2005 Ford Focus Transmission Problems

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE GEAR SHIFTER WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 83,600.... UPDATED 08/19/13 *BF THE SHIFTER WAS REPLACED ON JULY 30, 2013

NHTSA ID

10532610

Incident

Jul 16, 2013

Mileage

83,600 mi

TL* THE CONTACT OWNS A 2005 FOR FOCUS ZXW STATION WAGON. THE CONTACT STATED THAT WHEN THE KEY WAS IN THE IGNITION AND THE SHIFT OVER RIDE BUTTON WAS DEPRESSED, THE KEY WOULD BECOME LOCKED IN THE IGNITION. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE CONTACT GLUED THE SHIFT OVER RIDE BUTTON IN PLACE AND CHANGED THE IGNITION, WHICH RESOLVED THE FAILURE. THE CONTACT ALSO STATED THE METAL FRAME OF THE DRIVER'S SEAT BECAME CRACKED. THE CONTACT HAD TO PROP THE SEAT UP SO THAT HE COULD DRIVE THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 205,000. UPDATED 02/20/13*LJ THE CONSUMER STATED THE TRANSMISSION WAS POORLY DESIGNED. UPDATED 02/21/13 THE CONSUMER STATED THE EXPERIENCED NUMEROUS PROBLEMS WITH THE TRANSMISSION, AFTER HAVING THE FLUID FLUSHED. THE CONSUMER STATED THE SIDE VIEW MIRRORS WERE RIGID AND WERE EASY TO BREAK, THE REAR SUSPENSION SPRINGS WERE NOT DESIGNED TO CARRY WEIGHT, WHICH CAUSED THE VEHICLE TO BOUNCE ON THE HIGHWAY AND SECONDARY ROAD BUMPS. THE HEAT SHIELDS ATTACHED TO THE EXHAUST SYSTEM WERE DESIGNED POORLY, TO THE POINT THEY WERE BENT AND CAUSED A RATTLE. THE STEEL RIMS, BENT EASILY, WHICH CREATED A VIBRATION AND BALANCE PROBLEM. THE HEADLIGHTS LENSES WERE DISCOLORED, THE VALVE COVER GASKET LEAKED OIL ONTO THE SPARK PLUGS, THE HOOD CABLES WERE DEFECTIVE. THE HOOD CABLE FROZE AND BROKE. UPDATED 07/25/13

NHTSA ID

10487466

Incident

Oct 22, 2010

Mileage

205,000 mi

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE SECOND AND THIRD GEARS FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. APPROXIMATELY 50,000 MILES LATER, THE FAILURE RECURRED AND THE TRANSMISSION BEGAN TO SLIP. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. UPDATED 09/19/11 *BF UPDATED 2/23/12 *CN

NHTSA ID

10418556

Incident

Jul 10, 2011

Mileage

38,000 mi

STOPPING CAR AND PLACING CAR IN PARK SOMETIMES THE CAR WILL NOT GO ALL THE WAY IN PARK AND THE KEYS WILL NOT RELEASE FROM IGNITION. WHEN THE CAR IS RESTARTED THE BUTTON FOR THE AUTOMATIC SHIFTER WILL SHIFT OUT OF PARK WITHOUT PRESSING DOWN THE BRAKE PEDAL. *TR

