2005 Ford Focus Tires & wheels Problems

I BOUGHT MY CAR FROM THE ORIGINAL OWNER. I HAD TO BUY A RE-FURBISHED MOTOR, THE TIRES WERE SPLITTING AND THE SUSPENSION AND AIR CONDITIONER ALL NEEDED REPAIRING. WHEN I RECEIVED THE RECALL FROM DOT, [XXX], I IMMEDIATELY CONTACTED TALLAHASSEE FORD. THEY DENIED THERE WAS A RECALL AND I WAS MISTAKEN. MY VIN # WAS LISTED IN THE RECALL. I TRIED SEVERAL TIMES BUT FORD KEPT GIVING ME A RUN-AROUND AND THEY LIED. SO NOW, I HAVE APPARENTLY MISSED A DEADLINE WHICH WAS NOT LISTED ON THE ORIGINAL NOTICE TO ME. I AM A SENIOR CITIZEN AND THIS HAS REALLY STRESSED ME OUT AND IT REALLY MAKES ME NOT TO PURCHASE ANOTHER FORD FROM ANYONE. ON ETHICS ALONE, I SHOULD BE ABLE TO MAKE THEM DO WHAT THEY BASICALLY REFUSED BY LYING TO ME. IT WAS IN MOTION AND WENT TO THE SHOP WITHIN TWO WEEKS AFTER THE NOTICE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10924031

Incident

Oct 6, 2015

Mileage

35 mi

ALL 4 EAGLE GT TIRES THAT ARE ONLY 6 MONTHS OLD ARE WORN AND SCALLOPED DUE TO A KNOW PROBLEM TO FORD TECHNICAL SERVICE BULLETIN ID: 10034585 JULY 10, 2010 AND SERVICE BULLETIN NO.: TB-21399 COMPONENT(S): TIRES NHTSA ID NUMBER: 10034585. OUR MECHANIC RAN A DIAGNOSTIC AND SERVICE BULLETIN SEARCH FOR POSSIBLE MANUFACTURING ISSUES TO CAUSE THE TIRE WEAR. THE SOLUTION THAT FORD HAS COME UP WITH IT TO ADD 4 ADDITIONAL UPPER CONTROL ARMS AT $140 A PIECE PLUS LABOR. WHEN I SPOKE WITH FORD THEY INDICATED THAT THE PROBLEM IS A KNOWN ONE BUT ARE UNWILLING TO DO ANYTHING TO CORRECT THE PROBLEM. THEY ARE WAITING UNTIL PEOPLE ARE EITHER INJURED OR KILLED TO CORRECT THE PROBLEM. ADVISED THEM THAT I WILL KEEP ALL RECEIPTS FOR NEW TIRES. THIS IS THE 4 SET OF TIRES IN 3 YEARS DUE TO THIS PROBLEM. I ADVISED THEM I WILL WAIT UNTIL THE TIRES ARE TOTALLY WORN AND CAUSE AN ACCIDENT AND DAMAGE AND THEN LET MY INSURANCE CARRIER DEAL WITH THEIR FAULTY VEHICLE. *TR

NHTSA ID

10618111

Incident

Jul 21, 2014

Mileage

157,000 mi

GOODYEAR EAGLE GT TIRE SHOWS SIGNS OF TREAD SEPARATION AROUND PERIMETER OF TIRE WHERE SIDEWALL MEETS TREAD. *TR

NHTSA ID

10361745

Incident

Oct 21, 2010

TL*THE CONTACT OWNS A 2005 FORD FOCUS. THE MANUFACTURER OF THE TIRES WAS B.F GOODRICH AND THE TIRE SIZE WAS P205/50/16. THE CONTACT STATED THAT THE TIRES HAVE EXCESSIVE TREAD WEAR. AS A RESULT OF THE TIRE BLOW-OUT, THE TIRE FAILURE INCREASED THE RISK OF VEHICLE CRASH. SHE HAD TO REPLACE THE TIRES ON TWO OCCASIONS. THE MANUFACTURER WILL ONLY ASSUME PARTIAL RESPONSIBILITY. SHE HAS PICTURES OF THE FAILED COMPONENT. THE FAILURE MILEAGES WERE 20,000.

NHTSA ID

10282902

Incident

Dec 14, 2008

Mileage

92,112 mi

TL*THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THERE WAS A SERIOUS DEFECT WITH THE REAR BRAKES. THE REAR BRAKES HAVE BEEN REPLACED SIX TIMES SINCE THE VEHICLE WAS PURCHASED. IN ADDITION, THE REAR TIRES HAVE BEEN REPLACED ELEVEN TIMES WITHOUT ANY EXPLANATION. THE MANUFACTURER HAS NOT PROVIDED ASSISTANCE. THE CURRENT MILEAGE WAS 83,463 AND FAILURE MILEAGE WAS 212.

NHTSA ID

10276233

Incident

Nov 11, 2004

Mileage

212 mi

MY FAMILY AND I WERE COMING UP FROM FLORIDA WHEN IT STARTED TO RAIN. I FELT THE CAR SLIPPING ON THE ROAD SO I MOVED OVER INTO THE FAR RIGHT HAND LAND. THE CAR SLIPPED AGAIN AND I HYDROPLANED AND CRASHED CAR ON NOV. 29TH DUE TO TIRES THAT WERE ONLY 6MONTHS OLD. I FELT THESE NEW TIRES HAD BEEN WORN SMOOTH AFTER ONLY 10,000 MILES OF USAGE WITH A CAR THAT HAD NO BRAKE OR ALIGNMENT ISSUES. THE TIRES WERE FULL OF AIR AT THE RIGHT PRESSURE AND I NOTICED NO TREAD ISSUES BEFORE LEAVING OUT OF TOWN. WHEN FILLING OUT THE POLICE REPORT, THE OFFICER WROTE ME A TICKET CLAIMING THE ACCIDENT HAPPENED BECAUSE OF THE TIRES. WE HAD TO STAY OVERNIGHT IN A HOTEL AND PURCHASED NEW TIRES THE NEXT DAY. I STILL RETAIN THE TIRES. *TR

NHTSA ID

10250576

Incident

Nov 29, 2008

Mileage

66,000 mi

2005 FORD FOCUS ZX4 FLAT TIRE WAS CAUSED BY THE WHEEL COVER HITTING THE VALVE STEM. CONSUMER STATES THAT THE WHEEL COVER IS BENDING THE VALVE STEM . *NJ ALL 4 OF THE WHEEL COVERS WERE ROTATING ON THE WHEELS . THE DEALER USED EPOXY GLUE TO FASTEN THE WHEEL COVERS TO THE WHEELS. THREE OF THE COVERS STUCK, BUT THE FOURTH CONTINUED TO ROTATE. *JB

NHTSA ID

10240408

Incident

Jul 27, 2008

TL*THE CONTACT OWNS A 2005 FORD FOCUS. THE VEHICLE HAS GOODYEAR EAGLE RS-A TIRES, SIZE P19560R15. THE CONTACT STATED THAT THE TIRES WERE DEFECTIVE AND THE STEEL BELT WAS VISIBLE. DUE TO THE LOW MILEAGE ON THE TIRES, THE FAILURE SHOULD NOT HAVE OCCURRED. HE ALSO NOTICED WEAR ON THE TIRES. THE CONTACT TOOK THE VEHICLE TO THE GOODYEAR DEALER AND THEY REPLACED ALL FOUR TIRES. RECENTLY, THE FRONT TIRES MALFUNCTIONED. THE DEALER REPLACED THE FRONT TIRES IN DECEMBER OF 2007 WITH KUMHO TIRES. THERE HAD BEEN NO FURTHER OCCURRENCES SINCE THE REPLACEMENT. CURRENTLY, THE REAR TIRES ARE DEFECTIVE. THE PURCHASE DATE AND DOT NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 75,000 AND FAILURE MILEAGE WAS APPROXIMATELY 26,000.

