Owner-reported complaints naming the brake system, filed with NHTSA
Data refreshed
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake. Every record below is an owner-reported complaint about the 2010 Ford Transit Connect submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
After placing vehicle in Park, vehicle rolled away and destroyed my mailbox. Luckily I was able to stop it inches away from neighbors car. There is a recall for other years, but none for this year. The vehicle has not been inspected by a dealer yet, however, after talking to the dealership service department, it is a common problem and would cost a lot to repair
VEHICLE WAS INVOLVED A TRAFFIC ACCIDENT ON JULY 16,2018 AND A CONTRIBUTING WAS A WORN BRAKE SYSTEM BY MY EMPLOYER'S VEHICLE. THE BRAKE SYSTEM NEEDED REPAIRS AND IT WAS BROUGHT SUPERVISIONS ATTENTION ON SEVERAL OCCASIONS. I WAS TERMINATED BECAUSE OF THEIR VEHICLE BEING UNSAFE. THE COMPANY THAT OWNS THIS VEHICLE IS IOCAFANO'S CATERING SERVICE AT 1739 SAM RITTENBERG BLVD.THE VEHICLE WAS TRAVELING TOWARD I-95 HEADED TO SAVANNAH GEORGIA FOR A FOOD DELIVERY WHEN IT WAS INVOLVED IN A REAR END COLLISON.
WHILE DRIVING ON DRY STREET AT 35-40 MPH HAD CAR IN FRONT OF ME COME TO A SUDDEN STOP. I APPLIED BRAKES AND THEY DID NOT STOP CAR. PEDAL FELT HARD AND THERE WAS NO ACTIVATION OF ABS. STEERED VAN TOWARDS CURB AND REACHED FOR EMERGENCY BRAKE BUT STRUCK REAR OF OTHER VEHICLE. NO SKID MARKS. EXTENSIVE DAMAGE TO VAN. INSURANCE COMPANY TOTALED VEHICLE. STATE SAFETY INSPECTION WAS CURRENT AND BRAKES HAD BEEN CHECKED BY A MECHANIC WITHIN THE LAST FEW MONTHS. HAVE HAD PRIOR ISSUES WITH BRAKE WEAR. HAD TO REPLACE FIRST SET OF BRAKES AT ABOUT 8000 MIKES. DEALER STATES THAT IT WAS "NORMAL WEAR AND TEAR". HAVE ALSO HAD ISSUES WITH FUSES FOR ELECTRIC WINDOWS BLOWING AND SIGNAL AND BRAKE LIGHT BULBS FAILING CONSTANTLY. ALL OCCUPANTS WERE RESTRAINED BUT 13 YEAR OLD FEMALE IN REAR SEAT STRUCK HEAD ON B POST AND SUFFERED CONCUSSION.
MY INITIAL PROBLEM WAS TRACTION CONTROL. IF YOU SLIP COMING OUT OF A DRIVEWAY AND YOU HIT GRAVEL, MUD, SNOW, RAIN YOUR TRACTION CONTROL WILL STOP YOU IN THE MIDDLE OF THE STREET AND YOU CANNOT DRIVE. KIND OF A PROBLEM WITH CARS COMING RIGHT AT YOU. PROBLEM 2 IS THAT THIS SEEMS TO ALSO AFFECT THE WHEEL BEARINGS AND CAUSE PREMATURE FAILURE. I AM GOING ON MY SECOND REPLACEMENT AT 72,000 MILES. PROBLEM 3 IS THAT WHEN THE WHEEL BEARINGS FAIL THEY WEAR ON YOUR ROTORS AND I AM NOW ALSO NEEDING TO REPLACE THOSE ALSO. I CERTAINLY HOPE THAT THIS GETS ADDRESSED SOON. THIS VEHICLE IS NOT ONLY A SAFETY HAZARD IT IS ALSO A MONEY PIT. *TR
TL* THE CONTACT OWNS A 2010 FORD TRANSIT CONNECT. THE CONTACT WAS DRIVING 50 MPH WHEN A RUMBLING NOISE WAS HEARD FROM THE FRONT TIRES . IN ADDITION, THE VEHICLE WOULD SQUEAL ABNORMALLY WHEN BRAKING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT BOTH FRONT ROTORS AND BRAKES NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 400 AND THE CURRENT MILEAGE WAS 1000.
TL*THE CONTACT OWNS A 2010 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THE FRONT BRAKES WERE WORN PREMATURELY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE BRAKES AND ROTORS. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 28,000. THE APPROXIMATE FAILURE MILEAGE WAS 10.
TL* THE CONTACT OWNS A 2010 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND WAS TOWED TO AN AUTHORIZED DEALER WHERE THE STARTER WAS REPLACED. LATER, THE CONTACT HEARD AN UNUSUAL NOISE FROM THE FRONT END THAT PERSISTED FOR SEVERAL WEEKS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FRONT BRAKES AND CALIBERS WERE REPLACED AT 21000 MILES. THE VEHICLE THEN BEGAN TO EXHIBIT AN ABNORMAL HUMMING AND WAS TAKEN BACK TO THE DEALER WHERE BOTH FRONT BEARINGS AND HUBS WERE REPLACED AT 27000 MILES BUT THE NOISE PERSISTED. THE DEALER THEN REPLACED BOTH REAR BEARINGS AND HUBS, TEST DROVE AND REPLACED THE AIR BRAKE SYSTEM SENSORS AND RELEASED THE VEHICLE TO THE CONTACT. THE CONTACT STATED THAT LATER WHILE THE VEHICLE WAS PARKED, HE NOTICED ANTI-FREEZE ABNORMALLY LEAKING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE COOLANT HOSE WAS REPLACED. THE FAILURE MILEAGE WAS 16,000 AND THE CURRENT MILEAGE WAS 31,500.
FRONT BRAKE PADS COMPLETELY WORN DOWN TO THE METAL AT 5000 MILES. REAR BRAKES DEALER MECHANIC FIRST TOLD ME HAD 15% LEFT, THEN THEY "REINSPECTED" AND SAID THEY HAD 50% LEFT AND WERE "FINE" AFTER I COMPLAINED. DEALER FINALLY REPLACED FRONT BRAKES UNDER WARRANTY, AFTER FIRST TELLING ME WERE "NORMAL" WEAR AND TEAR AND THUS WERE NOT COVERED. *TR
PREMATURE BREAK WEAR...FRONT BREAKS NEEDED TO BE REPLACED AT JUST UNDER 30,000 MILES INCLUDING NEED FOR NEW ROTORS. AT 39800, TOLD BY DEALERSHIP THAT FRONT BRAKE PADS AND ROTORS NEEDED TO BE REPLACED AGAIN. FORD IS SAYING THERE IS A PROBLEM WITH PREMATURE BREAK WEAR, BUT THIS IS VERY, VERY DANGEROUS AND COULD RESULT IN BRAKE FAILURE. *LN
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .