2012 Ford F-250 Brakes Problems

SPONGE BRAKE PEDAL DEALER SAID NOTHING IS WRONG

NHTSA ID

11416678

Incident

May 15, 2021

Mileage

53,000 mi

ON MARCH 27,2021. I WAS RETURNING FROM A SHOPPING TRIP. I PULLED INTO MY DRIVE WAY PARKED, TURNED OFF THE TRUCK. OPENED DOOR AND IMMEDIATELY SMELLED HOT BRAKES. I TURNED LOOKED TO REAR OF VEHICLE NOTICED SMOKE RISING FROM DRIVER AND PASSENGER SIDE. I IMMEDIATELY GRABBED GARDEN HOSE A SPRAYED DOWN THE BRAKES REAR AND FRONT, WATER TURNED TO STEAM INSTANTLY. AS TO WHEN THE BRAKES LOCKED UP I CANNOT PIN POINT, BUT GOING TO SAY WHEN I TURNED TO MY STREET WHICH IS JUST UNDER 3/4 MILE FROM HOUSE. ONCE I WAS SURE VEHICLE WAS SAFE I CALLED SERVICE DEPARTMENT TO MAKE AN APPOINTMENT TO INITIATE REPAIRS. REPAIRS COMPLETE APRIL 6, 2021. I DID NOT RECEIVE ANY REAL ANSWER AS TO THE CAUSE.

NHTSA ID

11406765

Incident

Mar 27, 2021

Mileage

128,300 mi

TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING, HE HAD TO SLAM ON THE BRAKES TO AVOID CRASHING INTO A VEHICLE THAT HAD TURNED IN FRONT OF HIM. THE BRAKE PEDAL WENT SOFT WHILE PRESSED DOWN. THE VEHICLE WAS TAKEN TO RON TIRAPELLI FORD (4355 W. JEFFERSON ST, SHOREWOOD, IL 60404, (815) 725-3033). THE DEALER CHECKED THE BRAKES AND RECOMMENDED THAT THE BRAKE PADS BE CHANGED AND THE BRAKE LINES BE BLED TO REMOVE AIR IN THE SYSTEM. THE CONTACT PICKED UP THE VEHICLE AND TESTED THE BRAKE PEDAL AND THE BRAKE PEDAL WENT DOWN TO THE FLOORBOARD. THE CONTACT HAD THE MANAGER STEP ON THE BRAKE PEDAL AND IT WENT DOWN TO THE FLOOR. THE DEALER MADE AN APPOINTMENT THE NEXT DAY AND PROVIDED COMPLETE SERVICE CHECK. THE FAILURE RECURRED AGAIN WHILE DRIVING 45 MPH. THE CONTACT TOOK THE VEHICLE BACK TO THE SAME HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

11383663

Incident

Jul 1, 2016

Mileage

95,000 mi

SOFT PEDAL, BRAKE SYSTEM PEDAL PRESSURE HAS MOVEMENT WHEN STARTING. WHILE DRIVING HAS LIMITED STOPPING POWER.

NHTSA ID

11170089

Incident

Jan 15, 2019

Mileage

30,000 mi

TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND HESITATED TO RESPOND WITHOUT WARNING. THE CONTACT MENTIONED THAT THE BRAKE PEDAL HAD TO BE DEPRESSED TO THE FLOORBOARD FOR THE VEHICLE TO BE STOPPED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 32,000. UPDATED 04/20/16*LJ

NHTSA ID

10839902

Incident

Oct 17, 2015

Mileage

32,000 mi

THE VEHICLE'S ENGINE WILL STALL (CUT OFF) WITHOUT ANY INDICATION OR NOTICE DURING MOTION OR AT A STOP. THIS HAS HAPPENED AT CITY SPEEDS (LESS THAN 25 MPH) AND AT HIGHWAY SPEEDS (GREATER THAN 55 MPH) THE VEHICLE WILL NOT IMMEDIATELY START BUT MAY START AFTER STANDING FOR SOME TIME. THIS CAUSES POWER STEERING, POWER BRAKES AND OTHER IMPORTANT SAFETY FEATURES TO BE DEGRADED OR LOST.

NHTSA ID

10787647

Incident

Oct 24, 2015

Mileage

49,000 mi

WE WENT TO SLOW DOWN AND THE BRAKES DIDN'T FEEL RIGHT AND WASN'T STOPPING THE TRUCK BY THE TIME WE DID STOP THE BRAKES WHERE SMOKING. *TR

NHTSA ID

10597305

Incident

Jun 6, 2014

Mileage

27,000 mi

WE CAME TO A RED LIGHT AND THE BRAKES FAILED TO STOP WE HAD TO PUT THE TRUCK TO A SUDDEN STOP BY USING THE TRAILER SWITCH. WE CALLED THE DEALER BUT THEY SAID THEY COULDN'T HELP SO WE HAD TO MAKE THE REPAIRS ON A BACK ROAD WE COULD NOT FIND ANY COMPANY WILLING TO TOW TRUCK AND TRAILER SO WE GOT A RIDE TO A PARTS STORE AND GOT THE PARTS OEM BRAKE PADS AND CALIPERS, PROBLEM IS THE TRUCK IS SHOWING SIGNS OF SAME ISSUE WITH 130 MILES ON REPAIR. *TR

NHTSA ID

10594419

Incident

May 16, 2014

Mileage

28,000 mi

WHEN DRIVING DOWN THE ROAD AND I START TO BRAKE THE VEHICLE MY FOOT TRAVELS HALF THE DISTANCE TO THE FLOOR BEFORE THE BRAKES ENGAGE AND START TO STOP VEHICLE. THIS HAPPENS ON HIGHWAY AND RESIDENTIAL DRIVING. MADE MY CONCERNS KNOWN TO FORD DEALER BUT I GET A PRINTOUT OF HOW "NEW" BRAKES WORK. WHEN I MADE IT CLEAR TO AVOID ACCIDENTS I HAD TO PUMP BRAKES IN ORDER TO ENGAGE BRAKES TO STOP VEHICLE, DEALER AGAIN INDICATES THAT IS THE WAY IT IS TO WORK. HAD DEALER SERVICE REPRESENTATIVE CLIMBED INTO TRUCK AND DEPRESS BRAKES WHILE VEHICLE WAS STOPPED WITH TRANSMISSION IN PARKED AND DECLARED "NO PROBLEMS" AND "BRAKES WORKED AS IT SHOULD". WHEN I AGIAN MENTION IT ONLY HAPPENS WHEN DRIVING OR VEHICLE IN MOTION, DEALER AGAIN ADVISES THIS IS THE NEW BOOSTER. I HAVE REPEATEDLY MENTION THAT THE BRAKES OR BOOSTER ARE DEFECTIVE I GET NO REPONSE FROM DEALER. REQUEST NHTSA INVESTIGATE THE PROBLEMS WITH THE BRAKES. I HAVE AVOIDED ACCIDENTS BY PUMPING BRAKE PEDAL TO ENGAGE BRAKES SOONER. *TR

NHTSA ID

10548527

Incident

Jun 4, 2012

Mileage

1,000 mi

I DROVE THRU 12" OF SNOW ON MY ROAD TO MY HOME. THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD NO BRAKING POWER AT ALL. I CHECKED IF THERE WAS ANY LEAKS AND THERE WERE NONE. THE TEMP WAS ABOUT 20 DEGREES AT THIS TIME. I WAITED UNTIL THE NEXT DAY WHEN THE TEMP WAS AT 30 DEGREES AND TRIED THE BRAKES AGAIN AND THEY WERE AT FULL STRENGTH. I CALLED DEALER AND WAS TOLD THEY NEVER HEARD OF PROBLEM BEFORE. I CALLED FORD CUST CARE DEPT AND DESCRIBED WHAT HAPPENED. THEY TOLD ME THAT THEY WOULD NEED TO DUPLICATE THE BRAKE ISSUE TO REPAIR IT.. AT THIS POINT NEITHER DEALER OR FORD IS WILLING TO DRILL DOWN TO FIND OUT WHAT HAD HAPPENED. I DO NOT FEEL SAFE IN THIS VEHICLE AT THIS TIME. *TR

NHTSA ID

10497702

Incident

Feb 9, 2013

Mileage

8,000 mi