NHTSA ID

10225574

Incident

Jun 20, 2006

Mileage

26,000 mi

BOUGHT 2005 FOCUS ZX5 NEW. ORIG TIRES PIRELLI. LOST AIR CONSTANTLY. NO ONE WOULD HONR OR FIX. I HAD TO BUY NEW TIRES WITH ONLY 2,245 MILES ON THE CAR. GOODRICH 205/50-16 WHICH THE TIRE DEALER SAID IS MADE FOR FOCUS. THE FORD DEALER SAID THE TIRES WERE THE WRONG TIRE FOR FOCUS. NOW THE TIRES HAVE 24,000 MILES ON THEM AND THEY ARE BALD. FORD DEALER DENIES HE TOLD ME TIRES WERE WRONG AND I AM NOW FACING HAVING TO BUY NEW TIRES AGAIN. DEALER WILL NOT HELP. TIRE DEALER SAYS "OH WELL" THE CAR DOES TERRIBLE ON WET & SNOW-ICY ROADS EVEN AT 15 TO 35 MILES AN HOUR. WHAT AM I TO DO? WHY IS FOCUS KNOWN FOR ABNORMAL TIRE WEAR PER TSB'S AND THE DEALERS WILL NOT HELP? THIS HAPPENS ALL THE TIME, LAST TIME WAS 3/17/08. *TR

NHTSA ID

10221993

Incident

Feb 28, 2008

Mileage

22,400 mi

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT NOTICED THAT THE WEAR BAR WAS EXPOSED ON EACH TIRE. THE MILEAGE WAS 44,244 WHEN THE NEW TIRES WERE PURCHASED. THE TIRE MANUFACTURER AND BRAND WERE TOYO TIRES, THE DOT#CX3V862205 , AND THE SIZE WAS 205/15VR16. THE TIRES WERE 40,000 MILE TIRES, WHICH CAUSED TIRE FAILURE AT 19,415 MILES EARLIER. THE TIRE DEALER WAS NOTIFIED. THE CURRENT AND RECENT FAILURE MILEAGE WERE 63,659. *AK THE CONSUMER STATES THAT EVERY 5,000 MILES THE WERE ROTATED TWICE BY FORD MOTOR CO AND TWICE BY HER HUSBAND. THE CONSUMER ALSO STATES SHE HAS A 90,000 MILE WARRANTY. THE CONSUMER STATES SHE WANTS TO REIMBURSED FOR A PORTION OF THE COST OF THE NEW TIRES. UPDATED 05/13/07 *TR

NHTSA ID

10189408

Incident

Apr 25, 2007

Mileage

63,659 mi

I RECENTLY HAD A TIRE FAILURE. I AM NOT SURE WHAT TO CALL IT AS THE ENTIRE MIDDLE SECTION OF RUBBER CAME COMPLETELY OFF. THERE WAS ONLY A SMALL AMOUNT (IF ANY) SIDEWALL LEFT (I HAVE PHOTOS). I TOOK IT TO A GOODYEAR DEALER WHO REPLACED IT AT A "PRORATED" RATE ALTHOUGH MY UNDERSTANDING OF THE WARRANTY WAS THAT IT WOULD BE COMPLETELY COVERED. I HAD IT REPLACED AND PAID THE $80.00. I ALSO CONTACTED GOODYEAR TO MAKE SURE THIS WAS THEIR POLICY AND THAT MY TRANSACTION WAS HANDLED CORRECTLY, I INCLUDED A PHOTO WITH MY CORRESPONDENCE. THEY INFORMED ME THAT IT WAS THEIR POLICY AND THE DEALER HAD CONTACTED THEM ABOUT MY INCIDENT. THEY ALSO ASSURED ME THAT A TIRE SHOULD NOT DO THAT AND THEY ARE SORRY ABOUT IT. I AM FEELING THAT THIS IS A VERY DANGEROUS POSSIBILITY, IF IT HAD BEEN A FRONT TIRE I WOULD NOT HAVE SURVIVED THE INCIDENT AS I WOULD HAVE LOST TOTAL CONTROL (GOODYEAR TIRE). *NM

NHTSA ID

10183463

Incident

Feb 15, 2007

Mileage

19,785 mi

I WAS WESTBOUND ON 5TH ST. IN OLIVEHURST, CA, AND HEADED TO OLIVEHURST DRIVE. THE CONDITIONS WERE DRY AND COOL, AND THE SPEED LIMIT WAS 25 MPH. I HAD NOT YET COME UP TO THE SPEED LIMIT (BELOW 10 MPH) WHEN MY FRONT END BEGAN TO SHAKE. SECONDS LATER, MY PASSENGER AND I HEARD A LOUD BANG, AND THE FRONT END SWERVED SHARPLY TO THE RIGHT. I TRIED TO CORRECT TO THE LEFT, AND ENDED UP CLIPPING A POLE (ON THE RIGHT SIDE OF THE ROAD) INSTEAD OF HITTING IT HEAD ON. MY PASSENGER SUSTAINED A BLOW TO HIS KNEE. NO OTHER INJURIES OCCURRED, AND WE DID NOT FEEL IT NECESSARY TO CALL AN AMBULANCE. AS THERE WAS MINIMAL SCRAPES ON THE POWER POLE, AND MY CAR WAS NOT COVERED FOR COLLISION DAMAGE, I DID NOT NOTIFY THE AUTHORITIES. MY RIGHT FRONT TIRE WAS BENT INWARD, AND THE TIRE WAS BLOWN DOWN THE CENTER OF THE TREAD. UPON REPLACING THE TIRE WITH THE SPARE, WE FOUND THAT THE A ARM HAD SEPARATED FROM THE ROTOR, AND THE RIGHT CV AXLE HAD PULLED AWAY FROM THE TRANSMISSION, EFFECTIVELY DISABLING MY CAR. THE TIRE IN QUESTION IS A GOODYEAR EAGLE RS-A P195/60R15; THE ORIGINAL TIRE FROM THE PURCHASE DATE OF 9/13/05, AND WITH LESS THAN 27,000 MILES ON THE ODOMETER. THE TIRES WERE CLOSE TO BALD PRIOR TO THE BLOWOUT, AND I HAD BEEN CONSIDERING TAKING THEM IN FOR A WARRANTY REPLACEMENT DUE TO THEIR SHORT LIFESPAN. I HAVE HAD PRIOR TIRE ROTATIONS DONE AT LARRY GEWEKE FORD IN YUBA CITY, AND THEY HAD NOT INFORMED ME OF ANY TREAD WEAR PROBLEMS AT THE TIME FOR THIS PARTICULAR TIRE. THIS TYPE OF DEFECT COULD HAVE EASILY KILLED MYSELF AND MY PASSENGER IF IT HAD OCCURRED AT HIGHER SPEEDS. *NM

NHTSA ID

10176689

Incident

Nov 19, 2006

Mileage

27,774 mi

2005 FORD FOCUS, HAS LOST TO 7 SPOKE WHEEL COVERS IN 3 MONTHS. *NM

NHTSA ID

10166862

Incident

Aug 12, 2006

Mileage

11,541 mi

MY CAR KEPT STALLING IN THE MIDDLE OF THE ROAD AND AT STOP SIGNS AND WHERE EVER IT FELT LIKE. THIS STARTED AT ABOUT 20,000 MILES. THEN JUST BEFORE IT GOT TO 36,000 MILES IT WOULD STALL WHEN EVER IT BECAME HOT. AS I WAS GOING UP AND DOWN THE MOUNTAIN PASSES IN WASHINGTON, OREGON AND CALIFORNIA IT WOULD JUST STOP RUNNING EVERY MILE. IT WAS VERY DANGEROUS AS I HAD CARS BEHIND ME AND TRUCKERS ON ALL SIDES AND THE CAR WOULD JUST QUIT AT 65 MPH OR WHAT EVER SPEED I WAS AT. I HAD MAD TRUCKERS AND MAD CARS AND TRUCKS, BUT I DIDN'T KNOW WHAT THE PROBLEM WAS. WHEN I LIMPED HOME (780 MILES) I GOT THE CAR IN TO BE CHECKED AND FOUND THAT IT WAS THE FUEL RAIL SENSOR. I CALLED FORD AND THEY REFUSED TO COVER IT UNDER WARRANTY. I WAS FORCED TO PAY FOR A FAULTY PART OUT OF MY OWN POCKET. THEN LAST WEEK I SAW ON THE NEWS THAT TOYOTA AND ANOTHER COMPANY HAD RECALLED THEIR VEHICLES FOR THE SAME EXACT PART. I CALLED FORD TODAY AGAIN AND THEY ARE STILL REFUSING TO ADMIT THAT THIS IS DANGEROUS ON THEIR CARS. IT SEEMS TO BE OK TO RECALL OTHER VEHICLES, BUT FORD THINKS THEIR '!@#$% DOESN'T STINK AS WE SAY ON THE FARM. I WANT THIOS RECTIFIED. IF OTHER MANUFACTURERS THINK THIS IS A PROBLEM. I THINK FORD SHOULD BUCK UP AND ADMIT THAT THEIR VEHICLES COULD POSSIBLY HAVE THE SAME PROBLEM AND THAT THEY SHOULD BE FIXED UNDER WARRANTY. I WILL NEVER BUY ANOTHER FORD IF THIS IS THE WAY THEY TREAT CUSTOMERS WHO HAVE A PROBLEM WITH THE FORD CARS. GAYLE SORENSEN *TR

NHTSA ID

10163112

Incident

May 13, 2006

Mileage

20,000 mi

DT: THE CONTACT STATED THE WHEEL COVERS POPPED WHILE DRIVING, ONE OF THE COVERS CAME OFF THE CAR. THE CONTACT WAS UNABLE TO GET THE COVER BECAUSE OF TRAFFIC. HE CONTACTED FORD, AND THEY WOULD REVIEW THE PROBLEM ONLY IF THE WHEEL COVER WAS AVAILABLE FOR INSPECTION. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THEY COULD NOT DIAGNOSE A PROBLEM. THE VEHICLE PULLED TO THE LEFT, AND THE DEALERSHIP WAS UNABLE TO DIAGNOSE A PROBLEM. *AK

NHTSA ID

10142645

Incident

Nov 11, 2005

'05 FORD FOCUS ZXW. VEHICLE LESS THAN 2 WEEKS OLD. IN SHOP 4TH TIME FOR VIBRATION IN FRONT END AND PULLING TO RIGHT. DEALER REPLACED 1 FRONT TIRE, BALANCED ALL 4, CHANGED CAMBER ANGLE AND RE-ALIGNED STEERING WHEEL. CAR STILL VIBRATES AT 65 AND NOW PULLS TO LEFT. BACK TO DEALER AGAIN FOR 5TH TIME. APPEARS TO ORIGINATE FROM RIGHT FRONT. WILL PRESS FOR STRUT AND SUSPENSION INSPECTION. *JB

NHTSA ID

10133136

Incident

Aug 8, 2005

Mileage

200 mi

HOOD LATCH WAS NOT ATTACHED PROPERLY TO BODY. CAUSED HOOD TO BRAKE FREE AND FLY UP UPSTRUCKING VISION AND CAUSING A WRECK. NO AIR BAGS DEPLORED AND CRUSE CONTROL STUCK ON. NEW VEHICLE VIN # DID NOT MATCH VEHICLE DESCRIPTION.

NHTSA ID

10121743

Incident

Apr 8, 2005

2005 FORD FOCUS EXPERIENCING PROBLEMS WITH THE BRAKE EQUIPMENT AND THE TIRE TREAD ON THE FRONT TWO TIRES.*MR THE BRAKE ROTORS AND PADS WHERE BAD. DEALER TOLD CONSUMER ALL FOCUS DISC BRAKES WEAR LIKE THAT, WITH GROOVES ON ROTORS AND PADS . CONSUMER'S SON WAS ON I-95 AND HAD TO STOP FAST AND TIRES GOT SOFT SPOTS AND FLATTEN OUT AND TREAD CAME APART. MANUFACTURER WOULDN'T WARRANTY THE 2 FRONT TIRES AND THE CONSUMER HAD TO BUY NEW ONES. *BF

NHTSA ID

10119228

Incident

Apr 10, 2005

Mileage

4,523 mi