1995 Ford F-250 Owner Complaints

SEAT BACK BOLTS BROKE WHILE DRIVING VEHICLE. LOST CONTROL ALMOST GOING OFF ROAD. IN MOTION, TWO LANE HIGHWAY DRIVING WINDING ROAD. BROKE ROUNDING A CURVE.

NHTSA ID

10862318

Incident

Mar 20, 2016

Mileage

226,000 mi

TL* THE CONTACT OWNED A 1995 FORD F-250. WHEN THE VEHICLE CAME TO A COMPLETE STOP, THE CONTACT NOTICED FLAMES UNDERNEATH THE HOOD. THE CONTACT SUSTAINED HAND INJURIES WHILE ATTEMPTING TO EXTINGUISH THE FIRE. MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT DISCOVERED THAT THE FIRE STARTED AT THE WIRING HARNESS. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

NHTSA ID

10818215

Incident

Dec 31, 2015

Mileage

103,000 mi

I REPLACED THE REAR BRAKES ON MY 1995 FORD F250. I PUT ON NEW DURALAST BRAKE SHOES (PART #358) FROM AUTOZONE. AFTERWARDS, THE EMERGENCY/PARKING BRAKE FAILED. I TOOK EVERYTHING APART AND TOOK A WHILE BEFORE I FOUND THE PROBLEM. AT THE TOP OF THE BRAKE SHOES THERE IS A HALF CIRCLE WHERE THE FRONT AND BACK SHOE MEETS AND THAT IS WHERE THE EMERGENCY/PARKING BRAKE CAM PUSHES THE SHOES APART. THE OEM SHOES HAVE A TALL SHOULDER AT THE VERY TIP TOP WHERE THE CAM PUSHES AGAINST THE REAR SHOE, THE DURALAST SHOE HAS A SHORTER SHOULDER AND ALLOWED THE CAM TO SLIP OVER THE TOP OF THE REAR SHOE CAUSING THE UNEXPECTED EMERGENCY/PARKING BRAKE FAILURE. *DT

NHTSA ID

10667440

Incident

Dec 20, 2014

Mileage

400,000 mi

TL* THE CONTACT OWNS A 1994 FORD F-250. THE CONTACT STATED THAT THERE WAS A VISIBLE FUEL LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ID

10662140

Incident

Dec 1, 2014

Mileage

130,000 mi

DRIVER SIDE SEAT BELTS WILL NOT RETRACT AUTOMATICALLY CAUSING CONCERN BELT WOULD FAIL TO WORK. *TR

NHTSA ID

10610443

Incident

Jul 14, 2014

Mileage

91,710 mi

1995 FORD F250. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH LEAKING GAS LINE, BRAKES, TRANSMISSION AND SEVERAL OTHER ISSUES WITH VEHICLE. CONSUMER STATES UNSATISFACTORY CUSTOMER SERVICE FROM SEVERAL DEALERSHIPS. *SMD THE MASTER CYLINDER, AIR PUMP, BRAKE PADS, SERPENTINE BELT, BRAKE LINES, ALTERNATOR, CRUISE CONTROL SENSOR, BATTERY, HEADLIGHT CONTROL AND UPPER SWITCH WERE ALL REPLACED. ALSO, THE STARTER SOLENOID SWITCH WAS REPLACED, AS WELL AS THE OIL PAN, THAT WAS RUSTED. THE TIRES WERE REPLACED, DUE TO CRACKING.

NHTSA ID

10524433

Incident

Feb 10, 1995

Mileage

495 mi

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED THAT THE PARKING BRAKE FAILED. THE CONTACT STATED THAT THEY WERE ABLE TO DRIVE THE VEHICLE WITH THE PARKING BRAKE ENGAGED. THE VEHICLE WAS TAKEN THROUGH STATE INSPECTION AND DID NOT PASS BECAUSE THE PARKING BRAKE WAS INOPERABLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 02V068000 (PARKING BRAKE) AND WAS TOLD BY THE MANUFACTURER THAT THE RECALL WAS ONLY FOR VEHICLES WITH MANUAL TRANSMISSIONS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 202,000. *TR

NHTSA ID

10510507

Incident

May 2, 2013

Mileage

202,000 mi

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED THAT THERE WAS A RECURRING FAILURE WITH THE FLY WHEEL IN WHICH THE FLY-WHEEL HAD TO BE REPLACED CONTINUOUSLY. THE FAILURE MILEAGE WAS 78,955 AND THE CURRENT MILEAGE WAS 86,760. *TR

