Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 1996 Ford F-250 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 10 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
TL* THE CONTACT OWNS A 1996 FORD F250. THE CONTACT STATED THE VEHICLE WAS OFF AND THE KEY WAS OUT OF THE IGNITION WHEN THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE WHO STATED THAT THE FIRE STARTED UNDER THE HOOD FROM A WIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.
I HAD RAISED MY HOOD TO CHECK THE OIL, AND THERE WAS SMOKE FROM THE CRUISE CONTROL SHUT OFF SWITCH LOCATED AT THE END OF THE MASTER CYLINDER. IT CONTINUED TO SMOKE AND BURN UNTIL I UNPLUGGED IT. IT WAS NEARLY ON FIRE. THE BODY OF THE SWITCH IS MELTED AND BURNED. WHEN I WENT TO FORD DEALER ON 4/17/06 FOR A REPLACEMENT PART, THE PARTS MANAGER THOUGHT THAT THIS MIGHT BE PART OF THE RECALL THAT IS IN FORCE FOR THE F-150. THE SERVICE MANAGER CHECKED, AND IT DOES NOT APPLY TO THE F-250. THIS IS DISTURBING TO ME, BECAUSE THE SWITCH IS THAT SAME FOR EITHER VEHICLE. *NM
WHILE PARKED IN MY DRIVEWAY MY FORD F-250 WITH TWO GAS TANKS BURST INTO FLAMES AND TOTALED THE PICKUP. FORTUNATELY, THE TRUCK WAS BACKED INTO THE DRIVE WAY BECAUSE OTHERWISE THE HOUSE WOULD HAVE BURNED DOWN AND THE HOTWATER HEATER WOULD HAVE BEEN IGNITED. AS IT WAS, WE WERE LUCKY THAT THE FIRE AND POLICE DEPARTMENTS RESPONDED SO QUICKLY AND PREVENTED THE GAS TANKS FROM EXPLODING. BOTH LANES ON HWY 412 WERE SHUT DOWN, MANY PEOPLE GATHERED , ETC. THE MEDIA WAS THERE TAKING PICTURES. I AM CONCERNED THAT THIS MAYBE A WIRING DEFECT THAT COULD BE A COMMON PROBLEM IN OTHER FORD PICKUPS. I ALSO OWN A FORD F-360 DIESEL. I THINK THE PROBLEM SHOULD BE INVESTIGATED TO AVOID HAVING POSSIBLE FATALITIES. I HAVE INSURANCE, HOWEVER, IT WILL NOT PUT ME BACK WHERE I WAS. THE VEHICLE WAS EXTREMELY WELL MAINTAINED AND I PLANNED TO RETAIN IT FOR 20 OR MORE YEARS. MY CHILDREN WERE HOME, WHEN A PASSERBY POUNDED ON THE DOOR HYSTERICALLY TO TELL THEM THAT THE PICKUP WAS ON FIRE AND COULD BE A BOMB. MY 18 YEAR OLD DAUGHTER GOT THE OTHER CHILDREN OUT AND PHONED 911. THEN, SHE WENT BACK IN TO WAKE THE INDIVIDUAL WHO LIVES IN OUR BASEMENT AS SHE HEAR EXPLOSIONS. (THE FRONT TIRES EXPLODED AND IT COULD HAVE BEEN MUCH WORSE.) PLEASE INVESTIGATE AND LET ME KNOW WHAT YOU FIND OUT! THANK YOU, [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
CONSUMER STATED THE FACTORY INSTALLED WIRING HARNESS WHICH IS COMING OUT OF THE ENGINE COMPARTMENT FUSE BOX BEGAN HAVING ELECTRICAL PROBLEMS WHICH WAS CAUSING THE TURN SIGNAL AND BRAKE LIGHTS TO BE INOPERATIVE.*JB
AFTER LEAVING VEHICLE PARKED OVERNIGHT, NEXT DAY VEHICLE CAUGHT ON FIRE EVEN BEFORE CONSUMER GOT CLOSE TO VEHICLE. PLEASE PROVIDE MORE INFORMATION.*AK
WHILE DRIVING VEHICLE WOULD SHUT DOWN. HAPPENED AT STOP LIGHT OR SIGNS. CONTACTED FORD MANUFACTURER & INFORMED CONSUMER TO TAKE VEHICLE TO DEALER. AT DEALERSHIP, MECHANIC PLACED VEHICLE ON DIAGNOSTIC MACHINE & NO CODES APPEARED. TRANSMISSION COULD NOT SHIFT PROPERLY INTO EITHER 1ST OR 2ND GEARS WITHOUT MAKING GRINDING NOISES. MECHANIC REFUSED TO REPAIR VEHICLE DUE TO BEING OUT OF WARRANTY.*AK
VEHICLE WOULD NOT START. CONSUMER HAD CAR TOWED TO DEALER, AND THEY SAID VEHICLE NEEDED A TUNE UP AND COIL PACK REPLACE. DEALER SAID THAT PLUGS WOULD NOT COME OUT BECAUSE THEY WERE STUCK. SO CONSUMER WAS NOT ABLE TO DRIVE VEHICLE BECAUSE THE PLUGS WON'T COME OUT. DEALER CHARGED A $1000 TO TAKE THEM OUT.*AK THE LIGHT AT THE REAR OF THE VEHICLE FAILED. THE STARTER FAILED THREE TIMES. A/C FAILED. THE GEAR SHIFTER FAILED. THE EXHAUST SYSTEM FAILED. BRAKE CALIPER AND ROTOR FAILED. WIRES UNDERHOOD RUST OUT. POWER STEERING HOSE FAILED. *YH
STARTER HAS BEEN REPLACED 4 TIMES. VEHICLE ONCE ROLLED IN DRIVEWAY THROUGH THE GARAGE / WITHOUT THE KEY IN THE IGNITION AND BRAKES ON. DEALER KEPT REPLACING IT, BUT COULDN'T REMEDY PROBLEM. *AK
WHILE DRIVING IN SNOW CONDITIONS FAN BELT FELL OFF DUE TO SNOW HITTING THE UNDERBODY OF THE VEHICLE, ALLOWING ALL ELECTRICAL FUNCTIONS TO STOP. PRIVATE MECHANIC REPLACED THE BELT AFTER DEALER WAS UNABLE TO/REFUSED TO COVER COST. *AK *ML
2 DEFECTIVE WIRES WHICH GO OVER THE HEATER CORE SHORT CIRCUITED AND CAUSED THE VEHICLE TO STALL UNEXPECTEDLY AND WITHOUT WARNING. THIS COULD CAUSE A CRASH. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .