2010 Ford Flex Problems

The contact owns a 2010 Ford Flex. The contact stated while driving 50 MPH, the steering wheel became firm, and the vehicle lost motive power. The contact pulled over to the side of the road and was able to restart the vehicle after 3 attempts. No warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to the oil mixing with the coolant. The manufacturer was made aware of the failure and determined that the vehicle was not under warranty. The failure mileage was approximately 148,000.

While driving at 65mph, vehicle started to accelerate funny and cel came on. was getting on the freeway and the vehicle overheated and CEL light came on. I was able to safely pull over before the vehicle died. Got vehicle towed to my home and when engine oil was checked, it was discovered that there was coolant in the oil. Took to a local shop where it was determined that the water pump had failed and dumped all of the coolant into the oil pan. Estimated cost of repair with labor is $5,000. Failure mileage was ~192,000. The oil was in good standing and gold in color 12 hours prior and was only driven ~45 miles at highway speeds before the failure happened. From what I can tell, this was a catastrophic failure of the water pump bearing seal that happened almost instantaneously. This needs to be looked into, as the repair bill does not match the issue. A water pump repair should not cost more than the vehicle.

Leaving home to go to the grocery store and as I exited my street a dash warning came on stating "Power Steering Assist" fault Steering wheel locked up making it impossible for me to steer. Fortunately this happened in a spot where there was no other traffic and I was able to just turn off the car and restart and the message was gone and my steering was restored. I am now terrified to drive my car because if this had happened in traffic there could have been a serious accident because steering capability was non existent. . In reading online this is a very common problem with my make and model and apparently there was a recall by Ford for 2011 and later cars but not 2010 even though it is a "known problem" at dealerships. For me this now seems intermittent but in calling the dealership they know of the issue. It would cost me about $2200 to fix. I am happy to provide my vehicle for inspection. Thank you so much for your help ... greatly appreciated

On the road and power steering went out and was super hard to turn

The contact owns a 2010 Ford Flex. The contact stated that while driving at an undisclosed speed, the brakes seized. There was no warning light illuminated. The contact was unable to pull to the side of the road. The contact stated that the vehicle responded as needed after waiting for a while. The vehicle was taken to an independent mechanic, where the brake master cylinder, the brake booster, the vacuum pump, the brake calipers, the brake check valve, the brakes lines, and the brake pedal sensor were replaced. Additionally, the ECM was replaced and reprogrammed; however, the failure persisted. The contact stated that the failure occurred when the brake fluid was hot after driving 15-20 miles. The dealer was not notified of the failure. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 102,000.

WHEN I PRESS ON GAS IT JERKS AND FEELS LIKE ITS STRAING TO KICK UP.DRAGGING NO GAS ITS PULLING. AND WHEN I BREAK THE PEDDLES PUSH BACK AND MAKE WEIRD NOISES.IT SOMETIMES DON'T STOP .THE RADIO BUTTONS DOESN'T WORK NONE OF THEM.I PURCHASED THIS VEHICLE 08/15/2020

My 2010 Ford Flex began inadvertently surging forward in acceleration without me making it do this exactly 3 months after I purchased the vehicle. The Ford Dealer was unable to re-produce the problem on several occasions and said my vehicle was fine. No error messages reported in the computer. This has continued to happen sporadically since ownership. I have had another Ford Dealership (as well as an independent mechanic) try and reproduce and diagnose the problem with no luck. Several weeks ago I was driving my vehicle in my residential neighborhood when all of a sudden my car surged forward with great acceleration with no warning. I had to swerve into a driveway and cut the vehicle off to get the vehicle under control. I am 82 and have a heart condition. This safety issue is critical as someone could get hurt or killed. Ford has several complaints of this happening with several models. I believe it is a Ford design flaw in the vehicles electronic throttle system. Ford Corporate was put on notice of these events after the latest safety event. Please, I urge the NHTSA to issue a recall before lives are lost. I can no longer drive this vehicle as I am concerned someone is going to get hurt. It is being towed to the Ravenel Ford Dealership for inspection and diagnosis again.....

