2015 Ford Transit Connect Engine Problems

The contact owns a 2015 Ford Transit Connect. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the contact became aware that the engine was overheating. The contact was not able to pull the vehicle to the side of the road and was forced to keep driving. The vehicle was taken to an independent mechanic; however, had not yet been diagnosed. The contact related the failure with an unknown NHTSA recall; however, the vehicle was not included. The local dealer was contacted and confirmed that the vehicle was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 190,000.

NHTSA ID

11595736

Incident

Jun 20, 2024

Mileage

190,000 mi

99398 MILES FRONT DRIVE AXLE REPLACED,99652 MILES VEHICLE GOT STUCK IN THE MIDDLE OF PARKING LOT LANE PREVENTING SHIFTING OUT OF PARK (SHIFTER BUSHING REPLACED),99690 VEHICLE TRANSMISSION REPLACED,101043 MILES VALUE COVER OIL LEAK,101500 TRUCK IDLE SURGING.

NHTSA ID

11389872

Incident

Jan 25, 2021

Mileage

99,398 mi

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE HEATER WOULD ONLY BLOW COLD AIR AND THE DEFROSTER WAS INOPERABLE CAUSING A VISIBILITY HAZARD TO THE DRIVER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ECO BOOST ENGINE SENSOR WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER(UNKNOWN) AND THE MANUFACTURE WERE NOTIFIED OF THE FAILURE BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 187,000.

NHTSA ID

11300729

Incident

Nov 1, 2019

Mileage

187,000 mi

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. WHILE DRIVING APPROXIMATELY 70 MPH, IT BEGAN TO RAIN AND THE AIR CONDITIONING DID NOT WORK. THE SENSOR THAT READ THE TEMPERATURE INDICATED MINUS 4 AND ALL THE WINDOWS FOGGED UP. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD, ROLLED DOWN ALL THE WINDOWS, AND WAITED UNTIL THE RAIN STOPPED. THE CONTACT STATED THAT THE FAILURE OCCURRED AT LEAST TWENTY TIMES. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

NHTSA ID

11218918

Incident

Jun 9, 2019

Mileage

50,000 mi

TL* THE CONTACT OWNS A 2015 FORD TRANSIT CONNECT. WHILE DRIVING 65 MPH, THE PASSENGER IN THE CONTACT'S VEHICLE FELT LIGHTHEADED AND NAUSEOUS. THE CONTACT WAS ABLE TO PULL THE VEHICLE SAFELY OFF OF THE ROADWAY. THE PASSENGER EXITED THE VEHICLE AND PASSED OUT. THE CONTACT EXITED THE VEHICLE TO CHECK ON THE PASSENGER AND ALSO PASSED OUT. THE CONTACT STATED THAT THROUGH A TEXT MESSAGE SENT PRIOR TO PASSING OUT, THE CONTACT'S CHILDREN WERE ABLE TO SEND EMERGENCY SERVICES TO THE LOCATION WHERE THE VEHICLE WAS STOPPED. THE CONTACT AND PASSENGER WERE TRANSPORTED BY AMBULANCE TO SEEK MEDICAL ATTENTION DUE TO CARBON MONOXIDE POISONING. THE CONTACT STATED THAT OXYGEN WAS ADMINISTERED TO BOTH OCCUPANTS AND THEY STARTED TO FEEL BETTER. THE VEHICLE WAS PREVIOUSLY TAKEN TO AL PACKER FORD WEST PALM BEACH (1530 N. MILITARY TRAIL, WEST PALM BEACH, FL, 33409, 561-689-6550) DUE TO A STRONG EXHAUST ODOR IN THE VEHICLE. THE VEHICLE WAS RETURNED WITHOUT THE CONTACT BEING INFORMED OF WHAT CAUSED THE EXHAUST ODOR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. *DT*JB *DT *JB

NHTSA ID

11161208

Incident

Nov 27, 2018

Mileage

87,000 mi

ENGINE OVERHEATING WHILE DRIVING A NORMAL SPEEDS

NHTSA ID

11132061

Incident

Sep 28, 2018

Mileage

59,000 mi

UNDER NORMAL DRIVING THE VEHICLE GOT REAL HOT ,AND OVER HEATED. THE WATER AND OIL LEVELS WHERE AT THE PROPER LEVELS. THE ENGINE HEAD CRACKED OR BLEW THE HEAD GASKET . TOWED TO FORD THEY HAD TO REPLACE THE ENGINE. THIS HAPPENED ON THE HIGHWAY, GOING HOME. THE NEXT DAY THE VEHICLE WOULD NOT START. THERE IS A SAFETY RECALL # 17S09, OUT ON THESE VEHICLES, BUT MY VIN # WAS NOT ON THE LIST. YET LM HAVE THE SAME ISSUE. LUCKILY WE CAUGHT IT BEFORE IT GOT HOT ENOUGH TO CATCH ON FIRE.

NHTSA ID

11123285

Incident

Oct 24, 2017

Mileage

70,112 mi

THE CHECK ENGINE LIGHT CAME ON AT ABOUT 81,000 MILES, AND A WEIRD NOISE STARTED HAPPENING COMING FROM THE ENGINE AREA. I GOT INTO THE DEALER SERVICE DEPARTMENT (DEALER WHERE I BOUGHT THE CAR) AT ABOUT 81,500 MILES. THEY DIAGNOSED A BAD CATALYTIC CONVERTER - IT WAS BREAKING UP. SEVERAL ISSUES AROSE FROM THAT: FIRST, I HAVE BEEN SMELLING CARBON MONOXIDE IN THE CAB FOR QUITE A WHILE AND DID NOT KNOW WHY (NOW I THINK I KNOW - CLOGGED CATALYTIC, REVERSION THROUGH THE ENGINE BAY). SECOND THE CATALYTIC WARRANTY EXPIRES AT 80,000 MILES. (THE LIGHT WENT ON AT 81,000). THIRD, AT THE TIME OF PURCHASE, THE DEALER FINANCE GUY FORCED ME TO BUY AN EXTENDED WARRANTY. HE SAID THAT FORD WOULD NOT FINANCE ME IF I DID NOT BUY IT SO I AGREED. IT WAS OVER $2000 TAKEN OUT OF MY DOWN PAYMENT. I FULLY EXPECTED THE EXTENDED WARRANTY TO COVER THE BROKEN CAT - WRONG - CATS ARE NOT COVERED. THE REPAIR WAS QUOTED AT ABOUT $1000. MY BEEF HERE IS SEVERAL FOLD: THE 1) FORD WARRANTY EXPIRES AT 80,000 AND THE ENGINE LIGHT COMES ON AT 81,000 EVEN THOUGH THE CONVERTER HAD BEEN GOING BAD THE WHOLE TIME. 2) I HAVE BEEN BREATHING CO2 IN THE PASSENGER COMPARTMENT. 3) THE EXTENDED WARRANTY WAS USELESS AND I PAID A HEFTY SUM FOR IT. THE REPAIR IS QUITE EXPENSIVE AND THE PROBLEM IS NOT COVERED BY ANY OF THE WARRANTIES I HAVE, WHICH I THINK IS UNFAIR. I HAVE NOT BROUGHT THIS COMPLAINT TO THE DEALER TO ALLOW THEM A REBUTTAL - I SIMPLY LEFT IN SHOCK THAT I AM ON THE HOOK, AND NOW I'M BREATHING THE STINK OF A DECOMPOSING CAT IF I DON'T USE RECIRCULATE (AND A SLIGHT AMOUNT EVEN IF I DO USE RECIRCULATE, WHICH IS ANOTHER COMPLAINT - RECIRCULATE STILL LETS IN OUTSIDE AIR. IN TRAFFIC, YOU ARE ALWAYS BREATHING EXHAUST).

NHTSA ID

11072166

Incident

Jan 8, 2018

Mileage

81,500 mi