1997 Ford F-250 Owner Complaints

The contact owns a 1997 Ford F-250. The contact stated that the fuel strap failed and there was a hole in the fuel tank. The contact stated that there was fuel leaking from the vehicle. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 11V385000 (Fuel System, Gasoline) and 00V231000 (Fuel System, Gasoline). The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 133,000.

NHTSA ID

11610939

Incident

Aug 26, 2024

Mileage

133,000 mi

TIRE BLOW OUT ON FREEWAY CALIFORNIA I-5 AT 210 INTERCHANGE BFGOODRICH LT235/85 R16 LTR M+S 1655 MILES ON THE TIRES INSTALLED 05-20-2019 OF LAST YEAR

NHTSA ID

11316921

Incident

Mar 8, 2020

Mileage

134,560 mi

THE DRIVER SIDE SEATBELT DISCONNECTS RANDOMLY. THIS HAS HAPPENED WHILE I WAS IN PARK, DRIVING AND WHILE REVERSING. THIS HAS OCCURRED ON CITY STREETS AS WELL AS FREEWAY/HIGHWAY. IT HAS HAPPENED WHILE I WAS TURNING LEFT OR RIGHT, MAKING A U-TURN AS WELL AS DRIVING FORWARD. IT HAS ALSO HAPPENED WHILE I WAS ATTEMPTING TO CHANGE RADIO STATIONS. AS IT STANDS EVERY TIME I DRIVE THE TRUCK THE SEATBELT WILL DISCONNECT AT LEAST 3 TIMES.

NHTSA ID

11232638

Incident

Jun 10, 2019

Mileage

112,000 mi

FUEL TANK 1 SEEMS TO PUMP FUEL INTO TANK 2. FUEL SWITCH ON "FRONT" SEEMS TO INDICATE PROPER AMOUNT OF FUEL. FUEL SWITCH ON "REAR" ALWAYS READS FULL. SOMETIMES FUEL WILL FLOW OUT OF REAR TANK AS SOON AS FUEL CAP IS REMOVED. I DROVE ABOUT 75 MILES WITH THE FUEL SWITCH ON "REAR". WHEN I ARRIVED AT MY DESTINATION, I UNSCREWED REAR TANK CAP AND FUEL SPEWED OUT.......MAYBE A GALLON OR SO.

NHTSA ID

11100615

Incident

May 4, 2018

Mileage

130,745 mi

I HAVE HAD MY 1997 FORD F-250 FOR A FEW YEARS AND BESIDES AN ABI'S I'VEW PREVIOUS OWNER IT HASN'T GIVEN ANY ISSUE. THAT IS UP UNTIL A MONTH AGO WHEN MY INSTRUMENT CLUSTER UP AND QUIT WORKING. THERE WAS NO WARNING AND NO FUSES OR RELAYS FAULTY EITHER, I SPOKE WITH FRIENDS OF MINE WHO OWN SIMILAR MODEL YEARS OF MY TRUCK AND THEY SAY THEY HAVE HAD THE SAME ISSUE.

NHTSA ID

11051871

Incident

Nov 4, 2017

Mileage

253,400 mi

THE TRUCK WOULD STOP RUNNING WHILE DRIVING DOWN THE STREET, NOT START AFTER DRIVING, STOP SHUT OFF AND THEN WOULD NOT START. SOME TIMES IT MAY NOT START FOR SEVERAL DAYS THEN ALL OF A SUDDEN IT WOULD START UP AGAIN AND BE FINE FOR WEEKS THEN WOULD START THE WHOLE PROCESS OVER AGAIN. IT MAY STOP AT ANY TIME ANY WHERE WHETHER HIGHWAY OR CITY STREET. TOTAL LOSS OF POWER, ENGINE SHUTS OFF. I HAD MANY EXTREMELY DANGEROUS SITUATIONS, WITH FAMILY MEMBERS AND OTHER VEHICLES CAUSING THEM TO MAKE EVASIVE ACTIONS. THIS VEHICLE HAS A MANUFACTURES BUY BACK FROM ORIGINAL PURCHASER WHEN, NEW BUT NO EXPLANATION COULD BE FOUND. I SPOKE TO FORD AND THEY SAID THEY HAVE NO RECORD OF THE BUY BACK. IT IS ON THE TITLE ALSO.

