2004 Ford F-550 Sd Owner Complaints

TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED; HOWEVER, THE FAILURE RECURRED APPROXIMATELY ONE MILE LATER. THE VEHICLE DID NOT RESTART AND WAS TOWED TO THE CONTACT'S JOB. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WAS FAULTY, MELTED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 155,862.

NHTSA ID

10825172

Incident

Feb 1, 2016

Mileage

155,862 mi

TL* THE CONTACT OWNS A 2004 FORD F-550 SUPER DUTY. WHILE THE LINK WAS IN THE AIR WITH A WORKER LOCATED IN THE BUCKET, THE LINK FRACTURED WITHOUT WARNING. THE WORKER'S BUCKET CAME DOWN WITH FORCE CAUSING INJURY TO HIS HEAD, BACK, AND PELVIC AREA. THE WORKER RECEIVED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT STATED THAT THE VIN WAS INCLUDED IN AN EQUIPMENT MANUFACTURER RECALL FOR A LINK FAILURE, BUT THE CONTACT DID NOT RECEIVE A NOTIFICATION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND RECALL NUMBER WERE NOT AVAILABLE.

NHTSA ID

10781529

Incident

Sep 7, 2015

THE TRUCK IN QUESTION IS A 2004 FORD F-550 DIESEL. UPON DEPRESSING GAS PEDAL, TRUCK STALLED AND NO LONGER WORKED PROPERLY. TRUCK WAS TOWED TO LOCAL FORD DEALER WHERE IT WAS DETERMINED THAT THE FUEL TANK WAS SUFFERING FROM RUST INSIDE THE TANK. BASED ON THE WORK DONE, RUST PARTICLES THAT FORMED INSIDE THE TANK WERE FORCED THROUGH THE FUEL PUMP AND FILTER DAMAGING BOTH AND CAUSING AN ISSUE WITH THE FUEL INJECTORS. I CALLED FORD DIRECTLY TO ASK ABOUT ANY RECALLS FOR THIS ISSUE AND THEY TOLD ME THERE WAS NO RECALL CURRENTLY FOR THIS PROBLEM. THEY SAID THE TRUCK WAS OUT OF WARRANTY AND THERE WAS NOTHING THEY COULD DO ABOUT THE $3000 BILL FROM THEIR INDEPENDENT DEALER. I FIND IT HARD TO BELIEVE THAT A TRUCK THAT IS NOT USED FOR PLOWING AND ONLY HAS 36,000 MILES WOULD SUFFER SUCH A CATASTROPHIC FAILURE. THE REPLACEMENT TANK WAS MADE OF SOME TYPE OF PLASTIC NOT THE OEM METAL TANK THAT WAS ORIGINALLY USED ON THE TRUCK WHICH MADE ME QUESTION THE DEALER. THEY SAID THEY HAD SEEN THIS HAPPEN ON TANKS OF THIS MODEL QUITE OFTEN SO THEY REPLACED THEM WITH A PVC MODEL. UPON FURTHER DISCUSSIONS THROUGH BLOGS AND OTHER ONLINE RESOURCES I WAS ABLE TO FIND A FEW OWNERS OF THE SAME TRUCKS THAT HAD SIMILAR PROBLEMS. THESE DISCUSSIONS PROMPTED ME TO FILE THIS CLAIM. *TR

NHTSA ID

10499917

Incident

Feb 13, 2013

Mileage

36,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 45 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TURBO CHARGER WOULD HAVE TO BE REPLACED. AFTER THE REPAIR THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER A SECOND TIME WHERE THE FUEL PUMP WAS REPLACED BUT TO NO AVAIL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE LAMINATION OF THE FUEL TANK WAS PEELING AND ENTERING THE FUEL SYSTEM AND THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

NHTSA ID

10470140

Incident

May 15, 2009

Mileage

45,000 mi

2004 F550 DIESEL. CONSUMER STATES VEHICLE HAS A FAULTY HEAD-GASKET *TGW THE CONSUMER STATED THE TRUCK WOULD ONLY RUN FOR 20 MINUTES BEFORE IT OVERHEATED. THE CONSUMER WAS INFORMED IT COST CLOSE TO 10,000 TO FIX THE TRUCK. *JB

