2005 Ford Mustang Problems

The contact owns a 2005 Ford Mustang. The contact stated that during inclement weather, water was entering the cabin of the vehicle through the passenger’s side glove box. The contact stated that due to the failure, mold had developed throughout the vehicle on the carpet, doors, and interior seats. The contact's husband also discovered that water had entered the computer module after inspecting the vehicle and the module was removed. The contact stated that the vehicle was inoperable after several repairs and several battery replacements. The vehicle was not repaired. The contact called the dealer and was referred to the manufacturer for assistance. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 87,000.

Took the 2005 Mustang GT in several years ago to have one airbag replaced. Dealer (Autonation Torrance, California) stated parts were not available for the other side. One of the airbags has never been replaced. I now read there is a "Do Not Drive" recall for vehicles of this year and model in "Zone A".

The contact owns a 2005 Ford Mustang. The contact stated that during inclement weather, water was entering the cabin of the vehicle through the passenger’s side glove box. The contact stated that due to the failure, mold had developed throughout the vehicle on the carpet, doors, and interior seats. The contact's husband also discovered that water had entered the computer module after inspecting the vehicle and the module was removed. The contact stated that the vehicle was inoperable after several repairs and several battery replacements. The vehicle was not repaired. The contact called the dealer and was referred to the manufacturer for assistance. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 87,000.

The contact owns a 2005 Ford Mustang. The contact stated while driving 65 MPH on a rainy night, the headlights started flickering. The contact stated that upon exiting the freeway, while driving 30 MPH, the headlights completely turned off and the hazard lights were inoperable. The contact drove to the nearest gas station and turned off the vehicle. The contact stated that upon attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to the residence. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 170,000.

The contact owns a 2005 Ford Mustang. The contact stated that while her husband was attempting to fuel the vehicle, the fuel tank was unable to be fully fueled. The contact stated that either the nozzle would shut off prematurely or gasoline would be prevented from flowing into the fuel tank. There was no warning light illuminated. The contact stated that the failure was intermittent, but by late 2024, the fuel tank could no longer be filled, and the vehicle was placed in storage. The vehicle was taken to a local dealer prior to being placed in storage, and the contact was informed that the fuel tank needed to be replaced. The contact was made aware of Technical Service Bulletin Number: 05-15012; however, the vehicle was not covered under warranty. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 32,000.

Ford did issue a recall for several issues for my car, including but not limited to, problems when filling gas tank with evaporative purge system as well as cavitation of the fuel pump in high heat conditions, the doors not closing all the way or handles remaining open( not flush with rest of door) when door is shut, driver's side door trim/bezel around power window switch making buzzing sounds when stereo is in use, as well as ticking sounds coming from motor during operation and various creaks and sounds from front suspension when cornering and going over uneven terrain, and the transmission, the 5r55s, has the known hard shift into gear caused by bad servo. I have reached out to the dealers in my area regarding these issues and even though my car is the correct model and year for the service recall bulletins and has the exact issues described there in, I am told that the vin on my car is not covered even though it is clearly suffering from equipment that exhibits all the same problems listed in the recall. I feel the responsibility to perform and pay for these repairs should fall on the manufacturer, not i, the customer.

The contact owns a 2005 Ford Mustang. The contact stated that during inclement weather, water was entering the cabin of the vehicle through the passenger’s side glove box. The contact stated that due to the failure, mold had developed throughout the vehicle on the carpet, doors, and interior seats. The contact's husband also discovered that water had entered the computer module after inspecting the vehicle and the module was removed. The contact stated that the vehicle was inoperable after several repairs and several battery replacements. The vehicle was not repaired. The contact called the dealer and was referred to the manufacturer for assistance. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 87,000.

Ford did issue a recall for several issues for my car, including but not limited to, problems when filling gas tank with evaporative purge system as well as cavitation of the fuel pump in high heat conditions, the doors not closing all the way or handles remaining open( not flush with rest of door) when door is shut, driver's side door trim/bezel around power window switch making buzzing sounds when stereo is in use, as well as ticking sounds coming from motor during operation and various creaks and sounds from front suspension when cornering and going over uneven terrain, and the transmission, the 5r55s, has the known hard shift into gear caused by bad servo. I have reached out to the dealers in my area regarding these issues and even though my car is the correct model and year for the service recall bulletins and has the exact issues described there in, I am told that the vin on my car is not covered even though it is clearly suffering from equipment that exhibits all the same problems listed in the recall. I feel the responsibility to perform and pay for these repairs should fall on the manufacturer, not i, the customer.

I WAS PULLING OUT OF WORK ONTO A BUSY STREET WHEN CAR WENT INTO IDLE MODE BECAUSE OF THE THROTTLE BODY DRIVE BY WIRE SYSTEM.THERE WAS NO INDICATION ANYTHING WAS WRONG OR ABOUT TO GO WRONG. GOD WAS REALLY LOOKING OUT FOR ME ON THIS PARTICULAR DAY BECAUSE THE CARS THAT WERE ON THIS BUSY ROAD WASN'T IN A HURRY LIKE THEY NORMALLY ARE AND I AVOIDED A (T-BONE)COLLISION. IT REALLY SCARED ME AND I HAVEN'T DROVE THE CAR ANYMORE AND IT'S FOR SALE. I THOUGHT IT SHOULD BE REPORTED AND I WILL TELL WHOEVER BUYS THE CAR WHAT HAPPENED UPFRONT. I'M NOT WILLING TO RISK IT DOING THE SAME THING AGAIN. I SWITCHED THE KEY OFF AND STARTED THE CAR BACK UP AND DROVE IT 40 MILES HOME WITHOUT ANY PROBLEMS AND IT WILL NEVER BE DRIVEN BY ME AGAIN.

ENGINE GOES TO FUEL THROTTLE WHILE DRIVING ON HIGHWAY OR IN TOWN & ALSO WHEN AT A FULL STOP ON ITS OWN I HAVE TO EITHER SHUT OFF IGNITION OR IF DRIVING PUT VEHICLE IN NEUTRAL THEN HIT THROTTLE TO STOP THE HIGH RPM EXTREMELY UNSAFE. HAVE NOT DRIVEN CAR IN OVER TWO MONTHD

The contact owns a 2005 Ford Mustang. The contact stated that the check engine warning light was illuminated. While driving at approximately 25-35 MPH for approximately two miles, the engine started overheating. The oil pan gasket was leaking. The contact stated that the failure was related to NHTSA Campaign Number: 16V779000 (Engine and Engine Cooling). There were several hoses that were split. The vehicle was taken to an independent mechanic who determined that the radiator and engine were cracked, and the pistons were loose. There was air in the oil. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 123,000.

I have experienced two engine failures in my 2005 Ford Mustang due to timing chain issues, specifically the failure of the timing chain cassette, guides, and tensioners in the 4.0L SOHC V6 engine. The first failure happened suddenly with no warning, resulting in severe bottom-end damage, including rod knock. The timing chain cassette ends tend to snap off, sending debris through the engine and damaging lifters, camshafts, and other critical components. The second failure was preceded by an audible “death rattle,” a known symptom of timing chain guide and tensioner failure. Despite this, my vehicle never displayed a check engine light or oil pressure warning before either failure. Unlike later Mustangs with an oil pressure gauge, mine only has a warning light, which never activated.This issue poses a major safety risk, especially at highway speeds. My first engine failure occurred with no prior symptoms, which could have led to an accident had I been merging or overtaking. A failing timing chain can cause misfires, loss of power, or sudden engine shutdown, endangering the driver and others on the road. Independent mechanics have confirmed this issue, and Ford service centers recognize it as a common problem with the 4.0L SOHC V6 engine. Ford has quoted $3,000–$4,000 for timing chain service, making repairs nearly as expensive as engine replacement. These engines rely on multiple chains and hydraulic tensioners that wear out over time, causing slack in the timing chain, jumped timing, and catastrophic damage, typically after 100,000 miles. Despite this, there are no clear warning systems to alert drivers before failure occurs. While timing chains are considered serviceable components, the high failure rate of the timing chain guides and tensioners in these engines, combined with excessive repair costs, indicates a design flaw. I have spent around $4,500 addressing this issue, yet the risk of recurrence remains.

I have done all my airbag recalls and the light came on a few months ago and is steady flashing. Called Cresent Ford in High Pint and they looked up my VIN and my car replacement history. They told me it had been replaced but it was still under warranty and to make an appointment to have it looked at. Made an appointment, which I may add I had to take the day off and drive 40 mins one way, I was told by [XXX] that I had to pay for a diagnostic test because it may not be the airbag and they refused to look at the car until I paid for a diagnostic test. I continue to receive airbag notices and if I was told on the phone this was under warranty. If there are problems in the past with airbags and in the future, we have problems why should this not be covered and looked at by Ford at cost to them to run a diagnostic test. This is absurd. Had this happened to me 3 months ago I NEVER would not have purchased a 2010 Mustang if this is how you do your customers for your defective parts. Also went to pull the parking brake up, which was passed inspection SEVERAL times, and the brake does not work. This is a BIG safety hazard. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

JUST GOT IT DON'T KNOW WHAT'S WRONG WITH IT

THERE WAS A RECALLL FOR DEFAULT WITH THE EMERGENCY BRAKE AND TAKATA AIRBAG

TL* THE CONTACT OWNED A 2005 FORD MUSTANG. WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT DRIVER SIDE CONTROL ARM FRACTURED AND CAUSED THE DRIVER TO LOSE STEERING CONTROL. AS A RESULT, THE VEHICLE CRASHED INTO A TREE. IN ADDITION, THE AIR BAGS FAILED TO DEPLOY. THE DRIVER SUFFERED FROM A HEAD CONCUSSION, LACERATION TO THE FACE, AND BODY BRUISES THAT INCLUDED SEVERE INJURIES TO THE STOMACH AND BLOOD CLOTS. MEDICAL ATTENTION WAS RECEIVED. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE FACILITY. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,603.

The contact owns a 2005 Ford Mustang. The contact stated while driving 65 MPH on a rainy night, the headlights started flickering. The contact stated that upon exiting the freeway, while driving 30 MPH, the headlights completely turned off and the hazard lights were inoperable. The contact drove to the nearest gas station and turned off the vehicle. The contact stated that upon attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to the residence. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 170,000.

Body control module. It gets wet when it rains because of an engineering mess up. It shorts out my lights. Sometimes it can't get out of car because it messes with the locks and windows. Can't use my electric mirrors anymore. Instead of being a much needed recall they decided to not even make replacement bcm. It is a problem everything it gets wet that should have been recalled and fixed. At least a thousand other incidents of this happening to others.

TL* THE CONTACT OWNS A 2005 FORD MUSTANG. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO SWITCH GEARS, THE CLUTCH PEDAL WAS DEPRESSED AND A CRUNCH SOUND WAS HEARD. THE CLUTCH PEDAL TRAVELED ALL THE WAY TO THE FLOORBOARD. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS SWITCHED TO THE NEUTRAL POSITION AND CAME TO A COMPLETE STOP. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS INSPECTED AND A PIECE OF PLASTIC WAS FOUND FRACTURED INTO TWO PARTS ON THE FLOOR OF THE VEHICLE UNDER THE CLUTCH PEDAL. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

WHEN STOPPED SUDDENLY THE CAR WILL REMAIN IDLE FOR ABOUT 30 SECONDS BEFORE IT WILL KICK BACK INTO GEAR. WHEN THIS HAPPENS, CAR WILL ROLL BACKWARDS IN DRIVE. IF YOU TRY TO PRESS THE GAS TO FORCE THE CAR TO MOVE IT WILL STALL COMPLETELY. CAR HAS BEEN DOING IT SINCE 2007. FORD DEALERSHIP COULD NOT FIND ANYTHING WRONG WITH IT. CAR CURRENTLY HAS 44,000 MILES ON IT. ALSO GAS, TEMP AND SPEEDOMETER GAUGES HAVE STARTED GOING CRAZY THE LAST THREE WEEKS. *TR

: :..UPDATED 03/08/17 *BF

PRIMEWELL VALERA TOURING PART NUMBER 004-217, BOUGHT TIRES IN OCT/NOV 2013 AT 83000 MILES. CURRENTLY HAVE 106,000 MILES. ONE OF THE FOUR TIRES IS STARTING TO GET VISUAL TIRE SEPERATION, A SECOND HAS SIMILIAR MARKINGS BUT NOT AS SEVERE

THERE WAS A RECALLL FOR DEFAULT WITH THE EMERGENCY BRAKE AND TAKATA AIRBAG

MY TACHOMETER FAIL A FEW YEARS AGO. WHEN I TOOK IT TO THE DEALER, HE SAID ALL MUSTANG GAUGES FAIL AND TO BE HAPPY IT WASN'T THE SPEEDOMETER. SLOWLY OVER TIME ALL THE ELECTRICAL HAS BEEN HAVING PROBLEMS. SOMETIMES THE CAR WON'T START, ALL THE GAUGES STOP WORKING, THE CHECK ENGINE LIGHT GOES ON AND OFF FOR NO REASON. ALSO THE DRIVER SEAT ELECTRICAL FAILED, WAS REPLACED AND FAILED AGAIN. I COULDN'T AFFORD TO HAVE IT FIXED.

Ford did issue a recall for several issues for my car, including but not limited to, problems when filling gas tank with evaporative purge system as well as cavitation of the fuel pump in high heat conditions, the doors not closing all the way or handles remaining open( not flush with rest of door) when door is shut, driver's side door trim/bezel around power window switch making buzzing sounds when stereo is in use, as well as ticking sounds coming from motor during operation and various creaks and sounds from front suspension when cornering and going over uneven terrain, and the transmission, the 5r55s, has the known hard shift into gear caused by bad servo. I have reached out to the dealers in my area regarding these issues and even though my car is the correct model and year for the service recall bulletins and has the exact issues described there in, I am told that the vin on my car is not covered even though it is clearly suffering from equipment that exhibits all the same problems listed in the recall. I feel the responsibility to perform and pay for these repairs should fall on the manufacturer, not i, the customer.

THROTTLE BODY FAILED AS I WAS DRIVING AT SPEED ON THE FREEWAY. WHEN IT FAILED, THE VEHICLE IMMEDIATELY WENT INTO IDLE MODE WHICH MADE IT VERY DANGEROUS TO AVOID TRAFFIC AS I ATTEMPTED TO MOVE ONTO THE SHOULDER OF THE FREEWAY. THE CAR MOVED AT NO MORE THAN 5MPH! THE REPAIR IS VERY EXPENSIVE. I FEEL THAT THIS PART SHOULD NOT FAIL AFTER JUST 76,000 MILES. ATTACHED IS THE REPAIR BILL. *TR

THE CAR WAS COASTING AND THEN JUST COMPLETELY TURNED OFF REDUCING STEERING AND BRAKING ABILITY AT LEAST 50% UNTIL I COULD COME TO A COMPLETE STOP, TURN OFF THE IGNITION, THEN RESTART IT AGAIN. SINCE THEN THIS HAS HAPPENED AT LEAST 5 TIMES, 4 IN THE LAST WEEK! MY TOTALLY TRUSTWORTHY MECHANIC DID A DIAGNOSTIC TEST AND FOUND NO FAILURES BESIDES THE FACT THAT THE FUEL GAUGE HASN'T WORKED IN YEARS, THE SPEEDOMETER DOESN'T ALWAYS TELL ME THE SPEED, THE GAS TANK SHUTS OFF BEFORE FILLING UP, THE HEAD LIGHTS AND INTERIOR LIGHTS HAVE STAYED ON AFTER TURNING OFF THE CAR AND HASN'T TURNED OFF AFTER IT'S RAINED. THE RPM SEEMS TO BE THE PROBLEM FOR WHY THE ENGINE TURNS OFF WHEN THEY ARE TOO LOW. THERE USED TO BE A JERKY PROBLEM DURING ACCELERATION WHEN THE CAR WOULD SHOOT FORWARD THEN BACK OFF A COUPLE TIMES BEFORE RETURNING TO A MORE STEADY ACCELERATION. I WOULD CONSIDER THIS VEHICLE A COMPLETE LEMON AND THREAT TO THE SAFETY OF ME AND ANYBODY ELSE ON THE ROAD BUT SINCE THE WARRANTY PERIOD IS OVER AND IT'S BEEN TAKEN TO A MECHANIC I DON'T HAVE ANY OTHER OPTIONS BESIDES REPORTING IT TO YOU, I REALLY WISH THERE WAS SOME WAY THIS PROBLEM COULD BE SOLVED AND I'M CERTAIN MANY OTHER OWNERS OF THIS SAME VEHICLE ARE DEALING WITH THE SAME PROBLEM. *TR

THE CAR STALLED WHILE CRUISING AT HIGHWAY SPEEDS. NEEDED TO PULL OVER TO WITHOUT POWER STEERING OR BRAKES AND RESTART THE CAR. THIS IS NOT AN ISOLATED INCIDENT. HTTP://WWW.NCCONSUMER.ORG/NEWS-ARTICLES/NCCC%20PETITIONS%20NHTSA%20FOR%20DEFECT%20INVESTIGATION%20INTO%20FORD%20ESCAPE%20VEHICLES.HTML. *TR

ALL OF MY TIRES HAVE BULGES AND PITS IN THEM. I'VE ONLY HAD MY VEHICLE FOR ONE YEAR. THE TIRES STILL HAVE EXCELLENT TREAD ON THEM, BUT THEY'VE DEVELOPED PITS AND BULGES. I NEVER DRIVE ON THE GRAVEL AND I LIVE ON A PAVED ROAD. I TOOK MY CAR TO MY MECHANIC AND HE BELIEVES THAT THE TIRES HAVE SOME KIND OF DEFECT. THE SIZE OF MY TIRES ARE 215 / 65/R16. *TR

I STARTED TO HAVE PROBLEMS WITH THE HANDLING OF MY 2005 MUSTANG GT WHEN I WOULD DRIVE DOWN THE ROAD. IT WOULD SWERVE IN THE OTHER LANES AND IT WOULD HIT THE ROAD BUMPS AND HOLES LIKE A "GO KART" WOULD. I NOTICED SINCE I PUT ON MY 245/45/17 B.F.GOODRICH TIRES THAT I STARTED HAVING ALL THESE PROBLEMS. I ASKED THE FORD PLACE WHAT I NEEDED TO DO BECAUSE MY TIRE IN THE INNER PART WAS WEARING OUT AND MY FABRIC HAD STARTED TO SHOW. THE FORD DEALERSHIP WOULD NOT HELP ME AT ALL, ALL THEY WOULD TELL ME IS THAT I SHOULD HAVE NEVER CHANGED THE ORIGINAL TIRES AND WHEELS. I HAVE NOW AMERICAN RACING WHEELS WITH THOSE B.F.GOODRICH TIRES STILL ON, BUT I HAVE NOT DROVE MY CAR IN ABOUT A WEEK. *NM

I WAS DRIVING ON THE FREEWAY REAR ENDED A OLD NISSAN TRUCK WHICH RESULTED IN ME HITTING MY HEAD AGAINST THE STEERING WHEEL AND TOTALING MY CAR. I WAS GOING 40MPH AND MY AIR BAGS DID NOT DEPLOY. *TR

TL*THE CONTACT OWNS A 2005 FORD MUSTANG. WHILE DRIVING 39 MPH, AN ONCOMING VEHICLE CRASHED INTO THE DRIVERS SIDE OF THE CONTACTS VEHICLE. THE SEAT BELT DID NOT ENGAGE AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED A CONCUSSION. THE VEHICLE WAS DESTROYED. THE CONTACT CALLED THE DEALER WHO STATED THAT THEY WOULD GIVE HIS INFORMATION TO THE COUNCIL AND PROVIDE HIM WITH A RESPONSE. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 49,000.

THE 2005 MUSTANG WINDSHIELD GLASS SEEMS TO BE MUCH "SOFTER" THAN OTHERS ON THE MARKET. WITH ONLY A FEW THOUSAND MILES ON THE CAR I STARTED NOTICING QUITE A FEW VERY SMALL (PIN SIZE) CHIPS IN THE GLASS. NOW AFTER 17K MILES THERE ARE THOUSANDS OF THESE LITTLE CHIPS. THIS WINDSHIELD LOOKS WORSE THAN MY OLD PICKUP THAT HAD OVER 250K MILES. I HAVE SPOKEN TO SEVERAL OTHER 05 OWNERS IN THE FORUMS AND HAVE FOUND THAT THEY TOO ARE EXPERIENCING SOMETHING SIMILAR TO THIS ISSUE WITH THEIR VEHICLE. THE DEALER STATED THAT IT TOO SEEMED TO BE AN EXCESSIVE AMOUNT OF CHIPS WHEN LOOKING AT THE GENERAL CONDITION OF THE REST OF THE VEHICLE. A FEW MINOR CHIPS ON THE FRONT FASCIA AND HOOD ARE ALL THAT THERE IS UP FRONT. NO GRAVEL ROADS IN MY AREA, NOT MUCH CONSTRUCTION EITHER. MY HABITS WHEN DRIVING ARE TO AVOID LARGE VEHICLES AND STAY IN THE OTHER LANES WHEN BEHIND ONE.*JB