NHTSA ID

10810623

Incident

Aug 28, 2015

Mileage

127,000 mi

THIS IS THE FOURTH TIME THIS HAS HAPPENED, THE SPARK PLUG SHOOTS OUT OF THE BLOCK AND SHORTLY AFTER YOU CAN SMELL GAS FUMES WITH IS AN OBVIOUS FIRE HAZARD. NOT ONLY IS IT EXPENSIVE TO FIND A MECHANIC WHO CAN COIL THE PLUG BACK INTO THE BLOCK, AFTER READING ABOUT IT THE SAME INCIDENT HAPPENS TO MANY OWNERS WHO HAVE THE SAME TRUCK AS I DO. YET, THERE HASN'T BEEN A RECALL.

NHTSA ID

10715974

Incident

Apr 20, 2015

Mileage

207,000 mi

TL*THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT FROM LOW GEAR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 168,000.

NHTSA ID

10679367

Incident

Jan 28, 2014

Mileage

168,000 mi

WHEN BUCKLING IN THE RETRACTOR FAILED. I AM NOT ABLE TO HAVE ANYONE IN THE PASSENGER SIDE OF MY TRUCK NOW. I SEE A SAFETY RECALL FOR THE SAME YEAR TRUCK BUT THE F150. I HAVE AN F250. ALL REPLACEMENT BELTS I HAVE FOUND HAVE HAD THE SAME PROBLEM. *TR

NHTSA ID

10672305

Incident

Jan 6, 2015

Mileage

130,000 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT HE WAS INVOLVED IN A CRASH WHERE THE AIRBAGS DID NOT DEPLOY AT THE POINT OF IMPACT. A POLICE REPORT WAS FILED AND AN INJURY WAS SUSTAINED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 278,000.

NHTSA ID

10618177

Incident

Jul 5, 2014

Mileage

278,000 mi

REF:EEN19-47774 (TO BE FWD BY MAIL) THE FRONT TANK STRAP ON THE VEHICLE FAILED AND THE TANK DROPPED UNTIL SUPPORTED BY SKID PLATE. SOME DIESEL FUEL SPILLED IN GARAGE, CREATING FIRE HAZARD BUT WAS CLEANED UP W/O INCIDENT. I CONTACTED DIEHL FORD IN BELLINGHAM WA AS NO FORD DEALER IN JUNEAU AK AT THAT TIME. I ORDERED AND THEY SENT 2 STRAPS (F72Z-9054-BA), BOLTS&NUTS WHICH I FOUND OUT LATER WERE NOT AUTHORIZED BY SAFETY RECALL 11S21! I CONTACTED THE LOCAL (TEMPORARY) FORD REPAIR FACILITY--EVERGREEN MOTOR WORKS RELATIVE TO THIS REPAIR AND THEY DISCOVERED THE SAFETY RECALL 11S21 AND STATED THAT ALASKA VEHICLES WERE NOT COVERED BY THIS RECALL.I COTACTED FORD MOTOR CO. BY EMAIL AND GOT THE SAME ANSWER. AS A SENIOR ELECTRICAL ENGINEER I KNOW THIS IS TOTAL BS AS ALASKA HAS MUCH WORSE WEATHER CONDITIONS THAN ANY OF THE :SOUTH 48" STATES COVERED BY SAFETY RECALL 11S21!! STANLEY FORD IS NOW THE LOCAL FORD DEALER BUT STILL COULD NOT FIX MY FORD F250 TANK STRAP UNDER THE RECALL BUT COULD FIX THE SAFETY RECALL 09S09 SPEED CONTROL MOD! IT SHOULD BE ALSO NOTED THAT THE DRIVER SEAT BELT BUCKLE FAILED ABOUT THE SAME TIME!! FORD CO. DID NOT SEEM INTERESTED IN THIS PROBLEM. I REPLACED THIS IMMEDIATELY AS I FEEL SAFETY IS VERY IMPORTANT! SIGNED/ [XXX] SR. ENGINEER INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

