Owner-reported complaints naming the brake system, filed with NHTSA
Data refreshed
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake. Every record below is an owner-reported complaint about the 2002 Ford F-250 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 20 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
The vehicle is equipped with adjustable brake and accelerator. The pedals should move up and down together. But the brake pedal is several inches higher causing a safety issue.
THE EMERGENCY PARKING BREAK DOES NOT WORK, I DON'T THINK IT EVER HAS. I HAVE HAD IT REPAIRED TWICE OVER THE YEARS AND IT QUICKLY QUIT BOTH TIMES. IT FEELS LIKE NORMAL RESISTANCE WHEN YOU PUSH IT IN WITH YOUR FOOT, AND DOES A NORMAL CLUNK AND RELEASE WHEN YOU RELEASE IT, BUT IT DOES NOT AT ALL HOLD THE TRUCK IN PLACE. IT IS A MANUAL TRANSMISSION SO IT IS VERY INCONVENIENT FOR THIS TO NOT WORK. AN EXAMPLE, THAT I HAVE TO DEAL WITH REGULARLY IS HOOKING UP TO A TRAILER. I NEED TO GET OUT TO SEE HOW CLOSE I AM AND I HAVE TO PUT IT IN GEAR (ONLY REVERSE WILL HOLD IT, THE OTHER GEARS WILL SLIP AND THE TRUCK WILL ROLL) AND TURN IT OFF TO GO LOOK.
TL* THE CONTACT OWNS A 2002 FORD F-250 SD DIESEL. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, A LOUD NOISE WAS EMITTED FROM THE VEHICLE. THE CONTACT ATTEMPTED TO ENGAGED THE BRAKES BUT THE VEHICLE WOULD NOT RESPOND. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE POWER STEERING AND BRAKE PULLEY HAD DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 260,000. *TR
2002 FORD F250 SUPER DUTY RUSTED STEEL BRAKE LINE WHICH CAUSED THE BRAKES TO FAIL AT 25MPH IN NEIGHBORHOOD. I HAVE 84,507 MILES ON THE VEHICLE AND DO NOT LIVE IN A HARSH ENVIRONMENT. THE LOCATION OF RUSTY AREA IS APPROXIMATELY 6 - 12 INCHES AWAY FROM JUNCTION SPLICE FOR THE FRONT BRAKES AND REAR BRAKE LINE. THE RUSTY BRAKE LINE IS THE LONG REAR BRAKE LINE. THE STEEL BRAKE LINE IS RUBBING A CABLE COVER THAT HAS METAL TAPE ON IT AND HAS CAUSED PREMATURE RUSTING. I LIVE IN EAST TENNESSEE AND THE WEATHER IS NOT HARSH. I PURCHASED THE VEHICLE NEW AND HAD BRAKE ROTOR PROBLEMS BEFORE AND HAD THE DEALER TO TURN THE ROTORS ONCE AND REPLACE THE FRONT ROTORS. THANK GOODNESS I WAS TRAVELING IN THE NEIGHBORHOOD WHEN THIS HAPPEN. THE WEEK BEFORE I DROVE THE TRUCK ON I-40 GOING TO NORTH CAROLINA THRU THE GORGE. WHAT IF IT HAPPENED THEN? *TR
TL*THE CONTACT OWNS A 2002 FORD F250. THE TURN SIGNAL AND BRAKE LIGHTS FAILED COMPLETELY. THE CONTACT BELIEVES THAT THE FAILURE WAS CAUSED BY THE WIRING HARNESS. THE FAILURE OCCURRED A YEAR AGO, BUT THE VEHICLE IS NOT DRIVEN FREQUENTLY. NO REPAIRS WERE MADE. THE VIN, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 62,940.
TL*THE CONTACT OWNS A 2002 FORD F250. WHILE DRIVING 65 MPH, THE CONTACT FELT A VIBRATION FROM UNDERNEATH THE VEHICLE. THE STEERING WHEEL SHOOK AND THE FRONT DRIVER SIDE TIRE DETACHED. THE VEHICLE DROVE OFF THE ROAD, CRASHED INTO SOME TREES, AND CAUGHT FIRE. BOTH THE DRIVER AND PASSENGER WERE INJURED. A POLICE REPORT WAS FILED. THE CONTACT STATED THAT THERE WAS NO BLOW OUT OR LOOSE TREADS THAT MAY HAVE CAUSED THE FAILURE. THE INSURANCE INVESTIGATION CONCLUDED THAT THE TIRE SELF-DETACHED FROM THE VEHICLE BECAUSE THE HUB AND CALIPER WERE DEFECTED. THE FAILURE MAY HAVE ALSO BEEN DUE TO HEAT FRACTURE THAT CAUSED THE CALIPER TO FAIL. AFTER INSPECTING THE VEHICLE, A MECHANIC SUGGESTED THAT THE FAILURE MAY HAVE BEEN CAUSED BY BAD METAL. THE MANUFACTURED DISTRIBUTED A QUESTIONNAIRE, BUT THE CONTACT HAS NOT RECEIVED A RESPONSE FROM FORD. THE VEHICLE AND TIRE ARE IN STORAGE. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 100,000.