NHTSA ID

10466085

Incident

Jul 2, 2012

TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT PRIOR WARNING. THE VEHICLE FAILED TO RESTART AND IT WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THE FAILURE WAS CONTRIBUTED TO THE HIGH PRESSURE OIL PUMP. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 8/8/12 *CN UPDATED 08/15/2012 *JS

NHTSA ID

10460223

Incident

May 30, 2012

Mileage

30,000 mi

2004 F550 TRUCKS HAVE THE INSIDE GAS TANKS PAIN OR LINEN, PEELING OR DELAMINATING. THIS CAUSE THE MOTOR TO STALL. BECAUSE ALL THE LITTLE PIECES OF PAINT GOING TO THE INJECTORS.FOR 3 YEARS (2009-2010 AND 2011) IN A ROW, WE NEED TO FIX THE PROBLEM OURSELVES COSTING US $3,500 EVERY TIME -THIS YEAR IS THE SAME PROBLEM. LAST YEAR I CALL FORD MOTOR CO, AND THEY TOLD ME THAT WERE NOT ENOUGH COMPLAINTS TO MAKE A RECALL. BUT IF YOU CHECK GOGGLE.COM AND GO TO 2004 F550 COMPLAINT'S PAGE YOU WILL SEE HUNDREDS AND HUNDREDS OF COMPLAINTS. WE BOUGHT THE TRUCK ON DEC 2004 AND PAID FOR IT $56,000- DOLLARS, WAS NOT A CHEAP TRUCK. ALSO, I WERE TALKING TO A LOT OF F550'S OWNERS ( MOST OF THEM LANDSCAPERS)AND THEY HAD OR HAVE THE SAME PROBLEM. SO..........FORD CO IS WASHING THE HANDS, AND NOT DOING A RECALL ON THIS. *TR

NHTSA ID

10454588

Incident

Apr 10, 2009

TL-THE CONTACT OWNS 2004 FORD F550 SUPER DUTY. THE CONTACT STATED THAT THE FUEL TANK LINING FAILED AND WAS REPLACED TWICE. THE FAILURE WAS NOT CORRECTED HOWEVER AND THE FUEL TANK LINING REPEATEDLY FAILED, CONTAMINATING THE FUEL SYSTEM UPON EACH RECURRENCE. THE FAILURE WAS NOT REPAIRED. THE MANUFACTURE ADVISED THE CONTACT THAT THE FUEL LINING FAILURE WAS NOT A MANUFACTURING DEFECT. THE FAILURE MILEAGE WAS 47,000 AND THE CURRENT MILEAGE WAS 117,000. KMJ

NHTSA ID

10454492

Incident

Jul 27, 2004

Mileage

47,000 mi

VEHICLE (2004 DIESEL F550 TRUCK) WAS TRAVELING ON I-405 DURING RUSH HOUR TRAFFIC WHEN THE VEHICLE STALLED. DEALER SAYS THAT THE PAINT/LAMINATE INSIDE THE FUEL TANK IS CORRODING AND PIECES OF DEBRIS ARE BEING FED INTO THE FUEL SYSTEM CAUSING SUDDEN STALLING OF VEHICLE. NO OFF-ROAD DIESEL HAS EVER BEEN USED IN THE TANKS--STANDARD DIESEL FUEL ONLY. *TR

NHTSA ID

10442595

Incident

Dec 21, 2011

Mileage

83,000 mi

TL* THE CONTACT OWNS A 2004 F-550 SD. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED STEAM COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIANS ADVISED THAT THE TURBO HAD OVER BOOSTED AND CAUSED THE ENGINE TO FAIL. THE ENGINE WAS REPLACED AND AFTER THE REPAIRS, THE CONTACT NOTICED WHITE SMOKE FROM THE EXHAUST PIPE AND AN ANTI-FREEZE SMELL EMITTING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE INNER COOLER HAD TO BE REPLACED AND THE HEAD GASKET EXHIBITED A LEAK. THE INNER COOLER WAS REPLACED. THE APPROXIMATE FAILURE MILEAGE WAS 6,500. UPDATED 10/05/11

NHTSA ID

10420003

Incident

Mar 29, 2006

Mileage

6,500 mi

PROBLEM 1: IN 2004 I PURCHASED A NEW FORD F-550 WITH THE GASOLINE V10. ABOUT ONE MONTH AFTER OWNING THE TRUCK THE THROUGH-OUT BEARING ON THE CLUTCH STARTED MAKING NOISE AND HAS DONE SO. THIS YEAR WITH ONLY 49,000 MILES ON THE TRUCK NOW IT DOES NOT WANT TO GO INTO GEAR SOMETIMES.BY THE TIME I CONTACTED MY DEALER HE SAID THAT THE TRUCK WAS OFF WARRANTY. DID THEY SELL CHEAP BEARINGS IN THESE TRUCKS, BECAUSE MY LAST F350 I HAD FOR 14 YEARS WITHOUT ANY PROBLEMS. PROBLEM 2: EVER SINCE I HAVE OWNED THIS TRUCK. WHEN YOU ARE SITTING AT A LIGHT AND GET READY TO GO. ALL OF A SUDDEN THE ENGINE SHUTS DOWN FOR ABOUT 2 SECONDS AND THEN GOES. *TR

NHTSA ID

10419489

Incident

Mar 20, 2004

Mileage

100 mi

TL* THE CONTACT OWNS A 2004 FORD F-550. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER DIAGNOSED THAT THE FUEL INJECTOR WIRE WAS MELTING ON THE ENGINE. THE VEHICLE WAS REPAIRED AND RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE FAILURE MILEAGE WAS 116,000 AND THE CURRENT MILEAGE WAS 121,164.

NHTSA ID

10417113

Incident

Jun 16, 2011

Mileage

116,000 mi

TL*THE CONTACT OWNS A 1997 FORD F-550 SUPER DUTY. THE CONTACT STATED THE VEHICLE WOULD STALL WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THE VEHICLE WAS STALLING DUE TO DELAMINATION OF THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 144,250.

NHTSA ID

10405893

Incident

Jun 1, 2011

04 FORD F550 SD DUMP TRUCK WAS BOUGHT NEW ON 12/04.. IN APRIL 2005 TRANSMISSION LEAKED FLUID WHILE IN PARK AND TRUCK WAS TOWED TO DEALER. THE DEALER CLAIMED CAUSE OF PROBLEM WAS DUE TO LOOSE BOLTS ON TRANS CASE. TRANSMISSION CONTINUED TO SLIP BUT DEALER COULD NOT FIND PROBLEM. FEBRUARY 2006, APPROXIMATELY 16,000 MILES ON TRUCK, TRANSMISSION COMPLETELY FAILS. TRUCK TOWED TO DEALERSHIP AND NEW TRANSMISSION INSTALLED. ON JUNE 2008 (APPROXIMATELY 56,000 MILES) WHILE DRIVING ON MAJOR HIGHWAY, TRUCK BEGINS TO LOSE POWER AND BLACK SMOKE POURS OUT OF MUFFLER. THE TRUCK WAS DRIVEN TO LOCAL DEALERSHIP AND DIAGNOSED WITH A BLOWN TURBO. FORD DID NOT COVER COST OF REPAIR. I PAID $4,500.00 OUT OF POCKET TO REPLACE TURBO. AUGUST 2009 (APPROXIMATELY 68,000 MILES) AGAIN WHILE DRIVING ON MAJOR HIGHWAY, TRUCK LOSES POWER AND STALLS. TRUCK WAS TOWED TO FORD DEALERSHIP AND DIAGNOSED WITH CLOGGED INJECTORS DUE TO DETERIORATING GAS TANK. DEALER ADVISED ME THAT ALL 8 INJECTORS WOULD HAVE TO BE REPLACED AND NEW FUEL PUMP INSTALLED. THE TOTAL COST OF REPAIRS WOULD BE $4,300.00 AND IT WOULD NOT BE COVERED BY FORD. I WAS INCENSED TO SAY THE LEAST...AFTER GETTING A SECOND OPINION, I PAID AN ADDITIONAL $475.00 AND HAD THE TRUCK TOWED TO ANOTHER FORD DEALERSHIP WHICH MADE THE REPAIRS WITHOUT ANY COST TO ME. THE FUEL TANK WAS NOT REPLACED EVEN THOUGH IT WAS THE CAUSE OF THE PROBLEM. I REPLACED THE TANK AND PAID $750.00 OUT OF POCKET...DECEMBER 27, 2010 (96,000 MILES) WITHOUT WARNING, TRANSMISSION BEGINS TO SLIP. I CONTACTED THE FORD DEALERSHIP THAT MADE THE LAST REPAIRS. I WAS TOLD THE TRANSMISSION WAS OUT OF WARRANTY AND WOULD NOT BE COVERED BY FORD. IT WOULD COST $4,200.00 TO REPLACE. I TOOK TRUCK TO A LOCAL TRANSMISSION REPAIR SHOP AND PAID $3,000.00 TO REBUILD TRANSMISSION. ITS OBVIOUS THAT FORD DOES NOT BACK UP THEIR PRODUCT. I WILL NEVER BUY ANOTHER FORD AGAIN!!!! *TR

NHTSA ID

10374870

Incident

Aug 17, 2009

Mileage

68,000 mi

SUDDEN POWER LOSS TRAVELING AT HIGHWAY SPEEDS RESULTING IN ENGINE SHUTTING DOWN AND NOT BEING ABLE TO BE RESTARTED. *TR

NHTSA ID

10374731

Incident

Nov 23, 2010

Mileage

155,375 mi

TL*THE CONTACT OWNS A 2004 FORD F-550 SUPERDUTY. WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE STALLED. IT WAS TOWED TO ANOTHER LOCATION WHERE THE DRIVER WAS ABLE TO GET IT RESTARTED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THE DRIVER WAS INFORMED THE FUEL TANK WAS DE-LAMINATING DUE TO RUST AND CORROSION. IT WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 80,978.

NHTSA ID

10353775

Incident

Aug 31, 2010

Mileage

80,978 mi

TL* THE CONTACT OWNS A 2004 FORD F-550 SD. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY LOSE POWER WHEN DRIVING AT VARIOUS SPEEDS. ON ONE OCCASION THAT THE FAILURE OCCURRED, THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, HE WAS ABLE TO DRIVE A VERY SHORT DISTANCE BEFORE THE FAILURE RECURRED. THE VEHICLE WOULD NOT ACCELERATE PAST 5 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FUEL PUMP, FILTERS, FUEL TANK AND EIGHT FUEL INJECTORS WOULD NEED TO BE REPLACED BECAUSE THE FUEL TANK WAS RUSTED. THE MANUFACTURER ADVISED THE FAILURE OCCURRED BECAUSE THE CONTACT FAILED TO KEEP THE FUEL TANK FULL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 27,120 AND THE CURRENT MILEAGE WAS APPROXIMATELY 46,000.

NHTSA ID

10347608

Incident

Dec 15, 2007

Mileage

27,120 mi

WE OWN A FLEET OF FORD DIESEL ENGINE TRUCKS WHICH CONTINUE TO EXPERIENCE FUEL DELIVERY PROBLEMS. THE PROBLEM IS ENGINE CUT-OFF AND SURGING AND HARD STARTING. FORD SAYS NOT THEIR PROBLEM AND CHARGES US. I DON'T THINK WE HAVE THE ONLY ONES. TOYOTA IS NOT THE ONLY COMPANY NOT DEALING WITH THIS PROBLEM. THINK ONLY THE GOVERNMENT WILL MAKE THEM FIX IT. *TR

NHTSA ID

10329666

Incident

May 7, 2010

Mileage

74,145 mi

WE PURCHASED A FORD F550 6.0L DIESEL TRUCK NEW IN 2004 AND HAVE BEEN THE ONLY ONES TO DRIVE IT AND HAVE DONE PROPER CARE AND MAINTENANCE OF THIS VEHICLE. IT HAS LESS THAN 40,000 MILES ON IT. THE VEHICLE WOULD NOT START FOR NO REASON ON APRIL 29, 2010 NECESSITATING IT BEING TOWED TO THE LOCAL FORD DEALERSHIP. THEY DIAGNOSED A BAD FICM (FUEL INJECTION CONTROL MODULE) AND REPLACED IT. I HAVE FOUND THERE WAS A RECALL ON THIS VEHICLE FOR THIS PROBLEM, CAMPAIGN NUMBER 05V270000 ON 6/10/05. DUE TO THE LOW MILES AND PROPER CARE OF THIS VEHICLE I AM WONDERING IF THIS PROBLEM IS RELATED TO THAT RECALL. WE USE THIS IN OUR WORK AND HAD THE FICM GONE OUT WHILE WE WERE DRIVING IT WITH A LOAD OF CHIPS IT COULD HAVE POTENTIALLY BEEN EXTREMELY HAZARDOUS. *TR

NHTSA ID

10328229

Incident

Apr 29, 2010

Mileage

38 mi

FUEL INJECTOR PROBLEMS 3 TIMES, VEHICLE BROKE DOWN,FUEL TANK PROBLEMS, VEHICLE WILL STALL OR START RUNNING SO BADLY THAT U COULDN'T GO, AND OTHER VEHICLES WOULD ALMOST HIT MY VEHICLE, COULD NEVER TELL WHEN IT WAS GOING TO HAPPEN DEFECTIVE FUEL TANK....? *TR

NHTSA ID

10327739

Incident

Nov 20, 2008

Mileage

11,500 mi

I PURCHASED A 2004 F550 FORD TRUCK IN 2005 WITH 13,000 ORGINIAL MILES. I STATRTED HAVING PROBLEMS AT 40,000 MILES WHEN THE WARRANTY RAN OUT. I HAVE TWO MAJOR PROBLEMS: (1) THE LINER IN THE FUEL TANK SEPARATED FROM THE TANK AND WENT THROUGH THE FUEL SYSTEM. I HAD TO REPLACE THE TANK, INJECTORS, AND INJECTOR PUMP. (2) THE HEAD GASKETS BLEW AND THE TRUCK HAS NO POWER. I PLAN ON REPAIRING THE GASKETS THIS WEEK. WHEN DRIVING AT ANY SPEED, THE TRUCK SUDDENLY STOPS. I HAVE CONTACTED MY DEALER AND WENT THROUGH THEIR ASSISTANCE PROGRAM. THEY DID NOT HELP WITH THE REPAIRS. I HAVE CONTACTED FORD'S CUSTOMER COMPLAINT DIVISION AND EXPERIENCED THE SAME RESULTS. I SPOKE WITH SEVERAL FORD MECHANICS AND THE ABOVE TWO ITEMS ARE ONGOING MAJOR PROBLEMS. I AM LOOKING FOR IMMEDIATE ASSISTANCE WITH REPAIRING THE 6.0 DIESEL ENGINE. THE VEHICLE IS UNSAFE TO DRIVE AND A HAZARD TO OTHER DRIVERS ON THE ROAD. THIS IS A SEVERE HIGHWAY SAFETY ISSUE. PLEASE CONTACT ME AS SOON AS POSSIBLE TO RESOLVE THESE PROBLEMS. THANKS. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*CC

NHTSA ID

10321313

Incident

Nov 20, 2009

Mileage

40,000 mi

TL*THE CONTACT OWNS A 2004 FORD F550 SD. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 45- 55 MPH. THE ENGINE STALLED WITHOUT WARNING. THE ENGINE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE FAILURE WAS CONTRIBUTED TO THE FUEL INJECTOR WHICH WAS REPLACED ON THREE SEPARATE OCCASIONS. THE FAILURE CONTINUED WITH NO RESOLUTIONS. THE FAILURE MILEAGE WAS 25,000. THE CURRENT MILEAGE WAS 184,602. UPDATED 12/08/10. *LJ THE RADIATOR HOSE WAS REPLACED. UPDATED 12/13/10

NHTSA ID

10316599

Incident

Jun 23, 2006

Mileage

25,000 mi

DISCOVERED MY F550 SUPERDUTY 6.0 DIESEL AT 94000 MILES WITH 8 MONTHS OVER ITS WARRANTY HAD AN EXHAUST LEAK COMING FROM BOTH SIDES OF ITS 6.0 LITER DIESEL ENGINE EXHAUST MANIFOLDS. THESE FUMES WERE COMING INTO THE PASSENGER COMPARTMENT AT IDLE. AT THE SAME MILEAGE, DEALER DISCOVERED THAT ENGINE HAD OIL IN COOLANT AND THAT ITS ENTIRE PASSENGER SIDE INJECTORS WERE MALFUNCTIONING ALONG WITH THE FUEL PUMP AND ITS REGULATOR. EXCESSIVE FUEL IN ENGINE, RUNNING VERY LEAN COULD CAUSE ENGINE TO CEASE WHILE DRIVING. DEALER ADVISED THAT OIL IN COOLANT IS COMMON FOR THESE ENGINES AND THAT THIS CAUSES A OTHER MALFUNCTIONS SUCH AS HEAD GASKETS TO GO. THE EXHAUST MANIFOLDS WERE REPAIRED AT APPROX. $1172. THE OTHER ENGINE WORK WAS NOT REPAIRED AS OF YET DUE TO IT COSTING APPROX. $4240. THE HEAD GASKET WORK WOULD COST ANOTHER $6000. FORD SAID IT WOULD NOT COVER THE REPAIRS BECAUSE I WAS THE SECOND OWNER. BBB COMPLAINT FILED AND IN SEARCH FOR CLASS ACTION LAW SUIT TO COVER REPAIRS ONLY. *TR

NHTSA ID

10285295

Incident

Sep 24, 2009

Mileage

94,000 mi

TL*THE CONTACT OWNS A 2004 FORD F550. TWO HOURS AFTER THE VEHICLE WAS PARKED, IT CAUGHT FIRE. THE CONTACT STATED THAT IT WAS AN ELECTRICAL FIRE INSIDE THE CAB THAT DID NOT SEEM TO AFFECT THE ENGINE. THE FIRE WAS NOT REPORTED TO THE FIRE DEPARTMENT OR POLICE. THE CONTACT USED WATER AND A FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES. THE VEHICLE HAS NOT BEEN TAKEN TO A DEALER OR MECHANIC AND HAS NOT LEFT THE SCENE OF THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

NHTSA ID

10274619

Incident

Jun 16, 2009

Mileage

50,000 mi

I OWN TWO 2004 FORD F-550 AND ONE 2003 F-550 SUPERDUTY TRUCKS. INTERIOR FUEL TANK COATING IS DE-LAMINATING AND RUSTING AT AROUND 100,000 MILES. VEHICLES STOP WITHOUT ANY WARNING. SILVERY MATERIAL IN WATER SEPARATOR AND FUEL FILTERS. I KNOW OF SEVERAL VEHICLE OWNERS THAT HAVE THIS SAME PROBLEM AND FORD WILL DO NOTHING. MY VEHICLES STOP SUDDENLY IN HEAVY TRAFFIC AND WE WERE LUCKY NO ONE WAS INJURED. I HAVE REPLACED THE 2003 AND ONE 2004 TANK ASSEMBLY. OTHER 2004 IS SHOWING SILVERY RESIDUE ALSO. I KNOW OF A DEALER IN ST LOUIS MO., THAT HAS REPLACED MANY TANKS FOR CUSTOMERS WITH THE SAME PROBLEM. THIS IS A DEFECTIVE TANK COATING AND FORD SHOULD BE HELD RESPONSIBLE. IT IS MY UNDERSTANDING THEY (FORD) HAVE KNOWN OF THIS ISSUE SINCE 2005 AND WILL DO NOTHING. DO PEOPLE NEED TO BE HURT/KILLED BEFORE ACTION IS TAKEN? IS FORD STILL MAKING THESE TANKS WITH THE DEFECTIVE COATING, IF SO THEY SHOULD BE STOPPED ASAP BEFORE SOMEONE GETS KILLED BECAUSE A VEHICLE STALLS WITHOUT WARNING. THERE IS A TSB ON THE FUEL TANK VENT, MY VEHICLES HAVE BEEN TO FORD DEALERS AND THIS WAS NEVER BROUGHT TO MY ATTENTION. DO I HAVE TO ALWAYS ASK IF THERE IS A RECALL, TSB OR WHATEVER OR AM I AT FORD'S MERCY. SMACKS OF A COVER UP AND WILLFUL NEGLIGENCE. *TR

NHTSA ID

10259143

Incident

Dec 12, 2008

Mileage

125,000 mi