NHTSA ID

10592574

Incident

Jul 1, 2011

Mileage

248,000 mi

THE FUEL TANK STRAPS FAILED ON MY TRUCK CAUSING THE FUEL TANK TO DETACH AND MAKE CONTACT WITH THE GROUND WHILE THE VEHICLE WAS IN MOTION. I HAD THE TANK AND RELATED PARTS REPLACED AT A LOCAL SHOP. HOWEVER, THE MECHANIC INFORMED ME THAT THE MOUNTING POINTS FOR THE VEHICLE'S GAS TANK STRAPS WERE ALSO RUSTED AND NEW STRAPS COULD NOT BE INSTALLED IN THE NORMAL MANNER. WHEN THE RECALL WAS ISSUED I TOOK THE VEHICLE TO A LOCAL FORD DEALER THAT ATTEMPTED AN OFFICIAL REPAIR OF THE STRAPS BUT CONCLUDED THE MOUNTING BRACKETS WERE TOO DAMAGED TO INSTALL NEW STRAPS. WHETHER THE DEFECT WAS ALL CORROSION OR A COMBINATION OF CORROSION AND THE EFFECTS OF THE TANK BEING RIPPED FROM THE REMAINING MOUNTS WHEN THE STRAPS FAILED WAS NOT DETERMINED. THE DEALER AND I CALLED A FORD COMPANY REPRESENTATIVE WHO INITIALLY AGREED TO HAVE FORD COVER THE REPAIR OF THE VEHICLE BUT THIS WAS LATER RESCINDED BY A SUPERIOR AND I LEFT WITH AN UNSAFE, INCOMPLETE REPAIR. I WOULD LIKE THE NATIONAL HIGHWAY TRAFFIC SAFETY ASSOCIATION TO EXAMINE THE INCIDENCE OF STRUCTURAL AND MOUNTING BRACKET FAILURES DUE TO PREMATURE CORROSION NOT LIMITED TO THE STRAPS THEMSELVES. SEVERAL LOCAL MECHANICS HAVE COMMENTED THAT THEY SEE THIS VERY, VERY FREQUENTLY ON FORD TRUCKS OF THAT VINTAGE. MY TRUCK WILL NOT PASS INSPECTION WITH THE BRACKETS RUSTED AS THEY ARE. GIVEN THE SERIOUSNESS OF THE ISSUE, I BELIEVE THIS BEARS VERY CLOSE EXAMINATION. FORD SAYS IT HAS NOT PROCESS TO FOLLOW UP ON THIS CONCERN. I CONTINUE TO RECEIVE RECALL NOTICES BUT THEY ARE USELESS SINCE FORD WILL NOT ACKNOWLEDGE RELATED DAMAGE, DAMAGED CAUSED BY THE DEFECTIVE STRAPS AND/OR ADDITIONAL ISSUES THAT VERY LIKELY EXIST WITH THE CORROSION RESISTANCE OF SOME FORD TRUCK FRAMES. THIS TRUCK'S FRAME HAS CONTINUED TO EXPERIENCE SIGNIFICANT FRAME BASED RUST DETERIORATION WHILE OTHER PARTS OF THE VEHICLE SEEM TO FOLLOW A MUCH MORE NORMAL AGING PATTERN. *TR

NHTSA ID

10584323

Incident

Aug 10, 2010

Mileage

114,000 mi

DRIVING THE VEHICLE AT A SLOW SPEED OVER A GRAVEL ROAD, THE STRAPS AND/OR THEIR ATTACHMENT POINTS TO THE FRAME FAILED, ALLOWING THE TANK TO DROP AND MAKE CONTACT WITH THE ROAD. THIS WAS PRIOR TO FORD'S RECALL REGARDING THE STRAPS AND A REPAIR WAS MADE AT THE LOCAL SHOP. REPAIRS CONSISTED OF A NEW TANK, SENDING UNIT AND STRAPS. THE SHOP INDICATED THAT THE STRAPS HAD FAILED BUT NEW STRAPS COULD NOT BE FITTED BECAUSE, EITHER BECAUSE OF THE MECHANICAL ACTION OF TEARING AWAY THE TANK OR BECAUSE OF DETERIORATION, THE MOUNTING POINTS WERE NOT IN SUFFICIENTLY GOOD SHAPE TO REATTACH THE STRAPS. THE SHOP FASHIONED AN ATTACHMENT CONSISTING OF CHAINS SUSPENDING THE TANK FROM THE FRAME. SUBSEQUENTLY, ON RECEIVING FORD'S RECALL NOTICE REGARDING THE STRAPS, I TOOK THE VEHICLE TO A FORD DEALER WHO, AFTER AN ATTEMPT TO REPAIR, INDICATED THE VEHICLE NEEDED MORE WORK TO IMPLEMENT THE CORRECTION. THE DEALER (AND I) SPOKE TO A FORD REPRESENTATIVE WHO INITIALLY AUTHORIZED THE REPAIR BUT, WHEN THE EXTEND OF THE REQUIRED REPAIR WAS SOMEWHAT GREATER THAN ANTICIPATED, WAS OVERRULED BY SOMEONE ELSE AT FORD AND FORD DENIED THE REPAIR. THE TRUCK EFFECTIVELY COULD NOT BE INSPECTED IN THE FUTURE BECAUSE OF THIS DEFECT AND IT USE WAS LOST OTHER THAN OCCASIONAL USE ON THE PROPERTY. FOLLOW-UPS WITH FORD RESULTED IN THEIR CLAIM THAT FORD WAS ONLY LIABLE FOR THE STRAPS AND NOT ANY CONSEQUENTIAL OR RELATED DAMAGE AND NO OTHER RECOURSE WAS AVAILABLE. I WOULD LIKE THE NATIONAL HIGHWAY TRAFFIC SAFETY ASSOCIATION TO LOOK INTO THE RAMIFICATIONS OF LIMITING A SAFETY RECALL OF THIS NATURE TO THE DEFECTIVE STRAPS ONLY AND NOT THE CONSEQUENCES OF THE DEFECT.I AM ALSO REQUESTING AND EXAMINATION OF FORD'S WILLINGNESS TO SEND A VEHICLE BACK ONTO THE STREETS WITH AN UNCORRECTED KNOW SAFETY ISSUE. *TR