2002 FORD F-250 BRAKE LINE ROTTED. LETTER TO MANUFACTURER NOT ATTACHED. *KB THE CONSUMER BELIEVES THE ROTTED BRAKE LINE MAY HAVE BEEN THE RESULT OF POOR MATERIAL. *NM
2002 FORD TRUCK / CONSUMER APPLIED BRAKES WHILE ROUNDING A CURVE AND THE FRONT WHEELS BEGAN TO SHIMMY.*MR *JB
DEFECT IN THE PARKING BRAKE MECHANISM ON 2002 FORD F250. *MR THE PARKING BRAKE NEVER WORKED AS INTENDED AND WAS NOT ADJUSTABLE. THE CONSUMER WAS FORCED TO DEPEND ON THE TRANSMISSION PARK POSITION TO HOLD THE TRUCK WHEN PARKED. THE PARKING BRAKE WOULD NOT HOLD THE TRUCK ON A MODERATE GRADE. *SC *JB
WHEN BRAKING AT ANY SPEED VEHICLE VIBRATED IN THE STEERING WHEEL. AS OF MAY 5, 2004 VEHICLE IS BEING REPAIRED THE THIRD TIME FOR BRAKE ROTORS. *AK
WHEN DRIVING AT AN UNDETERMINED SPEED VEHICLE VIBRATED. THE CONSUMER TOOK VEHICLE TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT BOTH FRONT ROTORS FAILED. THE CONSUMER STATED THAT FRONT ROTORS WERE REPLACED AT 38,000 MILES, AND CURRENTLY NEED TO BE REPLACED AGAIN AT 77,000 MILES. *AK THE ROTORS WOULD GET EXTREMELY HOT RATHER IN USE OR NOT. *SC
WHEN APPLYING THE BRAKES THE VEHICLE PULLS TO THE RIGHT. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *PH 2002 FORD F250 EXPERIENCING PROBLEMS WITH BRAKE EQUIPMENT. WHEN BRAKES ARE DEPRESSED THE VEHICLE PULLS TO THE LEFT AND EXPERIENCES VIBRATION. BRAKE PADS HAVE BEEN CHANGED BUT THE PROBLEM STILL CONTINUES.*MR
ABS BRAKING SYSTEM MADE A LOUD HOLLOW SOUND WHEN BRAKES WERE APPLIED. THERE WAS VIBRATION AND TREMBLING THROUGHOUT THE BRAKE PEDAL. *AK
WHEN THE BRAKES WERE BEING APPLIED VEHICLE WOULD PULL TO LEFT OR RIGHT.*JB. *AK
THE VEHICLE STALLED ON 5 DIFFERENT OCCASIONS, NUMEROUS PARTS WAS REPLACED, HOWEVER THE VEHICLE CONTINUED TO STALL, ALSO A FAULTY BRAKE RELAY SWITCH WAS REPLACED.*JB
CONSUMER NOTICE WHILE DEPRESSING THE BRAKE PEDAL BRAKES LOCKED UP CAUSING CONSUMER UNABLE TO STEER. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS
CONSUMER HAD THE BRAKES CHANGED TWO DIFFERENT TIMES, BUT PROBLEM STILL PERSISTS.DEALER HAS BEEN NOTIFIED.*AK THE VEHICLE DIES WHILE DRIVING DUE TO CAM SENSOR FAILURE. THE GAS GAUGE READS 1/2 FULL AFTER DRIVING 40 MILES DUE TO FUEL SENDING UNIT FAILURE. *YH
CONSUMER WAS DRIVING TO UNLOAD SOME TRASH. HE HIT BRAKES AND VEHICLE KEPT GOING UNTIL HE TOOK KEY OUT OF IGNITION. THEN, HE TRIED IT AGAIN, AND IT DID THE SAMETHING. CONSUMER CALLED DEALER, AND WAS TOLD TO HAVE VEHICLE TOWED BECAUSE IT WAS NOT SAFE TO DRIVE WITH THIS WAS HAPPENING. CONSUMER FOUND THAT WHEN HE APPLIED BRAKES CABLE SLIPPED, WHICH PREVENTED HIM FROM ACTUALLY APPLYING BRAKES.*AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHEN APPLYING BRAKES IN EMERGENCY SITUATIONS PEDAL FEELS HARD, AND THERE IS NO BRAKING ACTION, AT ANY SPEED. VEHICLE NOT TAKEN TO DEALER YET.*AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .