1991 Ford Probe

ON JUNE 29, 2007, NHTSA RECEIVED A PETITION FROM MR. RICHARD H. MCSWAIN OF MCSWAIN ENGINEERING INC., REQUESTING THAT THE AGENCY INVESTIGATE SEATBACK RECLINER FAILURE IN THE SUBJECT VEHICLES. THE PETITIONER IDENTIFIED A FAILURE MODE INVOLVING BYPASS OF THE SEATBACK STOP PIN WHICH COULD RESULT IN A FALSE OR PARTIAL ENGAGEMENT OF THE SECTOR AND PAWL TEETH, ALLOWING THE SEATBACK TO RECLINE IN A VEHICULAR COLLISION.ODI BELIEVES THAT THE ALLEGED FAILURE MODE MAY BE THE RESULT OF PROGRESSIVE WEAR AND TEAR OF THE SEATBACK STOP PIN, THE SEATBACK STOP, AND OTHER SEAT COMPONENTS IN VEHICLES THAT ARE, ON AVERAGE, 17 YEARS OLD.AVAILABLE DATA DO NOT SUGGEST THAT THIS HAS OCCURRED WITH A NOTABLE FREQUENCY. ODI REVIEWED ITS CONSUMER COMPLAINT DATA RECEIVED OVER THE LAST NINETEEN YEARS AND FOUND NO COMPLAINTS OF SEATBACK COLLAPSE (WITH OR WITHOUT A VEHICLE COLLISION) IN THE SUBJECT VEHICLES.CONSIDERING THE ADVANCED AGE OF THE SUBJECT VEHICLES, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THE STATUTORY REQUIREMENT THAT THE MANUFACTURER PROVIDE A FREE REMEDY DOES NOT APPLY IF THE VEHICLE WAS BOUGHT BY THE FIRST PURCHASER MORE THAN 10 CALENDAR YEARS BEFORE AN ORDER IS ISSUED. THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.

There is no summary currently available

MALFUNCTION OF THE AUTOMATIC SEAT BELT SYSTEM

There is no summary currently available

THE DRIVER SIDE SEAT BELT IS STUCK ON THE TRACK TOWARDS THE BACK OF IT'S TRACK AND NO LONGER MOVES OR ENGAGES.

NHTSA ID

11128305

Incident

Jan 1, 2000

Mileage

80,000 mi

TL*THE CONTACT OWNS A 1991 FORD PROBE. WHENEVER THE CONTACT DROVE THE VEHICLE AT VARIOUS SPEEDS TO INCLUDE APPROXIMATELY 60 MPH, USING THE CRUISE CONTROL THE VEHICLE SPEED INCREASED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 113000.

NHTSA ID

10303610

Incident

May 16, 1991

Mileage

113,000 mi

TL*THE CONTACT OWNS A 1991 FORD PROBE. THE CONTACT STATED THAT THE CABLE WHICH RETRACTS THE BUCKLE ASSEMBLY JAMMED AND CAUSED THE SEAT BELT TO FAIL. THE DEALER STATED THAT THIS VEHICLE WAS EXCLUDED FROM RECALL # 96V172001 DUE TO THE VIN. THE CURRENT AND FAILURE MILEAGE WERE 100,000.*AK

NHTSA ID

10187450

Incident

Jan 6, 1996

Mileage

100,000 mi

DT*: THE CONTACT STATED IMMEDIATELY AFTER PURCHASING A VEHICLE, IT WAS NOTICED THE SEAT BELT DID NOT RETRACT AND WAS JAMMED IN THE RAIL RENDERING THE BELT INOPERATIVE. THE CONTACT CHECKED FOR RECALLS ON THE NHTSA WEBSITE AND FOUND THE NHTSA RECALL CAMPAIGN # 96V172001 COVERED THE DEFECT. THE MANUFACTURER WAS CONTACTED WHO INFORMED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE CONTACT WAS VERY CONCERNED BECAUSE THE DESCRIPTION IN THE RECALL MATCHED EXACTLY THE PROBLEMS, THE VEHICLE'S SEAT BELT HAD.

NHTSA ID

10174070

Incident

Oct 18, 2006

Mileage

174,356 mi

I OWN A 1991 FORD PROBE. THE DRIVERS SIDE AUTO-RETRACT SEAT-BELT ASSEMBLY IS JAMMED. SEARCHING ON THE INTERNET, (AUTOZONE RECALLS AND THIS WEB-SITE FOR TWO), I FIND INTERESTING INFORMATION REGARDING THIS ISSUE. PARTICULARLY NHTSA ID # 96V172001 / FORD RECALL 96S48 THAT DESCRIBES THIS. ALSO THE LINK ON YOUR SITE TO THIS PDF (RC-96V172-NN.PDF), IS ALSO OF INTEREST. MY ISSUE / COMPLAINT IS THAT I TOLD MY LOCAL FORD DEALER AS WELL AS HAD FORD MOTOR CO. RUN MY VIN AND THEY STATED MY VIN WAS NOT PART OF THE RECALL CAMPAIGN. I DO NOTICE THAT IN THE ABOVE PDF A STATEMENT THAT ALL PROBES STARTING AS EARLY AS 1990 WITH THIS RESTRAINT SYSTEM ARE TO BE COVERED UNDER THE RECALL. THIS SYSTEM ON THIS CAR IS FAULTY. IN IOWA THERE IS A SEAT BELT LAW. ALTHOUGH I AM NOT THE ORIGINAL OWNER, I KNOW 2 OF THE 3 OTHER OWNERS OF THIS. IT HAS ONLY 88,000 MILES. REGARDLESS OF AGE OR CONDITION, I UNDERSTAND THIS SHOULD BE COVERED UNDER THE FORD RECALL CAMPAIGN AND I SHOULD BE FREE OF ANY FINANCIAL RESPONSIBILITY TO REPAIR THE PROBLEM. ANY INPUT? *JB

NHTSA ID

10164135

Incident

Aug 1, 2006

(1) PURCHASED THE VEHICLE (2) LEARNED THE HORN DID NOT WORK (3) PURCHASED A REPLACEMENT HORN, AND REQUESTED INFORMATION FROM FORD AND 3 DEALERS WHERE IT WOULD BE LOCATED. ALL, EXCEPT 1 DEALER, REFUSED TO GIVE US ANY INFORMATION. THE LAST DEALER WAS NOT CERTAIN. FORD'S COMMENT WAS THIS WAS "PRIVATE COMPANY INFORMATION" OR "WE DON'T HAVE THAT INFORMATION". SUGGESTED WE CONTACT THEIR PRINTING COMPANY WHO WOULD SELL US SCHEMATICS. PRINTING COMPANY HAD NO IDEA WHICH SET OF SCHEMATICS WE WOULD NEED. VEHICLES ARE REQUIRED TO HAVE WORKING HORNS FOR SAFETY REASONS. FORD WANTED TO SELL US $100 WORTH OF SERVICE TO INSTALL A $15 PART.*AK

NHTSA ID

10097939

Incident

Aug 4, 2004

Mileage

130,000 mi

I READ YOUR COMPLAINT PAGE, HAVE HAD THE CAR SINCE 91 AND I HAVE ALL THE SAME PROBS, 1 PERSON SAID HE HAD 2 INCHES OF WATER IN THE CAR, TRY 6. THE PAINT WASNT RIGHT FROM DAY 1. THE CV JOINTS/AXELS WENT BAD AFTER 2 YEARS AND IVE GOT BY TILL NOW BUT THE RATTLE IS ANNOYING. THE EXHAUST SYS ALSO RATTLES. FRONT TIRES GO YEARLY. AIR CONDITIONER NEVER HAS BLOWN COLD. AND THE DOOR ON THE GLOVE COMPARTMENT IS TO HEAVY FOR THE LATCH, I RIDE 6 MNTHS OF EVERY YEAR WITH AN OPEN GLOVE COMPARTMENT.THE HATCHBACK LEAKS, AND THE PAINT WELL, WHO KNOWS WHERE THEY GOT THAT BLEND. THE CAR ALWAYS RUNS COLD WHICH CAUSES THE ROUGH IDLE AND START AND 14 INCH WHEELS WERENT SUFFICIENT FOR A CAR THAT BIG. I WILL SAY THAT FORD BENT OVER BACKWARDS TO GET THE ITEMS FIXED I JUST CANT LEAVE IT THERE BI-WEEKLY.THEY DID REPAINT IT TWICE AND HONORED THE SEATBELT RECALL THIS YEAR, 2003.THE CAR NOW HAS 200,000 MILES AND HAS NEVER FAILED SMOG OR SPENT ONE DAY ON A TOW TRUCK OR IN A SHOP BECAUSE IT WOULDNT START. ITS BEEN A LONG NOISY AND EXTREMELY HOT RIDE, AND I HOPE THEY LEARNED AFTER THOSE BAD YEARS. BUT JUST RECENTLY I ASKED A MECHANIC ON HIS OPINION IF I SHOULD BUY A TAURUS. HE POINTED TO A CAR IN THE BACK OF HIS SHOP AND SAID THAT CAR IS PAYING FOR HIS SONS COLLEGE. 6TH TIME THIS YEAR HES HAD IT AND HE STRONGLY ADVISED ME TO NEVER PURCHASE A FORD CAR. ALL THE PROBS WITH THE PROBE ARE SAME WITH THE TAURUS. I MIGHT GET 50000 MORE MILES BUT DOUBT IT. BUT I DONT THINK THEY TRIED TO CHEAT ME, FORD WORKED WITH ME FROM THE DAY I SAT IN THE DEALERSHIP AND THEY STILL ARE.

NHTSA ID

10069753

Incident

Jan 15, 1993

Mileage

15,000 mi

THE CONSUMER WAS REFERRED TO THE DEALER BY AN AUTO REPAIR SHOP FOR RECALLS ON THE SEAT BELTS. THE DEALER STATED THE VEHICLE WAS IN THE REMEDY SCOPE, BUT THE RECALL HAD EXPIRED. THE DRIVER AND PASSENGER SIDE SEAT BELTS DID NOT RETRACT PROPERLY. RECALL# 96V172001 AND 96V172002 SUBJECT: AUTOMATIC SHOULDER BELT.*AK *JB

NHTSA ID

10034285

Incident

Aug 20, 2003

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC

ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS

INFORMATION REGARDING THE RECALL 96S48 & 96S99 (MOTORIZED SEAT BELT RAIL AND MOTOR ASSEMBLY). *MJS

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT

INFORMATION ON "WHINING" / "BUZZING" NOISE COMING THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER CAUSED BY THE FUEL PUMP. *TT