LEAKY FUEL TANK. STRONG SMELL OF LEAKY FUEL. WORRIED THAT VEHICLE MIGHT CATCH FIRE. TOOK IT INTO MY LOCAL OIL CHANGE PLACE AND THEY COULD NOT FIND LEAK. I CAN SEE A PUDDLE OF FUEL ON MY DRIVEWAY - ABOUT 2-3 FEET ROUND. BELIEVE FUEL TANK HAS CORRODED. BUT I AM TOLD THE TANK IS MADE OF PLASTIC. LOOKED UP 2 OTHER NHTSA COMPLAINTS WITH SIMILAR FAILURE COMPLAINTS. VEHICLE HAS 152,000 MILES.

constant failure of the blend door actuator causes a clicking noise in the cabin upon starting the vehicle, or switching from vent mode to defrost mode. Also happens intermittently when activating the air conditioning. the clicking is loud enough to be heard from outside the vehicle. Unit has been replaced 4 times in 2 years. usually only lasts about a month before the unit starts to click again.

INTERMITTENT ELECTRICAL FAILURE OF THE ADVANCE TRAK TRACTION CONTROL SYSTEM CAUSES THE VEHICLE TO UNEXPECTEDLY PULL TO THE LEFT OR TO THE RIGHT WHILE UNDER ACCELERATION ON VEHICLE SPEEDS ABOVE 20 MPH WITHOUT INDICATION FROM THE TELL-TALE TO THE OPERATOR TO INDICATE THERE IS A PROBLEM OR INTERMITTENT FAILURE OF THE TRACTION CONTROL SYSTEM. THIS UNEXPECTED PULL TO THE LEFT OR RIGHT IS VIOLENT ENOUGH TO CAUSE THE VEHICLE TO VEER ACROSS THE CENTERLINE OF A LANE, POTENTIALLY CAUSING A RISK TO ONCOMING TRAFFIC AND WELL AS THE OPERATOR OF THE VEHICLE TO BECOME INVOLVED IN A CRASH. THE FAILURE WILL CONTINUE TO OCCUR INTERMITTENTLY WITHOUT INDICATION TO THE DRIVER UNTIL THE EVENT OCCURS FREQUENTLY ENOUGH DURING AN IGNITION CYCLE TO TRIGGER THE TELL-TALE TO INDICATE A FAILURE OF THE ADVANCE TRAK SYSTEM, BUT THIS TELL-TALE ON THE DASH ONLY STAYS LIT DURING THE CURRENT IGNITION CYCLE AND WILL NOT BE PRESENT ON THE NEXT IGNITION CYCLE, AGAIN FAILING TO INDICATE THE INTERMITTENT FAILURE OF THE ADVANCE TRAK TRACTION CONTROL SYSTEM VIA THE WARNING LIGHT TELL-TALE ON THE DASHBOARD.

While driving car suddenly losses power and the wrench light comes on. Loss of power with the car transmission wont move the car at all. have to pull over and turn off car about 5min then start it back up and now everything works with no codes. Happened 3 times.VERY DANGEROUS BECUASE CAR LOSSES POWER AND CARS BEHIND YOU ALMOST HITS YOU.

POWER TAKE OFF UNIT OR POWER TRANSFER UNIT STARTED MAKING A LOUD WHINING SOUND STARTING AT 40 MPH. NOW BEING TOLD THE UNIT MUST BE REPLACED. LOOKING ONLINE AND SEEMS TO BE AN ISSUE WITH THE MAJORITY OF FOR FLEX AND FORD EDGE.

WHEN I PRESS ON GAS IT JERKS AND FEELS LIKE ITS STRAING TO KICK UP.DRAGGING NO GAS ITS PULLING. AND WHEN I BREAK THE PEDDLES PUSH BACK AND MAKE WEIRD NOISES.IT SOMETIMES DON'T STOP .THE RADIO BUTTONS DOESN'T WORK NONE OF THEM.I PURCHASED THIS VEHICLE 08/15/2020

INTERMITTENT ELECTRICAL FAILURE OF THE ADVANCE TRAK TRACTION CONTROL SYSTEM CAUSES THE VEHICLE TO UNEXPECTEDLY PULL TO THE LEFT OR TO THE RIGHT WHILE UNDER ACCELERATION ON VEHICLE SPEEDS ABOVE 20 MPH WITHOUT INDICATION FROM THE TELL-TALE TO THE OPERATOR TO INDICATE THERE IS A PROBLEM OR INTERMITTENT FAILURE OF THE TRACTION CONTROL SYSTEM. THIS UNEXPECTED PULL TO THE LEFT OR RIGHT IS VIOLENT ENOUGH TO CAUSE THE VEHICLE TO VEER ACROSS THE CENTERLINE OF A LANE, POTENTIALLY CAUSING A RISK TO ONCOMING TRAFFIC AND WELL AS THE OPERATOR OF THE VEHICLE TO BECOME INVOLVED IN A CRASH. THE FAILURE WILL CONTINUE TO OCCUR INTERMITTENTLY WITHOUT INDICATION TO THE DRIVER UNTIL THE EVENT OCCURS FREQUENTLY ENOUGH DURING AN IGNITION CYCLE TO TRIGGER THE TELL-TALE TO INDICATE A FAILURE OF THE ADVANCE TRAK SYSTEM, BUT THIS TELL-TALE ON THE DASH ONLY STAYS LIT DURING THE CURRENT IGNITION CYCLE AND WILL NOT BE PRESENT ON THE NEXT IGNITION CYCLE, AGAIN FAILING TO INDICATE THE INTERMITTENT FAILURE OF THE ADVANCE TRAK TRACTION CONTROL SYSTEM VIA THE WARNING LIGHT TELL-TALE ON THE DASHBOARD.

The air bag light is on stating that the code of b0001 driver frontal stage 1 deployment control and also code u0253. I have never in my life ever had an issue like this. No accidents either

ON MARCH 11TH, THE FORD FLEX COLLIDED AT AN INTERSECTION WHEN AN EXPEDITION TURNED UNSAFELY LEFT IN FRONT OF THE WEST BOUND FLEX. ALTHOUGH THE AIR BAGS INFLATED, THEY QUICKLY DEFLATED BECAUSE OF TWO LARGE HOLES. SEE THE PHOTOS. THE DRIVER OF THE VEHICLE WAS WEARING HIS SEAT- BELT BUT CONTINUES TO EXPERIENCE CHEST PAIN.

constant failure of the blend door actuator causes a clicking noise in the cabin upon starting the vehicle, or switching from vent mode to defrost mode. Also happens intermittently when activating the air conditioning. the clicking is loud enough to be heard from outside the vehicle. Unit has been replaced 4 times in 2 years. usually only lasts about a month before the unit starts to click again.

TL* THE CONTACT OWNS A 2010 FORD FLEX. THE CONTACT STATED THAT THE DEFROSTER FAILED WITHOUT WARNING. IN ADDITION, THE BLOWER FAILED AND THE HEATER OR AIR CONDITIONING UNITS WOULD NOT TURN ON, TURN ON INDEPENDENTLY, OR WOULD FAIL TO TURN OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 92,000.

60/40 SEAT LARGER SEAT (60) WILL NOT FOLD DOWN

2010 FORD FLEX 2ND ROW OF SEATS 40/60. THE LARGER SEAT HAS LOCKED INTO POSITION CAUSED BY A CABLE PART THAT CAN SLIP OUT OF PLACE. SEAT WILL NOT FLIP UP OR DOWN. DEALERS ARE CHARGING $700 TO FIX THIS CABLE AND PLASTIC PART. THIS HAS HAPPENED 2X SINCE I'VE OWNED THE CAR. HERE IS A YOUTUBE LINK HTTPS://M.YOUTUBE.COM/WATCH?V=OAOYMBZTC6S MANY ONLINE REPORTS OF THIS PROBLEM TO OTHER FLEX OWNERS. THANKS

While traveling at highway speeds 75+ a loud bang and then control of vehicle was hard to keep on road, swerved left then right, left rear quarter panel hit guard rail and caused car to spin around and went sideways and backwards down a 30 ft embankment. Fortunately did not roll. left side tires came off of rims and damage to driver side door was done. Highway Patrol had car towed to holding lot, where I then got car towed to my mechanic. The left side Lateral stabilizer Rod had broken due to rusted part, causing left rear wheel to go out of alignment. The rubber boot on the rod was attached, rust was internal would never had known about a problem. Had both lateral rods replaced tires re-balanced and alignment done.

Vehicle was shaking in the rear area for some time at highway speeds. I took the vehicle in to the local tire shop to get the alignment checked. After that the vehicle still shook. I took the vehicle back to the tire shop and the alignment was already off quite a bit in the back tires. I took the vehicle in to the local ford dealership and was informed that the rear passenger toe link was cracking. This was replaced and the vehicle still shakes/vibrates a little bit at highway speeds. After tire rotation ,the vibration is getting better. The toe link had caused the tires to wear down inconsistently, which caused the secondary vibration.

UNKNOWN I was on the highway during dry conditions, and very suddenly fishtailed and swerved into another lane. Caused an accident. Could have been much worse. Rear driver's side wheel is not facing forward - tow driver says looks like a broken toe link. Insurance company has possession of the vehicle and will likely total the car, with no inspection by a repair shop.

TL* THE CONTACT OWNS A 2010 FORD FLEX. THE CONTACT STATED WHILE DRIVING 35 MPH, THE PASSENGER'S SIDE REAR TIRE WAS DRIFTING TO THE RIGHT INDEPENDENTLY CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT REGAINED CONTROL OF THE VEHICLE AND PULLED TO THE SIDE OF THE ROADWAY. THE CONTACT HAD THE VEHICLE TOWED TO BILL KNIGHT FORD (9607 S. MEMORIAL DR, TULSA, OK 74133) WHO INSPECTED THE VEHICLE AND DIAGNOSED THAT THE REAR TOE LINK WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 351,000.

2010 FORD FLEX SECOND ROW PASSENGER CENTER SEAT BELT RETRACTOR STUCK. CHILD RELEASED STUCK SEAT BELT, LOWER CENTER SEAT WHICH IS NOW ALSO IN A STUCK POSITION. NO WAY TO GET TO RETRACTOR OR RAISE SEAT. *TR

GOT IN MY CAR AND WHEN I STARTED THE VEHICLE THE AIR BAG LIGHT ALONG WITH THE TRACTION CONTROL INDICATOR LIGHT CAME ON, TOOK IT TO A DEALER TO SEE WHAT THE ISSUE WAS AND WAS TOLD IT IS THE RESTRAINT CONTROL MODULE AND TO REPLACE IT WILL COST 900.00. THIS IS OBVIOUSLY A FAULTY PART AND SHOULD BE COVERED AS IT DIRECTLY CONTROLS THE SIR BAGS AND THE SEAT BELTS. SO BECAUSE I DO NOT HAVE 900.00 LAYING AROUND I G=HAVE TO HOPE I AM NOT IN A COLLISION UNTIL I CAN COME UP WITH THE RIDICULOUS AMOUNT OF MONEY TO REPLACE A PLUG IN MODULE THAT COSTS LESS THAN 100.00 TO MANUFACTURE. *TR

Water ingress into rear side door latch - froze - door opened while car was in motion

WE WERE INVOLVED IN AN ACCIDENT WHERE A JEEP WAS THROWN INTO THE FRONT OF OUR VEHICLE BY A FORD F-150, TOTALING OUR VEHICLE, AND OUR AIRBAGS DID NOT DEPLOY, NONE OF THEM. WE WERE AT A STOP SIGN AND ALL WALKED AWAY FROM THE ACCIDENT, BUT THE POLICE, FIRE DEPARTMENT, AND INSURANCE ADJUSTER ALL SAID SOMETHING WAS WRONG FOR THE METAL IBEAM BEHIND THE BUMPER TO BE CRUSHED INTO THE RADIATOR AND FOR OUR AIRBAGS TO NOT DEPLOY. THE INSURANCE ADJUSTER HAD ALREADY DEEMED OUR FLEX AS A TOTAL LOSS BUT MENTIONED THAT HAD WE REPAIRED THE VEHICLE WE WOULD NEED TO INVESTIGATE FURTHER WHY THE AIRBAGS MALFUNCTIONED AND HAVE IT FIXED. WE WOULD STILL LIKE TO INVESTIGATE TO UNDERSTAND WHY THIS HAPPENED AND TO ENSURE THIS WAS AN ISOLATED INCIDENT OR THAT A RECALL IS ISSUED BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED DUE TO THIS SAFETY FEATURE MALFUNCTION HAPPENS TO SOMEONE ELSE. *TR

TL* THE CONTACT OWNS A 2010 FORD FLEX EQUIPPED WITH HANKOOK OPTIMO H725A TIRES SIZE P235/60R17 (N/A), DOT NUMBER 5MJCDFHP4209. THE CONTACT STATED ALL FOUR TIRES WERE BALD. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE TIRES WERE UNSAFE TO DRIVE ON AND OFFERED NO REASON FOR THE FAILURE OR ANY ASSISTANCE. THE TIRE MANUFACTURER WAS NOTIFIED. THE VEHICLE MANUFACTURER WAS NOTIFIED WHO OFFERED NO REASON FOR THE FAILURE OR OFFERED ANY ASSISTANCE IN REPLACING THE TIRES. THE FAILURE WAS UNKNOWN. THE FAILURE MILEAGE ON THE TIRES AND THE VEHICLE WAS 22,000.

I RECENTLY PURCHASED A 2010 FORD FLEX, WITH A CLASS III TRAILER TOW PACKAGE. THE PACKAGE,ACCORDING TO FORD'S BROCHURE IS SUPPOSED TO INCLUDE A TIRE MOBILITY KIT. THE KIT, AS I UNDERSTAND IT, IS ESSENTIALLY MADE UP OF AN AIR COMPRESSOR AND A CAN OF SEALANT COMPOUND USED TO PLUG A HOLE IN A TIRE. THEREFORE THE COMPRESSOR INJECTS THE SEALANT COMPOUND,WHILE INFLATING THE TIRE. ON PAGE 309, OF THE OWNER'S GUIDE, IS THE FOLLOWING WARNING: " WARNING: WHEN TOWING A TRAILER, USE THE TEMPORARY MOBILITY KIT AND NOT THE MINI SPARE TIRE IF NECESSARY. THE MINI SPARE TIRE IS NOT INTENDED FOR THE HIGHER TOWING LOAD LIMITS OF THIS VEHICLE. WHEN TOWING HEAVY LOADS WITH THE MINI SPARE TIRE, VEHICLE HANDLING MAY BE DIMINISHED, WHICH COULD LEAD TO LOSS OF CONTROL, AND SERIOUS PERSONAL INJURY." MY CAR IS NOT EQUIPPED WITH THE TIRE MOBILITY KIT, AND THE FORD MOTOR COMPANY TELLS ME, "IF YOUR CAR IS EQUIPPED WITH A SPARE TIRE, IT WILL NOT BE EQUIPPED WITH THE TIRE MOBILITY KIT". IT SEEMS STUPID TO ME, AND PERHAPS CRIMINAL, THAT THEY INCLUDE THE WARNING IN THE OWNER'S MANUAL AND REFUSE TO PROVIDE THE SAFETY EQUIPMENT THEY CLAIM TO BE NECESSARY, AND WHICH THEY CLAIM IS INCLUDED IN THEIR SALES BROCHURE. INCIDENTALLY, IT TOOK THE SALESMAN TWO WEEKS TO COME UP WITH FORD'S EXPLANATION, AND HE SAID, "IT'S ALL HUSH HUSH". *TR

BLUE FLASHING LIGHT HAS COME ON LEFT SIDE DRIVERS SIDE ABOVE THE EMERGENCY BRAKE UNDERSIDE OF THE DASH. STAYS ON EVEN AFTER CAR IS TURNED OFF.

TL* THE CONTACT OWNS A 2010 FORD FLEX. THE CONTACT STATED THAT THE BLOWER FOR THE HEATING AND AIR CONDITIONING FAILED ON THE PASSENGER SIDE OF THE VEHICLE. THE HEATING AND AIR CONDITIONING DID NOT WORK ON THE ENTIRE PASSENGER SIDE OF THE VEHICLE. WHEN THE FAILURE OCCURRED, THE VENT BLEW HOT AIR AND ONE SIDE BLEW COLD AIR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE BLOWER MOTOR FOR THE AIR CONDITIONING AND HEATING FAILED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 65,000.