2014 Ford Taurus Engine Problems

Driving down CR 230 in Wyoming, the situation started if I have to estimate, 7 miles west of Woods Landing, I heard a metal on metal grinding noise from the engine bay, and a loss of power on the throttle. I look at my RPM gauge and notice it is a zero. No check engine light, all electronics working as normal along with the brakes, and I slow the vehicle down to 30 MPH. Shortly after noticing, I get a "Check Brake System" flash on my instrument panel cluster, also the light which illuminates for my parking brake turns on, and I lose power brakes, the brake pedal turned extremely stiff. I immediately look for a pull off zone, but because I had lost brakes I did not want to risk keeping the vehicle moving. I get the vehicle stopped on the side of the road, and instantly put it in park along with the parking brake and shut the vehicle off. The vehicle would not start or crank, just a flash across all of the electronics, the lights go dark, then illuminate again as if normal. This is an extremely dangerous situation, the vehicle had not notified me that the motor had stopped turning; not a check engine light or ring at all, and shortly after that the power brakes stop working. This is very dangerous for motorists because of the lack of notification from the vehicle, and the incredibly weak breaking ability. If the vehicle had been moving at highway speeds, any sort of traffic, I could've ended up injured or dead, and even worse, killed another driver. The vehicle was towed to the nearest town where it would be inspected by a dealership; they reported to have found coolant in the oil and that the vehicle needed a new motor. No other details have been confirmed, and the problem has not been reproduced by the dealership. It is unknown if the dealership inspected the braking system.

NHTSA ID

11636388

Incident

Jan 16, 2025

The contact owns a 2014 Ford Taurus. The contact stated that while his son was stopped at the drive-thru, the temperature gauge indicated that the engine was overheating. The contact's son turned off the vehicle and waited for the engine to cool down before restarting. Upon inspection under the hood, the contact discovered that there was no coolant in the coolant reservoir. The contact added coolant to the coolant reservoir, but the failure recurred while driving and there was coolant leaking onto the ground while the vehicle was parked. The vehicle was taken to the dealer, where it was determined that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 85,000.

NHTSA ID

11633829

Incident

Dec 29, 2024

Mileage

85,000 mi

The contact owns a 2014 Ford Taurus. The contact stated that the vehicle failed to immediately restart and experienced rough driving and would not properly accelerate. The vehicle was taken to the local dealer who diagnosed that the water pump was faulty causing water to leak onto the air compressor. The contact was informed that the water pump needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 91,000.

NHTSA ID

11630280

Incident

Dec 1, 2024

Mileage

91,000 mi

This vehicle was sold to me with a not for sale in states requiring California emissions, no governor on the vehicle as well faulty lighting mechanisms. The fuel pump is fluctuating and the car is a danger to myself and those around me. I consulted with a independent licensed mechanic who confirmed these defaults. No warning lights no messages and the dealer did not point out these flaws. I discovered this issue after getting some routine maintenance done on the vehicle

NHTSA ID

11528090

Incident

Jun 1, 2023

Water pump failure causing a major leak. Because the vehicle is designed to have the water pump run on the timing chain and the oil pan right underneath the water pump, the coolant leaks right into the oil pan and coolant enters the engine. I was driving on a back road and had to abruptly pull over on the side of the road because the driver assist screen said “engine coolant overheating.” This was the first and only time this message appeared. There was smoke coming from under the hood. Numerous mechanics that I’ve spoken to said that if I drove it any longer, there’s a good chance the engine could blow. So now I’m looking at a $3,000+ repair for this. Realistically, any other make and model (that was designed with common sense) with a failed water pump should cost $500-1,000. And won’t run the risk of ruining your engine on top of it. I spoke to several Ford dealers and third party mechanics. Every one of them knew exactly what I was talking about like they had seen this many times before. The third party mechanics refused to fix it because it’s an 11+ hour labor None of them said there are any pro’s to having the water pump connected to the timing chain. But there are many con’s to this design. Sounds like negligence on behalf of the engineers who designed all the 3.5L and 3.7L V6’s in the Fords. Luckily, I was going between 20-30 mph on a backroad when this occurred. Otherwise, this could have ended very badly and I’d like to prevent this from happening to anyone else in the future.

NHTSA ID

11523160

Incident

May 19, 2023

NOTICED SMALL AMOUNT OF FLUID UNDER CAR. CHECKED LEVEL IN COOLANT RESEVOIR. FOUND FLUID LEVEL LOW ADDED COOLANT TO PROPER LEVEL. CHECKED LEVEL A FEW DAYS LATER FOUND LOW AGAIN. DROVE TO MECHANIC SHOP TO HAVE CHECKED. WATER PUMP FAILURE. WATER PUMP IS INTERNAL ON 3.6 FORD TAURUS. REPAIRED AND REPLACED AT A COST OF $1835.00. MILEAGE ON VEHICLE AT TIME OF FAILURE WAS 77,000 MILES.

NHTSA ID

11502787

Incident

Jan 9, 2023

The contact owns a 2014 Ford Taurus. The contact stated that while operating the vehicle, the engine overheated and the vehicle stalled. Upon inspection, it was discovered that the coolant reservoir level was low. The vehicle was taken to the local mechanic who diagnosed that the water pump was faulty and needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure. The failure mileage was 100,000.

NHTSA ID

11499988

Incident

Jan 3, 2022

Mileage

100,000 mi

The contact owns a 2014 Ford Taurus. The contact stated that while her husband was driving at an undisclosed speed, the vehicle overheated, lost motive power and stalled. There were no warning lights illuminated. The driver coasted to the side of the road, inspected the vehicle, and became aware of coolant leaking underneath the vehicle. The driver was able to add coolant to the reservoir, restarted the vehicle, and drove to an independent mechanic where the vehicle was diagnosed, and it was determined that the water pump and timing chain had failed and needed to be replaced. The contact was advised to take the vehicle to the dealer for assistance. The dealer diagnosed that the water pump and timing chain needed to be replaced; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 163,000.

NHTSA ID

11496302

Incident

Nov 6, 2022

Mileage

163,000 mi

The contact's aunt owns a 2014 Ford Taurus. The contact stated that his aunt noticed a puddle of fluids underneath the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant was leaking from the water pump. The contact was informed that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case number was provided. The failure mileage was approximately 55,000.

NHTSA ID

11481784

Incident

Aug 27, 2022

Mileage

55,000 mi

The contact owns a 2014 Ford Taurus. The contact stated that she and her husband noticed that the coolant in the radiator was low. The contact added coolant to the reservoir and noticed two days later that the coolant level was low again. The vehicle was taken to the dealer where they diagnosed the vehicle and stated that the water pump was failing and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure but offered no assistance. The failure mileage was approximately 81,000.

NHTSA ID

11468415

Incident

May 9, 2022

Mileage

81,000 mi

On the 24th February, 2022, I was driving my 2014 Ford Taurus taxi cab on the highway to go pick up a client. I saw a dash light indicating slippery road and suddenly, I could not control the steering of the car. All attempts to control the steering proved futile, and the car kept swerving on both sides, till it hit the divider between the roads. This is the second time that this incident is happening to me. The first incident resulted to a minor damage, and the car was taken to the shop for fix. With the second incident from last month, this resulted to my car being totaled. I am lucky and grateful to be alive. I spoke to my son and learned that there was a recall on the 2014 Ford Taurus. Below is an excerpt regarding the recall that was responsible for my car being damaged; Summary Feb 10,2020 Manufacturer Recall Number20S04 NHTSA Recall Number20V072 Recall StatusRecall Incomplete VEHICLES THAT ARE EXPOSED TO FREQUENT FULL REAR SUSPENSION ARTICULATION (JOUNCE AND REBOUND) MAY EXPERIENCE A FRACTURED REAR SUSPENSION TOE LINK. Safety Risk A FRACTURE OF A REAR TOE LINK SIGNIFICANTLY DIMINISHES STEERING CONTROL, INCREASING THE RISK OF A CRASH. Link for reference: https://www.nhtsa.gov/recalls?vin=[XXX]#vin Due to this crash, I have lost my means of livelihood. I've contacted Ford and was sent back to the insurance. I have contacted C INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11457139

Incident

Feb 23, 2022

THE WATER PUMP ON OUT HOW TO REPLACE IT THEN AFTER THE CAR GOT FIXED THE LOW OIL PRESSURE LIGHT CAME ON THEN MIGHT HAVE TO REPLACE THE ENGINE IF IT'S NOT THE OIL PUMP 145,000 MILES ON IT

NHTSA ID

11399742

Incident

Feb 20, 2021

THE WATER PUMP ONE OUT AND HAD HAD TO REPLACE IT AND THE GASKETS THEN THE LOW OIL PUMP LIGHT CAME ON POSSIBLY HAVE TO REPLACE THE MOTOR OR OIL PUMP

NHTSA ID

11399740

Incident

Feb 19, 2021

CATALYTIC CONVERTER BOTH OF THEM ONE OUT ON MY CAR LESS THAN 145,000 MILES

NHTSA ID

11399739

Incident

Jul 15, 2020

TL* THE CONTACT OWNS A 2014 FORD TAURUS. THE CONTACT STATED THE VEHICLE FAILED TO START WITHOUT WARNING. THE CONTACT CALLED SHEEHY FORD OF MARLOW HEIGHTS (5000 AUTH RD, MARLOW HEIGHTS, MD 20746, (301) 298-0793) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT STATED THE FAILURE WAS LIKE THAT OF NHTSA CAMPAIGN NUMBER: 16V621000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000.

NHTSA ID

11351827

Incident

Aug 27, 2020

Mileage

61,000 mi

OCCURS EVERY 2000 TO 3000 MILES WHEN SLOWING DOWN TO STOP. AS I GET NEAR THE IDLE SPEED (2-3 MPH) WITH MY FOOT ON THE BRAKE PEDDLE THE ENGINE STARTS TO REV UP AND PULL THE CAR FORWARD. I HAVE TO THROW THE TRANSMISSION INTO NEUTRAL AND THE ENGINE RPM'S SPIKE UP TO 5000 TO 6000 AND THEN IMMEDIATELY SETTLES OUT TO AN IDLE SPEED. I HAD A TUNEUP DONE AT 100K MILES AND PART OF THE SERVICE WAS TO "RESET" THE COMPUTER SYSTEM. THE SHOP RAN A FULL DIAGNOSTIC. THIS DID NOT RESOLVE THE PROBLEM. I'M AT ABOUT 118K MILES NOW. THIS PROBLEM STARTED TO OCCUR AFTER ABOUT 75K MILES DURING CALENDAR YEAR 2018.

NHTSA ID

11322261

Incident

Apr 24, 2020

Mileage

118,000 mi

TL* THE CONTACT'S FATHER OWNS A 2014 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND IMMEDIATELY STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT AND HAPPENED 3 TIMES. CONSUMER STATED THE LAST FAILURE HAPPENED IN HER DRIVEWAY WHEN IT STALLED AND COULD NOT GET IT STARTED, IT STARTED THE FOLLOWING MORNING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO BE DIAGNOSED. IMPERIAL FORD (8 UXBRIDGE ROAD, MENDON, MA 01756), WAS CONTACTED BY PHONE AND INFORMED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 83,577.*DT*JB CONSUMER BELIEVES THE CAUSE OF MALFUNCTION IS WITH THE FUEL PUMP CONTROL MODULE, BEHIND THE REAR PASSENGER SEAT.*JB

NHTSA ID

11322057

Incident

Apr 22, 2020

Mileage

83,577 mi

TL* THE CONTACT OWNS A 2014 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE WOULD NOT IMMEDIATELY START. ON OCCASION, WHILE DRIVING, THE ENGINE SUDDENLY STALLED RANDOMLY. THE VEHICLE WAS TAKEN TO CARMAX (16110 NORTH FWY, HOUSTON, TX) WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.

NHTSA ID

11265419

Incident

Sep 1, 2019

Mileage

127,000 mi

TL* THE CONTACT OWNS A 2014 FORD TAURUS. WHEN THE CONTACT ENTERED THE VEHICLE AND PRESSED THE PUSH TO START BUTTON, THE ENGINE WOULD NOT REV. THE VEHICLE WAS TOWED TO UNIVERSITY FORD NORTH (5331 N ROXBORO ST, DURHAM, NC 27712) WHERE THEY RESET THE SYSTEM. THE FOLLOWING DAY, WHILE DRIVING OUT OF A PARKING LOT, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY REPLACED THE FUEL PUMP MODULE. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 79,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

11172098

Incident

Jan 21, 2019

Mileage

79,000 mi

FUEL PUMP CONTROL MODULE FAILED CAUSING ENGINE TO STALL AND NOT ABLE TO BE RESTARTED. FORTUNATELY AT THE TIME I WAS AT THE SIDE OF THE ROAD IDLING, HOWEVER I WAS 5 MINUTES AWAY FROM GETTING ON THE HIGHWAY. PARKED CAR, AND PURCHASED REPLACEMENT FUEL MODULE FROM FORD DEALER AND ABLE TO GET CAR RUNNING AGAIN. FORD HAS ISSUED RECALL 16S31, HOWEVER MY '14 TAURUS WITH A NATURALLY ASPIRATED 3.5L IS NOT INCLUDED IN THAT RECALL. PART NUMBER OF THE MODULE IS AA8A-9D412-CA AND SUPPLIER CODE DOESN'T APPEAR TO BE ONE OF THE STATED SUPPLIERS THAT IS OK TO USE. SUPPLIER CODE APPEARS TO BE -OC. SEE ATTACHED PHOTO AND COMPARE TO INFORMATION SUPPLIED IN RECALL 16S31. REPLACEMENT PART IS P/N AA8Z-9D370-B. DEALER COST WITH TAX FOR THE PART WAS APPROX. $70

NHTSA ID

11053887

Incident

Dec 1, 2017

Mileage

77,500 mi

TL* THE CONTACT OWNS A 2014 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE STALLED ON NUMEROUS OCCASIONS AND ALL THE LIGHTS ON THE INSTRUMENTAL PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THE FAILURE COULD NOT BE LOCATED. THE DEALER REPLACED THE COMPUTER MODULE AND THE FUEL PUMP. THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 400. MA 10/21/15 *CN

NHTSA ID

10760915

Incident

Sep 1, 2014

Mileage

400 mi