NHTSA ID

10584297

Incident

Aug 10, 2010

Mileage

114,000 mi

NOVEMBER,2005 WOKE UP TO HEAVY ODOR OF GAS COMING FROM MY ATTACHED GARAGE FOUND MY 1997 F-250 TRUCK HAD LOST GALLONS OVERNITE TOOK TO LOCAL FORD DEALER TOLD ME TANK RUSTY,UNDER SKID PLATE& SPARE TIRE. COST ME $734.27 I SAID IS THERE A PROBLEM WITH THESE TANKS,WAS ASKED ABOUT RECALL WAS TOLD NO RECALL-WENT HOME CALLED FORD MOTOR CO.TOLD THEM MY SITUATION &COSTS FOR A GARAGE KEPT,RARELY SAW SNOW & METICULOUSLY KEPT UP INSIDE & OUT TRUCK ,THEY WERE NO HELP AT ALL. SOLD THIS TRUCK APPROX 2006 TO MY FRIEND WHO OWNS A LOCAL HARLEY DAVIDSON BUSINESS,IT IS STILL RUNNING AND LOOKING GREAT. THEN BOUGHT 1997 F-150 AT LOCAL FORD DEALER 5/14/12 THAT I GOT A RECALL ON FOR THE SAME PROBLEM, HAD WORK DONE FOR THEFUEL TANK/STRAP ASY TOOK IT IN DONE AT NO COST,I BELIEVE I AM OWED A REFUND & INTEREST ON THE $734.27 ON THE 1997 F250 IN MY GARAGE ALSO WERE 2 HARLEYS ONE BEING A COLLECTIBLE I FEEL FORD CHOSE TO KEEP THIS MATTER HUSHED AND I COULD HAVE LOST EVERYTHING. I BELIEVE I AM DUE A REFUND ASAP I SHOULD NOT HAVE HAD TO PAY FOR FORD MOTOR COMPANY'S MISTAKES AND ATTEMPTED COVER UP. THANK YOU FOR YOUR TIME & ATTENTION TO MY LONG OVERDUE MATTER, ANY HELP TO RIGHT THIS WRONG WOULD BE GREATLY APPRECIATED. *TR

NHTSA ID

10563491

Incident

Nov 7, 2005

Mileage

114,967 mi

REAR GAS TANK LEAKING GAS.STRAPS APPEAR TO HAVE RUBBED HOLE IN TANK. *TR

NHTSA ID

10550552

Incident

Nov 1, 2013

Mileage

156,000 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE CABLE THAT HOLDS THE BRACKET AND THE SPARE TIRE WAS LOOSE. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 97,000.

NHTSA ID

10496285

Incident

Jan 4, 2013

Mileage

97,000 mi

TL* THE CONTACT OWNS A 1997 FORD F250. THE CONTACT STATED HE SMELLED FUEL COMING FROM THE REAR OF THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED FUEL LEAKING ONTO THE GROUND. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT UNDER RECALL. THE FAILURE AND THE CURRENT MILEAGE WAS 146,000. UPDATED 09/19/12*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED BY A LOCAL SHOP. THE MANUFACTURER OFFERED NO ASSISTANCE. UPDATED 09/19/2012 *JS

NHTSA ID

10470119

Incident

Aug 3, 2012

Mileage

146,000 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT AUTO REPAIR FACILITY FOR AN UNRELATED REPAIR WHEN THE TECHNICIAN DETECTED THAT FIVE OF THE SEVEN SPOKES ON THE FRONT DRIVER'S SIDE WHEEL WERE COMPLETELY RUSTED. THE OTHER THREE WHEELS EXHIBITED RUST HOLES AND CRACKS. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 145,318. UPDATED 09/05/12*LJ THE CONSUMER STATED THE PROBLEM WAS FOUND AFTER THE AXLE, HUB AND ROTOR WERE REPLACED AT A COST OF $ 1000.00. UPDATED 09/10/12

NHTSA ID

10466989

Incident

Jul 20, 2012

Mileage

145,318 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. WHILE THE VEHICLE WAS PARKED AND TURNED OFF, THE CONTACT NOTICED AN OVERPOWERING GASOLINE SMELL COMING FROM THE REAR OF THE VEHICLE. AFTER EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL TANK WAS LEAKING NEXT TO THE FUEL TANK STRAPS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT NHTSA CAMPAIGN ID NUMBER:11V385000 APPLIED TO HIS VEHICLE AND THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 180,000.

NHTSA ID

10450463

Incident

Mar 1, 2012

Mileage

180,000 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED WHILE DRIVING, THE WHEEL DETACHED COMPLETELY FROM THE VEHICLE. THE CONTACT STATED THAT SALT WAS LODGED INSIDE OF THE RIM, CAUSING THE RIM TO RUST. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRING THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 175,000. UPDATED 04/13/12 *BF UPDATED 05/12/2012 *JS

NHTSA ID

10447885

Incident

Oct 3, 2011

Mileage

175,000 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE COULD NOT BE REPAIRED BECAUSE THE FUEL TANK WAS ALSO RUSTED. THE MANUFACTURER DENIED ANY ASSISTANCE WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 142,000.

NHTSA ID

10439178

Incident

Dec 9, 2011

Mileage

142,000 mi

UPON READING ABOUT A FORD RECALLS 2.7 MILLION F150-250 TRUCKS I FOUND THAT MINE WAS INCLUDED IN THAT RECALL BY CALLING THE DEALERSHIP IN SCARSDALE, NY. MADE AN APPOINTMENT FOR SEPT 20, 2011 AND AFTER AN HOUR IN SERVICE THEY TELL ME THEY CANNOT REPLACE STRAPS BECAUSE THE STRAPS HAVE MADE A HOLE IN TANK (RUSTED THROUGH). I WAS SENT OUT OF THE DEALERSHIP WITH NOTICE THAT FORD WAS NOT GOING TO PAY FOR REPLACEMENT TANK AND THEY COULD NOT DO THE STRAP RECALL BECAUSE OF THE TANK. NO TEMPORARY STRAP WAS PLACED AROUND MY TANK TO KEEP IT FROM FALLING ONTO ROADWAY. SO I HAD BEEN DRIVING THE TRUCK READY TO DROP THE BOMB AT ANYTIME. ON SEPT 27, 2011 I WENT TO ANOTHER DEALERSHIP SMITH CAIRNS IN YONKERS AND AFTER A DAY WAS TOLD THE SAME THING. I HAVE AND WILL NOT REMOVE MY TRUCK FROM THIS DEALERSHIP UNTIL FORD MAKES IT SAFE TO DRIVE AT THEIR EXPENSE. *TR

NHTSA ID

10428211

Incident

Sep 16, 2011

Mileage

77,944 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE STORAGE: TANK ASSEMBLY: MOUNTING). THE CONTACT WAS INFORMED THAT THE RECALL REPAIRS COULD NOT BE PERFORMED BECAUSE THE RUSTED FUEL TANK STRAPS CAUSED FRICTION AND CREATED A HOLE IN THE FUEL TANK AND CAUSED FUEL TO LEAK. THE TANK WAS NOT COVERED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 77,989 AND THE CURRENT MILEAGE WAS 77,944. UPDATED 10/14/11 *BF THE COSNSUMER WAS ALSO INFORMED HE MUST PAY FOR A RUSTED FILLER NECK AT A COST OF $ 319.52.

NHTSA ID

10426426

Incident

Sep 20, 2011

Mileage

77,989 mi

TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE FUEL TANK WAS RUSTED, WHICH CAUSED A FUEL LEAK. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) BUT DID NOT WANT TO MOUNT A RUSTED TANK. NEITHER THE DEALER NOR MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 138,048. UPDATED 1/20/12 *CN THE CONSUMER STATED THE GAS TANK WAS LEAKING, DUE TO RUSTED MOUNTED STRAPS. UPDATED 02/01/12

NHTSA ID

10425588

Incident

Sep 1, 2011

Mileage

138,048 mi

TL* THE CONTACT OWNS A 1997 FORD F-250 HD. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A LOUD NOISE COMING FROM OUTSIDE OF THE VEHICLE AND ALSO SMELLED A SLIGHT BURNING ODOR. UPON REACHING THE DESTINATION THE CONTACT NOTICED BOTH FUEL TANK STRAPS WERE FRACTURED WHICH WERE SUPPORTING THE FRONT FUEL TANK. THE VEHICLE WAS EQUIPPED WITH A DUAL FUEL TANK. AS A RESULT OF THE DRAGGING OF THE FRONT FUEL TANK, THERE WAS DAMAGE WHICH CAUSED A LARGE FUEL LEAK. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10425566

Incident

Sep 15, 2011

Mileage

140,000 mi