NHTSA ID

10509446

Incident

Feb 8, 2010

Mileage

78,955 mi

1995 FORD F250. CONSUMER STATES ENGINE STALL WHILE DRIVING. *TGW WHEN THE ENGINE STALLED, THE CONSUMER HAD TO PUT THE SHIFTER INTO PARK OR NEUTRAL AND THE ENGINE WOULD RESTART. HE ALSO, STATED THE FUEL/WATER SEPARATOR WAS REPLACED. ALSO, OTHER REPAIRS INCLUDED, NEW HOSES, FAN CLUTCH, IDLER WHEEL, BRAKE PADS, RELAY ON GLOW PLUG, V-BELT, SEVERAL BATTERIES, THE LIFT PUMP AND THE SOLENOID ON THE STARTER. JB ALSO, THE O-RINGS WERE REPLACED. UPDATED 12/31/12 THE DEALER FOUND PROBLEMS WITH THE ICP INJECTOR PRESS, EBA EXH BACK PRESS, MAP, MANIFOLD AND ABS. UPDATED 03/14/13. *JB

NHTSA ID

10480485

Incident

Oct 1, 2012

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED THE VEHICLE HAD A DUAL FUEL TANK, ONE IN THE FRONT AND ONE IN THE REAR. WHILE DRIVING, THE FRONT FUEL TANK BEGAN TO LEAK. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THE FAILURE AND STATED THE CHECK VALVE INSIDE THE FUEL TANK CAUSED THE FAILURE. THE DEALER STATED THAT IN ORDER TO PERFORM A DIAGNOSTIC TEST THE CONTACT HAD TO PAY A FEE AND OFFERED NO OTHER ASSISTANCE. THE MANUFACTURER WAS NOTIFIED WHO STATED THE VEHICLE WAS NOT COVERED BY A WARRANTY AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 168,000. THE CURRENT MILEAGE WAS 170,000.

NHTSA ID

10465186

Incident

Jun 11, 2011

Mileage

168,000 mi

TL* THE CONTACT OWNS A 1995 FORD F-250. THE CONTACT STATED WHILE DRIVING 2 MPH AND ATTEMPTING TO PLOW SNOW, THE FRAME OF THE VEHICLE BENT WHEN CONTACT WAS MADE WITH THE SNOW. THE CONTACT EXITED THE VEHICLE AND NOTICED THAT THE FRAME WAS RUSTED NEAR THE FRONT END. THE CONTACT ATTEMPTED TO TOW THE VEHICLE, BUT IT FLATTENED WHEN IT WAS RAISED ONTO THE TOW TRUCK. THE DEALER AND MANUFACTURER WERE NOTIFIED AND PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 98,000.

NHTSA ID

10458672

Incident

Jan 21, 2012

Mileage

98,000 mi

1995 FORD F250. CONSUMER WRITES IN REGARDS TO PROBLEM WITH SPEEDOMETER CLUSTER. *TGW THE CONSUMER STATED WHEN HE SHIFTED FROM PARK TO DRIVE, OR FROM NEUTRAL TO REVERSE THE ENGINE WOULD SHUT OFF

NHTSA ID

10380653

Incident

Feb 1, 2011

TL* THE CONTACT OWNS A 1995 FORD F250. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE FIRE ORIGINATED FROM THE MASTER CYLINDER. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE AND THE HOOD, FENDER WALLS AND WIRES WERE DESTROYED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT TO WAIT UNTIL THE LEGAL DEPARTMENT CONTACTED HIM BEFORE ANY REPAIRS WERE PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 140,000. UPDATED 04/15/11*LJ UPDATED 12/19/2011 *LN

NHTSA ID

10373965

Incident

Jan 3, 2011

Mileage

148,000 mi

ENGINE COMPARTMENT FIRE ON A PARKED 1995 FORD F-250. THE FIRE SPREAD RAPIDLY THROUGHOUT THE ENGINE COMPARTMENT, AND CAUSED A CAR PARKED NEXT TO THE TRUCK TO CATCH FIRE. THE VEHICLE IS TOTALED. THE FIRE INVESTIGATOR FOR MOUNT PROSPECT, IL, INDICATED THAT IT WAS LIKELY AN INTERNAL ELECTRICAL FAULT. *TR

NHTSA ID

10340188

Incident

Jun 26, 1981

Mileage

97,000 mi

1995 FORD F-250 TRUCK CAUGHT FIRE. *TR

NHTSA ID

10336299

Incident

Jun 12, 2010

Mileage

200,000 mi

TL* THE CONTACT OWNS A 1995 FORD F250. THE CONTACT STATED HE WAS AWAKENED BY THE HORN OF HIS VEHICLE INDEPENDENTLY SOUNDING. THE CONTACT THEN OBSERVED FLAMES SHOOTING FROM THE DRIVER'S SIDE OF THE ENGINE COMPARTMENT. THE ENGINE WAS DESTROYED AND THE LEFT SIDE OF THE ENGINE, INCLUDING THE METAL, HAD MELTED. THE INSURANCE COMPANY WAS CONTACTED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 133,000.

NHTSA ID

10336166

Incident

Jun 13, 2010

Mileage

133,000 mi

1998 FORD F150 TRUCK (BRAKES LOCKING WHENEVER FAST BRAKING APPLIED, FORD F250 SAME THING TRUCK WAS WRECKED LAST NIGHT DUE TO THIS PROBLEM THANKS GOD NO ONE WAS KILLED ! 1997 FORD MUSTANG SAME PROBLEM ,BRAKES LOCK WHEN FAST PRESSURE IS APPLIED . HELP THESE VEHICLES ARE GOING TO KILL SOMEBODY . OH YES AND ON THE F250 WE NOW HAVE A TRAFFIC TICKET FOR FAILURE TO CONTROL SPEED AND THE TRUCK IS TOTALED. *TR

NHTSA ID

10314812

Incident

Feb 27, 2010

Mileage

300 mi

1995 FORD F-250 7.3 POWERSTROKE. CAM POSITION SENSOR (CPS) FAILURE , REPLACED AND TRUCK STARTED , GOES BAD OFTEN , WHEN IT DOES TRUCK DIES WONT START. OLD PART IS AVAILABLE. *TR

NHTSA ID

10245806

Incident

Oct 10, 2008

MY 1995 F250 FORD PICKUP BURNED UP WHILE PARKED. ABSOLUTELY NO-CONTACT FROM FORD MANUFACTURING SINCE THE INCIDENT - EVEN AFTER I TRIED TO CONTACT FORD ON SEVERAL OCAASIONS - COULD GET THROUGH TO PHONE OPERATOR BUT NO RESPONSE FROM FORD MOTOR CO.

NHTSA ID

10230519

Incident

Apr 1, 2000

Mileage

60,000 mi

1995 FORD F250 7.3L TURBO DIESEL : CAM POSITION SENSOR FAILED AFTER NUMEROUS, WORSENING EXPERIENCES WITH ERRATIC ENGINE PERFORMANCE. SENSOR REPLACED BY DEALER ON 12/07/2006 WITH TRUCK BARELY ABLE TO CONTINUE RUNNING. THIS CORRECTED THE PROBLEM AT THE TIME, BUT I AM NOW OCCASIONALLY EXPERIENCING THE SAME SYMPTOMS AGAIN. I HAVE SUBSEQUENTLY DISCOVERED THAT THIS IS A CHRONIC PROBLEM WITH THIS NAVISTAR ENGINE. MANY FORD VEHICLES HAVE BEEN RECALLED AS A RESULT, BUT MINE HAS NOT, DESPITE NUMEROUS VEHICLES OF MY MODEL YEAR (1995) EXPERIENCING THIS PROBLEM. *TR

NHTSA ID

10222397

Incident

Dec 7, 2006

Mileage

157,900 mi

TL*THE CONTACT OWNS A 1995 FORD F250. THE VEHICLE HAS FTS WESTLAKE CR861 TIRES. THE CONTACT STATED THAT HIS DOT NUMBER IS INCLUDED IN THE RECALL REGARDING TREAD SEPARATION. HE CALLED FTS AND THEY REFUSED TO PROVIDE ASSISTANCE. THEY STATED THAT THE BOSS WAS ON VACATION AND WOULD NOT BE ABLE TO HELP UNTIL HE RETURNED. THE CONTACT BELIEVES THAT THE TIRES SHOULD BE REPAIRED AS SOON AS POSSIBLE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 115,000.

NHTSA ID

10207713

Incident

Nov 1, 2007

TL*THE CONTACT OWNS A 1995 FORD F-250. THE AUTO MECHANIC CALLED ON BEHALF OF THE CONTACT. THE MECHANIC STATED THAT THE VEHICLE HAS A DEFECTIVE STORAGE TANK ASSEMBLY. HE STATED THAT A FUEL PUMP CHECK VALVE OVERFLOWED FROM ONE TANK TO THE OTHER AND SPILLED FROM THE FILTER CAP. HE AND THE CONTACT NOTIFIED FORD AND THEY STATED THAT NOTHING COULD BE DONE BECAUSE RECALL NUMBER 93V125000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) DOES NOT INCLUDE THE VEHICLE'S MAKE AND YEAR. FORD REFERENCED SERVICE RECALL BULLETIN NUMBER 93S68. THE CONTACT PAID $607 TO HAVE THE DEFECTIVE STORAGE TANK ASSEMBLY REPAIRED REPLACING THE ELECTRIC FUEL PUMP ASSEMBLY WHICH INCLUDES THE CHECK VALVE. THE DEALER INFORMATION WAS UNKNOWN. THE FAILURE MILEAGE WAS 174,921 AND CURRENT MILEAGE WAS 190,000. UPDATED 09/06/07 *TR

NHTSA ID

10200387

Incident

Sep 1, 2006

Mileage

174,921 mi

TL*- THE CONTACT STATED THAT WHILE PARKED IN THE DRIVEWAY THE 1995 FORD F 250 WITH 98000 FAILURE MILEAGE)CAUGHT ON FIRE, WITHOUT ANY WARNING. THE ENTIRE FRONT END, BACK TO THE BED CAUGHT ON FIRE. THERE WAS RECALL 05V38800) ON THE 1995 FORD F250. THE VEHICLE SUSTAINED MAJOR DAMAGE.

NHTSA ID

10184884

Incident

Feb 8, 2007

Mileage

98,000 mi

CONSUMER COMPLAINT CONCERNING THE RECALL ON HIS VEHICLE. *TS THE CONSUMER IS CURRENTLY AWAY AND UNABLE TO HAVE THE RECALL (05S28) REPAIR MADE ON THE CRUISE CONTROL DEACTIVATION SWITCH. THE CONSUMER WOULD LIKE TO KNOW IF THE RECALL WORK CAN STILL BE DONE A YEAR TO A YEAR AND A HALF FROM NOW. *NM

NHTSA ID

10171178

Incident

Jan 1, 1901

DT*: THE CONTACT STATED IN THE PAST TWO YEARS WHILE DRIVING AT ANY SPEED WITH THE CRUISE CONTROL ENGAGED, THE TURN SIGNALS DEACTIVATED THE CRUISE CONTROL. THIS OCCURRED DURING HALF OF THE INCIDENCES OF CRUISE CONTROL USE. THE VEHICLE WAS NOT DRIVEN VERY OFTEN THEREFORE IT WAS NOT TAKEN TO THE DEALER. DURING A LONG TRIP, THE VEHICLE WAS PULLED OVER BY A POLICE OFFICER WHO INDICATED THE TAIL LIGHTS WERE NOT WORKING WHICH INCLUDED THE RUNNING AND TURN SIGNAL LIGHTS. WHILE TESTING THE EMERGENCY FLASHERS, THE LICENSE PLATE LIGHTS BEGAN FLASHING. TWO RECALLS WERE OBSERVED BY THE CONTACT, #05V388000 AND #06V286000 PERTAINING TO THE VEHICLE SPEED CONTROL. WHEN THE DEALER WAS CONTACTED, THEY DETERMINED THE VEHICLE WAS NOT INCLUDED IN EITHER RECALL DUE TO THE VIN. THE MANUFACTURER WAS ALSO CONTACTED WHO RECOMMENDED THE CONTACT CALL THE NHTSA. THE CONTACT ALSO EXPRESSED THAT THE TURN SIGNAL AND THE CRUISE CONTROL SWITCH WERE BOTH LOCATED IN THE STEERING COLUMN WITHIN THE WIRING HARNESS.

NHTSA ID

10167665

Incident

Jul 14, 2006

Mileage

115,000 mi