RoadVitals

2012 Ford F-59

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Jul 2, 2014
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2012 Ford F-59. 2 safety recalls have been issued covering this model year; and 14 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
14V401000

ELECTRICAL SYSTEM

Jul 2, 2014
4,867 units potentially affected
The defect: Ford Motor Company (Ford) is recalling certain model year 2011-2014 Ford F-59 commercial chassis vehicles manufactured December 17, 2009, to April 30, 2014. Corrosive environments, such as water mixed with road salt, may cause a short circuit between the electrical junction block and the mounting bracket/frame.
The risk: A short circuit may result in a fire.
The remedy: Ford will notify owners, and dealers will replace the junction block with an improved design, free of charge. The recall began on July 28, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S11. Note: Since the short may result in a fire whether the vehicle is being operated or not, owners are advised to park affected vehicles outside until they have received the recall remedy.
Ford Motor CompanyManufacturer number 14S11View on NHTSA.gov
12V035000

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Feb 2, 2012
13,239 units potentially affected
The defect: FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-53 AND F-59 STRIPPED CHASSIS VEHICLES MANUFACTURED FROM FEBRUARY 1, 2010 THROUGH JULY 1, 2011 AND CERTAIN MODEL YEAR 2012 F-53 AND F-59 STRIPPED CHASSIS VEHICLES MANUFACTURED FROM MAY 10, 2011 THROUGH OCTOBER 25, 2011. THE ‘PRNDL’ CABLE MAY BREAK AT THE ATTACHMENT TO THE TRANSMISSION CONTROL SELECTOR ARM ASSEMBLY MOUNTED ON THE STEERING COLUMN. IF THE CABLE BREAKS, THE TRANSMISSION GEAR INDICATOR IN THE ‘PRNDL’ DISPLAY IN THE INSTRUMENT PANEL WILL REMAIN IN THE FIRST GEAR POSITION REGARDLESS OF THE GEAR SELECTED.
The risk: AN INCORRECT GEAR INDICATION IN THE INSTRUMENT PANEL MAY PREVENT THE DRIVER FROM KNOWING IF THEY ARE IN PARK OR REVERSE, INCREASING THE RISK OF A CRASH.
The remedy: FORD WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE TRANSMISSION SELECTOR ARM ASSEMBLY AND THE ‘PRNDL’ CABLE ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
FORD MOTOR COMPANYManufacturer number 12S27View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

SSM 48123

ELECTRICAL SYSTEM

For Ford and Lincoln vehicles that require positive or negative battery terminal replacement, it is not necessary to replace the complete battery cable harness (14300 and 14301) for this concern. Positive battery cable clamp BT4Z-14450-AA and negative battery cable clamp BT4Z-14450-BA are available for this type of repair. Do not cut or shorten the battery cable, instead carefully remove the affected battery cable clamp and clean the cable end as necessary to preserve wire length. Some rework may be necessary for some vehicle environments. Bend the new positive battery cable clamp as needed and crimp it to the existing battery cable. Make sure to use heat shrink tubing over the battery cable to battery cable clamp connection. Obtain the heat shrink tube locally.

SSM 47976

POWER TRAIN

On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01.

17B30-S2

ENGINE; EQUIPMENT ADAPTIVE/MOBILITY

Certain 2012-2016 Model Year F-450 ? F-750 and F-59 Commercial Stripped Chassis Vehicles Equipped with a 6.8L Engine Camshaft Roller Follower Replacement Coverage

SSM 47009

EQUIPMENT:ELECTRICAL

The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access. Access to this site is granted through Dealer Program Enrollment System (DPES) and Dealer Principal, General Manager or Parts and Service Director can authorize users. Once authorized the retrieval process for master code can be obtained. The master code for the Accessory Keyless Entry Keypad cannot be retrieved from the body control module(BCM) with a diagnostic tool.

SSM 46900

ELECTRICAL SYSTEM; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use the Ford Integrated Diagnostic System (IDS) service tool or Ford J2534 Diagnostic Software, select - Toolbox - Body - Security - PATS Functions - Parameter Reset. Follow the on-screen instructions to complete the procedure. This procedure will transfer the existing Key ID information between the modules without the need of having 2 programmed PATS keys present. There is no need to program keys when the PCM is going to be replaced. Additional information can be found in the Workshop Manual (WSM), Section 419-01. Missing or lost keys are not warrantable.

16-0059

TRAILER HITCHES

Some 2011-2015 F-59 Commercial Stripped Chassis vehicles built on or before 5/29/2015 may experience hazard lighting, turn signal operation or trailer tow (TT) lighting that is not functioning properly. Vehicle vibrations may internally damage the relays that control the lighting circuits.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Ford F-59 by model year
YearComplaintsRecallsInvestigationsIssue Index
2026120—
2025030—
2024010—
2023010—
2022340—
2021430—
2020520—
2019000—
2018000—
2017010—
2016010—
2015100—
2014120—
2013010—
2012Viewing020—
2011020—
2009000—
2008000—
1994000—
1993000—
1992000—
1991000—
1990000—
1989000—
1988000—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.