BROKE), REAR STRAP VERY CLOSE TO BREAKING, PLASTIC FUEL TANK DROPPED APPROXIMATELY 6" WHEN FRONT STRAP FAILED. HAD REAR FAILED AS WELL, TANK WOULD HAVE DROPPED TO THE GROUND, WITH LIKELY ACCIDENT/FIRE. I HAVE REPLACED BOTH FUEL TANK STRAPS, REAR BROKE ON REMOVAL. *TR
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT WHEN EXITING HIS VEHICLE HE NOTICED THAT ONE OF THE FUEL TANK STRAPS HAD DETACHED FROM THE VEHICLE AND WAS COVERED WITH RUST. THERE WAS NO FUEL SPILLING FROM THE TANK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THEY WOULD LOOK INTO IT. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 91,000.
TL* THE CONTACT OWNS A 1999 FORD 250. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED THAT THE VEHICLE BEGAN TO WOBBLE ABNORMALLY. THE CONTACT ALSO NOTICED THAT ONE OF THE DRIVER SIDE TIRES WAS DETACHED FROM THE VEHICLE THROUGH THE DRIVERS SIDE MIRROR. THE CONTACT WAS ABLE TO STOP THE VEHICLE AT THE SHOULDER OF THE ROAD BEFORE THE VEHICLE DROPPED TO THE GROUND. THE VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP FOR INSPECTION BY THE INSURANCE COMPANY AND A MECHANIC. THE MECHANIC STATED THAT THE REAR DRIVER SIDE RIM WAS FATIGUED OR DISINTEGRATED AND CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS DECLARED AS DESTROYED AS A RESULT OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED WHILE DRIVING 35 MPH THE VEHICLE STARTED OVERHEATING. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE RADIATOR NEEDED TO BE REPLACED. THE DEALER REPLACED THE RADIATOR AND IMMEDIATELY AFTER THE VEHICLE WAS REPAIRED THE VEHICLE STARTED TO OVERHEAT AGAIN. THE CONTACT TOOK THE VEHICLE TO A DIFFERENT DEALER WHO INFORMED THE CONTACT THAT THE HEAD GASKET WAS CRACKED. THE CONTACT CALLED THE MANUFACTURER REGARDING THE CRACKED HEAD GASKET AND THEY STATED THERE WAS NO RECALL; THEREFORE, THERE WERE UNABLE TO OFFER ANY ASSISTANCE. THE CONTACT STATED THIS WAS A COMMON FAILURE WITH HIS YEAR, MAKE, AND MODEL. THE FAILURE MILEAGE WAS 167,000.
TL* THE CONTACT OWNS A 1999 FORD F250 SD. THE CONTACT STATED THAT THE SPEED CONTROL DEACTIVATION SWITCH WAS LEAKING BRAKE FLUID AND AS A RESULT, THE CRUISE CONTROL FAILED. THE VEHICLE WAS TO THE DEALER WHO REFUSED TO DO ANY REPAIRS SINCE THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 06V286000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS CONTACTED WHO STATED IT WAS UP TO THE DEALER WHETHER THEY WOULD REPAIR IT FREE OF CHARGE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 219,838 AND THE CURRENT MILEAGE WAS 241,000.
FORD F250 V-10 ENGINE BLOWNING OUT SPARK PLUGS
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .