2015 Ford Transit Connect

In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD

In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

The contact owns a 2015 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part for the repair was unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the remedy to be available. The screen would display a blank screen. The back over prevention camera would also suddenly activate even while in forward drive. The vehicle was taken to the dealer, who replaced the back-over prevention camera twice; however, the failures persisted. The manufacturer was not made aware of the issue. The failure mileage was approximately 150,000

NHTSA ID

11750251

Incident

Sep 8, 2025

Mileage

150,000 mi

I am submitting this complaint to report an unresolved safety recall and the inability to obtain a timely inspection or repair, which I believe places me and my family at increased risk of a crash. My vehicle is a 2015 Ford Transit Connect. The vehicle is subject to Ford Safety Recall 25S89 and NHTSA Recall 25V572, concerning a failure of the rearview camera system. The rearview camera on my vehicle frequently displays a message stating “Rear View Camera Unavailable, Contact Ford Dealership” and then goes to a black screen. This results in a complete loss of rear visibility while backing up, increasing the risk of a collision, especially involving pedestrians or other vehicles. I received the safety recall notice in September 2025. Since then, I have made numerous attempts to have the vehicle inspected and repaired. Despite repeated contact with my local dealership, has informed me that they cannot perform the inspection or recall repair because they do not have an SSCC repair procedure available and therefore cannot proceed. I have also contacted Ford Motor Company customer service by phone multiple times, but these calls have not resulted in a resolution or a clear path to getting the vehicle repaired. As a result, I am left operating a vehicle with a known safety defect and no access to the recall remedy. I am deeply concerned for my safety and the safety of my family. Operating this vehicle without a reliable rearview camera significantly increases the chance of a crash, and I believe the continued delay in providing a remedy defeats the purpose of a safety recall. I respectfully request that NHTSA document this complaint and take any appropriate action to ensure that Ford Motor Company provides a timely inspection and repair for this safety defect.

NHTSA ID

11716171

Incident

Sep 1, 2025

No remedy from Ford for this recall since September 8 2025. This is a work vehicle I can not use until recall fixed

NHTSA ID

11700725

Incident

Sep 8, 2025

The contact owns a 2015 Ford Transit Connect. The contact received notifications of NHTSA Campaign Numbers: 20V331000 (LATCHES/LOCKS/LINKAGES), 23V502000 (LATCHES/LOCKS/LINKAGES), and 25V572000 (BACK OVER PREVENTION); however, the parts to do the recall repairs were not yet available. The contact stated that the dealer refused to perform the recall repairs regarding the latches, locks, and linkages. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11693357

Incident

Oct 14, 2025

The contact owns a 2015 Ford Transit Connect. The contact stated while reversing, the back over prevention camera system failed to function as intended. The contact stated that the back over prevention camera system independently activated and deactivated. In addition, the contact stated that occasionally the back over prevention camera system was inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall; however, the VIN was not included. The contact was informed to take the vehicle to the dealer for a diagnostic test. The failure mileage was approximately 65,000.

NHTSA ID

11663885

Incident

Dec 3, 2024

Mileage

65,000 mi

The contact owns a 2015 Ford Transit Connect. The contact stated while driving 35 MPH, The vehicle speedometer failed to display the speed of the vehicle. The vehicle was not taken to a dealer or independent mechanic for diagnoses or repairs. The manufacturer was not notified of the failure and offered no assistance. The contact was referred to call the NHTSA Hotline to file a complaint. The failure mileage was 49,000.

NHTSA ID

11632726

Incident

Oct 11, 2024

Mileage

49,000 mi

The contact owns a 2015 Ford Transit Connect. The contact stated while her husband was closing the door, he heard an abnormal sound. The driver removed the panel and located a separation. The side panels had separated, and he became aware that water was entering the vehicle. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 14V777000 (Structure). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 133,934.

NHTSA ID

11604010

Incident

Jul 9, 2024

Mileage

133,934 mi

The rear passenger side sliding door fell off the track and fell off the vehicle, while the door was being closed. I originally reported difficulty to the dealership shortly after purchasing the vehicle around 2016. I asked the dealership on multiple occasions to fix the door sliding issue. I was told there was nothing they could do to fix it. The door was always difficult to open and close. 6/25/24, the door fell off the vehicle while it was being closed.

NHTSA ID

11597058

Incident

Jun 25, 2024

Mileage

122,959 mi

2015 Transit Connect ONLY under 25N15 - PAUSED effective July 15, 2026 - July 15, 2026 - 2015 Transit Connect ONLY under 25N15 - PAUSED effective July 15, 2026 AWARENESS COMMUNICATION Monitor FSA Landing Page in PTS for further details - Certain 2015-2019 Model Year Multiple Vehicle Lines - Rear View Camera Inspection For One-Time Replacement

Customer Satisfaction Program 25N15 - Supplement #1 Certain 2015-2019 Model Year Multiple Vehicle Lines Rear View Camera Inspection For One-Time Replacement

Advance Notice – Customer Satisfaction Program 25N17 Certain 2015-2025 Model Year Multiple Vehicle Lines Rear View Camera Replacement If Required After Dealer Evaluation

Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k

Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Pinpoint test HK in the Powertrain Control and Emissions Diagnosis (PC/ED) or in Section 303-14 of the Workshop Manual (WSM) has been updated to address this concern.

While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.