NHTSA ID

10355459

Incident

Sep 14, 2010

Mileage

67,000 mi

O/D LIGHT CAME ON. AUTOMOTIVE SHOP RAN A TEST AND RETRIEVED CODE P0767. SHOP REPLACED THE SOLENOID AND CAR WOULD STILL NOT SHIFT INTO 2ND GEAR. SHOP WANTED TO REPLACE THE TRANSMISSION BUT I DECLINED AS THE CAR ONLY HAD 52,000 MILES. TOOK THE CAR TO A FORD DEALERSHIP AND THEY SAID THERE WAS NO 2ND OR 4TH GEAR. DEALERSHIP SAID IT WAS A POSSIBLE BROKEN BAND OR FAILED BAND APPLY PISTON. THEY REMOVED THE PAN AND VERIFIED BROKEN BAND. THEY REPLACED THE 2-4 BAND AND INSTALLED NEW BAND APPLY PISTON AT A COST OF $931.22 PLUS THE COST OF A RENTAL CAR AT $101.16. NO CAR SHOULD HAVE A TRANSMISSION FAIL AT 50,000 MILES. I FEEL THERE WAS A DEFECT IN THE PARTS USED IN THE TRANSMISSION. WHEN I ASKED ABOUT INSTALLING A NEW TRANSMISSION, I WAS CONCERNED THAT THEY WOULD INSTALL THE SAME TRANSMISSION THAT FAILED IN MY CAR. THE SHOP SAID NOT TO WORRY BECAUSE THE TRANSMISSION HAS ALL UPDATED PARTS! THE RESPONSE LEADS ME TO BELIEVE THAT THE PARTS IN MY TRANSMISSION WERE DEFECTIVE AND I SHOULD BE REIMBURSED THE COST OF MY REPAIRS. I CALLED FORD MOTOR COMPANY AND SINCE THERE WAS NOT A RECALL THEY COULD NOT HELP ME. AGAIN, NO CAR SHOULD HAVE A TRANSMISSION FAIL AT 50,000 MILES. *TR

NHTSA ID

10353881

Incident

Jun 22, 2010

Mileage

52,000 mi

I'M HAVING PROBLEMS WITH THE CAR HESITATING WHILE DRIVING. THIS HAS REPEATEDLY HAPPENED. I HAVE A LITTLE OVER 90,300 MILES ON THE CAR. IT REALLY SCARES ME WHEN I'M GOING AT LEAST 60 MPH ON THE HIGHWAY AND PRESS THE GAS TO ACCELERATE AND THEN GET THE HESITATION OR PULLBACK AS IF IT IS GOING TO CUT OFF. I'M AFRAID IT IS GOING TO CUT OFF WHILE I AM DRIVING IT. IT ALSO HAPPENS WHEN I'M DRIVING 35 MPH. WHEN THIS HAPPENS AND I CUT THE CAR AND START IT BACK UP, THE CLOCK RESETS TO 12:00 AND THE RADIO COMES ON BLASTING. MY LIGHTS FLICKER WHEN IT HAPPENS AT NIGHT. I TOOK IT TO THE DEALERSHIP AND THEY REPLACED THE FUEL PUMP MODULE. THIS HAS NOT HELPED ONE BIT AND I AM OUT $462. THEY HAVE QUOTED ME A PRICE OF $1500 IF THE FUEL PUMP MODULE REPLACEMENT DID NOT WORK. THEY TELL ME IT WILL PROBABLY BE THE PCM THAT NEEDS REPLACING. *TR

NHTSA ID

10346927

Incident

Jun 18, 2010

Mileage

90,200 mi

THE IGNITION KEY STICKS IN MY 2005 FORD FOCUS. IT CANNOT BE REMOVED FROM THE IGNITION. RESEARCH ON THE INTERNET REVEALS THAT THIS A COMMON PROBLEM. IT HAS TO DO WITH SHIFTER CABLE THAT COSTS $650. IS IT SAFE? I AM NOT CERTAIN. I AM NOT SURE WHETHER THE SHIFT IS LOCKING ADEQUATELY. WHY HASN'T FORD RECALLED THIS PROBLEM? *TR

NHTSA ID

10314033

Incident

Feb 24, 2010

Mileage

53,000 mi

TL*THE CONTACT OWNS A 2005 FORD FOCUS. WHILE DRIVING APPROXIMATELY 25 MPH IT BECAME VERY DIFFICULT TO SHIFT GEARS. THE DEALER ADVISED THE CONTACT THAT THE CLUTCH NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGE WAS 4000.

NHTSA ID

10281232

Incident

Jul 25, 2005

Mileage

4,000 mi

I WAS DRIVING WITHOUT ANY WARNING A POP SOUND AND MY CLUTCH WOULD NOT GO INTO ANY GEARS. I HAD TO FORCE IT INTO SECOND GEAR ALL THE WAY HOME. TOTAL OF 3 FAILURES APPROX. 1 MONTH APART FINAL RESULT ON MY THIRD TRIP FOR REPAIRS ENDED WITH ME UNABLE TO STOP IN TIME WHICH CAUSED ME REAR ENDING THE BACK OF A TRUCK. I DAMAGED THE FRONT OF MY CAR. AFTER NUMEROUS ATTEMPTS TO REPAIR MY CAR BOTH ENGINE AND BODY I STILL HAVE NO CAR. MY CAR HAS 1,200 MILES ON IT. 2005 FORD FOCUS BOUGHT BRAND NEW FROM DEALERSHIP AND UNABLE TO GO ANYWHERE IN IT. I DON'T HAVE THE OLD PARTS. THE LADY TOLD ME THAT SHE WOULD CHECK INTO IT TO SEE IF THE DAMAGES WOULD BE COVERED BY THEM. CONSIDERING THE ACCIDENT WOULD NOT OF HAPPENED IN THE FIRST PLACE IF THEY WOULD OF FIXED MY CAR RIGHT THE FIRST TIME. EITHER WAY SHE CALLED ME TO LET ME KNOW THEY WEREN'T GOING TO COVER IT. *TR

NHTSA ID

10276944

Incident

Jul 17, 2005

Mileage

1,200 mi

FORD FOCUS 2005, 20,000 MILES CAN NOT REMOVE KEY FROM IGNITION DUE TO PROBLEM AFTER SHIFTING THE CAR INTO PARK. THIS IS NOT AN ISOLATED INCIDENT AS WE HAVE DISCOVERED MANY OTHER OWNERS WITH FORD FOCUS FROM 200-2007 HAVING THE SAME PROBLEM. THE DANGEROUS ISSUE HERE IS THAT WE HAVE TO LEAVE THE CAR PARKED WITH THE KEY IN THE IGNITION. EVEN THOUGH THE KEY CAN'T BE REMOVED IT CAN STILL START THE CAR AGAIN AND GO. THIS CAR IS LEFT OPEN FOR THIEVES TO STEAL. IT HAS NOT BEEN RECALLED AND IT IS AN EXPENSIVE FIX BY DEALERS SINCE IT'S NOT UNDER WARRANTY. WHY IF THERE ARE SO MANY SITES ON THE WEB WITH OWNERS LIKE MYSELF WITH THIS PROBLEM, NOT BEING ADDRESSED AS A RECALL BY FORD. *TR

NHTSA ID

10276767

Incident

Jul 14, 2009

Mileage

20,000 mi

I PURCHASED A USED 2005 FORD FOCUS WITH EXACTLY 30,000 MILES ON IT, AROUND 40,000 I NOTICED MY TRANSMISSION STARTED TO SLIP, FURTHER RESEARCH REVEALED MANY PEOPLE COMPLAINING OF THIS SAME THING BEFORE THEY EVEN REACH 60,000. SEEMS TO ME IT IS A FACTORY DEFECT IN THE TRANSMISSION. EVEN AFTER BEING LOOKED AT I AM GOING TO HAVE TO PAY LOTS OF MONEY TO GET IT REPAIRED DUE TO THE WARRANTY ONLY BEING AT THE 40,000 MARK. WHICH THE DEALER NEVER TOLD ME THAT THE WARRANTY THEY OFFERED WAS VOID IF ORIGINAL FACTORY WARRANTY WAS STILL IN EFFECT. IN WHICH I ENDED UP ON THE SHORT END OF THE STICK BECAUSE THEIR WARRANTY THEY GIVE FOR THE USED CARS OUTLASTS WHAT I HAD REMAINING ON THE FACTORY WARRANTY. THIS IS RIDICULOUS. SEVERE SLIPPING WHEN TRANSMISSION GOES TO SHIFT INTO THIRD AND FOURTH GEAR. *TR

