2018 Forest River Xlr Toyhauler Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 Forest River Xlr Toyhauler, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical250.0%
- Body & structure125.0%
- Other / unspecified125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
AS PER NHTSA CAMPAIGN #18E050 THE AWNING ON THE RV TRAILER MAY EXTEND WHILE TRAILER IS IN MOTION. THE AWNING MANUFACTURER LCI IS AWARE OF THIS RECALL BY DID NOT INFORM MY DEALER ABOUT THE RECALL. I TRIED TO HAVE THE CONTROL MODULE REPLACED THROUGH THE DEALER BUT THEY DID NOT PERFORM THE REPLACEMENT OF THE DEFECTIVE MODULE. I THEN TRIED TO HAVE THE MODULE REPLACED BY LCI AND THEY REQUIRED ME TO GO THROUGH A 3RD PARTY SERVICE PROVIDER TO HAVE THE MODULE REPLACED. THE 3RD PARTY SERVICE COULD NOT PERFORM THE REPLACEMENT AT A CONVENIENT TIME AND INSISTS THAT I DELIVER MY RV TO THEIR PLACE OF BUSINESS FOR AN UNSPECIFIED TIME PERIOD. THE MODULE IS A PLUG IN DEVICE THAT REQUIRES LESS THAN 5 MINUTES TO REPLACE AND REQUIRING ME TO TAKE MY TRAILER OUT OF STORAGE AND ALLOW THEM TO KEEP IT FOR AN UNSPECIFIED TIME PERIOD IS UNACCEPTABLE. THE ORIGINAL DEALER HAD MY TRAILER FOR OVER 3 MONTHS AND DID NOT PERFORM THE REPLACEMENT. I HAD TO CANCEL VACATIONS DUE TO THE 1ST SERVICE ATTEMPT AND I WILL NOT JEOPARDIZE THE LOSS OF USE FOR A SECOND TIME. PLEASE PROVIDE ME WITH THE BASIS FOR LCI'S DEMAND THAT I MUST HAVE THE REPLACEMENT DONE BY A 3RD PARTY IF THAT IS A TRUE REQUIREMENT. I HAVE ATTACHED PICTURES OF THE MODULE TO SHOW IT'S SIZE AND ACCESSIBILITY.
FRONT BEDROOM A/C WAS INCORRECTLY WIRED CAUSING MELTDOWN AND FAILURE OF THE WIRE NUT. THERE WAS INSUFFICIENT INSULATION STRIPPED FROM THE JOINING WIRES TO GIVE A GOOD PHYSICAL CONNECTION AND THE WIRE NUT WAS LOOSE. VEHICLE WAS STATIONARY AT THE TIME OF THE FAILURE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
28 KW NITRO, FRESH WATER, CITY WATER AND BLACK TANK WASH OUT WILL MELT OFF THE SIDE OF UNIT, DUE TO THE PROPANE HOT WATER TANK EXHAUST BEING DIRECTLY BELOW THE PLASTIC FITTINGS. THE VEHICLE WAS SET UP IN A CAMPING LOCATION WITH A CITY WATER HOOKUP CONNECTED. *TT *TR *DT*JB*DT*AS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
28 KW NITRO, FRESH WATER, CITY WATER AND BLACK TANK WASH OUT WILL MELT OFF THE SIDE OF UNIT, DUE TO THE PROPANE HOT WATER TANK EXHAUST BEING DIRECTLY BELOW THE PLASTIC FITTINGS. THE VEHICLE WAS SET UP IN A CAMPING LOCATION WITH A CITY WATER HOOKUP CONNECTED. *TT *TR *DT*JB*DT*AS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .