2023 Ford Transit Problems

Transmission, drive shaft and rear axle "grenaded" and shut down the vehicle. Symptoms included erratic shifting at highway speed, clunking sounds, hard downshifts at low speeds, mis-shifting gears causing performance issues. No warning lights. Codes appeared in FordPass app after vehicle shut down.

The contact owns a 2023 Ford Transit. The contact stated that while in drive, the transmission slammed into fourth gear. The hill assist feature was activated during the failure. The contact believed that the failure was caused by an inoperable back over prevention camera. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and offered a buyback, but no assistance was provided. The failure mileage was approximately 23,459.

This is a Ford Palladium Van, year 2024, the secondary alternator charging circuit that Thor has installed has a lot of problems. Specifically, the alternator from Balmar fails and you cannot charge lithium batteries while the van is in motion. The whole point of the secondary alternator is to charge these batteries while in motion. Its a safety issue when traveling with children or pets because battery voltage drops if you have to run AC while in a store or something. You proceed down the road and the battery is not recharged. Next stop you may not be able to run AC at all.

The contact owns a 2023 Ford Transit. The contact stated that while in drive, the transmission slammed into fourth gear. The hill assist feature was activated during the failure. The contact believed that the failure was caused by an inoperable back over prevention camera. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and offered a buyback, but no assistance was provided. The failure mileage was approximately 23,459.

The contact owns a 2023 Ford Transit. The contact stated that while in drive, the transmission slammed into fourth gear. The hill assist feature was activated during the failure. The contact believed that the failure was caused by an inoperable back over prevention camera. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and offered a buyback, but no assistance was provided. The failure mileage was approximately 23,459.

The contact owns a 2023 Ford Transit. The contact stated that while attempting to reverse, the rearview 360° camera became inoperable. The contact stated that the rearview image was blank. The contact previously received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention). The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the accessory protocol interface module (APIM) had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 31,000.

Campaign/NHTSA# 24S21/24V226 No remedy provided by Ford; Issue Date 2024-03-22 Campaign/NHTSA# 24S46/24V542 AND Campaign/NHTSA# 24S48/24V591 Ford notified me that the recall is ready for repair, however the parts are not available; my dealer has been waiting for 4 weeks now to receive the parts

Tire rub

The contact owns a 2023 Ford Transit. The contact stated that while driving approximately 25 - 60 MPH, the check engine warning light illuminated, and the vehicle started to decelerate. During the most recent failure, the contact was able to drive to the dealer before the vehicle lost power. The vehicle was diagnosed, and the contact was informed that water was leaking into the engine, causing a shortage with the spark plugs and other electrical systems. The #4 spark plug was replaced. The contact researched and became aware of an issue with the cowl allowing water and debris to enter the engine and causing the #4 spark plug to be short-circuited. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 45,000.

Vehicle shuts off completely off while driving intermittently. This issue has happened several times starting at 15000 miles. Vehicle has been back to dealership more than once regarding this issue. No codes are detected during diagnostics. UNSAFE

The contact owns a 2023 Ford Transit. The contact received notifications of NHTSA Campaign Numbers: 24V542000 (Steering) and 24V591000 (Steering); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Campaign/NHTSA# 24S21/24V226 No remedy provided by Ford; Issue Date 2024-03-22 Campaign/NHTSA# 24S46/24V542 AND Campaign/NHTSA# 24S48/24V591 Ford notified me that the recall is ready for repair, however the parts are not available; my dealer has been waiting for 4 weeks now to receive the parts

August 2024: Vehicle started to grab/pull when breaking and turning to the right, especially around curves. This progressed to happening when the van weight shifted forward during breaking. Dealerships in Eugene, Oregon and Marin, CA confirmed this behavior is related to the wheel clearance. Dealership in Eugene confirmed damage to the wheel well liner. I was unable to get any support from Ford regarding a loaner or assistance getting my van home 900+ miles. September 2024: loaded excess weight into the rear of the van and drove slowly back to Southern California. For safety purposes, dealership advised “parking the van until Ford comes up with something.” I have been unable to use the van since, with no updates from Ford. There have been four recalls (the rear view camera is fixed) and at least one Customer Satisfaction service (software update for the transmission performed in Eugene). Van has less than 5,000 and was purchased in March 2024.

All the dash warning lights come on. Parking limited braking. Pre collision assist not avail. Hill assist not avail. Turning hard mostly to the left the brakes are activating causing the vehicle to stop without depression the brakes. Also have to use half gas peddle to over come the brakes to get the van to move. All intermitant

A very strong gas smell was detected on the vehicle cabin. It lingers for a long time when it seems to be going away, it comes back strong again. This began July 2nd 2024. I have not taken my vehicle to get checked out because I cannot afford it, but i did ask around and everyone including some that know about cars said the car is too new and it is not normal, it is bad for our health since we are inhaling those nasty fumes everyday. This vehicle has never been hit or has had any type of damage to it in any way. It has been driven 85k miles and it is still in perfect condition. Honestly since I purchased this vehicle it has been nothing but problems. This is not the only issue this vehicle came with since day 1. I reached out to dealer at first but had no luck. Please help with this vehicle, I really believe this vehicle was not made correctly in so many ways.

Rodent chewed on fuel line and gas sprayed all over engine bay and under car on start-up.

The contact owns a 2023 Ford Transit. The contact stated that while driving approximately 25 - 60 MPH, the check engine warning light illuminated, and the vehicle started to decelerate. During the most recent failure, the contact was able to drive to the dealer before the vehicle lost power. The vehicle was diagnosed, and the contact was informed that water was leaking into the engine, causing a shortage with the spark plugs and other electrical systems. The #4 spark plug was replaced. The contact researched and became aware of an issue with the cowl allowing water and debris to enter the engine and causing the #4 spark plug to be short-circuited. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 45,000.

August 2024: Vehicle started to grab/pull when breaking and turning to the right, especially around curves. This progressed to happening when the van weight shifted forward during breaking. Dealerships in Eugene, Oregon and Marin, CA confirmed this behavior is related to the wheel clearance. Dealership in Eugene confirmed damage to the wheel well liner. I was unable to get any support from Ford regarding a loaner or assistance getting my van home 900+ miles. September 2024: loaded excess weight into the rear of the van and drove slowly back to Southern California. For safety purposes, dealership advised “parking the van until Ford comes up with something.” I have been unable to use the van since, with no updates from Ford. There have been four recalls (the rear view camera is fixed) and at least one Customer Satisfaction service (software update for the transmission performed in Eugene). Van has less than 5,000 and was purchased in March 2024.

After purchasing brand tires from the Ford dealership, I began experiencing vibrations between 75mph-80mph. I reported this issue to the dealer, but they disregarded my concerns. Subsequently, I consulted my personal mechanic, who conducted a Road Force Balance test, indicating that tire number 4 is defective. I possess documentation supporting this claim, and the dealer manager has failed to respond to me for over a week.

Driver noticed excessive vibration when driving vehicle on June 17, 2025. The next day, the vehicle was taken to Mavis Tire & Brakes, Flagler Beach, FL, who confirmed a tread separation on the driver's side front tire. The tire is a HANKOOK Dynapro HT 205/75R16C. This tire is an original tire from when the vehicle was purchased new. The tire shop exchanged the faulty tire with the spare. If the vehicle were to continue to be driven, eventually the tread would have delaminated completely, causing a potential accident. This is the SECOND Hankook tire to fail this way on this vehicle. I did not report the first incident to NHTSA.

My cargo van has no rearward windows. It has front/rear/left/right exterior cameras which generate a simulated, 360-degree, overhead view on a monitor. The right camera functions about half of the time. Once it generated an all-orange view. Now it often generates an all-blue view. I know other Ford vehicles are subject to a recall for this software issue and Ford has (or is generating) a fix for the problem. The 2023 Transit is not part of that recall group, but it should be.

The contact's employer owns a 2023 Ford Transit. The contact stated that the rear passenger's side sliding door failed to latch while the front driver's and passenger's side doors were closed. The contact had to open the front driver's or passenger's side doors or roll down the windows for the rear passenger's side sliding door to latch. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was unavailable.

FORD has failed to fix 2 recalls. Rear differential is howling and potentially low on fluid per recall--my FORD dealer cannot get to it until AUGUST. Local dealer is Chapel hills ford in Colorado Springs--that is were I purchased vehicle on [XXX] 2024. They have been NO help. Both front Tires rubbing the body at any slight turn--like into a driveway--with no load in the van. Tires and body both getting damaged. No resolution from FORD. Because of tires rubbing, it has now caused the wheel well liner to dislodge from the plastic fasteners and I am worried the liner will completely fall into the front wheel and steering linkage causing a wreck. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)