NHTSA ID

10267724

Incident

Apr 2, 2009

Mileage

40,000 mi

I BOUGHT A 2005 FORD FOCUS ZX3 AT THE END OF 2004. AT 42,000 MILES THE CLUTCH WENT OUT WITHOUT ANY WARNING. I HAVE DRIVEN MANUAL CARS SINCE FIRST GETTING MY LICENSE OVER 20 YEARS AGO, SO I KNOW HOW TO DRIVE A MANUAL TRANSMISSION. I LOOKED UP INFO ON THE INTERNET AND FOUND THAT FORD KNOWS OF THE PROBLEM (TSB# 05256 NHTSA ID# 10018945 DATED JAN. 1, 2005). NOW THAT THE CLUTCH (WHICH FORD KNEW ABOUT ) WENT BAD, FORD SAYS IT IS NOT A WARRANTY PART AND THEY WILL NOT REPLACE, LEAVING ME TO PAY FOR IT OUT OF MY POCKET. I DON'T THINK CUSTOMERS SHOULD PAY FOR FORD'S BAD PARTS. *TR

NHTSA ID

10228759

Incident

May 21, 2008

Mileage

42,000 mi

I PURCHASED A 2005 FORD FOCUS IN JANUARY 2005. APPROXIMATELY 14 MONTHS AFTER THE PURCHASE THE CAR STARTED HAVING MAJOR POWER TRAIN FAILURE. THIS HAS RESULTED IN THE REPAIR/REPLACEMENT OF THE ENGINE, THE CLUTCH 3 TIMES, THE TRANSMISSION, AND THE SHIFTING CABLES. *AK

NHTSA ID

10194267

Incident

Jun 22, 2007

THE TRANSMISSION ON MY 2005 FOCUS WAS DIFFICULT TO SHIFT INTO 1ST GEAR. THE DEALERSHIP REPLACED IT UNDER WARRANTY DURING 7 - 16 MARCH 2007. WHILE DOING THE WORK THEY NICKED THE BRAKE LINE JUST ENOUGH TO CREATE A SLOW LEAK. THE LOCATION OF THE LEAK WAS NEAR THE FRONT LEFT TIRE. AFTER ONE DAY OF DRIVING, ALL THE FLUID LEAKED OUT AND THE BRAKES FAILED WHILE MY WIFE WAS DRIVING IT. THE DEALERSHIP ARRANGED TO PICK UP THE FOCUS WITH A TOW TRUCK. THEY REPAIRED THE BRAKES (19-23 MAR). ON 23 MAR, MY WIFE PICKED UP THE FOCUS. APPROXIMATELY 1/2 MILE FROM THE DEALERSHIP, THE DRIVER'S SIDE AIRBAG DEPLOYED WHILE SHE WAS TURNING LEFT. THE FORCE OF THE IMPACT PUSHED HER LEFT ARM DOWN AND TO THE RIGHT, PULLING THE STEERING WHEEL TO THE LEFT, CAUSING HER TO HIT THE CURB. NO OTHER VEHICLE WAS NEARBY OR INVOLVED. SHE WAS ABLE TO MANEUVER THE FOCUS INTO THE PARKING LOT OF A MEDICAL TREATMENT FACILITY, WHERE SHE WAS TREATED FOR CERVICAL INJURY. THE DEALERSHIP PICKED UP THE FOCUS WITH A TOW TRUCK. AT THE DEALERSHIP THEY PUT THE FOCUS UP ON A LIFT AND I INSPECTED THE UNDERCARRIAGE ALONG WITH THE SERVICE MANAGER AND MECHANIC. THE BRAKE ROTOR WAS COMPLETE SEPARATED FROM THE WHEEL AND THE LOWER CONTROL ARM WAS BENT AT ABOUT A 20 DEGREE ANGLE FROM NORMAL. THE WHEEL WAS NOTICEABLY SCRATCHED AND THE TIRE WAS CUT. THE SERVICE MANAGER SUGGESTED THAT MY WIFE HIT THE CURB CAUSING THE AIRBAG TO DEPLOY. MY WIFE IS ABSOLUTELY POSITIVE THE AIRBAG DEPLOYED CAUSING HER TO HIT THE CURB.*AK

NHTSA ID

10186152

Incident

Mar 23, 2007

ON 2/24/07, I MADE A PURCHASE AT A DRIVE THROUGH WINDOW AT A FAST FOOD RESTAURANT. I LEANED ACROSS THE CENTER CONSOLE TO PLACE THE ORDER ON THE PASSENGER SIDE FLOOR. WHILE DOING SO, I BUMPED THE GEAR SHIFT AND IT MOVED FROM DRIVE TO NEUTRAL WITHOUT DEPRESSING THE LOCK BUTTON ON THE SIDE OF THE GEAR SHIFT HANDLE. UPON ARRIVING HOME, I TESTED THE GEAR SHIFT HANDLE, AND FOUND I COULD MOVE IT FROM REVERSE TO NEUTRAL TO DRIVE, AND FROM DRIVE TO NEUTRAL, ALL WITHOUT DEPRESSING THE GEAR SHIFT RELEASE BUTTON. IT SEEMS TO ME THAT UNINTENDED SHIFTING WHILE DRIVING COULD RESULT IN A SERIOUS INCIDENT, AND I BELIEVE THE SHIFT RELEASE BUTTON IS DESIGNED TO PREVENT THAT. ON THIS VEHICLE, THIS IS A PROBLEM. *JB

NHTSA ID

10183868

Incident

Feb 24, 2007

Mileage

26,150 mi

DT: THE CONTACT STATED THE SHIFT CABLES CONTINUED TO BREAK. THIS HAPPENED THREE TIMES SINCE PURCHASE OF VEHICLE AND ONCE PRIOR TO PURCHASE. THE DEALERSHIP REPLACED THE CABLES TWICE, MADE ADJUSTMENTS TO THE CABLES ONCE, AND REPLACED THE TRANSMISSION. THE CONTACT DID NOT KNOW WHAT REPAIRS WERE MADE BEFORE PURCHASE. THE VEHICLE IS STILL HARD TO GET INTO GEAR. THIS USUALLY HAPPENS BEFORE IT BREAKS. *AK

NHTSA ID

10143043

Incident

Sep 9, 2005

Mileage

14 mi

ONCE ON A 3 LANE EXPRESSWAY (7/29/05) AND ONCE ON A BUSY STREET (8/4/2005), THE STICK SHIFT DISCONNECTED ITSELF FROM THE TRANSMISSION LEAVING ME IN NEUTRAL THE FIRST TIME AND 1ST GEAR THE SECOND TIME. THE 2005 (245 MILES ON IT) FORD FOCUS LEFT ME IN A SITUATION WHERE I WAS A SITTING DUCK AND ALMOST GOT REAR ENDED THE FIRST TIME AND YELLED AT THE SECOND TIME. THE DEALER (FRONTIER FORD, SANTA CLARA, CA) RECONNECTED THE LINKAGE THE FIRST TIME IT WAS TOWED IN. IT FAILED AGAIN ON 8/4 AND WAS TOWED IN AGAIN. NOW THE CAR HAS BEEN SITTING AT THE DEALERSHIP SINCE 8/4/2005 AWAITING PARTS. THE DEALER SAID MY MANUAL TRANSMISSION CAR WAS NOT THE ONLY ONE TO EXHIBIT THIS FAILURE. THIS IS OBVIOUSLY A SAFETY HAZARD AND FORD IS DOING NOTHING TO FIX IT BUT TELL ME THAT THE CABLE ASSEMBLY IS ON ORDER. *NM

NHTSA ID

10135024

Incident

Jul 29, 2005

Mileage

245 mi

I PURCHASED A BRAND NEW 2005 FORD FOCUS ZX4 IN DECEMBER OF 2005. UPON DELIVERY I NOTICED MY CAR HAD A HARD TIME STARTING AND THE WHOLE ENGINE WOULD SHAKE AND KNOCK. AFTER A MONTH I TOOK IT INTO THE DEALER AND THEY SAID THEY COULDN'T FIND A PROBLEM. THE CONDITION CONTINUED AND I TOOK IT IN AGAIN AND THEY COULDN'T FIND A PROBLEM BUT ASKED TO KEEP IT FOR AN OVERNIGHT START. I BROUGHT IT IN A FEW DAYS LATER SO THEY COULD KEEP IT OVER NIGHT AND THEY FOUND A BULLETIN BY FORD SAYING THEY KNOW THERE IS A HARD START PROBLEM BUT THEY DON'T KNOW HOW TO FIX IT. I THEN HAD TO HAVE THE DRIVER'S SEAT BELT REPLACED BECAUSE IT WOULDN'T UNLATCH OCCASIONALLY. I THEN HAD TO HAVE THE PASSENGER SIDE DOOR CASING REPLACED BECAUSE IT WAS DISCOLORED. THEN ABOUT A MONTH AND A HALF AGO I WAS DRIVING DOWN THE HIGHWAY AT 62 MILES AN HOUR AND MY CLUTCH WENT OUT AND MY CAR DIED IN THE MIDDLE OF THE HIGHWAY. I WAS ALMOST HIT BY ANOTHER CAR AND HAD TO WEIGHT IN 90 DEGREE WEATHER FOR 2 HOURS FOR A TOW TRUCK TO COME. MY CAR WAS TOWED TO FORD AND THEY SAID MY FLY WHEEL HAD CRUMBLED AND MY CLUTCH WAS BAD. IT TOOK THEM 9 DAYS TO REPLACE MY CLUTCH. A DAY LATER MY CAR WOULD NOT DOWNSHIFT WITHOUT GRINDING AND I HAD TO TAKE IT BACK TO THE DEALER. THEY SAID THAT THIS TIME THEY HAD TO REPLACE MY TRANSMISSION BECAUSE IT WAS RUINED AS WELL. TO THIS DAY MY CAR IS STILL IN THE SHOP AND HAS BEEN THERE FOR 32 DAYS JUST FOR THE REPLACEMENT OF THE TRANSMISSION. MY CAR IS ONLY 8 MONTHS OLD AND HAS BEEN IN THE SHOP FOR REPAIR OR DIAGNOSIS FOR A TOTAL OF 45 DAYS SO FAR. NEITHER WENDLE MOTORS OR FORD WILL REPLACE THE CAR SO I AM PERUSING A LEMON LAW CASE. *JB

NHTSA ID

10134406

Incident

Jan 1, 2005

Mileage

9,000 mi

DT: 2005 FORD FOCUS. THE CONSUMERS VEHICLE HAS BEEN IN THE SHOP FOR OVER A MONTH. THE FIRST INDICATION WAS THAT IT WOULD NOT SHIFT RIGHT AND THE TRANSMISSION LOCKED UP. THE CONSUMER HAD TO DRIVE IT TO THE DEALERSHIP IN 3RD GEAR. THE PART WAS ON BACK-ORDER, AND THERE WERE SO MANY ON ORDER THAT THERE WAS NO KNOWN DATE WHEN THE PART WOULD BECOME AVAILABLE. *JB

NHTSA ID

10129901

Incident

Jun 26, 2005

Mileage

15,000 mi

2005 FORD FOCUS AUTOMATIC TRANSMISSION COMPLAINTS.*MR THE TRANSMISSION WHINED AT LOW SPEEDS (40-50 MPH). FORD REFUSED TO SEND A FACTORY REP. *NM

NHTSA ID

10119154

Incident

Nov 1, 2004

COMPLAINT RECEIVED VIA E-MAIL. PROBLEM CONCERNED ANNOYING LOW SPEED TRANSMISSION AT 40-50 MPH. FORD REFUSES TO SEND A FACTORY REPRESENTATIVE. *AK

NHTSA ID

10099835

Incident

Oct 15, 2004

TRANSMISSION SLIPS & ERRATIC SHIFTS. *NM

NHTSA ID

10095564

Incident

Aug 5, 2004