Owner-reported complaints naming the body or structure system, filed with NHTSA
Data refreshed
Body & structure reportsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
9
Latest Jul 2, 2025
Share of all reportsThis category as a share of every owner report on file for this model year. One report can name more than one component, so the categories overlap.
3%
of 266 total
Crash or fire reportedReports in this category whose submitter recorded that a crash or a fire occurred. The reporter's own answer on the NHTSA form, not a verified finding.
1
Injuries or deaths reportedTotals the submitters entered on their own reports in this category. Not verified by NHTSA and not a casualty statistic.
2
What this page shows
Reports naming the vehicle structure, frame, body panels, doors, hood and trim. Every record below is an owner-reported complaint about the 2012 Ford F-250 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Owner reports naming body or structure
Shown in the owner’s own words, exactly as filed
Body & structure
Filed Jul 2, 2025
I purchased this truck new in 2013 and it has only been serviced by Ford, except for an Air Lift Suspension Kit install to allow load leveling when towing. Low miles: 54484 actual. No collision damage, original paint. Date of repair:06/25/2025. Jenkins Ford RO#[XXX]. My truck has a Supercab (Extended Cab) with short rear doors that open to the rear. Both of these rear doors failed within 5 minutes of each other. Specifically, the inside door handles and opening levers on the forward facing side of the doors failed. This is absolutely a safety hazard because a Child, Senior, Handicapped person, pet, etc., would be trapped from making an emergency exit in case of accident or fire. A more athletic person may be able to pull themselves over the from bench seat to exit, but still delaying the exit and dangerous. There were no warnings to alert anyone of the failures. Jenkins Ford (Crystal River, FL) diagnosed the problem and made the costly repair. Both door cables were replaced, no warranty. Cost: $1558.80 I called Ford USA Customer Relations (800) 392-3673 at 1:16PM EDT on 06/24/2025. C/S Rep "Kisha" said Ford would not assist in any goodwill for repair of this safety item. I researched this problem online an apparently, this is a common failure due to plastic parts holding the cables. I acknowledge that this vehicle is over 10 years old, but feel that this is a safety item Ford should stand behind. People keep vehicles longer these days and mine has been garaged, meticulously maintained by Ford, and has extremely low miles. Jenkins Ford did a very professional repair and I'm very happy with this dealer. The Ford Motor Company should be required to recall and repair this problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ID
11670798
Incident
Jun 21, 2025
Body & structure
Filed May 8, 2025
The contact owns a 2012 Ford F-250. The contact stated that while driving at slow speeds, the rear end of the vehicle seemed to be falling apart. The contact stated that the failure was due to the cab mount bushing. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The approximate failure mileage was 100,000.
NHTSA ID
11659662
Incident
May 7, 2025
Mileage
100,000 mi
Body & structure
Filed Aug 9, 2021
1 injury reported
Today, while my wife was exiting my F250, the passenger A pillar handle failed and my wife fell to the ground. She sustained injuries to her hand and leg.
NHTSA ID
11428398
Incident
Aug 9, 2021
Body & structureDriver assistanceSteering
Filed Nov 22, 2019
EXPERIENCED 'DEATH WOBBLE' WHILE DRIVING A HIGHWAY 287 (SAME SPEED NO STOP AND GO WITH TRAFFICS). TRUCK WAS SUDDENLY VIOLENTLY SHAKING AND WOBBLING CAUSED MY HUSBAND ALMOST LOST CONTROL. HE WAS ABLE TO PULL OVER THE TUCK BUT SCARED HIM TO DEATH. WE HAD IT TOWED TO A DEALERSHIP AND THEY CONFIRMED THE DEATH WOBBLE PROVIDED A QUOTE.
NHTSA ID
11281814
Incident
Nov 14, 2019
Mileage
130,000 mi
Body & structure
Filed May 29, 2019
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT THE FLATBED OF THE VEHICLE WAS CORRODED AND CONTAINED A LARGE HOLE. THE CONTACT STATED THAT THE DESIGN OF THE FLATBED TRAPPED WATER AND SALT, WHICH CAUSED THE HEAT SHIELD AND EXHAUST ATTACHED TO THE BOTTOM OF THE VEHICLE TO FAIL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE CONTACT CALLED THE MANUFACTURER AND WAS PROVIDED CASE NUMBER: CAS-21767132. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
NHTSA ID
11210537
Incident
May 22, 2019
Mileage
115,000 mi
Body & structure
Filed Dec 11, 2017
SUNROOF BROKE WHILE ATTEMPTING TO CLOSE. THE PLASTIC RAILS USED TO OPEN AND CLOSE THE SUNROOF BROKE AND THE SUNROOF IS STUCK IN THE OPEN POSITION.
NHTSA ID
11054045
Incident
Oct 2, 2017
Mileage
120,000 mi
Body & structure
Filed Jun 9, 2016
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE FRONT END OF THE VEHICLE HIT A BUMP CAUSING A "DEATH WOBBLE". THE CONTACT ALMOST LOSS CONTROL OF THE VEHICLE BUT WAS ABLE TO REGAIN CONTROL AT APPROXIMATELY 10 MPH. THE VEHICLE WAS TAKEN TO BE REPAIRED BUT THE FAILURE RECURRED. THE REPAIRS WERE UNKNOWN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000.
NHTSA ID
10873435
Incident
Nov 18, 2015
Mileage
95,000 mi
Body & structureSuspension
Filed Jun 22, 2015
TL* THE CONTACT OWNS A 2012 FORD F-250. WHILE DEPRESSING THE BRAKE PEDAL AT LOW SPEEDS, THE RUBBER STOPPER STRUCK THE AXLE AND CREATED A LOUD BANGING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,000.MA 08/11/15 MA 10/8 THE CONSUMER STATED THE VEHICLE WAS REPAIRED. THE SHOCK ABSORBERS WERE REPLACED. UPDATED 8/14/15 *JS
NHTSA ID
10726608
Incident
Nov 3, 2014
Mileage
1,000 mi
AirbagsBody & structure
Filed Jul 16, 2014
Crash reported1 injury reported
COLLIED WITH A VEHICLE STOPPING TO MAKE A LEFT HAND TURN. DAMAGES INCLUDE FRAME DAMAGE, SMASHED IN FRONT END. HAD TO KICK THE DRIVER DOOR OPEN TO GET OUT. NO AIRBAGS EVER DEPLOYED. ENDED UP WITH HEAD LACERATIONS. *TR
NHTSA ID
10610938
Incident
Jun 12, 2014
Mileage
59,667 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Other components reported on this vehicle
Categories with enough reports to have a page of their own